Polaris Trail Blazer 2004 Owner's Manual page 73

MAINTENANCE AND LUBRICATION
Periodic Maintenance Schedule
Item
Taillight/brakelight
Air filter,
"
main element
Transmission oil
"
level
Battery
Brake pad wear
J
Engine cylinder
head and cylinder
base fasteners
General lubrication
"
Oil Pump Cable
Carburetor float
bowl
Throttle Cable/ETC
J
Switch
Choke (enricher)
cable
Shift linkage
Drive belt
J
Steering
"
Front suspension
"
Rear suspension
"
Drive chain(s)
"
Rear axle
"
More often under severe use, such as dirty or wet conditions
"
Dealer service item
J
70
Hours/ Frequency Remarks
Miles
Pre-Ride Pre-Ride
Weekly Weekly
20 hrs Monthly
20 hrs Monthly
10 hrs Monthly
25 hrs 3 months
50 hrs 3 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
50 hrs. 6 months
Check operation daily; ap-
ply Polaris dielectric grease
to socket when replaced
Inspect; replace as needed
Inspect monthly; change
annually
Check terminals; clean;
Inspect periodically
Inspect (re-torque required
at first service only)
Lubricate all fittings, pivots,
cables, etc.
Inspect, adjust, lubricate,
replace if required
Drain bowl periodically and
prior to storage
Inspect; adjust; lubricate;
replace if necessary
Inspect; adjust; lubricate;
replace if necessary
Inspect; adjust
Inspect; replace as needed
Inspect daily; lubricate
Inspect; lubricate; tighten
fasteners
Inspect; tighten fasteners
Inspect daily; adjust and lu-
bricate if needed
Inspect bearings