IMPORTANT Owner's Responsibility and Operating Safety Check List BE SURE TO READ AND DO THE FOLLOWING BEFORE OPERATING YOUR OUTBOARD MOTOR SAFETY CHECK LIST Learn observe boating laws of the U,S, Coast Guard, state, local author- ities. U.S. Coast Guard regulations require the following:...
MAIN I !-NAN_;i: outboard' m0tor" sh0uld LUBRICATION GEAR HOUSING mounted a stand vertically with The Gear Housing has been pre.lubricated power head up for storage. the factory; however, the grease level should Pull starter handle slowly until resist- be checked as follows using SAE out-...
klIl'lI |Vl| • BOAT MOUNTING Mount the motor the center of the boat transom (stern). (See Figure 4). CAUTION Hand tighten transom bracket and clamp stud handles simultaneously. Oo not use a wrench or any other device that would cause damage to brackets.
OPERATION 2-CYCLE ENGINE FUEL MIXTURE Use a good grade of regular gasoline. (See mix- ing table below.) CAUTION Always use BIA certified TC-W oil in the 50:I ratio. Failure to do so may result in excessive spark plug fouling, piston scoring, or bearing failure.
OPERATION WARNING In case of' an Emergency, the engine can be stopped by moving the Choke Lever to Full Choke Position. If the motor will be operated for a period of time, if it is to be removed from SLOW tilted boa[, it iS t0 be...
OPERATION FLYWHEEL MAGNETO IGNITION SYSTEM WITH TRANSISTERIZED ELECTRONIC IGNITOR The magneto ignition system consists of the following component parts: Flywheel Tran- sisterized EJectronic ignitor and ignitionCoil. b, Inspect the following if engine fails or is hard to start: Spark plug as often as necessary.
TROUBLE SHUUiiN5 (;lll:t;r_ Llbl *Take your outboard motor into any one of over 2000 Seers Se_ice Units. × Fuel Tank Empty ..• ..Fue! Shut.Off Valve Closed Fuel Line Kinked or Pinched Fuef Filter Dirty or C!ogged ........Vent Screw on Fuel Tank Filter Cap Closed ×...
Page 22
lUQL PI!_,I REENo. P.P.No. PARTS NAME O'ty 7-000 985-35304-900! TaOL X iT 85Z-20000-201! SPARK PLUG BOX SPAHHER 7-00! 7-002 808-20000-200 SPAEKER 10X13 7-003 862-20000-200 PLUS DEIVER 4 7-004 948-32352-200 TOOL BAG...
Page 23
SEARS MODEL 298.586192 For quick service or repair, take your Outboard Motor to any Sears Service Unit throughout FULL ONE YEARWARRANTYON U.S. and Canada. Each Service Unit is staffed OUTgOARDMOTOR trained technicians, using Sears approved For one yea[ from the first day of Use Of parts and repair procedures...