Sears, Roebuck And Co - Sears 143.998003 Operator's Manual

SEARS, ROEBUCK AND CO.
Federal and California Emission Control Systems Limited Warranty
Utility and Lawn and Garden Engines
CALIFORNIA & US EPA EMISSION CONTROL
WARRANTY STATEMENT
The U S Environmental Protection Agency (*EPA'), the California Air Resources
Board ('CARB') and Sears, Roebuck andCo, are pleased to explain the Federal
and California Emission Controt Systems Warranty on your new utility or lawn and
garden equipment engine. In California, new 1995 and later utiEtyand lawn and
arden equipment engines must be designedt bailsand equipped to meet the
_fata's stringent anti-smog standards. In other states, new 1997 and later model
year engines must be designed, built and equipped, at the time of sale. to meet
the U.E. EPA regulabons for small non-road engines Sears Roebuck and Co
will warrant the emission control system on your utility or lawn and garden
equipment engine for the periods of time listod below, provided there has been no
abuse, neglect, unapproved modification, or improper maintenance of your utility
or lawn and garden equipment engine
Your emission control system may include parts such as the carburetor, ignition
system and exhaust system, Also inoluded may be the compression release
system and other emission-related assemblies¸
Where a warrantable condition exists, Seats. Roebuck and Oo. will repair your
utility ot lawn and garden equipment engine 8t no cost to you for diagnosis, parts
and labor
MANUFACTURER'S EMISSION CONTROL SYSTEM
WARRANTY COVERAGE
Emission control systems on 1995 and later model year California ubliltyand fawn
and garden equipment engines are warranted for two years as hereinafter noted
In other states, 1997 and later model year engines are also warranted for two
years. If, during such warranty period, any emission-related part on your engine
=sdefective in materials or workmanship, the part witl be repaired or replaced by
Sears, Roebuck and Co.
OWNER'S WARRANTY RESPONSIBILITIES
As the utility or lawn and garden equipment engine owner, you are responsible for
the performance of the required maintenance listed in your Owner's Manual. but
Sears Roebuck and Co will not deny warranty solely due to the lack of receipts
or for your failure to provide wr tten evidence of the pedormance of all scheduled
maintenance.
As the utility ot lawn and garden equipment engine owner, you should, however,
be aware that Sears, Roebuck and Co may deny you warranty coverage if your
utility or lawn and garden equipment or a part thereof has failed due to abuse.
neglect, improper maintenance or unapproved modifications
You are responsible for presenting your utility or lawn and garden equipment
engine to a Sears. Roebuck and Do. Authorized Service Outlet as soon as a
problem exists. The warranty repairs soduld be completed Jn a reasonable
amount of time, not to exceed 30 days
Warranty service can be arranged by contacting either a Seat=, Roebuck and Co.
Authorized Service Outlet, or by contacting Sears, Roebuck and Co at 1-800*
473-7247¸
IMPORTANT NOTE
This warranty statement explains your rights and obligations under the Emission
Contrbl System Warranty ('ECS Warranty') which is provided to you by Sears.
Roebuck and Co, pursuant to Oatifornia law. See also the Sears, Roebuck and
CO. Limited Warranties for Sears. Roebuck and Co, which is enclosed therewith
on a separate sheet and also is provided to you by Sears, Roebuck and Co, The
ECS Warranty applies only to the emission control system of your new engine,
TO the extent that there is any conflict in terms between the ECS Warranty and
the Sears. Roebuck and Co. Warranty, the ECS Warranty shaft apply except in
any circumstances in which the Sears, ROebuck and Co Warranty may provide a
longer warranty period. Both the ECS Warranty and the Sears, Roebuck and Co,
Wa_anty describe important rights and obligations with respect to your new
engine.
Warranty service can only be performed by a Sears, Roebuck and Co. Authorized
Service Outlet, At the time of requesting warranty service, evidence must be
presented of the date of sale to the original purchaser. The purchaser shall pay
any charges for makin_ servJcecallsandlorfortransporfingthe pfroducts to a_ld
from the place where the inspection and/or warranty work is performed. The
purchaser shall be responsible for any damage or loss incurred in connection with
the transportation of any engine or any pert(s) thereof submitted for inspection
and/or warranty work,
If you have any questions regarding your warranty rights and responsibilities, you
should contact Sears, Roebuck and CO. at 1-500-473-7247
EMISSION CONTROL SYSTEM WARRANTY
Emission Control System Warranty "ECS Warranty" for 1995 and later model
year California utility and lawn and garden equipment engines for other states.
1997 and later model year engines):
A. APPLICABILITY: This warranty shall apply to 1995 and later model year
California utility and lawn and garden equipment engines for other states. 1997
and later model year engines). The ECS Warranty Pedod shaft begin on the date
the new engine or equipment is defivered to its original, end-use purchaser and
shall continue for 24 consecutive months thereafter.
R. GENERAL EMISSIONS WARRANTY COVERAGE: Sears, Roebuck and CO.
warrants to the original, end-use purchaser of the new engine or equipment and
to each subsequent purchaser that each of its utifity and lawn and garden
equipment engines is:
1 Designed. built and eduipped so as to conform with all applicable
regulations adopted by the Air Resources Eoard pursuant to its authority in
Chapters 1 and 2, Part 5. Division 26 of the Health and Safety Code, and
2 Free from defects in materials and workmanship which, at any time duhng
the ECS Warranty Period, will cause a warranted emissions*related part to
fair to be identicat in all material respects to the part as described in the
engine manufacturer's application rbr certification
C. The ECS Warranty only pertains to emissions-relatad parts on your engine, as
follows:
1. Any warranted, emissions-related parts which are not scheduled for
replacement as required thblntena nce in the Owner's Manual shall be
warranted for the ECS Warranty Period If any such part fails during the
ECS Warranty Period, it shall be repaired or replaced by Sears, Roebuck
and Co according to Subsection 4 below Any such part repaired or
replaced under the ECS Warranty shall be warranted for any remainder of
the ECS Warranty Period,
2,
Any warranted, emissions-refatad part which is scheduled only for regular
inspection as specified in the Owner's Manual shall be warranted for the
ECS Warranty Period A statement in such written instructions to the
effect of "repair or replace as necessary', shall not reduce the ECS
Warranty Period Any such part repaired or replaced under the ECS
Warranty shall be warranted for the remainder of the ECS Warranty
Period.
Any warranted, emission s-related part which is scheduled for replacement
as required maintenance in the Owner's Manual. shall be warranted for the
period of time prior to the first scheduled replacement point for that part. If
the part fails pdor to the first scheduled replacement, the part shall be
repaired or replaced by Sears, Roebuck and Co according to Subsection
4 below Any such emissions-related part repaired or replaced under the
ECS Warranty, shall be warranted for the remainder of the ECS Warranty
Period prior to the first scheduled replacement point for such emissions-
related part.
4 Repair or replacement of any warranted, emissions-related part under this
ECS Warranty shall be performed at no charge to the owner at a Sears,
Roebuck and Co. Authorized Service Outlet
fi The owner shall not be charged for diagnostic fabor which leads to the
determination that a part covered by the ECS Warranty is in fact defective,
provided that such diagnostic work is performed at a Sears, Roebuck and
CO. Authorized Service Outlet
5 Sears, Roebuck and Co. shall be fiable for damages to other originbl
engine components or alp|provedmodifications proximately caused by a
failure under warranty of an emission-related part covered by the ECS
Warranty,
7. Thro_Jghoutthe ECS Warranty Period. Sears. Roebuck and Co shall
maintain a sgppty of warranted emission-related parts sufficient to meet
the expected demand for such emission-related parts,
8 Any Sears, Roebuck and Co. authorized and approved emission*refated
replacement part may be used in the performance of any ECE Warranty
maintenance or repaJr and will be provided without chaa_a to the owner¸
Such use shall not reduce Sears, Roebuck and Co ECS Warranty
obligations.
9, Unapproved edd-on or modified parts may not be used to modify or repair
a Sears. Roebuck and Co. engine. Such use voids this ECS Warranty and
shall be sufficient grounds for disallowing an ECS Warranty claim. Seats,
Roebuck and Oo. shall not be Jiable hereunder for failures of any
warranted pads of a Sears. Roebuck and CO. engine caused by the use of
such an unapproved add-on or modified part.
EMISSION-RELATED PARTS INCLUDE THE FOLLOWING:
1. Carburetor Assembly and its Internal Components
a) Fuel filter
b) Carburetor gaskets
c) Intake pipe
2, Air Cleaner Assembly
a) Air filter e_ement
3. Ignition System. including:
a) Spark plug
b) Ignition module
C) Flywheel assembly
4 Catalytic Muffler (if so equipped)
a) Muffler gasket (if so equipped)
b) Exhaust manifold (if SOequipped)
5 Crankcase Breather Assembly and its Components
_,) _.reather co_nectk_n t_be
12297 Ep,VCAR]_
Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.
Page 6 181o1202-11