Bayco 2218 Operating Instructions

Operating Instructions for Rechargeable Task Light
Models 2218 / 2236 / 2266
LED Spotlight - Floodlight
INS-2218-12
CAUTION: Do not use this task light in explosive atmospheres, near flammable
liquids, or where explosion-proof lamps are required. Do not immerse in water.
CAUTION: For light duty work only.
Thank you for purchasing this Bayco task light. Save these instructions.
Please read these instructions before using your task light. Be sure to charge
the task light before the first use.
OPERATION
Initial Use
Fully charge the task light before the first use. If the battery is new or has been
unused for several months, several charge and discharge cycles may be
needed to reach full battery capacity. To reach maximum performance, run the
light to completely discharge the battery and then recharge. Each charge cycle
will extend the operation time until maximum capacity is achieved. The charge
time for maximum capacity is approximately 4 - 6 hours.
Regular Use
Use only the supplied AC charging adapter.
• For best performance, charge the task light when the LED's start to dim.
• Connect the AC power adapter to the light. The red indicator will light.
• The red light indicates the task light is being charged. The red light remains
on until the battery is fully charged. At full charge, the light turns off. The
total time to full charge varies depending on the remaining charge in the
battery pack.
• Keep the task light plugged into the charger to maintain a trickle charge.
IF THE RED INDICATOR LIGHT ON THE TASK LIGHT BLINKS, UNPLUG
FROM THE WALL AND PLUG THE LIGHT BACK IN. THE LIGHT SHOULD
REMAIN ON STEADY FOR CHARGING.
• Do not cover the task light while operating or during charging.
• Do not charge a hot battery. Allow the light to cool before charging
• Unplug the task light from the power source when charging is complete.
• The task light will become warm while charging.
The task light has a 2 position rocker switch to control the spotlight, floodlight
and off functions.
The hanging hook allows hands-free lighting.
FUNCTION 2218
Spotlight LEDs
Floodlight LED's
Spotlight
Switch Function
Floodlight
Run-time 10 to 30 hrs
Approximate charge
6 hrs
time
SAFETY
Caution bright led radiation: avoid direct eye exposure. The light is a
class 2 LED product per iec 60825-1 edition 1.2.2001.
• Do not use or charge this task light in explosive or hazardous areas.
• Do not attempt to repair or disassemble the task light or the charger power
supply.
• Use only the supplied AC charger.
TIPS TO EXTEND BATTERY LIFE
The task light NiMH internal battery pack does not have a memory effect.
Charging the task light often helps extend its useful life.
2236 2266
3 6 6
15 30 60
Spotlight Spotlight
Floodlight Floodlight
6 to 24 hrs 4 to 24 hrs
6 hrs 4 hrs
BAYCO • 640 South Sanden Blvd. • Wylie, TX 75098 • 1-800-233-2155 • www.baycoproducts.com
• A new task light or one that has not been used for a long period of time
may not accept a full charge initially. This is normal and does not indicate a
problem. Fully discharge and then charge the unit several times to
condition the battery pack for full capacity. As the battery pack capacity
increases the charge time shortens.
• Charge the unit after each use, whether the task light is fully discharged or
not.
• Store the task light at room temperature
WARRANTY
PRODUCTS COVERED UNDER THIS LIMITED WARRANTY:
This product is warranted to the original purchaser for 1 year and only covers
failures due to defects in materials or workmanship. If this product is used for
rental purposes, the warranty term is reduced to 90 days from the date of
purchase.
NOT COVERED
The warranty does not cover normal wear and tear or cosmetic damage. The
Limited Warranty also does not cover damages which occurred in shipment or
failures which are caused by accidents, misuse, abuse, faulty installation and
lightning damage. Consequential damages, incidental damages or incidental
expenses, including damage to property. Some states do not allow the
exclusion or limitation of incidental or consequential damages, so the above
limitation or exclusion may not apply to you. This warranty gives you specific
legal rights, which may vary from state to state. This warranty does not apply to
certain Bayco professional products that carry a specific warranty unique to
those products.
WARRANTY CLAIMS - USA
Contact Bayco for USA warranty claims. Call 800-233-2155 and Bayco
Customer Service will provide a Return Goods Authorization (RGA) to facilitate
rapid warranty action. After receiving the RGA, send the product (shipping
prepaid) to BAYCO • 640 S. SANDEN BLVD • WYLIE, TEXAS • 75098. Include
a dated proof of purchase and a brief description of the defect with your name,
address and phone number. Your product will either be repaired or replaced at
the option of Bayco and returned as soon as practical, but no later than 45
days after being received by Bayco.
WARRANTY CLAIMS - CANADA
Return the product to the place where purchased with a dated proof of
purchase and a brief description of the defect with your name, address and
phone number. Your product will either be replaced or purchase price
refunded.
REQUEST FOR WARRANTY ACTION
If you have any questions about this warranty or any other Bayco product
inquiries contact BAYCO • 640 S. SANDEN BLVD • WYLIE, TEXAS • 75098 or
call 800-233-2155