Bayco 8900 Series Operating Instructions

INS-8900-12
Operating Instructions for Model 8900 Series Retractable Reel
Multiple Patents Pending
Electrical Rating - All models use 125 Volts 60 Hz
CAUTION - TO REDUCE THE RISK OF ELECTRIC SHOCK AND FIRE - PULL PLUG
WHEN SERVICING, CONNECTING/DISCONNECTING FROM THE CORD REEL OR
WHEN RE-LAMPING
CAUTION
DO NOT use this cord reel in explosive atmospheres, near flammable liquids, or where
explosion proof lamps are required.
DO NOT use in the proximity of vehicles or equipment when there is a risk of flammable
liquids coming into contact with the hand lamp
DO NOT immerse in water
DO NOT use in areas where water can accumulate or in rain or mist
CAUTION: Risk of Electric Shock – For Light Duty Dry Location Use Only
GENERAL USE CORD REEL ONLY. NOT FOR HARD USE. FOR INDOOR DRY
LOCATION USE ONLY
WARNING: NOT FOR USE ABOVE HAZARDOUS LOCATIONS
CAUTION: DO NOT USE IN HAZARDOUS LOCATIONS AS REQUIRED BY THE
CANADIAN ELECTRICAL CODE, PART I
IMPORTANT SAFETY INSTRUCTIONS
This product has a 3 prong polarized plug on the power cord. Do not attempt to bypass
this safety feature by removing the round plug and defeat his safety feature. This plug will
fit into a grounded outlet only one way. If the plug does not fit fully into the outlet, contact
a qualified electrician. Never use with a two wire extension cord.
CAUTION: PULL OUT CORD TO FULL LENGTH WHEN USING RECEPTACLE
CAUTION: DO NOT ALLOW THE CORD TO RETRACT BY ITSELF AS DAMAGE OR
INJURY MAY OCCUR FROM EXCESSIVE REWIND SPEED
CAUTION: Drywall will not hold the weight of the reel assembly
CAUTION: Read and understand mounting instructions before attempting installation
and use of this product
Thank you for purchasing this Bayco cord reel. Please read these instructions before
using.
OPERATION
To operate, plug into a 120 Volt 60 HZ grounded outlet. For units with 3 or 4 outlets the
LED in the receptacle block lights when power is applied.
FEATURES
The cord on the reel has a polarized 3 prong plug
l
Mounts on ceiling or wall
l
Adjustable cord-stop.
l
Receptacle
Model Wire Gage
Amperage
8903 13 14/3 SJTW
8904
15 12/3 SJTW
8904-40
8906 15 12/3 SJEOW
8907 12 14/3 SJTW
8908 12 14/3 SJTW
MOUNTING INSTRUCTIONS
Ceiling or Wall Installation
1. Select a location within 2 feet of an electrical outlet. The outlet for a garage door
opener is desirable.
2. Remove the knobs holding the mounting bracket to the reel. Locate a ceiling joist
and using the mounting bracket as a template, mark the holes so they are centered
on the ceiling joist.
3. Drywall will not hold the weight of the reel assembly, so locate a ceiling joist or wall
stud and using the mounting bracket as a template, mark the holes so they are
centered on the ceiling joist or stud.
4. Attach the mounting bracket to the stud using the 2 wood screws provided.
5. Align the holes on the side of the reel with the holes in the side of the mounting
bracket and insert the knobs. Tighten knobs securely.
Cord
Length
50 ft 3 outlets
50 ft
4 outlets
40 ft
50 ft 4 outlets
50 ft 13 W Fluorescent
50 ft 26 W Fluorescent
BAYCO • 640 South Sanden Blvd. • Wylie, TX 75098 • 1-800-233-2155 • www.baycoproducts.com
6. Adjust the cord stop to hold the receptacle at the desired length when the cord is
retracted.
SAFETY / CARE
Caution: do not allow the cord to retract by it self as damage or injury may occur from
l
excessive rewind speed.
Adjust the cord stop to hold the receptacle at the desired length when the cord is
l
retracted.
Before cleaning the reel always unplug from the power source.
l
Clean the outside of the cord reel only. Use a soft cloth with mild detergent. Do not
l
use petroleum based to clean the cord reel. Never immerse the cord reel or
receptacles or work lights in water. Dry thoroughly before attempting to reattach to
power source.
WARRANTY
PRODUCTS COVERED UNDER THIS LIMITED WARRANTY:
This product is warranted to the original purchaser for 1 year and only covers failures due
to defects in materials or workmanship. If this product is used for rental purposes, the
warranty term is reduced to 90 days from the date of purchase.
NOT COVERED
The warranty does not cover normal wear and tear or cosmetic damage. The Limited
Warranty also does not cover damages which occurred in shipment or failures which are
caused by accidents, misuse, abuse, faulty installation and lightning damage.