Sealey SS98 Manual

thank you for purchasing a sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
Refer to Wear face
instructions shield
1. safety
1.1. GeNeraL safety
only use the sprayer for its intended purpose.
9
Familiarise yourself with the applications, limitations, and potential hazards of this product.
9
Use original Sealey spare parts only. Unauthorised parts may be dangerous and will invalidate the warranty.
9
ensure containers cannot easily be knocked over during filling.
9
Always ensure good contact on the 12V battery.
9
mark fluid containers with hazard labels to show their contents.
9
Keep any fluid containers in a well ventilated, lockable store, preferably outside the working area.
9
Keep children and unauthorised persons away from the working area, especially when the sprayer is in operation.
9
Keep the work area childproof by using padlocks and master switches.
9
maintain the sprayer in top condition. Keep it clean for best and safest performance.
9
Follow the same precautions when transferring fluid from the sprayer back into other containers.
9
ensure the sprayer is securely fixed to the ATV.
9
Always inspect and prepare the sprayer before use according to the directions provided in this manual.
9
Keep the sprayer turned off. do not turn on power to the sprayer until ready to spray in order to avoid unintentional spray release.
9
never spray when wind speed exceeds 4mph in order to minimize spray drift.
9
do Not over apply pesticide. Apply at a rate recommended by agents manufacturer. excess pesticide can be dangerous to humans,
8
damage desirable plants, and contaminate soil and water sources.
never point the spray gun at people or animals.
8
do Not eat, drink, rub your eyes, or touch any part of your bare skin while handling agents and spraying.
8
do Not spray near open flames or sources of heat.
8
Always clean up spills immediately per instructions on the agent's label.
9
Turn off vehicle and set brake or block wheels, turn off power to sprayer, and relieve system pressure before leaving sprayer
9
unattended.
do Not use an open flame or smoke anywhere near the sprayer or around stored fluid.
8
do Not spray fluid into dedicated workshop oil spray equipment.
8
do Not use any electrical equipment on or near the vehicle while fluid spraying is in progress. This includes the use of inspection
8
lights, mobile phones or pagers.
do Not use the sprayer if the pump is damaged in any way.
8
do Not use whilst under the influence of drugs, alcohol or other intoxicating medication, or if you are fatigued.
8
1.2. eLectricaL coNNectioN safety
If the battery terminals are corroded or dirty, clean them before using the tester.
9
disconnect the power after every use to avoid accidental starting.
9
do Not disassemble the remote switch for any reason. The tester must only be checked by qualified service personnel.
8
WarNiNG! To prevent the risk of sparking, short circuit and possible explosion DO NOT drop metal tools in the battery area, or allow
‰
them to touch the battery terminals.
do Not cross-connect remote switch clamps. ensure positive (Red) clamp is to positive terminal and negative (blAcK) clamp is to
8
negative terminal.
1.3. cHeMicaL safety
1.3.1. First and foremost ensure you read the safety data sheet of the substance you are going to spray.
1.3.2. The sprayer is intended for use in spraying agricultural pesticides and other non-flammable liquids.
1.3.3. Spraying pesticides - Pesticides are hazardous agents that must be handled with caution as directed throughout this manual and
on the pesticide label. The sprayer is intended for use in spraying pesticides in liquid form only. The sprayer is noT intended for use
in spraying pesticides in dry or in aerosol form, or for use with fumigants. Sprayers SS60 and SS98 come equipped with a spot spray
gun and a tank-mounted broadcast spraying system. Use the spot spray gun if you desire to apply pesticide only on selected plants.
Use the broadcast spraying system if you wish to spray large ground areas.
1.3.4. Spraying Other Liquids - In addition to spraying pesticides, this sprayer may be used to spray other non-flammable liquids. Example
uses include: watering plants/trees or spraying water for dust control, applying ice control agents, applying water-based, non-
flammable sealant or stain to outdoor wood surfaces.
1.3.5. However, We Recommend THAT THe SPRAYeR noT be USed FoR oTHeR PURPoSeS once IT HAS AlReAdY been
USed FoR SPRAYInG PeSTIcIdeS. Any agents will leave some residual in the tank liner or sprayer components, even after the
sprayer has been properly cleaned. These residual agents can have unexpected effects on future uses. For example, spraying water
or other liquids that are contaminated with residual pesticide may result in unforeseen hazards to plant or animal life.
© Jack Sealey limited
Broadcast/ spot sprayer
model no:
Wear protective
gloves
Original Language Version
ss98/ss60
SS98/SS60 | Issue 3 (HF) 26/03/18