Advertisement
Quick Links
MajorPower.Com
MAJORCHARGE
Battery Charger
Owner's Manual
GEL, PRO, HD SERIES
6/8/12/16/24/36/48 Volt
Standard Features of all Chargers
Battery Type Switch (BTS)
◊
High energy return, fast charging
◊
Constant current first stage
◊
Dual voltage limit (cyclic/standby)
◊
Proportional timed cyclic charge stage
◊
Constant voltage float standby
◊
Automatic safety override timer
◊
Start delay on battery connect
◊
Short and reverse connector shutdown
◊
Rugged SCR phase control
◊
Mains zero-crossing battery sensing
◊
***CAUTION***
READ THIS MANUAL CAREFULLY
FOR RULES OF SAFE OPERATION
AND PROPER USE OF THE CHARGER
***SAVE THESE INSTRUCTIONS***
http://www.majorpower.com
Advertisement
Summary of Contents for MAJORCHARGE MajorCharge12/25
-
Page 1: Battery Charger
MAJORCHARGE Battery Charger Owner’s Manual GEL, PRO, HD SERIES 6/8/12/16/24/36/48 Volt Standard Features of all Chargers Battery Type Switch (BTS) ◊ High energy return, fast charging ◊ Constant current first stage ◊ Dual voltage limit (cyclic/standby) ◊ Proportional timed cyclic charge stage ◊... - Page 2 12”L x 7”W x 7”H 6”L x 6.5”W x 5.25”H Model Input Output Model Input Output MajorCharge12/25 117VAC, 60Hz, 480VA 12VDC, 25A MajorCharge12/5 117VAC, 60Hz, 110VA 12VDC, 5A MajorCharge24/25 117VAC, 60Hz, 850VA 24VDC, 25A MajorCharge12/10 117VAC, 60Hz, 220VA 12VDC, 10A...
- Page 3 6/12/24 Volt SAVE THESE INSTRUCTIONS – This manual DIMENSIONS contains important safety and operating instructions. • 6”L x 6.5”W x 5.25”H 2. Before using this battery charger, read all instructions and cautionary markings on (1) the battery charger, (2) the battery, (3) product using Model Input Output...
- Page 4 1. If necessary to remove battery from vehicle to WORKING IN VICINITY OF A LEAD-ACID charge, always remove grounded terminal from battery first. Make sure all accessories in vehicle BATTERY IS DANGEROUS. BATTERIES are off so as not to cause an arc. GENERATE EXPLOSIVE GASES DURING 2.
- Page 5 FOLLOW THESE STEPS WHEN BATTERY IS INSTALLED IN VEHICLE. A SPARK NEAR THE BATTERY MAY CAUSE BATTERY EXPLOSION. Charger should be grounded to reduce risk or electrical shock. Charger is equipped with an electrical 1. Carefully position AC and DC cords to reduce risk cord having an equipment grounding conductor and a of damage by hood, door or moving engine parts.
-
Page 6: Special Note
1. Disconnect vehicle battery cables. 1. Disconnect vehicle battery cables. 2. Connect charger to battery. Ensure correct 2. Connect charger to battery. Ensure correct polarity. BLACK lead to negative (-) terminal and polarity. BLACK lead to NEGATIVE (-) terminal RED lead to POSITIVE (+) terminal. and RED lead to POSITIVE (+) terminal. - Page 7 2. Two or more 12 Volt batteries may be bank charged with the (1) charger if they are connected in parallel as shown in Figure 2.2. YELLOW CHARGE LIGHT DOES NOT SWITCH ON: The charger will not commence charging unless properly connected.
- Page 8 BATTERY CHARGER LIMITED WARRANTY MajorPower.Com warrants the accompanying battery charger (the “UNIT”) to be free from defects in materials and workmanship for a period of 12 months from the date of purchase. In addition, the manufacturer warrants the transformer for a period of two years. This warranty applies to normal and non-commercial use and is subject to the terms and conditions given below.