Page 1
MDX-C8900R 3 7 63 1515 0 SERVICE MANUAL AEP Model UK Model Model Name Using Similar Mechanism MDX-C7900R Base Mechanism Type MG-164KE-138 Optical Pick-Up Name KMS-241B/J2N SPECIFICATIONS L 13942296513 FM/MW/LW MINIDISC PLAYER u163 MICROFILM http://www.xiaoyu163.com...
Page 2
LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB- LISHED BY SONY.
http://www.xiaoyu163.com 3 7 63 1515 0 TABLE OF CONTENTS GENERAL ELECTRICAL ADJUSTMENTS Location of Controls ............4 Test Mode ................ 25 MD Section ..............25 Resetting the Unit ............5 Detaching the Front Panel ..........5 Tuner Section ..............25 Preparing the Rotary Commander ........
http://www.xiaoyu163.com SECTION 1 This section is extracted from instruction manual. GENERAL 3 7 63 1515 0 L 13942296513 u163 – 4 – http://www.xiaoyu163.com...
http://www.xiaoyu163.com SECTION 2 DISASSEMBLY 3 7 63 1515 0 Note: Follow the disassembly procedure in the numerical order given. SUB PANEL ASS’Y 2 two claws 4 sub panel ass’y 1 three screws (PTT2.6 × 6) 2 claw 3 connector 1 screw (CN701) (PTT2.6 ×...
Page 21
http://www.xiaoyu163.com 3 7 63 1515 0 AUDIO BOARD 4 AUDIO board 1 two screws (PTT2.6 × 10) 2 Bend two claws of bracket (AUDIO) in the direction of arrows. 3 connector (CN803) bracket (AUDIO) L 13942296513 SERVO BOARD 3 two screws (BVTT2 ×...
Page 22
http://www.xiaoyu163.com 3 7 63 1515 0 MAIN BOARD 6 six screws (PTT2.6 × 10) 1 two screws (PTT2.6 × 10) 3 shield plate (2) 2 three ground point screws 7 Remove the heat sink in the direction of the arrow. 4 MAIN board 5 insulating sheet L 13942296513...
Page 23
http://www.xiaoyu163.com 3 7 63 1515 0 HOLDER ASS’Y 5 holder ass’y 4 washer (M) 1 spring (CHKG) 2 stop ring E (1.5) 3 lever (lock R) 1 spring (CHKG) 3 lever (lock L) 2 stop ring E (1.5) L 13942296513 OPTICAL PICK-UP (KMS-241B/J2N) 4 screw (B2 ×...
Page 24
http://www.xiaoyu163.com 3 7 63 1515 0 MOTOR ASS’Y (M901, M902, M903), SENSOR BOARD 4 screw (P1.7 × 1.8) 9 two screws (P1.7 × 1.8) 5 bracket (SL) 2 two screws (2 × 8) 0 spindle motor 6 sled motor ass’y ass’y (M901) (M902) 3 sensor board...
http://www.xiaoyu163.com SECTION 3 ELECTRICAL ADJUSTMENTS 3 7 63 1515 0 TEST MODE TUNER SECTION 0 dB=1µV This set have the test mode function. In the test mode, FM Auto Scan/Stop Level and MW Auto Scan/Stop Level adjustments can Cautions during repair be performed easier than it in ordinary procedure.
Page 26
http://www.xiaoyu163.com 3 7 63 1515 0 FM Stereo Separation Adjustment (Wide) FM Stereo Separation Adjustment (Narrow) Setting: Setting: [SOURCE] [SOURCE] button : FM button : FM FM RF signal FM RF signal level meter level meter antenna jack (CN1) antenna jack (CN1) generator generator 0.01 µ...
Page 27
http://www.xiaoyu163.com 3 7 63 1515 0 FM RDS S-Meter Adjustment MW Auto Scan/Stop Level Adjustment Setting: Setting: [SOURCE] [SOURCE] [MODE] button : FM button : MW FM RF signal 30 Ω 15 pF generator antenna jack (CN1) 65 pF 0.01 µ F AM RF signal generator Carrier frequency...
Page 28
http://www.xiaoyu163.com 3 7 63 1515 0 Adjustment Location: – SET UPPER VIEW – RV1 MW Auto Scan/Stop Level Adjustment RV2 FM Auto Scan/Stop Level Adjustment RV3 FM Stereo Separation Adjustment (Wide) RV4 FM Stereo Separation Adjustment (Narrow) RV1 FM RDS S-Meter Adjustment L 13942296513 Front u163...
http://www.xiaoyu163.com 3 7 63 1515 0 4-6. NOTES FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS Note on Schematic Diagram: Note on Printed Wiring Board: • X : parts extracted from the component side. • All capacitors are in µF unless otherwise noted. pF: µµF •...
MDX-C8900R • Voltages and waveforms are dc with respect to Note: The components identified by mark ! or dotted line ground in playback mode. with mark ! are critical for safety. no mark : MD Replace only with part number specified.
MDX-C8900R • Voltages and waveforms are dc with respect to ground in playback mode. no mark : MD 4-10. SCHEMATIC DIAGRAM – SERVO Section (3/3) – • See page 72 for Waveforms. ∗ 3 7 6 3 1 5 1 5 0...
Page 56
http://www.xiaoyu163.com 3 7 63 1515 0 IC303 BH6511FS-E2 INTERFACE INTERFACE CHARGE PREDRIVE PREDRIVE PUMP. PREDRIVE PREDRIVE INTERFACE INTERFACE IC305 BA6287F OUT1 L 13942296513 OUT2 DRIVER DRIVER VREF CONTROL LOGIC POWER SAVE IC307 MSM51V4400-70TS-K CLOCK OSC XRAS XCAS A0–A9 COLUMN DECODER SENSE REFRESH AMP INPUT/OUTPUT CONTROL SWITCH A0–A9...
Page 57
http://www.xiaoyu163.com 3 7 63 1515 0 – MAIN Board – IC4 BU2624FV-E2 IC101 NJM2360AM (TE2) XOUT 8 CD PHASE 7 SI REFERENCE 6 V+ CT OSC DIVIDER FMIN MAIN PRESCALER VREF COUNT 5 INVIN 1.25V – COMP SHIFT REGISTER LATCH AMIN IF COUNT 20BIT COUNT...
Page 58
http://www.xiaoyu163.com 3 7 63 1515 0 IC403 CXA1846AN-T4 IC504 BA8270F-E2 BUS ON BUS ON SWITCH RESET SWITCH – BUS ON 8dB STEP 1dB STEP VOLUME VOLUME CLK IN BATTERY BATT BU IN SWITCH LATCH BUFFER LATCH CONTROL VREF DATA DATA IN SHIFT DATA OUT REGISTER...
Page 59
http://www.xiaoyu163.com 3 7 63 1515 0 IC702 MSM6585JSDR1 TEST TIMING RS/A REFRESH TIMER RWCK GENERATOR RFSH TEST TEST REFRESH ADDRESS 8,388,608DATA COUNTER REGISTER TEST TEST ROW ADDRESS COLUMN DECODER COUNTER ROW ADDRESS REGISTER COLUMN ADDRESS COUNTER WRITE CLOCK GENERATOR DOUT IC703 MSM6688GS-2K L 13942296513 TIMING...
Page 60
http://www.xiaoyu163.com 3 7 63 1515 0 – AUDIO Board – IC901 RSC-164 PORT 0 INTERNAL ROM 32 X 8 (HIGH) BUFFER INTERNAL ROM 32 X 8 (LOW) REGISTER STACK SPACE SPACE ANALOG CONTROL INTERNAL BUS AIN1 AIN0 AGND PULSE WIDTH INTERRUPT BUFOUT/PWM0 MODULATOR...
http://www.xiaoyu163.com 3 7 63 1515 0 4-23. IC PIN FUNCTION DESCRIPTION • SERVO BOARD IC301 CXD2652AR (DIGITAL SIGNAL PROCESSOR, DIGITAL SERVO PROCESSOR, EFM/ACIRC ENCODER/DECODER, SHOCK PROOF MEMORY CONTROLLER, ATRAC ENCODER/DECODER, 2M BIT D-RAM) Pin No. Pin Name Function Focus OK signal output to the MD mechanism controller (IC501) MNT0 “H”...
Page 62
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Function DVSS — Ground terminal (digital system) Output enable signal output to the D-RAM (IC307) “L” active XCAS Column address strobe signal output to the D-RAM (IC307) “L” active Address signal output to the D-RAM (IC307) XRAS Row address strobe signal output to the D-RAM (IC307) “L”...
Page 63
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Function DVDD — Power supply terminal (+3.3V) (digital system) FFDR Focus servo drive PWM signal (+) output to the BH6511FS (IC303) FRDR Focus servo drive PWM signal (–) output to the BH6511FS (IC303) Clock signal (176.4 kHz) output terminal (X’tal system) Not used (open) SRDR Sled servo drive PWM signal (–) output to the BH6511FS (IC303)
Page 64
http://www.xiaoyu163.com 3 7 63 1515 0 • SERVO BOARD IC302 CXA2523R (RF AMP, FOCUS/TRACKING ERROR AMP) Pin No. Pin Name Function I-V converted RF signal I input from the optical pick-up block detector I-V converted RF signal J input from the optical pick-up block detector Middle point voltage (+1.65V) generation output terminal 4 to 9 A to F...
Page 65
Bus on/off control signal output to the MD mechanism controller (IC501) and SONY bus BUS-ON interface (IC504) “L”: bus on Reset signal output to the MD mechanism controller (IC501) and SONY bus interface (IC504) “ L 13942296513 SYSRST L”: reset DOORSW Front panel open/close detection signal input “L”...
Page 66
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Function TIR-IND LED drive signal output of the TIR indicator (LED701) “H”: LED on LCDINH Blank indicate control signal output to the liquid crystal display driver (IC900) “L”: no display —...
Page 67
Input of acknowledge signal for the key entry Acknowledge signal is input to accept function KEYACK and eject keys in the power off status On at input of “H” Battery detect signal input from the SONY bus interface (IC504) and battery detect circuit BU-IN “L” is input at low voltage...
Page 68
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Function Not used (open) LINKOFF Not used (pull down) Not used (open) Not used (open) Not used (pull down) Not used (open) Not used (open) CSV-NAR “H” is input when RS-164 (IC901) sends data Illumination LED drive signal output terminal “H”: LED on LED-ON Also, power amp (IC600) standby on/off control is executed “L”: standby, “H”: amp on...
Page 69
Two way data bus with the external EEPROM device Not used (open) MD-SO Writing serial data signal output to the CXD2652AR (IC301) and CXA2523R (IC302) Unilink on/off control signal output to the SONY bus interface (IC504) LINKOFF “H”: link off, “L”: link on –...
Page 70
Pin No. Pin Name Function UNIREQ Data request signal output terminal (for SONY bus) “H”: request on Not used (open) UNICKI Serial data transfer clock signal input from the master controller (IC500) (for SONY bus) UNISI Serial data input from the SONY bus interface (IC504)
http://www.xiaoyu163.com SECTION 5 EXPLODED VIEWS 3 7 63 1515 0 NOTE: • Items marked “*” are not stocked since they • -XX and -X mean standardized parts, so they The components identified by mark ! or dotted line with mark may have some difference from the original are seldom required for routine service.
Page 72
http://www.xiaoyu163.com 3 7 63 1515 0 (2) FRONT PANEL SECTION not supplied (KEY board) not supplied not supplied EL900 L 13942296513 LCD900 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark X-3375-960-1 PANEL SUB ASSY, FRONT * 63 3-022-327-01 PLATE (LCD), GROUND 3-022-332-01 BUTTON (10 KEY) 1-694-414-11 CONDUCTOR BOARD, CONNENTION...
Page 73
http://www.xiaoyu163.com 3 7 63 1515 0 (3) MECHANISM DECK SECTION-1 (MG-164KE-138) L 13942296513 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark * 101 A-3317-122-A SERVO BOARD, COMPLE * 110 3-919-280-01 LEVER (LOCK R) * 102 X-3369-440-1 CHASSIS ASSY, MD 3-919-281-01 SPRING (CHKG) 3-919-296-01 SPRING (FL), TENSION * 112...
Page 74
http://www.xiaoyu163.com 3 7 63 1515 0 (4) MECHANISM DECK SECTION-2 (MG-164KE-138) 168 167 M903 M901 L 13942296513 M902 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part num- ber specified. Ref.
Page 75
http://www.xiaoyu163.com SECTION 6 AUDIO 3 7 63 1515 0 ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in the • Items marked “*” are not stocked since they The components identified by mark ! or dotted line with mark parts list may be different from the parts speci- are seldom required for routine service.
Page 76
http://www.xiaoyu163.com AUDIO 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R916 1-216-821-11 METAL CHIP 1/16W < CONNECTOR > R917 1-216-830-11 METAL CHIP 5.6K 1/16W R918 1-216-833-11 METAL CHIP 1/16W CN900 1-778-183-11 PLUG, CONNECTOR 18P R919 1-218-727-11 METAL CHIP 0.5%...
Page 77
http://www.xiaoyu163.com MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < RESISTOR > A-3294-510-A MAIN BOARD, COMPLETE (AEP, UK) A-3294-513-A MAIN BOARD, COMPLETE (German) R901 1-216-045-00 METAL CHIP 1/10W ********************* R902 1-216-045-00 METAL CHIP 1/10W R903...