Ace 73-100 Instruction & Maintenance Manual

ACE INDUSTRIAL PRODUCTS
PORTABLE AIR CLEANER
MODEL 73-200,
INSTRUCTION & MAINTENANCE MANUAL
CAUTION: This devlce rs powered by rotat ng electrica machineryll Careless or mproper use may resu t n
personal inJury Read the Safety PrecaLrlrons
and Warnings conlained withrn pllqr lo operaling this mach ne
READ AND SAVE THESE INSTRUCTIONS.
CAUTION: (AIRFLOW BLOCKAGE)
Srnce exhaust air leaves the bottom of thrs unrl
cautron should be observed not to set un down n
slch a way as to block the exhaust.
MISCELLANEOUS CAUTIONS:
1 Use of any attachment not recomrnended or
sold by the a r cieaner manufacturer may resLilt
rl 'sL or f re ere(rr- shoct or InJLrry ro op'sor s
2
To reduce the nsk of damage to the electrc plug
or cord. d sconnecl by pulling plLrg ralher ihan
cord when remov ng power from the a r cleaner
3 lrake sure cord and hose are located so thev
w I not be stepped on, tfpped over or otlrerwrse
subjected to damage or stress
4
An e^lens on coro shou d not be used J. ...
abso utely necessary Use of rmproper
extensron cord co|1ld result ln risk of fLre and
electrc shock lf extension cord musl be used
use only a grounded cord and follow lhese
recommendations
25 fr #14 AWG.
50 ft #12 AWG
100 fl #10 AWG
5. Do not disassemble the air cleaner. Take rt to a
qJa rl ed se.v'cenon when seryrce oI teoa I .
requ red. Incorrect reassembly may resuli In rsk
of electric shock or fire.
6. To reduce lhe rsk of electric shock or bodiy
Inlury. unplug the air cleaner from outlet before
atiempting any maintenance or cleaning.
T!rnLng off the power switch will not elirninaie
this nsk
SAFETY WARNINGS A CAUTIONS
FA]LURE TO OBSERVE THE FOLLOWING
PRECAUTIONS COULD RESULT IN SERIOUS
INJURY INCLUDING DEATH IN FXTRFI\,IF
CASES SAVE THESE INSTRUCTIONS
wARNING: (EXPLOSION HMARD)
This unrt contains unrversal motors, whrch spark
dur ng normal operahon Do not use n areas
orrsn'naled b) volrl
'e
o 'lanmablp nar-'als as
these spafks may gn ie the contaminaies and cause
a oangerous expros on
WARNING: (HARMFUL FUMES)
The filiers used in th s unit wrll remove so rd
pa.ljculare ONLY. a_d do _ot e'i.l i.ale f-nes and
gases thai rnay be a health hazard Farlure to
observe the presence of such fumes could cause
sefous illness ofdeath
CAUTION: (SHOCK HAZARD)
To insure continued protection against shocK
hazard, connect AC cord only to properly grounded
outlels Replace defective cords immed aiely Do
not expose to morsture or |quid as thrs could deieat
the electrrcal lnsulation thus causing electrical
CAUTION: (STRONG VACUUM)
Care must be taken to avod personal injury by nol
allowing hose inlet to contact any body area such as
eyes. ears, mouth, etc.
CAUTION: (LIFTING)
Although this unit weighs less than 40 lbs with
filters, rmproper lifting or handling of thls unit co!ld
cause back injury. Follow the recommended
nerhod for litrng