Table of Contents
Advertisement
• Hot! Do not touch! The glass and
surfaces of this appliance will be hot
during operation and will retain heat
for a while after shutting off the appli-
ance. Severe burns may result.
• Carefully supervise children in the
same room as appliance.
• If small children are present in the home, it is
recommended that this appliance be fitted with
a screen door or screen panel kit. See Page 12
for ordering information.
WARNING: IF THE INFORMATION IN THIS MANUAL
IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-
SION MAY RESULT CAUSING PROPERTY DAM-
AGE, PERSONAL INJURY OR LOSS OF LIFE.
FOR YOUR SAFETY: Do not store or use gasoline
or other flammable vapors or liquids in the vicin-
ity of this or any other appliance.
FOR YOUR SAFETY: What to do if you smell gas:
• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• DO NOT use any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone.
Follow your gas suppliers instructions.
• If your gas supplier cannot be reached, call the
fire department.
Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
A French manual is available upon request. Order Form Number
875,014CF.
Ce manuel d'installation est disponible en francais, simplement en
faire la demande. Numéro de la pièce 875,014CF.
WARNINGS
OTL Report No. 116-F-13-4
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
HOMEOWNER'S CARE AND
OPERATION INSTRUCTIONS
DIRECT-VENT
MPD-33/35/40/45 SERIES
VENTED GAS FIREPLACE HEATERS - DIRECT VENT MODELS
P/N 875,014M REV. K 03/2007
MODELS
M
l i
v i l
t l o
M
o
e d
s l
M
P
D
T
3 -
2 3
C 8
N
M
M
P
D
4 -
3 0
M
P
D
T
3 -
2 3
C 8
P
M
M
P
D
4 -
3 0
M
P
D
R
3 -
2 3
C 8
N
M
M
P
D
4 -
4 5
M
P
D
R
3 -
2 3
C 8
P
M
M
P
D
4 -
4 5
M
P
D
3 -
3 5
C 0
N
M
M
P
D
3 -
3 5
C 0
P
M
RETAIN THESE INSTRUCTIONS
FOR FUTURE REFERENCE
AVERTISSEMENT: ASSUREZ-VOUS DE BIEN SUIVRE
LES INSTRUCTIONS DONNÉ DANS CETTE NOTICE POUR
RÉDUIRE AU MINIMUM LE RISQUE D'INCENDIE OU
POUR ÉVITER TOUT DOMMAGE MATÉRIEL, TOUTE
BLESSURE OU LA MORT.
POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser
d'essence ni d'autre vapeurs ou liquides inflammables
dans le voisinage de cet appareil ou de tout autre
appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une
odeur de gaz:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où
vous vous trouvez.
• Evacuez la piéce, le bâtiment ou la zone.
• Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installeur, agence de service ou le fournisseur de gaz.
E
e l
r t c
n o
c i
M
C 5
N
M
M
P
D
T
3 -
2 3
C 8
N
E
M
P
C 5
P
M
M
P
D
T
3 -
2 3
C 8
E P
M
P
C 0
N
M
M
P
D
R
3 -
2 3
C 8
N
E
M
P
C 0
P
M
M
P
D
R
3 -
2 3
C 8
E P
M
P
M
P
D
3 -
3 5
C 0
N
E
M
P
D
3 -
3 5
C 0
E P
o
e d
s l
D
4 -
3 0
C 5
N
E
D
4 -
3 0
C 5
E P
D
4 -
4 5
C 0
N
E
D
4 -
4 5
C 0
E P
1
Advertisement
Table of Contents
Troubleshooting
Related Manuals for Lennox MPDR-3328CPE
Summary of Contents for Lennox MPDR-3328CPE
-
Page 1: Operation Instructions
HOMEOWNER'S CARE AND OPERATION INSTRUCTIONS DIRECT-VENT MPD-33/35/40/45 SERIES WARNINGS VENTED GAS FIREPLACE HEATERS - DIRECT VENT MODELS • Hot! Do not touch! The glass and P/N 875,014M REV. K 03/2007 surfaces of this appliance will be hot during operation and will retain heat MODELS for a while after shutting off the appli- ance. -
Page 2: Table Of Contents
CONGRATULATIONS! WARNING: ELECTRONIC MODELS OF THESE APPLIANCES ARE EQUIPPED In selecting this LENNOX Direct-Vent Gas Appliance you have chosen the finest and most WITH A THREE-PRONG (GROUNDING) dependable fireplace to be found anywhere. A beautiful, prestigious, alternative to a PLUG UTILIZED IN CONNECTING THE wood burning fireplace. -
Page 3: Operation/Care Of Your Appliance
Minimum inlet gas pressure to these appliances i l l WARNING: DO NOT PLACE CLOTH- is 5.0 inches water column (1.24 kPa) for natural ING OR OTHER FLAMMABLE MATERI- gas and 11 inches water column (2.74 kPa) for ALS ON OR NEAR THIS APPLIANCE. propane for the purpose of input adjustment. -
Page 4: Variable Flame Adjustment
See Figure 2 (SIT), 3 (Honeywell) for the location of the piezo ignitor. Variable Flame Height Adjustment Inlet Pressure Port Manifold Pressure Port Millivolt appliances may be fitted with an optional burner ON/OFF Rocker Switch. The optional ON/ OFF Rocker switch will be installed in the bracket just beneath the gas control valve. -
Page 5: Maintenance Schedule
Maintenance Schedule Annually (Before the onset of the Burning Season) Maintenance Task Accomplishing Person Procedure Inspecting/Cleaning Burner, Logs Qualified Service Technician Inspect valve and ensure it is properly operating. and Controls Check piping for leaks. Vacuum the control compartment, fireplace logs and burner area. Check Flame Patterns and Flame Height Qualified Service Technician Refer to Figure 7 (MPD-3328), 8 (MPD-3530) -
Page 6: Maintenance
PLACEMENT PANELS ARE AVAILABLE with air shutter openings that are too large will 3. Locate the two (2) latches at the top of the THROUGH YOUR LOCAL LENNOX exhibit flames that are blue and transparent. control compartment and disengage them from... -
Page 7: Adjustment
Sooting is indicated by black puffs developing Propane models may exhibit a flame pattern WARNING: THIS APPLIANCE IS NOT at the tips of very long orange flames. Sooting that may candle or appear stringy. If this is MEANT TO BURN WOOD. ANY AT- results in black deposits forming on the logs, problematic or persists as the appliance is TEMPT TO DO SO COULD CAUSE IR-... -
Page 8: Electronic Appliance Checkout
If you should experience any problem, first refer to the trouble shooting guide in this manual. If problem persists, contact your Lennox distributor. Figure 9 MPD-4035 AND MPD-4540 MODEL NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. -
Page 9: Wiring Diagrams
We recommend that you record the following important information about your fireplace. Please contact your Lennox dealer for any questions or concerns. For the number of your nearest Lennox A complete parts list is found at the end of this dealer, please call 1-800-9-LENNOX manual. - Page 10 NOTES: NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
-
Page 11: Accessory Components
ACCESSORY COMPONENTS Forced Air Blower Kits -Single Speed 80L84 FBK-100 Remote Control System (Standard) H0249 Remote Control System (Deluxe) H0251 RCL-T -Variable Speed with wall-mountable switch 80L85 FBK-200 Deluxe Remote Control System Standard Remote Control System -Variable Speed with unit- or wall-mountable switch 80L86 FBK-250 The Model RCL-T (Deluxe) Remote Control... - Page 12 ACCESSORY COMPONENTS CONTINUED The kits attach to the glass enclosure panel without the use of hardware. The decorative arch kits can not be used in conjunction with the screen panel kit. s t i l a t s t i These screen panels can be installed on the s t i glass enclosure panel to prevent direct contact...
- Page 13 ACCESSORY COMPONENTS CONTINUED s t i s t i s t i These louvers are designed to replace either the These hood kits replace the standard hood that middle charcoal louver of each louver set or the comes with these fireplaces. charcoal louver in each set closest to the glass Clean faced panel kits are available to convert enclosure panel.
- Page 14 ACCESSORY COMPONENTS CONTINUED Style View Doors - Style View Doors come in 4 beautiful styles. They are easy to install and will not require hardware to attach them to the standard glass door frame. The door includes heavy duty magnet door latches and functional twin-pane doors. Arch Design Square Design Square Pane Design...
- Page 15 ACCESSORY COMPONENTS CONTINUED Style View Doors Continued - Style View Doors also come in a Tall Arch Pane Design. Two distinctive grille kits, the “Crescents” and “Sunrise” design, are also offered seperately. They are easy to install and will not require hardware to attach them to the standard glass door frame.
-
Page 16: Lighting Instructions - Millivolt
LIGHTING INSTRUCTIONS – HONEYWELL AND SIT MILLIVOLT GAS VALVE FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A. This appliance has a pilot which must be lighted with a piezo •... - Page 17 INSTRUCTIONS D’ALLUMAGE – VANNE GAZ MILLIVOLT HONEYWELL ET SIT POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT : SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS À LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MATÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. A.
-
Page 18: Lighting Instructions - Electronic
LIGHTING INSTRUCTIONS — ELECTRONIC FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A. When lighting the appliance, follow these instructions •... - Page 19 INSTRUCTIONS D’ALLUMAGE — ELECTRONIC POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT: SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS À LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MATÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. A.
-
Page 20: Troubleshooting Guide - Millivolt
TROUBLESHOOTING THE MILLIVOLT GAS CONTROL SYSTEM Note: Before troubleshooting the gas control system, be sure external gas shut off valve (located at gas supply inlet) is in the “ON” position. Important: Valve system troubleshooting should only be accomplished by a qualified service technician. POSSIBLE CAUSES SYMPTOM CORRECTIVE ACTION... -
Page 21: Troubleshooting Guide - Electronic
TROUBLESHOOTING THE ELECTRONIC IGNITION SYSTEM ote: Before troubleshooting, be sure that the appliance main line gas shut-off valve, the gas control valve and the wall switch are in the “ON” position. Important: Valve system troubleshooting should only be accomplished by a qualified service technician. SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION... -
Page 22: Replacement Parts List
REPLACEMENT PARTS LIST r i F – – – – – – – – , y l , y l , e r t e l c i t t e l c i f c i f i t a e t i GAS CONTROLS —... - Page 23 REPLACEMENT PARTS 40/45 40/45 33/35 33/35 40/45 33/35 (REF) NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
- Page 24 Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. Printed in U.S.A. © 2002 by Lennox Hearth Products P/N 875,014M REV.