Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for American Standard QR031
Summary of Contents for American Standard QR031
- Page 1 SKU: QR031 Owner’s Manual Stainless Steel Chimney Range Hood THANK YOU for selecting American Standard… the benchmark of fine quality for over 100 years. To ensure that your installation proceeds smoothly, please read these instructions carefully before you begin.
-
Page 2: Table Of Contents
Table of Contents Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Operation . - Page 3 Safety Information Cooking Safety Information WARNING: To reduce the risk of fire, use only metal duct 1 . Never leave the range hood unattended when in use . work . Never use plastic duct work . 2 . Never cook over open flames under the range hood . WARNING: To reduce the risk of fire or electric shock, do 3 .
-
Page 4: Warranty
Warranty ONE YEAR LIMITED WARRANTY A thorough inspection must be made before installation and any damage must be promptly reported . We will not be liable for failures or damage that could have been discovered or avoided by proper inspection and testing prior to installation . Conglom Kitchen &... -
Page 5: Pre-Installation
Pre-Installation TOOLS REQUIRED Measuring tape Level Utility knife Adjustable Marker or pencil Duct tape wrench Electric drill Flathead Phillips screwdriver or powered screwdriver screwdriver Safety goggles Safety gloves HARDWARE INCLUDED NOTE: Hardware not shown to actual size . Part Description Quantity Toggle Bolt M5 x 16 mm Screw / Washer... -
Page 6: Package Contents
Pre-Installation (continued) PACKAGE CONTENTS Part Description Quantity Range hood (including pre-installed controls, lights, blower, baffle filters and damper) Lower chimney Upper chimney Hood bracket Chimney support bracket... -
Page 7: Planning Installation
Pre-Installation (continued) PLANNING INSTALLATION WARNING: Always wear safety goggles and gloves Number of people required: 2 or more during installation . Carefully check the range hood for damage and for missing parts prior to installation . If there is any damage or if you are missing parts, NOTE: Do not remove the plastic covering on the chimney do not proceed with the installation . - Page 8 Pre-Installation (continued) 6 . Adjust old duct work or install new duct work, as necessary, by following these guidelines: - Your venting system must vent to the outdoors either horizontally through the back wall (4) or vertically through the roof (5) . - A straight, short duct run will allow the hood to perform most efficiently .
- Page 9 Pre-Installation (continued) WIRING CONNECTION REQUIREMENTS Risk of electrical shock . This range hood DANGER: Installation work and electrical wiring must be done by a qualified must be properly grounded . person(s) in accordance with all applicable codes and standards, including fire-rated construction . DANGER: Turn off the power circuit breaker or the OBSERVE ALL GOVERNING CODES AND ORDINANCES WARNINGS power switch on the junction box before installing this...
-
Page 10: Installation
Installation Drilling the pilot holes - Draw a vertical line (1) on the supporting wall up to the ceiling, or as high as practical, at the center of the area in which the hood will be installed . - Draw a horizontal line (2) at 18 in . (458 mm) above an electric stove or 29 .5 in . - Page 11 Installation (continued) Installing the damper (if necessary) Ceiling 0.8 in. (20 mm) WARNING: Sharp edges . Wear safety gloves . 5.36 in. (136 mm) CAUTION: Be very careful when installing the damper . Applying too much force or bending the damper too much 11.2 in.
-
Page 12: Installing The Chimney
Installation (continued) Installing the chimney WARNING: Sharp edges . Wear safety gloves . CAUTION: Minimize movement of the chimney extensions to avoid scratches . - Remove the plastic covering on the chimney extensions (B,C) and place them on the floor . - Lower the upper chimney (C) onto the lower chimney (B) . -
Page 13: Operation
Operation There are four buttons, ON/OFF, SPEED, LIGHT and CLOCK SETUP . The center screen will show the clock (12 hour) . Turning ON/OFF the unit Delay shut off function - Press (5) to turn on the power . - While the fan is working, press (5) once, the fan and lights When you turn the power on, the unit starts working in will automatically turn off after 2 minutes . -
Page 14: Maintenance
Maintenance DANGER: Turn off the power circuit breaker or the power switch on the junction box before performing maintenance . Touching circuitry inside the range hood while it is energized will result in death or serious injury . WARNING: Failure to replace worn out or damaged filters will increase the risk of fire . -
Page 15: Care And Cleaning
Care and Cleaning RANGE HOOD WARNING: Failure to maintain basic standards of care and cleaning of the range hood will increase the risk of fire . The range hood should be cleaned (regularly internally and externally) to preserve its appearance and performance . Do Not: - Always clean in the direction of the grain (original - Do not use corrosive or abrasive detergents, steel... -
Page 16: Troubleshooting
Troubleshooting DANGER: Turn off the power circuit breaker or the power switch on the junction box before performing maintenance . Touching circuitry inside the range hood while it is energized will result in death or serious injury . Problem Solution The range hood will not operate . -
Page 17: Specifications
LCD Screen 1.5A lock base light bulb 10.2 in. (260 mm) H QR031 Lower Chimney 8.74 in. W x 8.82 in D x 24.02 in H (222 mm W x 224 mm D x 610 mm H) Upper Chimney 8.66 in. W x 8.74 in D x 24.02 in H (220 mm W x 222 mm D x 610 mm H) -
Page 18: Service Parts
Service Parts If you are missing parts or if you require replacement parts, please call our customer service team at 1-877-333-0098 (8:30 a .m .– 5 p .m ., EST, Monday–Friday) . Identify the required part(s) and have the part description(s) ready . Part Description Code Quantity... - Page 19 Questions, problems, missing parts? Before returning to the store, call Customer Service 8:30 a.m.– 5 p.m., EST. Monday–Friday 1-877-333-0098 CONGLOM .COM Retain this manual for future use.