1. Manuals
  2. Brands
  3. Spirit Manuals
  4. Motorhomes
  5. 29B
  6. Owner's manual

Spirit 29B Owner's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
About this Manual ............................................................................................................................ 1-1
Safety Messages Used in this Manual .............................................................................................. 1-1
Pre-Delivery Inspection .................................................................................................................... 1-2
Front Axle Tire Alignment ............................................................................................................... 1-2
Service and Assistance ...................................................................................................................... 1-2
Reporting Safety Defects .................................................................................................................. 1-2
Vehicle Certification Label ............................................................................................................... 1-3
specifications and Capacitites ........................................................................................................... 1-4
Owner and Vehicle Information ....................................................................................................... 1-6
2008 New Vehicle Limited Warranty ............................................................................................... 1-7
General Warnings ............................................................................................................................. 2-1
Driving Safety ................................................................................................................................... 2-1
Fuel and LP Gas ................................................................................................................................ 2-1
LP Gas Leaks .................................................................................................................................... 2-2
Propane Gas Leak Detector .............................................................................................................. 2-2
Carbon Monoxide Warning .............................................................................................................. 2-3
Carbon Monoxide Alarm .................................................................................................................. 2-3
Smoke Alarm .................................................................................................................................... 2-4
Fire Extinguisher ............................................................................................................................... 2-5
Electrical ........................................................................................................................................... 2-5
Loading ............................................................................................................................................. 2-5
Maintenance ...................................................................................................................................... 2-6
Emergency Exits ............................................................................................................................... 2-6
Formaldehyde Information ............................................................................................................... 2-7
Mold, Moisture and Your Motor Home ............................................................................................ 2-7
Roadside Emergency ........................................................................................................................ 2-8
Jump Starting .................................................................................................................................... 2-9
Engine Overheat ............................................................................................................................. 2-10
Seats - Driver/Co-Pilot ..................................................................................................................... 3-1
Fold-Down Dinette Seat ................................................................................................................... 3-1
Seat Belts .......................................................................................................................................... 3-1
Child Restraints ................................................................................................................................. 3-2
Keys .................................................................................................................................................. 3-3
Key One Lock System ...................................................................................................................... 3-3
Hazard Warning Flashers .................................................................................................................. 3-3
Mirrors - Power sideview Exterior ................................................................................................... 3-3
Rearview Monitor System ................................................................................................................ 3-4
Rev. 0820090622
Copyright 2007 Winnebago Industries, Inc. All Rights Reserved.

TABLE OF CONTENTS

Part No. 161500-08-004

Advertisement

Table of Contents
loading

Summary of Contents for Spirit 29B

  • Page 1: Table Of Contents

    TABLE OF CONTENTS 1 – - INTRODUCTION About this Manual ..........................1-1 Safety Messages Used in this Manual ....................1-1 Pre-Delivery Inspection ........................1-2 Front Axle Tire Alignment ....................... 1-2 Service and Assistance ........................1-2 Reporting Safety Defects ........................1-2 Vehicle Certification Label .......................
  • Page 2 Table of Contents Battery Boost Switch ........................3-5 Air Conditioner/Heater – Automotive (Dash) .................. 3-5 Radio – In-Dash ..........................3-5 Radio – In-Dash ..........................3-5 Engine Access – Interior ........................3-7 Engine Cooling System ........................3-7 Tires ..............................3-7 Suspension Alignment and Tire Balance ..................3-7 Air Springs –...
  • Page 3 Table of Contents Battery Access ..........................6-6 Battery Care ............................6-7 Circuit Breakers and Fuses – House 12-Volt ..................6-8 7 – - PLUMBING Fresh Water System .......................... 7-1 Water Pump ............................7-2 Cold Water Filter ..........................7-3 Disinfecting Your Fresh Water System .................... 7-4 Shower Hose Vacuum Breaker ......................
  • Page 4 Table of Contents General Slideout Care ........................10-9 Leveling System ..........................10-9 Checking Hydraulic Oil Level ...................... 10-11 11 – - MAINTENANCE AND STORAGE Sealants – Inspection and General Information ................11-1 Roof ..............................11-1 Undercarriage ..........................11-1 Exterior Finish ..........................11-2 Care of Appliques and Decals ......................

  • Page 5: Introduction

    SECTION 1 - INTRODUCTION Congratulations! We welcome you to the design without notice, and without exciting world of motor home travel and incurring obligation to install the same camping. You will find it convenient and on products previously manufactured. enjoyable to have all the comforts of home and The materials in your InfoCase contain still enjoy the great outdoors wherever you warranty information and operating and...

  • Page 6: Pre-Delivery Inspection

    SECTION 1 - INTRODUCTION SERVICE AND ASSISTANCE WARNING Your dealer will be glad to provide any additional information you need, as well as answer any questions you might have about WARNING indicates a potentially operating the equipment in your motor home. hazardous situation which, if not avoided, When it comes to service, remember that your could result in death or serious personal...

  • Page 7: Vehicle Certification Label

    SECTION 1 - INTRODUCTION VEHICLE CERTIFICATION LABEL This label is affixed to the lower driver side armrest panel, driver door or the driver side door jamb, depending on model. It contains vehicle identification numbers and other important reference information. EXPLANATION OF DATA 1.

  • Page 8: Specifications And Capacitites

    SECTION 1 - INTRODUCTION SPECIFICATIONS AND CAPACITITES Model Length 29' 11" /30' 10" 31' 5" /32' 3" 32' 1" 11' 5" /11' 8" 11' 5" /11' 8" 11' 5" Exterior Height w/AC Exterior Width 8' 5.5" 8' 5.5" 8' 5.5" Exterior Storage (cu.
  • Page 9 SECTION 1 - INTRODUCTION Specifications and Capacities Notes: Ford® E450 Chassis, 6.8L SOHC Triton® V10 engine, 305-hp, automatic transmission, TorqShift™, 5-speed with tow/haul feature, 4-wheel ABS, 130-amp. alternator, dual air bags, Trailer Hitch 5,000-lb. drawbar/350 lbs. maximum vertical tongue weight & wiring w/7-pin connector, Wheel Liners: stainless steel.

  • Page 10: Owner And Vehicle Information

    SECTION 1 - INTRODUCTION OWNER AND VEHICLE INFORMATION OWNER INFO Owner’s Name(s) __________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ VEHICLE INFORMATION Motor Home Model Number _________________________________________________________ Motor Home Serial Number __________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER...

  • Page 11: 2008 New Vehicle Limited Warranty

    SECTION 1 - INTRODUCTION 2008 NEW VEHICLE LIMITED WARRANTY WINNEBAGO INDUSTRIES, INC. WARRANTY COVERAGE TO OWNER ITEMS NOT SUBJECT TO WARRANTY COVERAGE Winnebago Industries, Inc. of Forest City, Iowa, warrants each new Chassis, drivetrain and related components* Winnebago and Itasca motor home to the owner for recreational use Wheels* in the U.S.A.
  • Page 12 SECTION 1 - INTRODUCTION OBTAINING WARRANTY REPAIRS CALIFORNIA: Winnebago Industries participates in the Consumer Arbitration While any Winnebago Industries motor home dealer can perform Program for Recreation Vehicles (CAP-RV). This third-party dispute warranty service, we recommend you return to the dealership that resolution program is available, at no charge to you, to settle sold you your vehicle.

  • Page 13: Safety And Precautions

    SECTION 2 - SAFETY AND PRECAUTIONS • Use care when accelerating or decelerating on GENERAL WARNINGS a slippery surface. Abrupt speed changes can cause skidding and loss of control. • Only seats equipped with seat belts are to be occupied while the vehicle is moving. •...

  • Page 14: Lp Gas Leaks

    SECTION 2 - SAFETY AND PRECAUTIONS • Never use an open flame to test for LP gas LP GAS LEAKS leaks. Replace all protective covers and caps on LP system after filling. Make sure valve is The following procedures are located in the closed and the door is latched securely.

  • Page 15: Carbon Monoxide Warning

    SECTION 2 - SAFETY AND PRECAUTIONS Because propane gas is heavier than air, the CARBON MONOXIDE leak detector is located on a cabinet face near the WARNING floor of the coach. WARNING WARNING Never use an open flame to test for gas Avoid inhaling exhaust gases, as they leaks.

  • Page 16: Smoke Alarm

    SECTION 2 - SAFETY AND PRECAUTIONS such as the furnace, gas range/oven, water heater, SMOKE ALARM refrigerator, chassis engine, and electric generator engine. Your motor home is equipped with a smoke alarm located on the ceiling in the lounge area. Press button to test The smoke alarm is powered by a 9-volt battery and has a sensor that is designed to detect smoke.

  • Page 17: Fire Extinguisher

    SECTION 2 - SAFETY AND PRECAUTIONS FIRE EXTINGUISHER ELECTRICAL A dry chemical fire extinguisher is located • Careless handling of electrical components near the main entrance door. can be fatal. Never touch or use electrical components or appliances while feet are bare, while hands are wet, or while standing in water or on wet ground.

  • Page 18: Maintenance

    SECTION 2 - SAFETY AND PRECAUTIONS MAINTENANCE • Do not remove the radiator cap while engine and radiator are still hot. Always check coolant level visually at the see-through coolant reservoir. • Never get beneath a vehicle that is held up by a jack only.

  • Page 19: Formaldehyde Information

    SECTION 2 - SAFETY AND PRECAUTIONS To open, pull on the red plastic strap at the Research is continuing on the possible long-term bottom of the window to remove the rubber cord effects of exposure to formaldehyde. Inadequate that holds the window in place. Pull on the rubber ventilation may allow formaldehyde and other cord until it is completely removed.

  • Page 20: Roadside Emergency

    SECTION 2 - SAFETY AND PRECAUTIONS thoroughly and quickly. Avoid grease buildup If Winnebago Industries determines that mold near the stove or sink. Clean the exhaust fan is present due to conditions it determines is not a above the stove often. result of a manufacturing defect found within the warranty period, Winnebago Industries will not Minimize moisture in your motor home and...

  • Page 21: Jump Starting

    SECTION 2 - SAFETY AND PRECAUTIONS • When you have come to a stop, activate your We recommend that you ask for an underlift hazard flashers to warn other motorists, then (wheel lift or frame lift) type towing assembly for exit the vehicle carefully.

  • Page 22: Engine Overheat

    SECTION 2 - SAFETY AND PRECAUTIONS CAUTION Do not attempt to push start this vehicle. Damage to the transmission or other parts of the vehicle will occur. ENGINE OVERHEAT If you see or hear steam escaping from the engine compartment or have any other reason to suspect an extreme engine overheating condition, pull the vehicle over to the roadside as soon as it is safe to do so, stop the engine and get all...

  • Page 23: Driving Your Motor Home

    SECTION 3 - DRIVING YOUR MOTOR HOME The information in this section refers only to features installed or adapted to the dash and driver compartment area by Winnebago Industries. It also includes passenger seating in the living area of the coach. See your chassis manual for all original chassis related controls, instrumentation, switches and other features.

  • Page 24: Child Restraints

    SECTION 3 - DRIVING YOUR MOTOR HOME Seat Belt Care and Cleaning 1- Insert tab into buckle • Be careful not to damage the belt webbing and slot until it ‘clicks’ and is hardware. Take care not to pinch them in the locked seat or doors.

  • Page 25: Keys

    SECTION 3 - DRIVING YOUR MOTOR HOME 4. Review the instructions for installation and KEYS use of the restraint. Be sure that you understand them fully and can install the Your motor home is supplied with several restraint properly and safely in your vehicle. keys.

  • Page 26: Rearview Monitor System

    SECTION 3 - DRIVING YOUR MOTOR HOME The mirrors may also contain heating elements to defog or de-ice the mirror glass during cold weather operation. An ON-OFF switch for the mirror heaters is located near the remote mirror controls. The ignition switch must be on to operate mirror controls and heaters.

  • Page 27: Battery Boost Switch

    SECTION 3 - DRIVING YOUR MOTOR HOME AIR CONDITIONER/HEATER – AUTOMOTIVE (DASH) See your chassis manual for operating information on driver and passenger comfort controls – air conditioner, heater, defroster and ventilation. NOTE: The dash air conditioner is not designed to cool the entire interior of the coach, but is intended only to provide cooling for the cab area.

  • Page 28: Radio Power Switch

    SECTION 3 - DRIVING YOUR MOTOR HOME Satellite Radio –If Equipped Your coach may be equipped with a Sirius satellite radio receiver that plays through your radio. See the receiver manufacturer’s information in your InfoCase for programming and operating instructions. NOTE:If your Sirius tuner is not activated, follow the instructions in the radio owners manual in your InfoCase for the...

  • Page 29: Engine Access - Interior

    SECTION 3 - DRIVING YOUR MOTOR HOME ENGINE ACCESS – INTERIOR TIRES Front Engine Cover Improper tire pressure can result in tire overloading and abnormal wear and also affects • To remove the engine cover, unlatch the two handling, ride characteristics and fuel economy. clips (located on the left and right sides of the engine cover) and unlatch the two clips (located on each side of the bottom of the...

  • Page 30: Air Springs - Rear Helper

    SECTION 3 - DRIVING YOUR MOTOR HOME See your chassis manual for further LIGHTS information. All exterior lights should be checked for AIR SPRINGS – REAR HELPER proper operation each time the vehicle is prepared for a trip. Any bulbs which fail to light (‘AIR BAGS’) should be checked and replaced, when necessary, –If Equipped...

  • Page 31: Appliances And Systems

    SECTION 4 - APPLIANCES AND SYSTEMS The appliances installed in your motor home are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. REFRIGERATOR The refrigerator in your coach can operate Bubble must be at least 1/2 inside circle from either of two energy sources available to the Normal vehicle leveling to provide comfort...

  • Page 32: Refrigerator Service Access Compartment

    SECTION 4 - APPLIANCES AND SYSTEMS To Close: • Auto- Refrigerator will operate on 120-VAC household current if the shoreline is 1. Replace the door into the opening. connected or the auxiliary generator is 2. Push the latch knobs in while turning to the running.

  • Page 33: Range Hood

    SECTION 4 - APPLIANCES AND SYSTEMS Avoiding Asphyxiation RANGE HOOD The following warning label has been located The range hood vent draws cooking odors and in the cooking area to remind you to provide an airborne grease particles into the filtration grid adequate supply of fresh air for combustion.

  • Page 34: Tank Capacities

    SECTION 4 - APPLIANCES AND SYSTEMS At the touch of a button this panel will display If a tank is about 1/4 full, the monitor will the fresh water and holding tank levels, propane register an empty tank because the fluid level is gas tank level, plus the house battery condition.

  • Page 35: Water Heater - Gas

    SECTION 4 - APPLIANCES AND SYSTEMS • The “Pilot Out” light will glow for about 10- 15 seconds, then it will go out. The “Heater On” indicator will remain lit. • If the “Pilot Out” light comes on during propane operation, it means that the burner has gone into “lockout”...

  • Page 36: Pressure-Temperature Relief Valve

    SECTION 4 - APPLIANCES AND SYSTEMS PRESSURE-TEMPERATURE RELIEF VALVE On occasion, water may be seen seeping from the water heater pressure temperature relief valve. This is no cause for repair or replacement of the valve. Gas Water Heater Switch on systems monitor panel For Electric Operation Turn on the Water Heater electric element...

  • Page 37: Motor Aid Water Heater

    SECTION 4 - APPLIANCES AND SYSTEMS CAUTION Any leak in the heat exchanger or its supply or return lines could cause loss of coolant and subsequent engine failure. We recommend that you periodically inspect these connecting lines and the heater to insure that no leaks have developed.
  • Page 38 SECTION 4 - APPLIANCES AND SYSTEMS NOTE: If heat does not come out of the heat ducts after a minute or so the burner is not lit. Turn thermostat off for 3-5 minutes, check to be sure propane gas tank valve is open and tank is not empty, then try steps 2-4 again.

  • Page 39: Furnace-A/C Thermostat Operation Chart

    SECTION 4 - APPLIANCES AND SYSTEMS FURNACE-A/C THERMOSTAT OPERATION CHART The following chart shows the system functions with the “Heat/Cool” thermostat. Disregard references to heat functions when using the “Cool Only” thermostat in the rear bedroom. X = Switch Position O = Switch position does not matter or is inactive for this feature FAN MODE FAN SPEED...

  • Page 40: Ducted Roof Air Conditioning System

    SECTION 4 - APPLIANCES AND SYSTEMS temperatures begin to reduce the efficiency of the NOTE: The ducted roof air conditioning system heat pump. The heat pump will not operate when has ceiling registers that can be closed if the outside temperature falls below 36 degrees F. necessary to force more cool air toward a specific area of the coach or to route cool To operate the heat pump:...

  • Page 41: Propane Gas

    SECTION 5 - PROPANE GAS PROPANE GAS SUPPLY The propane gas system supplies fuel for the WARNING gas range/oven, water heater, furnace and refrigerator (while in gas mode). When used and Do not alter or remove propane tank handled properly, this system is safe and gauge at any time.

  • Page 42: Safe Use Of The Propane Gas System

    SECTION 5 - PROPANE GAS phone directory yellow pages for locations of local propane gas refilling stations or bulk dealerships. DAN GE R NOTE: If you travel outside the U.S. with your motor home, you may find butane or pro- DO NOT FILL CONTAINER TO MORE pane/butane mixtures available in addi- THAN 80 PERCENT OF CAPACITY.

  • Page 43: Propane Gas Leaks

    SECTION 5 - PROPANE GAS • Exercise caution at all times. Be familiar with PROPANE GAS WARNINGS the distinctive odor of propane gas. If a leak is AND PRECAUTIONS suspected, turn off the supply valve immediately. Have the propane gas system It is illegal for vehicles equipped with propane checked by your dealer or other qualified tanks to travel on certain roadways or through...

  • Page 44: Propane Gas Pressure Regulator

    SECTION 5 - PROPANE GAS WARNING WARNING Propane cylinders shall not be placed or Visually inspect the pressure regulator stored inside the vehicle. vent periodically for blockage by Propane cylinders are equipped with accumulated debris or insect nests, etc. safety devices that relieve pressure by Vent obstruction could result in excessive discharging propane to the atmosphere.

  • Page 45: Propane Vaporization In Cold Weather

    SECTION 5 - PROPANE GAS This means that in extremely cold weather when a large volume of gas is being used by the furnace for heating, it is possible to experience a loss of gas pressure. At first, this problem may appear to be caused by an empty tank or a regulator freeze-up, but is actually caused by failure of the liquid gas to vaporize as fast as it is needed by the furnace.

  • Page 47: Electrical

    SECTION 6 - ELECTRICAL Your coach is equipped with an electrical the power converter automatically changes a system consisting of two separate voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motor home that is •...

  • Page 48: Power Center

    SECTION 6 - ELECTRICAL POWER CENTER (Converter) The power converter is generally located in a lower cabinet face in the galley or living area depending on the floorplan of your model. The converter power panel contains the house electrical system 120-volt circuit breakers and 30 Amp Receptacle 12-volt fuses.

  • Page 49: Circuit Breakers - House 120-Volt Ac

    SECTION 6 - ELECTRICAL (lights or motors or both) should be turned off to reduce total load. Also, inspect the power converter to make sure ventilation is not CAUTION obstructed. Do not block the converter cover vents in CIRCUIT BREAKERS – HOUSE any way.

  • Page 50: Ground Fault Circuit Interrupter

    SECTION 6 - ELECTRICAL An exterior outlet is also located on the outside of the coach near the entrance door or in a storage compartment on the passenger side of WARNING the coach. The GFCI will not completely eliminate GROUND FAULT CIRCUIT the risk of electrical shock.

  • Page 51: Operation Warnings And Cautions

    SECTION 6 - ELECTRICAL Operation Warnings and Cautions WARNING The exhaust of all internal combustion engines contains carbon monoxide (CO). This poisonous gas is colorless, odorless, tasteless, and lighter than air. The exhaust systems of both your motor home engine and your generator engine have been installed with your safety in mind.

  • Page 52: Electrical System - House 12-Volt Dc

    SECTION 6 - ELECTRICAL ELECTRICAL SYSTEM – AUXILIARY BATTERY HOUSE 12-VOLT DC DISCONNECT SWITCH (AUX. BATT) The DC voltage system consists of the chassis battery, the 12-volt house batteries, and the 12- The AUX BATT disconnect switch lets you volt power converter. disconnect the house batteries from the 12-volt system of your coach during storage periods to Converter...

  • Page 53: Battery Care

    SECTION 6 - ELECTRICAL inside the battery. This condition is called ‘sulfating’ and prevents the battery from either releasing or accepting a charge. If this condition occurs, the battery must be replaced. If a battery does not contain at least 80% charge during freezing temperatures, the electrolyte can freeze and crack the battery case.

  • Page 54: Circuit Breakers And Fuses - House 12-Volt

    SECTION 6 - ELECTRICAL • Check the state of charge periodically to avoid • Fluid level check may be omitted if equipped discharge or sulfating. with maintenance-free batteries. To ensure that the battery will always accept and hold a charge, follow these simple maintenance practices.

  • Page 55: Volt Fuse Panel

    SECTION 6 - ELECTRICAL A label on the panel states the amperage rating and circuit protected for each fuse or breaker. 12-Volt Fuse Panel The fuse panel is on the right-hand side of the power converter. 12-Volt House Fuses The fuse panel accepts only blade type plug-in fuses.

  • Page 57: Plumbing

    SECTION 7 - PLUMBING 2. Attach an RV city water hose from the FRESH WATER SYSTEM external water source to the city water connection typically located in the water The fresh water system provides water to the service compartment or on the left sidewall of galley sink, shower, bathroom lavatory, toilet and your vehicle.

  • Page 58: Water Pump

    SECTION 7 - PLUMBING These devices simply connect in-line between Unscrew bowl and remove to clean strainer the supply hose and the city water input on the coach. Water pressure regulators are commonly available at any well stocked RV dealership and many large retail discount or home supply centers.

  • Page 59: Cold Water Filter

    SECTION 7 - PLUMBING Initial Water Line Priming Replacing the Cold Water Filter Cartridge: 1. Make sure that all water drain valves are You should replace the filter cartrige every closed, including water heater valve. season and when water flow from the faucet is 2.

  • Page 60: Disinfecting Your Fresh Water System

    SECTION 7 - PLUMBING chlorine solution. One gallon of this solution should be used for each 15 gallons of tank capacity. 2. Complete filling of tank with fresh water. 3. Open each faucet in the coach and run the water until a distinct odor of chlorine can be detected in the water discharged.

  • Page 61: Shower Hose Vacuum Breaker

    SECTION 7 - PLUMBING tank, this will result in a 6.7 ppm level of chlorine, which should kill harmful bacteria and slime-forming organisms. • Chlorine may be removed from drinking water by the cold water filter at the galley faucet–if equipped–or by installing an activated carbon water purifier at the galley sink cold water line or a separate drinking water faucet with filter.

  • Page 62: Waste Water System

    SECTION 7 - PLUMBING See winterizing instructions at the end of this section to prepare the toilet for storage in freezing conditions. Further Information See the toilet manufacturer’s operation information in your InfoCase for complete operating, care and maintenance information. WASTE WATER SYSTEM (Holding Tanks) Holding Tank Dump Valves (Typical)

  • Page 63: Holding Tank Heater

    SECTION 7 - PLUMBING Using On-Site Sewer Hook-Ups The drain hose may remain attached to the dump outlet and be routed out the bottom of the compartment while the motor home is parked and connected to an on-site sewage hook-up. The center outlet section may be swiveled downward for better hose alignment and drainage.

  • Page 64: Water Heater Bypass Valve

    SECTION 7 - PLUMBING WATER HEATER BYPASS D R A I N D R A I N VALVE C L O S E Your coach may be equipped with a water C L O S E heater bypass valve for easier winterization of water lines using RV antifreeze.
  • Page 65 SECTION 7 - PLUMBING 2. Drain Fresh Water Tank and Water Lines. Open all water line drain valves and drain fresh water tank. (See “Water System Drain Valve Locations” chart at end of this section for locations of drain valves on your model.) 3.
  • Page 66 SECTION 7 - PLUMBING dryer, the water lines for these appliances the system. (A ‘blow-out’ plug can be must also be drained. purchased at any Winnebago or Itasca dealer. (See “Winterizing Optional Appliances” P/N 701705-01-000.) instructions at the end of this section.) If not, proceed to the next step.
  • Page 67 SECTION 7 - PLUMBING 17. Pour about one cup of RV antifreeze down water system antifreeze through the each drain for the galley sink, lavatory sink, plumbing system. and shower/tub. This fills the drain trap pipes This product is available from your to prevent holding tank odors from entering dealer and from most RV supply stores the coach during storage.
  • Page 68 SECTION 7 - PLUMBING Set Up Winterization Valves 1. Remove and discard the filter cartridge from the cold water filter assembly below the galley 3. Turn Winterization Valve 1 to ‘Water Heater sink. (If your coach is not equipped with Bypass’...
  • Page 69 SECTION 7 - PLUMBING Water Heater Drain Plug Remove with socket. RV Antifreeze Siphon Tube • Also open the Pressure-Temperature relief in water center or near water pump valve at the top right portion of the tank to (insert into container of RV water system antifreeze) prevent air locking in the tank while draining.

  • Page 70: Winterizing Optional Appliances

    SECTION 7 - PLUMBING 15. Pour about one cup of RV antifreeze down each drain for the galley sink, lavatory sink, and shower/tub. This fills the drain trap pipes to prevent holding tank odors from entering the coach during storage. Dump and Clean Holding Tanks 16.
  • Page 71 SECTION 7 - PLUMBING To use Washer-Dryer again: 3. Press ON/OFF Button (IN). Wait 1-2 minutes Flush antifreeze from the water lines, then 4. Press ON/OFF Button (OUT). Unplug the washer-dryer from the electrical outlet (or 1. Reconnect the water inlet hoses to the disconnect power) corresponding HOT/COLD faucets.
  • Page 72 SECTION 7 - PLUMBING To use Dishwasher again: Flush antifreeze from the water lines, then 1. Set the dishwasher controls to the start of the Rinse cycle and run briefly until antifreeze can be seen inside the dishwasher. 2. Set the controls to the end of the Rinse cycle and allow the machine to run through the complete cycle to clean out any remaining antifreeze.

  • Page 73: Water System Drain Valve Locations

    SECTION 7 - PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS Model System Drain Valve Locations Water Lines: Two (2) valves located in compartment behind passenger side rear wheels. One (1) valve in drivers side 2nd storage compartment. Water Tank: In drivers side 2nd storage compartment. Water Heater: Drain plug on outside of coach, behind service door.

  • Page 75: Entertainment

    SECTION 8 - ENTERTAINMENT To Watch VCR (if self-installed) VIDEO SELECTION SYSTEM • Press VCR button on MAIN TV section of –If Equipped Video Selection System panel. To Watch Rear/Bedroom TV (if equipped) • Video selection for the rear TV is similar to front TV viewing except all selections are made with buttons in the TV2 grouping.

  • Page 76: Tv/Dvd Master Power Switch - 12-Volt

    SECTION 8 - ENTERTAINMENT The available DVD home theater system TV/DVD MASTER POWER operates from 120-volt AC household current SWITCH – 12-VOLT only, so you must have either the shoreline connected, the generator running, or the inverter Swing-Out TV turned on (if equipped). –If Equipped The TV is connected to the Home Theater The TV and DVD player unit on models with...

  • Page 77: Dvd Player

    SECTION 8 - ENTERTAINMENT TV Sound through Home Theater should be turned off to avoid drain on the 12- Volt house battery. Speakers When watching TV programs alone, the TV Set TV Sound Output normally plays sound through its own built-in •...

  • Page 78: Tv Antenna

    SECTION 8 - ENTERTAINMENT TV ANTENNA ELECTRICAL INVERTER 300-Watt DC-to-AC The TV antenna on your motor home can be easily raised, rotated a full 360° and lowered –If Equipped from inside the vehicle by simply turning a crank The inverter changes 12-volt DC automotive or directional handle.

  • Page 79: Tv Signal Amplifier

    SECTION 8 - ENTERTAINMENT Lowering Antenna to Travel Position Checking Amplifier Performance Rotate antenna until pointer on directional The TV signals available to an RV are entirely handle aligns with pointer on ceiling plate. dependent on its location in relation to the transmitter (tower).

  • Page 80: Exterior Entertainment Center

    SECTION 8 - ENTERTAINMENT We recommend that you read the satellite dish EXTERIOR ENTERTAINMENT manual thoroughly to understand the system CENTER completely before attempting any setups or adjustments. –If Equipped • The coach must be level before attempting to The exterior entertainment center contains a aim the antenna dish.

  • Page 81: Furniture And Softgoods

    SECTION 9 - FURNITURE AND SOFTGOODS SLEEPING FACILITIES WARNING Do not exceed 225 lbs. maximum weight capacity. Misuse of ladder could result in death or serious injury. See Operators Manual before using ladder. WARNING • Maximum Capacity: 225 lbs. Do not use sleeping facilities while vehicle is moving.

  • Page 82: Sofa/Bed Conversion

    SECTION 9 - FURNITURE AND SOFTGOODS SOFA/BED CONVERSION Sofa to Bed: Lift the front edge of the sofa seat upward and pull outward from the wall while gently pushing downward on the backrest until the cushions lie flat. The bed is now ready for use. Bed to Sofa: Push the front edge of the seat toward the wall while lifting upward on the backrest until the sofa...

  • Page 83: U-Shaped Dinette/Bed Conversion

    SECTION 9 - FURNITURE AND SOFTGOODS 2. Remove the table from the wall support 2. Make sure that the table leg is secured into the bracket by lifting the end of the table. Then floor support bracket and the leg brace is lower the table to rest on the cleats attached to locked.

  • Page 84: Pleated Blinds

    SECTION 9 - FURNITURE AND SOFTGOODS following picture. This will ensure that NOTE: Reverse steps to reassemble to dinette the locking mechanism is reset for the configuration. next use. Round Table Leaf Extension Lift the leaf extension upward then reach beneath the tabletop and slide the support arms outward to hold the extension.

  • Page 85: Wood Furniture And Cabinetry

    SECTION 9 - FURNITURE AND SOFTGOODS The tension cords are attached to spools at the WOOD FURNITURE AND lower corners of the blinds as shown in the CABINETRY following photo. –If Equipped People are drawn to the natural beauty of wood.
  • Page 86 SECTION 9 - FURNITURE AND SOFTGOODS light. Color differences or changes in wood can also be caused by exposure to harsh chemicals, extreme heat or other contributing external conditions. Any color change that occurs in both the finish and the wood is considered part of the natural aging process and is not to be considered defect or damage.

  • Page 87: Slideout Rooms And Leveling

    SECTION 10 - SLIDEOUT ROOMS AND LEVELING SLIDEOUT ROOM TRAVEL LOCK –If Equipped Some models are equipped with an expandable prop-lock rod device to restrict movement of the slideout room while the vehicle is in motion. The Lock Rod must be released before extending the room or damage to the coach will result.

  • Page 88: Slideout Room Operation - Electric

    SECTION 10 - SLIDEOUT ROOMS AND LEVELING SLIDEOUT ROOM OPERATION – ELECTRIC WARNING Your motor home may have more than one slideout room. Understand which Slideout Room Keylock. switch operates which slideout room prior to operation. Make sure all slideout rooms are clear of people who could be harmed The key to turn the master keylock “off”...
  • Page 89 SECTION 10 - SLIDEOUT ROOMS AND LEVELING ROOMS so the engine alternator can • Insert the Safety Lock key and turn to activate provide maximum power for proper oper- slideout room control switch ation of the slideout mechanisms. • Press the Slideout Room ‘EXTEND/OUT’ switch and hold until the room is fully extended–...

  • Page 90: Slideout Room - Extreme Weather Precaution

    SECTION 10 - SLIDEOUT ROOMS AND LEVELING coach slightly to the left (driver’s side) as shown by raising both right side jacks to let excess water flow away from the rooftop weather seal and toward the outside of the slide-out roof. Retract the slideout slowly, starting and stopping to allow water to drain off room cover.
  • Page 91 SECTION 10 - SLIDEOUT ROOMS AND LEVELING While in the Manual Mode each of the two, Green light will flash error code room slide arms are activated by pressing and if system malfunctions* holding the IN and OUT buttons. The “OUT” button will retract the front arm.

  • Page 92: Slideout Emergency Retraction - Electric

    SECTION 10 - SLIDEOUT ROOMS AND LEVELING SLIDEOUT EMERGENCY Green light will flash error code if system malfunctions* RETRACTION – ELECTRIC (Front Slideout Room) Crank-In Mode If the room mechanism is malfunctions and will not retract using the buttons, you will need to manually crank the room in to the travel position.
  • Page 93 SECTION 10 - SLIDEOUT ROOMS AND LEVELING Crank-In Procedure Type B–Single Arm – Cover mounted beneath face of slideout room: • Insert the crank handle into the gear shaft socket, aligning the notches in the crank Remove the four bolts that fasten the cover to handle with the pins inside the socket as the arm –...

  • Page 94: Slideout Emergency Retraction/ Bedroom - Electric

    SECTION 10 - SLIDEOUT ROOMS AND LEVELING • Fasten slideout room travel latching device–if • Attach the shaft extension to hex-end shaft equipped–inside the coach before driving the and place the ratchet wrench onto the hex end vehicle. shaft, then insert into the hole in the bed base as shown.

  • Page 95: General Slideout Care

    SECTION 10 - SLIDEOUT ROOMS AND LEVELING LEVELING SYSTEM –If Equipped The hydraulic leveling system makes selecting a parking site easier and faster by reducing the effect of uneven ground. Hydraulic jacks raise the affected low corners of the coach to make leveling “set up” faster and easier for you.
  • Page 96 SECTION 10 - SLIDEOUT ROOMS AND LEVELING CAUTION WARNING • Do not try to drive vehicle unless ‘TRAVEL’ light is glowing with ignition • Keep all people clear of the coach switch on. while the leveling system is operating. • Do not try to drive the vehicle until the •...

  • Page 97: Checking Hydraulic Oil Level

    SECTION 10 - SLIDEOUT ROOMS AND LEVELING 4. See the Leveling System Operator’s Manual supplied in your InfoCase for troubleshooting instructions or operating the leveling system if jacks fail to retract or any other functions fail. CHECKING HYDRAULIC OIL LEVEL See your Leveling System Operators Manual for complete maintenance instructions and information.

  • Page 99: Maintenance And Storage

    SECTION 11 - MAINTENANCE AND STORAGE SEALANTS – INSPECTION AND GENERAL INFORMATION CAUTION Water is a recreational vehicle’s worst enemy when it is allowed to enter where it’s not Sealants must be inspected every 6 intended. Sealants perform a very important months and replaced if necessary.

  • Page 100: Exterior Finish

    SECTION 11 - MAINTENANCE AND STORAGE weight to the vehicle. This, in effect, reduces the • Wash with cool water out of direct sun light amount of cargo you can carry and remain within using a mild liquid soap (any ‘no-tears’ baby GVWR and GAWR limits.

  • Page 101: Care Of Appliques And Decals

    SECTION 11 - MAINTENANCE AND STORAGE If the finish begins to look dull or discolored, CARE OF APPLIQUES AND it may need to be cleaned with a polishing or DECALS cleaning compound formulated for gel-coated fiberglass finishes. The pressure-sensitive appliques and decals on your coach require very little maintenance.

  • Page 102: Exterior Lights

    SECTION 11 - MAINTENANCE AND STORAGE EXTERIOR LIGHTS Most Winnebago Industries vehicles have CAUTION polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical DO NOT use citrus based cleaners on solvents and cleaners. polycarbonate finishes. Use only soap and water to clean exterior Citric compounds will damage the high- lamp lenses–...
  • Page 103 SECTION 11 - MAINTENANCE AND STORAGE shades should be closed when the motor home is parked for an extended period of UltraLeather HP™ Cleaning Chart time. Detergent/ Cleaner/ Type of Stain Water Degreaser Coffee, Tea WARNING Red Wine, Liquor Cola, Soft Drinks Milk When cleaning upholstery and fabric, do not use lacquer thinner, nail polish...

  • Page 104: Ceiling Fabric Care

    SECTION 11 - MAINTENANCE AND STORAGE Most commercially available carpet and CEILING FABRIC CARE upholstery cleaners will do an excellent job removing stains. From time to time, additional While using your coach, your ceiling fabric cleaning methods may need to be used to remove may become soiled and require spot cleaning stubborn or difficult stains.

  • Page 105: Cabinetry - Cleaning

    SECTION 11 - MAINTENANCE AND STORAGE General Cleaning You may have to repeat this procedure more than once to achieve desired results. Finish up Clean often with hot water and soap. If a with clean water, using the same method, and cleaner or cleanser is necessary, make sure the blot dry.

  • Page 106: Doors And Windows

    SECTION 11 - MAINTENANCE AND STORAGE Tub and Shower Walls Use care when removing ice or frost from the windows. Always use a plastic ice scraper, never The tub and shower walls in the bathroom one made of metal. Use care when removing ice should be cleaned with mild soap and warm from the mirrors to protect the reflective surfaces.

  • Page 107: Vehicle Storage - Removal

    SECTION 11 - MAINTENANCE AND STORAGE 6. After charging batteries, turn the Aux Battery 6. Add a few gallons of water to the fresh water Switch off to disconnect the batteries and tank and turn on the water pump to check for avoid parasitic* drain.
  • Page 108 SECTION 11 - MAINTENANCE AND STORAGE Also inspect weather seals around doors, etc., and if necessary, have a dealer replace immediately. Ice Maker Start-Up –If Equipped 1. Close all drain valves. 2. Turn the water supply on. 3. Be sure the ice bin is in place and the automatic shutoff arm is down.

  • Page 109: Coach Maintenance Chart

    SECTION 11 - MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System Have propane gas system checked for leaks.
  • Page 110 SECTION 11 - MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items Headlights, Taillights and Marker Lights Turn Signals...
  • Page 111 SECTION 11 - MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect (see “Sealants”...

  • Page 112: Sealants - Recommended Application

    SECTION 11 - MAINTENANCE AND STORAGE SEALANTS – RECOMMENDED APPLICATION 11-14...

  • Page 113: Miscellaneous

    SECTION 12 - MISCELLANEOUS NOTE: We recommend that you dump all hold- LOADING THE VEHICLE ing tanks before traveling to avoid carry- ing unnecessary weight. NOTE: Your motor home’s load capacity is des- ignated by weight, not by volume, so you cannot necessarily use all available space when loading your motor home.
  • Page 114 SECTION 12 - MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motorhome is to weigh each ‘corner’...

  • Page 115: Car Or Trailer Towing

    SECTION 12 - MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual listed Gross Weight Ratings. See “Vehicle set (left rear duals or right rear duals) should not Certification Label” in the Introduction Section exceed 6,000 lbs. for information on gross weight ratings.

  • Page 116: Trailer Wiring Connector

    SECTION 12 - MISCELLANEOUS Before descending a steep or long grade when TRAILER WIRING towing a trailer, reduce speed and shift into a CONNECTOR lower gear to control vehicle speed. Avoid prolonged or frequent application of brakes Your coach is pre-wired for trailer or car which could cause overheating and brake failure.

  • Page 117: Entry Step - Manual

    SECTION 12 - MISCELLANEOUS Gross Combination Weight Rating Ford’s towing guide suggests 10 to 15 percent for trailers over 2,000 lbs. Within GCWR, a (GCWR): Class 3 hitch allows “dingy” towing a large car or This is the maximum allowable weight of the mid-size SUV;...

  • Page 118: Entry Step - Electric

    SECTION 12 - MISCELLANEOUS This position is normally used to keep the step extended when parked at a campsite or whenever people will be going in and out the vehicle CAUTION frequently. Automatic Retraction Feature Always remember to store the entry step before traveling or moving the vehicle.

  • Page 119: Power Roof Ventilator

    SECTION 12 - MISCELLANEOUS If the window will not open after three or more POWER ROOF VENTILATOR full turns of the knob, the glass may be stuck to the sealing gasket. Go to the outside of the coach Lounge, Galley or Bath Area and gently free the glass with your fingers.

  • Page 120: Manual Awning

    SECTION 12 - MISCELLANEOUS roof ventilator.The fan speed selector on NOTE:Typical method of tool storage shown. the fan allows you to adjust the amount of Actual features and locations may vary circulation you need at any time. depending on model, available equip- ment, and storage compartment configu- 5.

  • Page 121: Effects Of Prolonged Occupancy

    SECTION 12 - MISCELLANEOUS the rungs are wet, or if your shoes are wet or When you recognize the signs of excessive carry mud or debris that could result in a loss moisture and condensation in your coach, you of footing. should take immediate action to minimize their effects.
  • Page 123 INDEX 2008 New Vehicle Limited Warranty ..1-7 Engine Cooling System ....... 3-7 About this Manual ........1-1 Engine Overheat ........2-10 Air Conditioner Filter ........ 4-10 Entry Step – Electric ........12-6 Air Conditioner/Heater – Entry Step – Manual ........12-5 Automotive (Dash) ........
  • Page 124 Index Pleated Blinds ..........9-4 Suspension Alignment and Tire Balance ..3-7 Power Center ..........6-2 Swing-Out TV Mounts ........ 8-1 Power Roof Ventilator ....... 12-7 Systems Monitor Panel ........ 4-3 Pre-Delivery Inspection ....... 1-2 Tables and Countertops ......11-7 Pressure-Temperature Relief Valve .....

This manual is also suitable for:

31c31h

Table of Contents