Maintenance Interval Chart - Yamaha Z200Y Service Manual

INSP

MAINTENANCE INTERVAL CHART

ADJ
MAINTENANCE INTERVAL CHART
Use the following chart as a guide to general maintenance intervals.
Dependant on operating conditions, adjust the maintenance intervals accordingly.
Item
TOP COWLING
Top cowling fit
FUEL SYSTEM
Fuel line
Fuel filter
Mechanical fuel pump oil Change
Fuel tank
POWER UNIT
Water leakage
Motor exterior
Exhaust leakage
Cooling water passage
CONTROL SYSTEM
Throttle valve
synchronization
Engine idling speed
Throttle position sensor
Remote control shift cable Check/adjust
Remote control throttle
cable
(*2)
Drive belt
OIL INJECTION SYSTEM
Oil tank water drain
Oil pump lever
POWER TRIM AND TILT UNIT
Power trim and tilt fluid
LOWER UNIT
Gear oil
Lower unit leakage
Propeller and cotter pin
(*1)
When operating in salt water, turbid or muddy water, the engine should be flushed with
clean water after each use.
(*2)
Be sure to replace the drive belt after every 1,000 hours (5 years) of operation.
Remarks
Check
Check
Clean/check
Clean
Check
Check
Check
(*1)
Clean
Check/adjust
Check/adjust
Check/adjust
Check/adjust
Check/adjust
Clean
Check/adjust
Check
Change
Check
Check/replace
Initial
10 hours 50 hours 100 hours
(Break-in) (3 months) (6 months)
3-1
E
3
Every
Refer to
200 hours
page
(1 year)
3-3
3-3
3-4
3-6
—
—
—
—
—
3-7
3-9
3-8
3-10
3-10
3-11
—
3-13
3-15
3-16
3-18
6-3, 6-30