Advertisement
Quick Links
Advertisement
Summary of Contents for Pentair AquaTRAM
- Page 1 AquaTRAM PT Pool Lift User’s Guide WARNING IMPORTANT SAFETY INSTRUCTIONS WARNING! TO REDUCE RISK OF INJURY WARNING! DO NOT PERMIT CHILDREN TO OPERATE OR USE THIS PRODUCT. IMPORTANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS SAVE THESE INSTRUCTIONS...
- Page 2 3. WARNING- DO NOT PERMIT CHILDREN TO PLAY ON THIS PRODUCT. 4. WARNING- NEVER APPLY DIRECT WATER PRESSURE TO ELECTRONIC COMPONENTS. 5. DO NOT USE THE AquaTRAM PT FOR WATER-DRAFTS OVER 9” (DECK TO WATERLINE). 6. NEVER OPERATE THIS LIFT UNDER LOAD WITH NO WATER (DRY POOL).
-
Page 3: Table Of Contents
PAGE DESCRIPTION PACKING LIST INSTALLATION: ADA GUIDELINES AquaTRAM PT ASSEMBLY INSTRUCTIONS BATTERY CHARGING 9-10 TRANSPORTING AND USING THE AquaTRAM PT TRANSPORT INSTRUCTIONS: CHAIR REMOVAL AquaTRAM PT OPERATING INSTRUCTIONS 13-14 SAFETY & CARE FOR YOUR LIFT 15-18 TROUBLESHOOTING GUIDE AquaTRAM PT INTEGRATED LIFT PARTS LIST... - Page 4 THE AquaTRAM PT PORTABLE POOL LIFT 1. AquaTRAM PT INTEGRATED LIFT W/ FOOTREST (P/N 11230) 2. AquaTRAM Portable Cart (part of item 1) 3. AquaTRAM Portable Cart Cover (11285) 4. Weight Plates (50lbs each X 10) 5. 24V CONTROL & BATTERY (P/N 11235) 6.
-
Page 5: Installation: Ada Guidelines
NOTE: As per ADA requirements the slope of the deck from the pool edge to the centerline of the seat and within the clear deck space must be no greater than 1:48. The AquaTRAM PT should be used on pools with a deck to water measurement no greater than 9”. -
Page 6: Aquatram Pt Assembly Instructions
AquaTRAM PT- ASSEMBLY INSTRUCTIONS 1. Begin by placing the parts from the previous page at or near to the desired poolside location. 2. Stack 10 supplied weight plates on the portable platform. To ensure proper alignment stack 3 to 4 plates, check alignment by temporarily putting the cover on, remove the cover and then stack 3 to 4 more plates. - Page 7 EMERGENCY STOP BUTTON IS RELEASED!! CHARGING THE BATTERY: Before using the AquaTRAM PT Lift for the first time the 24V CONTROL/BATTERY must be fully charged. This will take about 24 hours on the charger. It is also recommended that the battery be fully charged before each use.
- Page 8 ALTERNATIVE: CHARGING THE BATTERY ON THE LIFT The AquaTRAM PT is portable, so that it can be stored in an equipment or storage room when not being used. If the AquaTRAM PT is used in this manner it allowable charge...
-
Page 9: Transporting And Using The Aquatram Pt
TRANSPORTING & USING THE AquaTRAM PT: The AquaTRAM PT has been designed to make transporting and using the lift as simple as possible. The design makes the lift 100% ADA compliant by providing two separate operating modes; one for transporting the lift and one for using it. - Page 10 RETURNING THE LIFT TO TRANSPORT MODE: To move the lift after use, reverse the steps above as follows: 1) Tilt the lift back on the upper-wheels until the lower wheels are at the cart level. 2) Roll the lift onto the cart, all the way until the pins hit the back of the guides.
- Page 11 TRANSPORTATION INSTRUCTIONS: CHAIR REMOVAL The AquaTRAM PT has been designed to fit through a 36” wide doorway, but not all doorways are the same. Therefore the AquaTRAM PT has a removable chair. WARNING! When the lift is on the pool deck, ensure the seat is properly secured to the lift frame using the two safety pins.
- Page 12 EACH USE. NEVER OPERATE THE LIFT WITH THE ARMRESTS FLIPPED UP. LOADING FROM A WHEELCHAIR: The AquaTRAM LT/PT Pool Lift should always be in the fully upright position when transferring into the chair. Before transferring, check to make sure the lift is operating by making a short test run: move the chair at least part way in and out of the pool.
- Page 13 Routine cleaning is an absolute necessity to ensure the integrity of the lift. Note that the AquaTRAM PT Pool Lift should not be stored in a pump room or in a storage room where pool chemicals are kept. Storing the lift near pool chemicals may cause rusting and other damage to occur.
- Page 14 DO NOT USE POOL WATER TO CLEAN USE ONLY FRESH WATER If the lift is used DAILY make sure to wash the lift at the end of the day. Wash the lift off using a mild soap and a soft cloth. Make sure to pay special attention to weld points and crevices.
-
Page 15: Troubleshooting Guide
TROUBLESHOOTING GUIDE First make sure the 24V Control & Battery unit is fully charged. If the lift doesn’t move when the handset button is pressed: When you can’t get the lift to move check the following things: 1. Make sure the battery is fully charged: Unplug the MOTOR CABLE and the ACTUATOR CABLE from the 24V CONTROL BOX. - Page 16 If the battery is fully charged and the lift is not moving then: 2. Check all cords: A. Check that the cords are properly plugged in. Start by unplugging the HANDSET and the ACTUATOR from the 24V CONTROL BOX. Once these cords are removed check the ends for corrosion or damage.
- Page 17 If you have checked all the cords and the lift still doesn’t move: 3. Make sure the “EMERGENCY STOP” button isn’t depressed: A. After you have fully charged the battery and checked the cords to make sure they are properly plugged in, look at the side of the ALL-IN-ONE unit and make sure the red EMERGENCY STOP button is “out”, or not engaged.
- Page 18 If the lift stops moving over the water and is stuck: 4. Try pushing the “EMERGENCY UP” button: A. If the lift gets stuck out over the water press the “EMERGENCY UP” button and hold it down. Under normal conditions this will bypass the HANDSET and return the lift to the deck.
-
Page 19: Aquatram Pt Integrated Lift Parts List
AquaTRAM PT INTEGRATED LIFT: PARTS LIST ITEM # DESCRIPTION INTEGRATED SLIDE-BASE AquaTRAM PT FRAME AquaTRAM PT SEAT ARM AquaTRAM PT SEAT ROTATE ARM AquaTRAM PT CONTROL ARM AquaTRAM PT ACTUATOR FRM AquaTRAM PT U-BRACKET LINEAR ACTUATOR 24V BATTERY & CONTROL... -
Page 20: Portable Cart Parts List
PORTABLE CART: PARTS LIST ITEM # DESCRIPTION PORTABLE CART BASEPLATE PORTABLE CART WELDMENT A PORTABLE CART WELDMENT B PORTABLE COVER ASSEMBLY PORTABLE CART TRAY, REV-A2 GUIDE-FRAME ASSEMBLY PLASTIC SLIDE, HDPE PLASTIC GUARD, HDPE 3-1/2" FIXED CASTER, SS 3-1/2" SWIVEL CASTER, SS 3-1/2"... - Page 21 Options for AquaTRAM Adjustable Head Rest (P/N 11205) Includes: Padded head rest mounted to adjustable bracket with mounting hardware. Adjustable Chest Strap (P/N 11206) Includes: Adjustable hook and loop style chest strap and mounting hardware. Pullout Leg Rest (P/N 11208) Includes: ...
- Page 22 OF 350 POUNDS (159 KG). To initiate a warranty claim, the owner of an AquaTRAM™ Lift must provide the place of purchase, in writing, with a full description of the Lift, its serial number, the dates of purchase and installation, and the exact nature of the claim. Within thirty (30) days after receipt of a written warranty claim by Pentair, and barring any unforeseen delays, the place of purchase will be notified of Pentair’s decision regarding the claim.
- Page 23 Pentair Water Commercial Pool and Aquatics™, A Division of Pentair Water Pool and Spa, Inc. 1620 Hawkins Ave., Sanford, NC 27330 1351 Route 55, LaGrangeville, NY 12540 AquaTRAM and Pentair Water Commercial Pool and Spa are trademarks and/or registered trademarks of Pentair Water Pool and Spa, Inc. and/or its affiliated companies in the United States and/or other countries.
- Page 24 P/N 11289 Rev A 01-04-12...