Normal Care; Schedule; Raising The Hood; Checking/Adding Gasoline - Simplicity Broadmoor 1600 Series Operator's Manual

SCHEDULE

The following schedule should be followed for normal care of your tractor and mower. You will need to keep a record
of your operating time. Determining operating time is easily accomplished by multiplying the time it takes to do one
job by the number of times you've done the job, or you can install the optional hour meter.
Safety Items
Check safety interlock system.
Check tractor brakes.
Check mower blade stopping time.
Normal Care Items
Check tractor & mower for loose hardware.
Check engine oil level.
Check engine & air filter.
Change engine oil and filter.**
Lubricate tractor & mower.
Check fluid levels & tire pressure
Change transmission fluid. (Hydro only)****
Check fuel filter.
Clean battery & cables
Clean/sharpen blades.
Inspect spark plug(s).
* See the engine manufacturer's owner's manual.
** Change original engine oil after first 5 hours of operation.
*** More often in hot (over 85° F: 30° C) weather or dusty operating conditions.
**** Transaxle is a sealed unit and requires no regular interval fluid changes.

RAISING THE HOOD

To gain access to the engine compartment, release the
rubber strap (D, figure 4) on each side of the hood and
raise the hood.
CAUTION
Do not run the engine with the hood raised.
Engine heat will cause damage to the headlight
bezel and hood.

CHECKING/ADDING GASOLINE

Check the gas gauge/cap to be sure there is enough
gasoline to complete the job. To add gasoline, remove
the gas gauge/cap. Do not overfill. Leave room in the
tank for fuel expansion. Refer to your engine manual for
gasoline recommendations. Install and hand tighten the
gas gauge/cap.
CAUTION
Never use gasoline containing METHANOL, gaso-
hol containing more than 10% ethanol, gasoline
additives, premium gasoline, or white gas because
engine/fuel system damage could result.
See Before Before
Page First Use Each Use
9
27
29 After adjustment or service of electric PTO clutch
–
*
*
*
18-19
17
–
19
19
20
*

CHECKING TIRE PRESSURE

Front tire pressure should be 12 to 15 psi (82 to 103 kPa).
Rear tire pressure should be 6 to 8 psi (41 to 55 kPa).
CHECKING FUEL FILTER
Do not remove fuel filter when engine is hot, as
spilled gasoline may ignite. DO NOT spread hose
clamps further than necessary. Ensure clamps
grip hoses firmly over filter after installation.
The fuel filter is located in fuel line between fuel tank and
carburetor. If filter is dirty or clogged, replace as follows.
Place a container below filter to catch spilled gasoline.
1. Using a pliers, open and slide hose clamps from fuel
filter.
2. Remove hoses from filter.
3. Install new filter in proper flow direction in fuel line.
Secure with hose clamps. See warning at beginning
of procedure.
17
Every Every 25
5 Hours Hours
***
***Every 50 hrs.
***
**
Only if transaxle is serviced.
WARNING

Normal Care

Every 100 Spring
Hours & Fall
***