Summary of Contents for Keating Of Chicago Top-Side Cooker 028951
Page 1
TOP-SIDE COOKER KEEP THIS MANUAL FOR TRAINING NEW PERSONNEL 028951 SERVICE MANUAL ™ ELEMENT 1-800-KEATING WATLOW WATLOW ELEMENT °F °F °C °C LOAD LOAD PUSH PUSH TO SET TO SET Keating of Chicago, Inc. 1-800-KEATING www.keatingofchicago.com Top Side 0107 09/07...
SECTION I INTRODUCTION General ........1 Standard Features ......1 Standard Accessories .
Page 3
This manual must be kept in a prominent, easily ™ reachable location near the Top-Side Cooker NOTICE: Keating of Chicago, Inc. (manufacturer) reserves the right to change specifications at any time. WARNING Do not store flammable liquids near this or any other appliance.
Locking mechanism for micro-level STANDARD ACCESSORIES Proprietary USDA and UL listed polymer cooking sheets (1) NOTE: Keating of Chicago, Inc. (manufacturer) reserves the right to change specifications at any time. COOKING HEAD SPECIFICATIONS Each Top-Side cooking head is designed to be connected to a 208, 220 or 240 volt single phase line.
ELECTRICAL CONNECTION Each Keating Top-Side Cooking head is equipped ™ with a 9' (2.74m) neoprene covered, 12 gauge 4mm(2), three wire with ground electrical cord. Each cooking head is rated 4000W, 18 amps, single phase at 220 Volts and is designed to be connected to its own 208- 240V single phase electrical supply.
WARNING BECAUSE SUPERIOR SURFACE, THE ONLY TOOLS YOU WILL EVER NEED TO CLEAN THE TOP-SIDE COOKING HEAD ARE A ™ DAMP SOFT COTTON CLOTH AND A KEATING SCRAPER. NEVER SCRAPE COOKING SHEETS WITH THE SCRAPER. NEVER USE A GRIDDLE STONE, BRICK, GRIDDLE SCREEN OR HARSH CHEMICALS TO CLEAN THE MIRACLEAN SURFACE.
INSTALLING A COOKING SHEET 1. Raise Top-Side Cooking head completely. ™ 2. Lay the 20'' x 24'' (508mm x 610mm) cooking sheet on the griddle plate with 20'' (508mm) dimension front to back. 3. Lower the Top-Side Cooker head onto the ™...
V SERVICE DIAGNOSIS A properly adjusted Keating Top-Side load, will cycle “ON” approximately every 5 minutes. Each cycle will last 40 seconds, ensuring that the temperature setting is held within a narrow range. A. Trouble-Shooting The following diagnosis is only to be used as a guide to qualified service personnel.
TROUBLESHOOTING THE THERMOSTAT Temperature reading is incorrect, showing a sensor error, LOAD LED is switching at the wrong temperature. Temperature reading is decreasing, but actual temperature is increasing. For troubleshooting the thermocouple, use the chart below • Sensor or controller may be bad. Sensor connections may be bad.
VI EXPLODED VIEW & PARTS LIST ORDERING PARTS Parts may be ordered by part number by calling 1-800-KEATING or your local service company. You may also order online at Keating’s part store, www.keatingofchicago.com. Refer to the Keating Top-Side Cooker Limited Warranty for complete service and ordering information. ™...
AUTO-LIFT TOP-SIDE COOKER ™ Figure 6-2 ITEM DESCRIPTION TOP-SIDE COOKER WELD. AUTO NEW ARM AUTO TOP SIDE A0-2 ACTUATOR MTG. ACTUATOR AUTO TOPSIDE COOKER 24V TOP-SIDE CONDUIT SUPPORT TOP-SIDE COOKER LIFT ARM ROD TOP-SIDE COOKER HEAD W/ CONDUIT AND CONTROL PANEL "...
Page 13
INSTRUCTIONS FOR MICROSWITCH ADJUSTMENT AUTO-LIFT TOP-SIDE™ ACTUATOR Figure 6-3 1. Remove the limit switch black plastic cover on the actuator. 2. Turn on the power on unit and push the T1, T2 or T3 button on the timer. The actuator will extend the stroke and lower head.
VII WIRING DIAGRAM TOP-SIDE COOKER MANUAL LIFT WIRING DIAGRAM ™ Figure 6-5 LIGHTED ROCKER LIGHTED ROCKER ON/OFF SWITCH ON/OFF SWITCH GREEN LIGHT GREEN LIGHT ON TOP ON BOTTOM NOTE: ANGLED TERMINALS OF SWITCH ARE ALWAYS TOWARD CONTROL PANEL BOTTOM.
Page 18
SERIAL NUMBER: ________________________________________ REMARKS: ______________________________________________ I HAVE READ THE INSTALLATION AND OPERATION INSTRUCTIONS. “Serving Those Who Serve The Very Best” SIGNED: ____________________________________________________________________________________ DATE: __________________________ SERVICE INFORMATION KEATING OF CHICAGO, INC. www.keatingofchicago.com KEATING LIMITED WARRANTY CARD FRYER TOP-SIDE COOKER FILTER SYSTEM...