Antunes, AJ MS-250/255 Owner's Manual
  1. Manuals
  2. Brands
  3. Antunes, AJ Manuals
  4. Electric Steamer
  5. MS-250/255
  6. Owner's manual

Antunes, AJ MS-250/255 Owner's Manual

Antunes, aj. & co. miracle steamer owner's manual
Hide thumbs
Table of Contents

Advertisement

Quick Links

MANUFACTURING
NUMBERS:
9100420
9100426
9100428
9100430
9100436
9100438
9100450
9100456
9100458
9100460
9100462
9100466
9100468
9100480
9100486
M M I I R R A A C C L L E E S S T T E E A A M M E E R R
Models MS-150/155,
MS-250/255 & MS-355
®
US
C
P/N 1010699
Rev. B
Owner
s Manual
'

Advertisement

Table of Contents
loading

Related Manuals for Antunes, AJ MS-250/255

Summary of Contents for Antunes, AJ MS-250/255

  • Page 1 9100480 9100486 M M I I R R A A C C L L E E S S T T E E A A M M E E R R Models MS-150/155, MS-250/255 & MS-355 ® P/N 1010699 Rev. B...

  • Page 2: Table Of Contents

    A.J. Antunes & Co. Owner Information...1 General ... 1 Warranty Information ... 1 Service/Technical Assistance ... 2 Model Designation ... 2 Important Safety Information ...2 Specifications ...4 Electrical Ratings ... 4 Electrical Cord & Plug Configurations ... 4 Dimensions ... 5 Installation ...6 Unpacking ...

  • Page 3: Service/Technical Assistance

    MIRACLE STEAMER Service/Technical Assistance If you experience any problems with the installation or operation of your unit, contact your local Roundup Authorized Service Agency. They can be found in the service agency directory packaged with the equipment. Fill in the information below and have it handy when calling your authorized service agency for assistance.
  • Page 4 A.J. Antunes & Co. In addition to the warnings and cautions in this manual, use the following guidelines for safe operation of the unit. • Read all instructions before using equipment. • For your safety, the equipment is furnished with a properly grounded cord connector.

  • Page 5: Specifications

    MIRACLE STEAMER • The following tips are recommended for main- tenance of your stainless steel equipment, - Always use soft, damp cloth for cleaning, rinse with clear water and wipe dry. When required, always rub in direction of metal polish lines. - Routine cleaning should be done daily using soap, ammonia detergent and water.

  • Page 6: Dimensions

    A.J. Antunes & Co. MIRACLE STEAMER Dimensions MS-150/155 & MS-250/255 21-3/16" (53.8 cm) 17-11/32" (28.8 cm) 20-3/4" 25" 14" (35.5 cm) (52.7 cm) 8-13/32" (21.4 cm) MS-355 17-5/32" (43.5 cm) 17-5/32" 25" 25" (63.5 cm) 14" (35.5 cm) 14" P/N 1010699 Rev. B...

  • Page 7: Installation

    MIRACLE STEAMER Unpacking 1. Remove unit and all packing materials from ship- ping carton. 2. Open the large box. It should contain the follow- ing: • Miracle Steamer, • Handle, Handle Guard & Shoulder Bolt, (MS-150/250 only) • Water Hookup Kit (MS-250 only). NOTE: If any parts are missing or damaged, contact Antunes Technical Service IMMEDIATELY at 1-877- 392-7854 or 1-630-784-1000.
  • Page 8 A.J. Antunes & Co. WARNING ELECTRICAL SHOCK HAZARD. FAILURE TO FOLLOW THE INSTRUCTIONS IN THIS MANUAL COULD RESULT IN SERIOUS INJURY OR DEATH. • Electrical ground is required on this appliance. • Do not modify the power supply cord plug. If it does not fit the outlet, have a proper outlet installed by a qualified electrician.

  • Page 9: Operation

    MIRACLE STEAMER Model MS-250/255 The MS-250/255 requires a direct water hookup. An installation kit is packed inside the unit. 1. Connect the 1/4" (6.5 mm) I.D. flexible tubing to your cold water line using the supplied hose clamp. 2. Push the quick disconnect insert into the fitting on the back of the unit (Figure 4).

  • Page 10: Operating Instructions

    • Steam Shot Time (H O) = MS-150/155/355 - (1_00) or 1.00 sec MS-250/255 - (0_70) or 0.70 sec (Range: 0.10 sec to 2.50 sec) This converts approximately 3/4 oz. (25 milliliters) of water to steam every 20 seconds for a 15 minute cook- ing cycle.
  • Page 11 POWER E. SHO Time in Seconds NOTE: Recommended settings are: MS-250/255 - [0_40] or 0.40 sec (120 VAC) MS-250/255 - [0_70] or 0.70 sec (208-240 VAC) MS-150/155/355 - [1_00] or 1.00 sec (208-240 VAC) 10. Press the Start/Stop button to store the changes, exit the PROGRAM Mode and initiate the cooking cycle.

  • Page 12: Steaming Tips

    A.J. Antunes & Co. Steaming Tips • Pre-cooked pasta is easily reconstituted, and gives you a hot product without the wetness of the nor- mal “dip” method. • Experiment with your products and different steam- ing times–a little more or less steam could change the appearance/flavor.

  • Page 13: Maintenance

    MIRACLE STEAMER WARNING Turn the unit off, disconnect the power source and allow the unit to cool down before performing any service or maintenance on the unit. CAUTION Chlorides or phosphates in cleansing agents (e.g. bleach, sanitizers, degreasers or detergents) could cause permanent damage to stainless steel equipment.
  • Page 14 A.J. Antunes & Co. 5. Examine all generator orifices (holes). If mineral deposits have formed, place a flat blade screw- driver into openings. Use a gentle twisting motion to scrape openings clean. NOTE: If the mineral deposits come off in “flakes” or in layers, build-up is excessive.
  • Page 15 9. Install access cover and tank assembly. 10. Fill water tank and test unit. NOTE: The MS-355 does not use a water filter. Direct water hook-up Units (MS-250/255) Use of the optional water regulator kit, part no. 7000235, is recommended (see page 25).

  • Page 16: Troubleshooting

    A.J. Antunes & Co. To avoid possible personal injury and/or damage to the unit, inspection, test and repair of electrical equip- ment should be performed by qualified service personnel. The unit should be unplugged when servicing, except when electrical tests are required. Problem Unit will not heat up.
  • Page 17 MIRACLE STEAMER Problem Steam from generator is Restrictor tube or generator tubes are reduced compared to former clogged. operation. Flooding condition. Insufficient preheat. Filters require cleaning. Control board setpoint temperature too low. Heavy deposit buildup on the genera- tor. Unit becomes flooded or Incorrect water pressure.
  • Page 18 A.J. Antunes & Co. Problem Unit heats up, pump or sole- Programming. noid valve works with the If Ready light does not light but the momentary switch but will unit steams regularly, the Ready light not steam during timer is inoperable. cycles.

  • Page 19: Replacement Parts

    MIRACLE STEAMER REPLACEMENT PARTS MS-150/155/250/255 A.J. Antunes & Co. P/N 1010699 Rev. B...
  • Page 20 A.J. Antunes & Co. Item Part No. Description 0010159 Filter Assy., Water Tank (MS-150) 4050125 Relay 0010584 Inlet Hose Assy. (MS-250) 0011114 Pump/Tube Assy., 24V (MS-150) 0011123 Solenoid Valve Assy. (MS-250) 0011289 Top Cover Assy. 0011314 Chimney Assy. 0021131 Floor/Chassis Weldment 0021179 Access Cover Weldment (MS-150) 0100217...
  • Page 21 MIRACLE STEAMER INSET B (Model MS 150) MS-150/155/250/255 NOTE: Refer to parts list on page 19. INSET A (Model MS 150) INSET C (Model MS 150) A.J. Antunes & Co. P/N 1010699 Rev. B...
  • Page 22 A.J. Antunes & Co. MIRACLE STEAMER MS-150/155/250/255 NOTE: Refer to parts list on page 19. INSET A (Model MS 250) INSET B (Model MS 250) P/N 1010699 Rev. B...
  • Page 23 MIRACLE STEAMER Item Part No. Description 0011314 Steam Vent Assy. 0011408 Top Cover Assy. (Incl. #73-77) 0011413 Liner Assy. (Incl. #65, 69, 72) 0011414 Drawer Assy. (Incl. #64-71) 0011416 Main Housing Assy. 0011418 Main Housing Assy. 0400138 Locknut, Conduit, 1/2" 0400251 Strain Relief 0503441...
  • Page 24 A.J. Antunes & Co. INSET A (Model MS 355) INSET C (Model MS 355) P/N 1010699 Rev. B MS-355 INSET B (Model MS 355) 44 62 MIRACLE STEAMER NOTE: Refer to parts list on page 22.
  • Page 25 MIRACLE STEAMER MS-355 NOTE: Refer to parts list on page 22. A.J. Antunes & Co. P/N 1010699 Rev. B...
  • Page 26 A.J. Antunes & Co. REPLACEMENT PARTS (continued) Water Pressure Regulator Kit - Part No. 7000235 To Steamer Water Supply P/N 1010699 Rev. B Item To Steamer 0503615 2030125 2040150 2040151 2080105 2080118 2170113 2170114 2190113 2110160 IMPORTANT: Two steamer units can be connected into one water pressure regulator.

  • Page 27: Wiring Diagrams

    MIRACLE STEAMER POWER CORD TERMINAL BLOCK POWER SWITCH WIRING DIAGRAMS MS-150/155/250/255 NOTE: ALL WIRES TO BE 14 GA. AWM–105 C UNLESS OTHERWISE SPECIFIED. #18 GA. AWM–105 C 22 GA. AWM–105 C HI-LIMIT HEATER THERMOSTAT SOLENOID 120V 230V TRANSFORMER MS-355 A.J. Antunes & Co. MOMENTARY THERMOCOUPLE SWITCH...

  • Page 28: Warranty

    Equipment manufactured by Roundup Food Equipment Division of A.J. Antunes & Co. has been constructed of the finest materials available and manufactured to high quality standards. These units are warranted to be free from mechanical and electrical defects for a period of one year from date of purchase or 18 months from shipment from factory, whichever occurs first, under normal use and service, and when installed in accordance with manufacturer’s recommendations.

This manual is also suitable for:

Roundup ms-355Roundup ms-150Roundup ms-155Roundup ms-250Roundup ms-255

Table of Contents