Tecumseh AH520 Technician's Handbook

Tecumseh AH520 Technician's Handbook

2-cycle engines
Hide thumbs Also See for AH520:
Table of Contents

Advertisement

TECUMSEH
T E C H N I C I A N ' S
H A N D B O O K
This manual covers the following basic type or model
numbers dependent on age of product: AH520, AH600,
AV520, AV600, HSK600, TVS600.
This manual covered many engines under an Old form of
Identification which will need to be reviewed as well.
TYPE / SPECIFICATION NUMBER 638-670 1398-1642 and
Craftsman 200 Series Models.
2-CYCLE
ENGINES

Advertisement

Table of Contents
loading

Summary of Contents for Tecumseh AH520

  • Page 1 T E C H N I C I A N ' S H A N D B O O K This manual covers the following basic type or model numbers dependent on age of product: AH520, AH600, AV520, AV600, HSK600, TVS600. This manual covered many engines under an Old form of Identification which will need to be reviewed as well.
  • Page 2 All rights reserved. No part of this book may be reproduced or transmitted, in any form or by any means, electronic or mechanical, including photocopying, recording or by any information storage and retrieval system, without permission in writing from Tecumseh Products Company Training Department Manager.
  • Page 3 IGNITION ..............CYLINDERS, REEDS & COMPRESSION RELEASE ..............IGNITION SERVICE ..........TROUBLESHOOTING ..........SPECIFICATIONS ..........OUTBOARD TIMING ..........SEARS CRAFTSMAN CROSS REFERENCE ..TABLE OF SPECIFICATIONS ....... CYLINDERS & INTERNAL COMPONENTS ..TABLE OF TORQUE LIMITS ......... EDUCATIONAL MATERIALS AND TOOLS ..CONNECTING ROD SERVICE ......
  • Page 15 Loosen screw until it just clears THROTTLE SHAFT AND LEVER IDLE SPEED ADJUSTMENT SCREW throttle lever, then turn screw in 1 Check shaft for looseness or binding. turn. THROTTLE SHUTTER Shutter must be positioned with detent reference mar ks on top Do not attempt to remove.
  • Page 16 Loosen screw until it just clears CHOKE SHAFT AND LEVER Check shaft for binding. Position throttle lever, then turn screw in 1 IDLE SPEED ADJUSTMENT SCREW shutter opening towards inlet fitting turn. CHOKE SHUTTER side of air horn. THROTTLE SHAFT LEVER AND Place detent reference mark to RETURN SPRING proper location.
  • Page 20 FLOAT TYPE CARBURETOR DIAPHRAGM TYPE CARBURETOR...
  • Page 24 ONE PIECE ROPE RETAINER...
  • Page 26 RETAINER WEDGE STARTER HOUSING STARTER PULLEY SPRING & COVER DOG SPRING STARTER DOG DOG RETAINER...
  • Page 28 * USED ON SOME MODELS...
  • Page 31 ­...
  • Page 33 Ô Ô...
  • Page 37 CRANKSHAFT POINTS PIVOT...
  • Page 38 DIAL AT .090” (2.29 mm) DIAL AT .080” (2.0 mm) DIAL SCREW DIAL AT 0 LINT FREE PAPER...
  • Page 39 STEPPED KEY STEPPED TOWARD ENGINE .0125” (.317 mm)
  • Page 48 Ô Ô Ô...

This manual is also suitable for:

Av600Ah600Hsk600Tvs600Av520

Table of Contents