Page 1
DSC-P93 SERVICE MANUAL LEVEL US Model Ver 1.1 2004.10 Canadian Model Revision History Revision History AEP Model UK Model E Model How to use How to use Acrobat Reader Acrobat Reader Hong Kong Model Australian Model Chinese Model Korea Model...
DSC-P93 SPECIFICATIONS x Camera [LCD screen] x BC-CS2A/CS2B Ni-MH battery [System] charger LCD panel used 3.8 cm (1.5 type) TFT drive Image device 9.04 mm (1/1.8 type) color Power requirements Total number of dots AC 100 to 240V 50/60Hz Primary color filter 134 400 (560×240) dots...
Page 3
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU PUBLISHED BY SONY.
DSC-P93 Ver 1.1 2004.10 SECTION 1 SERVICE NOTE 1-1. NOTE FOR REPAIR Make sure that the flat cable and flexible board are not cracked of When remove a connector, don’t pull at wire of connector. bent at the terminal. It is possible that a wire is snapped.
1-4. DESCRIPTION ON SELF-DIAGNOSIS DISPLAY Self-diagnosis display • C: ss: ss You can reverse the camera malfunction yourself. (However, contact your Sony dealer or local authorized Sony service facility when you cannot recover from the camera malfunction.) • E: ss: ss Contact your Sony dealer or local authorized Sony service facility.
DSC-P93 SECTION 2 HELP HELP DISASSEMBLY 2-1. FLOW CHART The following flow chart shows the disassembly procedure. 1 Tape (A) HELP 1 Open the BT lid. 1 Mic unit flexible: CN707 2 FP-854: CN702 2 Screw (M1.7) x5 2 Claw 3 Lens block flexible:601 3 Close the BT lid.
Page 8
DSC-P93 2-2. SY-100 BOARD SERVICE POSITION Rear cabinet block Flush unit ST-095 board Control switch block MS board FP-860 flexible board Lens block Color monitor SY-100 board AC power AC IN adaptor...
DSC-P93 2-3. CIRCUIT BOARDS LOCATION SY-100 (including CH-146) SW-417 CH-146 (included in SY-100) CD-498 ST-095 MS (FP-861) Board Name Function CD-498 CCD IMAGER CH-146 CCD SIGNAL PROCESS (included in SY-100) MS (FP-861) MEMORY STICK CONNECTOR ST-095 FLASH DRIVE SW-417 CONTROL SWITCH, LCD DRIVE...
Page 10
DSC-P93 HELP Sheet attachment positions and procedures of processing the flexible boards/harnesses are shown. Tape (A) CN702 RL electrostatic SY-100 board SY radiation sheet CN601 CN001 Lens block CD radiation sheet CN801 CD-498 board SW-417 board Reset sheet HELP...
DSC-P93 3. BLOCK DIAGRAMS Link Link OVERALL BLOCK DIAGRAM (1/2) POWER BLOCK DIAGRAM (1/2) OVERALL BLOCK DIAGRAM (1/2) POWER BLOCK DIAGRAM (1/2) OVERALL BLOCK DIAGRAM (2/2) POWER BLOCK DIAGRAM (2/2) OVERALL BLOCK DIAGRAM (2/2) POWER BLOCK DIAGRAM (2/2)
Page 12
DSC-P93 SECTION 3 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS BLOCK DIAGRAMS 3-1. OVERALL BLOCK DIAGRAM (1/2) ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. CD-498 BOARD (1/2) SY-100 BOARD (1/2)
Page 13
DSC-P93 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. 3-2. OVERALL BLOCK DIAGRAM (2/2) SY-100 BOARD (2/2) FP-860 FLEXIBLE BOARD CN751 (1/2)
Page 14
DSC-P93 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS 3-3. POWER BLOCK DIAGRAM (1/2) ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. SY-100 BOARD (1/2) CONTROL SWITCH BLOCK CN001 Q006, 007...
Page 15
DSC-P93 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. 3-4. POWER BLOCK DIAGRAM (2/2) SY-100 BOARD (2/2) ST-095 BOARD CN703 CN851 T851...
DSC-P93 4-2. SCHEMATIC DIAGRAMS Link Link CD-498 BOARD CD-498 BOARD (CCD IMAGER) FP-860 FLEXIBLE BOARD (CCD IMAGER) FP-860 FLEXIBLE BOARD (JACK) (JACK) SW-417 BOARD SW-417 BOARD MIC UNIT MIC UNIT (MA-002) (MA-002) (CONTROL SWITCH, LCD DRIVE) (CONTROL SWITCH, LCD DRIVE)
Page 18
DSC-P93 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS THIS NOTE IS COMMON FOR SCHEMATIC DIAGRAMS (In addition to this, the necessary note is printed in each block) (For schematic diagrams) 1. Connection • All capacitors are in µF unless otherwise noted. pF : µ...
Page 19
DSC-P93 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS CD-498 BOARD CD-498 BOARD For Schematic Diagram • Refer to page 4-37 for printed wiring board. CD-498 BOARD CCD IMAGER (CCD BLOCK) Note: Voltage and Waveform of mounted IC801,Q802,Q803 and Q805 on CD-498 board can not be measured because they are mounted XX MARK:NO MOUNT by the side of the lens.
Page 20
Schematic diagrams of the CH-146 and SY-100 boards are not shown. Pages from 4-9 to 4-26 are not shown.
Page 21
DSC-P93 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS SW-417 BOARD SW-417 BOARD For Schematic Diagram • Refer to page 4-43 for printed wiring board. SW-417 BOARD CONTROL SWITCH,LCD DRIVE (PD BLOCK) XX MARK:NO MOUNT NO MARK:REC/PB MODE CN201 KEY_AD2 KEY_AD2 REG_GND...
Page 22
DSC-P93 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS ST-095 BOARD ST-095 BOARD For Schematic Diagram • Refer to page 4-45 for printed wiring board. ST-095 BOARD FLASH DRIVE (ST BLOCK) T851 D852 XX MARK:NO MOUNT HAU160C030STP NO MARK:REC/PB MODE LND851 XE_H...
Page 23
DSC-P93 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS MS BOARD MS BOARD FP-860 FLEXIBLE BOARD FP-860 FLEXIBLE BOARD For Schematic Diagram For Schematic Diagram • Refer to page 4-47 for printed wiring board. • Refer to page 4-48 for printed wiring board.
Page 24
DSC-P93 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS MIC UNIT (MA-002) CONTROL SWITCH BLOCK (RL530TT) MICROPHONE UNIT (MA-002) is replaced as block, CONTROL SWITCH BLOCK (RL530TT) is replaced as block, so that PRINTED WIRING BOARD is omitted. so that PRINTED WIRING BOARD is omitted.
DSC-P93 4-3. PRINTED WIRING BOARDS 4-3. PRINTED WIRING BOARDS 4-4. MOUNTED PARTS LOCATION no mark : side A * mark : side B CD-498 BOARD * C801 C804 C807 C808 * C809 * C810 CN801 B-1 * D801 * D802...
Page 33
Mounted parts location of the CH-146 and SY-100 boards are not shown. Page 4-50 is not shown.
Page 34
DSC-P93 4-3. PRINTED WIRING BOARDS 4-3. PRINTED WIRING BOARDS no mark : side A * mark : side B SW-417 BOARD ST-095 BOARD * C202 C851 * C203 * C853 * C205 C854 * C206 * C207 CN851 A-3 * C208...
DSC-P93 NOTE NOTE 5. REPAIR PARTS LIST NOTE: Characters A to Z of the electrical parts list indicate location of exploded views in which the desired part is shown. EXPLODED VIEWS EXPLODED VIEWS Link Link FRONT CABINET FRONT CABINET LENS BLOCK SECTION...
Page 36
DSC-P93 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST SECTION 5 REPAIR PARTS LIST NOTE: • -XX, -X mean standardized parts, so they may have some differences from When indicating parts by reference number, the original one. please include the board name.
Page 37
DSC-P93 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST 5-1. EXPLODED VIEWS 5-1-1. FRONT CABINET BLOCK SECTION Rear cabinet block section (See page 5-5.) BT holder block section (See page 5-4.) Lens block section (See page 5-3.) Ref. No. Part No.
Page 38
DSC-P93 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST 5-1-2. LENS BLOCK SECTION - 4 9 IC801 (Note 1, 2) (Note 1) IC801 is not included in CD-498 complete board. (Note 2) Be sure to read “Precuations for Replacement of CCD Imager”...
DSC-P93 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST 5-1-3. BT HOLDER BLOCK SECTION ns: not supplied C852 (Note) - 1 0 - 0 9 (including CH-146 board) BT001 BT901 SP901 (Note) C852 is not included in ST-095 complete board.
DSC-P93 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST 5-1-4. REAR CABINET BLOCK SECTION ns: not supplied - 4 1 LCD901 D901 The components identified by Les composants identifiés par une mark 0 or dotted line with marque 0 sont critiques pour la mark 0 are critical for safety.
DSC-P93 CD-498 5-2. ELECTRICAL PARTS LIST Ref. No. Part No. Description Ref. No. Part No. Description A-7113-089-A CD-498 BOARD, COMPLETE *********************** (IC801 is not included in this complete board.) < CAPACITOR > C801 1-107-826-11 CERAMIC CHIP 0.1uF C804 1-100-505-11 CERAMIC CHIP 0.1uF...
Page 46
[Description of main button functions on toolbar of the Adobe Acrobat Reader Ver5.0 (for Windows)] Toolbar Printing a text Reversing the screens displayed once • To reverse the previous screens (operation) one by one, click 1. Click the Print button 2.
Reverse 987672532.pdf Revision History S.M. Rev. Ver. Date History Contents issued 2004.03 Official Release — — 2004.10 Correction-1 • Correction of SERVICE NOTE (C1) S.M. correction : Page 1-1...