SERVICING NOTICES ON CHECKING 1. KEEP THE NOTICES 6. AVOID AN X-RAY As for the places which need special attentions, Safety is secured against an X-ray by consider- they are indicated with the labels or seals on the ing about the cathode-ray tube and the high cabinet, chassis and parts.
CONTENTS SERVICING NOTICES ON CHECKING ...................... A1-1 HOW TO ORDER PARTS ..........................A1-1 IMPORTANT ............................... A1-1 CONTENTS ..............................A2-1 GENERAL SPECIFICATIONS ........................A3-1~A3-4 DISASSEMBLY INSTRUCTIONS 1. REMOVAL OF ANODE CAP ....................... SERVICE MODE LIST ..........................CONFIRMATION OF USING HOURS ......................NOTE FOR THE REPLACING OF MEMORY IC ..................
GENERAL SPECIFICATIONS G-1.Outline of the Product inch( 806.0 mmV):Measured diagonally Color CRT 110 degree deflection G-2.Broadcasting System System G-3.Color System NTSC SECAM or Monochrome signal G-4.NTSC Playback(PAL 60Hz) G-5.NTSC 3.58+4.43/PAL60Hz G-6.Antenna Input Impedance VHF/UHF 75 ohm unbalanced G-7.Tuner and Receiving Contactless Electric tuner 1Tuner System 2Tuner System...
Page 5
GENERAL SPECIFICATIONS G-17. P rotector: Power Fuse G-18.Regulation S afety NEMKO FEMKO DEMKO IEC65 SEMKO HOMOLO SABS SISIR AS3159 DENTORI GOST NONE Radiation SABA HOMOLO CISPR13 DENTORI AS/NZS NONE X-Radiation DHHS DENTORI NONE G-19.Temperature Operation ºC~ 40 ºC Storage ºC~ 60 ºC G-20.Operating Humidity Less than G-21.Clock and Timer...
Page 6
GENERAL SPECIFICATIONS G-26.OSD Language OSD Language Setting Not Applicable G-27.Speaker : P o s i t i o n Front Side Bottom Size inches 8 ohm x Power 3.5 + 3.5 W 10% 2.6 + 2.6 W (Typical) 4 ohm x (form OCT Order) Power 5.0 + 5.0 W...
Page 7
GENERAL SPECIFICATIONS G-32.Switch Front Power(Tact) Channel Up/Reset Volume Up/Set Up System Select Channel Down/Enter Volume Down/Set Down Main Power S W Sub Power Menu:Vol Up + Vol Down Rear AC/DC TV/CATV Selector Degauss Main Power S W G-33.Magnetic Field BV : +0.45G BV : +0.35G...
DISASSEMBLY INSTRUCTIONS 3. After one side is removed, pull in the opposite direction to 1. REMOVAL OF ANODE CAP remove the other. Read the following NOTED items before starting work. NOTE After turning the power off there might still be a potential Take care not to damage the Rubber Cap.
SERVICE MODE LIST This unit provided with the following SERVICE MODES so you can repair, examine and adjust easily. To enter the Service Mode, press both set key and remote control key for more than 2 seconds. Set Key Remocon Key Operations Releasing of V-CHIP PASSWORD.
ELECTRICAL ADJUSTMENTS 1. BEFORE MAKING ELECTRICAL 1. RF AGC DELAY ADJUSTMENTS 2. VIDEO LEVEL Read and perform these adjustments when repairing the 3. FM LEVEL circuits or replacing electrical parts or PCB assemblies. 4. OSD H 5. CUT OFF CAUTION 6.
Page 11
ELECTRICAL ADJUSTMENTS 2-4: SUB TINT/SUB COLOR (TV) 2-5: SUB TINT/SUB COLOR (AV) Receive the color bar pattern. (RF Input) Receive the color bar pattern. (Audio Video Input) Connect the synchro scope to pin 1 of CP101 and the Connect the synchro scope to pin 1 of CP101 and the pin 6 (GND) of CP101.
Page 12
ELECTRICAL ADJUSTMENTS 2-9: HORIZONTAL PHASE 2-14: CONSTANT VOLTAGE Receive the color bar pattern. Place the set with Aging Test for more than 15 minutes. Using the remote control, set the brightness and Using the remote control, set the brightness and contrast contrast to normal position.
ELECTRICAL ADJUSTMENTS 3-3: STATIC CONVERGENCE 3. PURITY AND CONVERGENCE ADJUSTMENTS NOTE Adjust after performing adjustments in section 3-2. NOTE Receive the crosshatch pattern from the color bar Turn the unit on and let it warm up for at least 30 generator.
Page 32
MT2325 SERVICE MANUAL COLOR TELEVISION RECEIVER REVISION 1 MFR’S VERSION B MFR’S VERSION SPEAKER MSF-30SB05 MSF-30SB05-1 Please file this revision with the original version.
Page 33
DIFFERENCES Alteration of SPEAKER. MFR'S VERSION A MFR'S VERSION B REF.NO PART NO. DESCRIPTION PART NO. DESCRIPTION SP351 070W036001 SPEAKER MSF-30SB05 070W036003 SPEAKER MSF-30SB05-1 SP352 070W036001 SPEAKER MSF-30SB05 070W036003 SPEAKER MSF-30SB05-1 R361 R801R7151J RC 150 OHM 1/10W R801R7101J RC 100 OHM 1/10W R362 R801R7151J RC 150 OHM 1/10W...