TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE, BODILY INJURY, OR EVEN DEATH. APPROVED FOR USE IN THE U.S. AND CANADA IF THIS HARMAN STOVE IS NOT INSTALLED CORRECTLY, A HOUSE FIRE MAY RESULT. FOR YOUR SAFETY, FOLLOW INSTALLATION DIRECTIONS PRECISELY.
Page 2
Please read this entire instruction manual before attempting to install or operate your new stove. If you have further questions regarding your new stove, contact your Harman dealer. Follow these in- structions and you will have many years of warmth and comfort enjoying your new coal stove.
Index SaFeTy CoNSIderaTIoNS - Warnings to operator of possible dangers, fire hazards and cautions. Keep children away -- may cause serious burns Fuel/Firing Warnings Curing Paint Mobile Homes aSSeMbly & INSTallaTIoN Unpacking and Inspection of Parts locating The Stove assembly General Information VeNTING Types of Chimneys...
Installation 1. Safety Considerations: 2. Assembly & Installation: 1.1 KEEP CHILDREN AWAY - MAY CAUSE 2.1 UNPACKING AND INSPECTION OF SERIOUS BURNS. PARTS. Inspect the stove for any visible damage. The blower CaUTIoN: all surfaces of the stove are hot. do not and the shaker handle are packaged inside the stove.
Installation 2.4 GENERAL INFORMATION. 2.3 ASSEMBLY. Slide the blower into the slotted bracket on the rear Installation Checklist: a. Have your stove installed by a trained installer. of the stove. The blower will rest at the bottom of the slot. Preferably one who is certified by the National Fire- place Institute or similar certification agency.
Venting 3.2 COMMON CHIMNEY PROBLEMS Where an existing chimney is used, it must be large In order to have a properly operating heating system, enough to provide a draft adequate for removing the the chimney needs to be capable of providing suf- gaseous products of combustion.
Venting & Grates 4. Grates e) Improperly sized flue - Too small of a chimney is incapable of moving the volume of air necessary. Too 4.1 GRATE SYSTEM AND CONTROLS. large of a flue could have trouble warming up to cre- The Grates are made of heavy-duty cast iron.
PleaSe reFer To yoUr WarraNTy To See ably hot fire. The coal bed should be bright and vigor- HarMaN SToVeS lIMIT oF lIabIlITy IN CaSeS ous. If the fire is burning hot and there is a deep bed oF abUSe or NeGleCT.
Maintenance 5.6 SAFETY To clean the chimney, use a stiff brush with an extend- Whenever a loading door is opened, it should always able handle. Start the brush from the top of the chim- be cracked slightly to allow oxygen to enter and burn ney and run it down through the flue.
Optional Water Coil 7. Optional Hot Water Coil: Plumbing Diagrams- Washer Inside Nut Outside Nut Packing Stove Body Magnafire Series Coal Stoves...
Page 11
Optional Water Coil To install the optional hot water coil, Two holes will need to be drilled or cut into the side of the stove. There is a template for the hole location(s) that is included with the coil. Keep the holes above the firebricks and toward the back of the firebox.
Page 14
Service & Maintenance Log Date Of Service Performed By Description Of Service...
Page 15
Service & Maintenance Log Date Of Service Performed By Description Of Service...