Coleman Firelight 5071 Series Instructions For Use

Setup with Hose and Refillable Cylinder
Warranty
(hose sold separately)
Limited One Year Warranty
The Coleman Company, Inc. ("Coleman") How to Obtain Warranty Service
warrants that for a period of one year from the Take the product to an authorized Coleman
date of original retail purchase, this product will service center.You can find the nearest
• Read and follow all instructions and warnings
be free from defects in material and authorized Coleman service center by visiting
provided with your appliance.
workmanship. Coleman, at its option, will repair or www.coleman.com or calling 1-800-835-3278 or
• Do not store LP gas cylinders under or near
replace this product or any component of the TDD 316-832-8707 in the United States or 1 800 this appliance.
387-6161 in Canada. If a service center is not • Never fill the cylinder beyond 80% full.
product found to be defective during the warranty
• Failure to follow the above instructions
period. Replacement will be made with a new or conveniently located, attach to the product a tag
exactly may result in fire causing death or
remanufactured product or component. If the that includes your name, address, daytime
serious injury.
product is no longer available, replacement may telephone number and description of the problem.
be made with a similar product of equal or greater Include a copy of the original sales receipt.
• A disposable propane cylinder must not remain
value. This is your exclusive warranty. Carefully package the product and send either by
connected to the fireplace when using the hose
This warranty is valid for the original retail courier or insured mail with shipping and
and refillable cylinder. Install the shut-off plug
purchaser from the date of initial retail purchase insurance prepaid to: into the remaining fuel connection.
and is not transferable. Keep the original sales • When using extension hose always point the
cylinder valve toward the fuel inlet of the
receipt. Proof of purchase is required to obtain The Coleman Company, Inc.
appliance.
warranty performance. Coleman dealers, service 3600 North Hydraulic
• Maintain proper clearances between cylinder and
centers, or retail stores selling Coleman® Wichita, KS 67219
appliance. The cylinder must be positioned with
products do not have the right to alter, modify or 60 inch clearance between the cylinder and the
inlet of the gas fireplace.
in any way change the terms and conditions of The costs of transporting the product to
• Clean and inspect the hose before each use. If
this warranty. Coleman or an authorized service center for
there is evidence of abrasion, wear, cuts or leaks,
warranty service is the responsibility of the
the hose must be replaced prior to use. The
What This Warranty Does Not Cover purchaser.
replacement hose must be that specified by The
This warranty does not cover normal wear of Do not mail products with fuel in tanks, or with Coleman Company, Inc.
• Never alter in any way or use with any device or
parts, parts that are not genuine Coleman® parts, disposable propane cylinders. Remove glass
part not expressly approved by Coleman.
or damage resulting from any of the following: globes from lanterns and wrap separately.
negligent use or misuse of the product; use on DO NOT RETURN THIS PRODUCT TO THE
INSTRUCTIONS FOR USE
improper voltage or current; commercial use of PLACE OF PURCHASE.
• High Pressure Hose Extension R5071-522 is
the product; use contrary to the operating If you have any questions regarding this
only for use with Coleman gas fireplace model
instructions; disassembly, repair or alteration by warranty please call 1-800-835-3278 or 5071. See your dealer or contact Coleman to
anyone other than Coleman or an authorized TDD 316-832-8707 in the United States purchase the accessory hose.
• The LP-gas supply cylinder to be used must be
service center. Further, the warranty does not or 1 800 387-6161 in Canada.
constructed and marked in accordance with the
cover Acts of God, such as fire, flood, hurricanes
specifications for LP-gas cylinders of the U.S.
and tornadoes. Warranty void if damage to
Department of Transportation (DOT) or the
product results from the use of a part other than a National Standard of Canada, CAN/CSA B339,
cylinders, spheres and Tubes for the
genuine Coleman® part.
Transportation of Dangerous Goods.
COLEMAN SHALL NOT BE LIABLE FOR
• If a refillable cylinder is used, it must have a
DEFECTS THAT ARE CAUSED BY THE USE
collar to protect the cylinder valve.
OF UNAUTHORIZED PARTS OR SERVICE.
COLEMAN SHALL NOT BE LIABLE FOR ANY
INCIDENTAL OR CONSEQUENTIAL
DAMAGES CAUSED BY THE BREACH OF
ASSEMBLING HIGH PRESSURE HOSE:
ANY EXPRESS OR IMPLIED WARRANTY OR
■ Close the burner
CONDITIONS. EXCEPT TO THE EXTENT
valve firmly (Fig. 28).
PROHIBITED BY APPLICABLE LAW, ANY
IMPLIED WARRANTY OF MERCHANTABILITY
OR FITNESS FOR A PARTICULAR PURPOSE
IS LIMITED IN DURATION TO THE DURATION
The Coleman Company, Inc. • 3600 North Hydraulic
• Wichita, KS 67219 U.S.A.
OF THE ABOVE WARRANTY OR
1-800-835-3278 • TDD: 316-832-8707
CONDITIONS. SOME STATES, PROVINCES,
OR JURISDICTIONS DO NOT ALLOW THE
■ Remove the plastic protective cap from the
EXCLUSION OR LIMITATION OF INCIDENTAL © 2006 The Coleman Company, Inc. All rights reserved.
shut-off plug. Install the shut-off plug into the
OR CONSEQUENTIAL DAMAGES OR
left fuel connection (Fig. 29 and 30).
LIMITATIONS ON HOW LONG AN IMPLIED
Coleman® and---------------------- are registered
WARRANTY LASTS, SO THE ABOVE trademarks and INSTASTART™ and FIRELIGHT™ are
trademarks of The Coleman Company, Inc.
LIMITATIONS OR EXCLUSION MAY NOT
APPLY TO YOU. THIS WARRANTY GIVES
YOU SPECIFIC LEGAL RIGHTS, AND YOU
MAY ALSO HAVE OTHER RIGHTS THAT VARY
FROM STATE TO STATE OR PROVINCE TO
PROVINCE. 5071B050 (10/18/06)
WARNING
• Hose R5071-522 is for use with gas fireplace
Model 5071 only.
• The gas hose is a tripping hazard. Keep
■ Attach the 8' accessory hose to the right side
yourself and others away from the gas hose
WARNING
connector on the Fireplace (Fig 31). when in use or attached to the fireplace.
• Do not tip or move the fuel supply.
Protective
Collar
Fig. 31
■ Attach the hose to the cylinder (Fig 32).
• Turn off fuel at the cylinder and disconnect
both ends of the hose when not in use.
• You must follow these instructions exactly or
a fire causing death or serious injury may
occur.
Dismantling High
Pressure Hose
■ Before dismantling high pressure hose, be sure
Fig. 32
gas pressure in hose is eliminated.
■ Ignite fireplace and turn off gas valve on
■ Open cylinder valve and perform leak check on
cylinder.
Hose to Regulator, and Hose to Cylinder con-
■ Allow flame to self-extinguish.
nections with soapy water. Bubbles indicate a
■ When flame is out, close valve on fireplace.
leak. Check that the connection is not cross-
■ Remove hose.
threaded and that it is tight. Perform another
leak check. If there is still a leak, remove the
To Light
cylinder and contact Coleman for service or
repairs (Fig. 33 and 34).
WARNING
If you smell gas:
1. Do not attempt to light appliance.
2. Extinguish any open flame.
3. Disconnect from fuel supply.
4. Call 1-800-835-3278.
DANGER
Fig. 33
• EXPLOSION - FIRE HAZARD
• Propane is heavier than air and can
accumulate in low places. If you smell gas,
Fig. 28
leave the area immediately.
• Always attach or detach propane source
outdoors; never while the gas fireplace is
lighted, near flame, pilot lights, other ignition
sources or while fireplace is hot to touch.
• This fireplace is very hot during use and can
ignite flammables too close to the burners.
Minimum distance from sides and back of unit
to walls or railings is 48 inches (122 cm). Do
Fig. 34
not use under overhead unprotected
combustible construction. Keep gasoline and
other flammable liquids and vapors well away
Fig. 29 Fig. 30 from the gas fireplace.
English-7
Battery
To Clean Troubleshooting
INSTASTART™
Symptom: Burner will not light using the
Electronic Ignition Fireplace ■ Make sure fireplace is cool.
■ Remove both propane cylinders from regulator INSTASTART™ ignition system.
■ Push igniter button and hold; then open fuel
Problem: Battery is dead.
and replace protective caps on cylinders
valve fully (Fig. 36). Solution: Replace with a fresh alkaline
(Fig. 38).
AA battery. You may also light the burner using
a match (see page 8).
Symptom: Burner will not light using the
INSTASTART™ ignition system.
Problem: Excess unburned fuel prevents ignition.
Solution: Turn off fuel and allow excess fuel to
dissipate for five minutes. Review lighting
procedure. You may also light the burner using
a match (see page 8).
Symptom: Burner will not light using the
Fig. 38
Fig. 36
INSTASTART™ ignition system.
Problem: Igniter cage opening is obstructed.
■ Wipe granite surfaces clean with soft cloth and
WARNING Solution: Clear cage of glass and rock, allow
mild dish detergent. Do not use abrasives.
excess fuel to dissipate before relighting (see
page 6).
To Store
Symptom: Burner will not light using the
• BURN HAZARD
INSTASTART™ ignition system.
DANGER
Problem: Ignition wires or electrode are
• Never leave gas fireplace unattended
disconnected or damaged.
Fig. 35 when hot or in use.
Solution: Check connections and replace
• Keep out of reach of children.
damaged items.
■ Proper fireplace operation produces a yellow • EXPLOSION - FIRE HAZARD
Symptom: Burner will not light or flame self-
flame approximately 6 - 8 inches tall. Flame • Never store propane near high heat, open
extinguished.
height is not adjustable. flames, pilot lights, direct sunlight, other
Problem: Fuel bottle is empty.
ignition sources or where temperatures
Solution: If using 16.4 oz. disposable
exceed 120 degrees F (49°C).
CAUTION
propane cylinders, replace with new
• The cylinder must be disconnected when the
cylinders. If using a refillable 20# cylinder,
gas fireplace is in storage.
If the burner flame is accidentally
refill the cylinder.
• Do not store a spare LP-gas cylinder under or
extinguished, turn off the regulator valve
near this appliance. Failure to follow the above
and wait 5 minutes before relighting
instructions exactly may result in fire causing
the appliance.
death or serious injury.
Note: If the fireplace is wet due to rain, high
humidity, etc., the electrode may not spark. Use
■ Place the Inner Granite Surface over the
match lighting procedure as follows.
firebowl (Fig. 39).
Match Light Fireplace
■ Place lighted match near electrode cage and
open fuel valve fully.
Things You Should Know
To Turn Off
1. It is unsafe and illegal in some places to store or
use propane cylinders of greater than 1.14 kg (2.5
DANGER
lbs) water capacity (approximately 1 lb. propane) in
occupied enclosures.
2. For repair service call one of the numbers on
the front cover for location of your nearest
Coleman Service Center. If a service center is not
Fig. 39
• EXPLOSION - FIRE HAZARD
conveniently located, attach to the product a tag
• Do not use the Inner Granite Surface or any
■ Place the Cover over the fireplace and secure that includes your name, address, daytime
other object to snuff out the flame.
telephone number and description of the problem.
with the hook and latch straps (Fig. 40).
• Allow the flame to self-extinguish by turning
Carefully package the product and send either by
off the fuel valve.
courier or insured mail with shipping and insurance
prepaid to:
■ Close the burner
valve firmly (Fig. 37).
3. If not completely satisfied with the performance
Fig. 37 of this product, please call 1-800-835-3278 in the
US or 1 800 387-6161 in Canada.
Fig. 40
English-8 English-9
Repair Parts List
No. Part Number Description
1 5071-5351 Electrode and Ground Wire Assy.
2 5071-5171 Shut-Off Plug w/Chain
3 5071-1991 Igniter Module
4 9942-1491 Knob
5 N/A AA Alkaline Battery (purchase locally)
6 5071-1351 Fuel Outlet Tube Assembly
7 5071-5611 Firebowl Assembly w/wires
8 5071-1241 Outer Granite Surface (one piece)
9 5071-1151 Inner Granite Surface
10 5071-1051 Firebowl Media - Rock
11 5071-1061 Firebowl Media - Tumbled Glass
12 5071-1131 Propane Bottle Cover
13 5071-1001 Fireplace Cover
1
5
6
4
8
13
12
11
10
Accessories (sold separately)
No. Part Number Description
14 R5071-522 8 ft. High Pressure Hose & Adapter
(connects fireplace to refillable propane cylinder)
15 R5071-104 Fireplace Media - Colored Tumbled Glass
14
The Coleman Company, Inc.
3600 North Hydraulic
Wichita, KS 67219
www.coleman.com
Fig. 42
English-10
5071 Series
Firelight™ Outdoor Decorative
Propane Fireplace
INSTASTART™ Electronic Ignition
Instructions for use
Patent Pending
© 2006 The Coleman Company, Inc.
www.coleman.com
2
3
AA Battery
Included
7
WARNING
If the information in this manual is not followed exactly,
a fire or explosion may result causing property
9
damage, personal injury or loss of life.
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.
Fig. 41
WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Immediately call your gas supplier. Follow the gas
supplier's instructions.
• If you can not reach your gas supplier, call the fire
department.
— Service must be performed by a qualified installer,
15
service agency or gas supplier.
ASSEMBLER/INSTALLER: Leave these instructions
with the consumer.
CONSUMER/USER: Read all instructions and keep
them in a safe placed for future reference.
Fig. 43
If you have questions about assembly, operation, servicing or repair of this
appliance, please call Coleman at 1-800-835-3278 or TDD: 316-832-8707.