Maintenance; Section 7 - Maintenance; Maintenance Chart - Recommended Service Intervals - Scag Power Equipment SFZ52-23FS Operator's Manual

R
7.1

MAINTENANCE CHART - RECOMMENDED SERvICE INTERvALS

HOURS
BREAk-IN
8 20
(FIRST 10)
X
X
X
X
X
X
X
X
X
X
X
* Perform these maintenance procedures more frequently under extreme dusty or dirty conditions

MAINTENANCE

40 100 200 400
Check all hardware for tightness
Check hydraulic oil level
Check all belts for proper alignment
Check engine oil level
Check hydraulic hoses for leaks
*Clean mower
Check condition of blades
Check tire pressure
Inspect seat belt for wear or damage
Check safety interlock system
Change engine oil and filter
Check battery, clean battery posts and
X
cables
Inspect pump drive belt. Replace every
X 400 hours or 2 years, whichever occurs
first.
Check belts for proper alignment
X
Check condition of fuel lines
X
Change engine oil
X
Drain hydraulic system, replace hydraulic
X
oil and filters
*Clean air cleaner element
X
X Check all hardware for tightness
X Change engine oil and filter
X Check hydraulic oil level
X Replace engine fuel filter
X Drain hydraulic system, replace hydraulic
oil and filters
X Adjust electric PTO clutch
PROCEDURE
28
Section 7
COMMENTS
See paragraph 7.2
See paragraph 7.7
See paragraph 7.3
U s e ex t r e m e c a u t i o n w h e n
checking the hydraulic hoses. See
paragraph 2.6
See paragraph 7.10
See paragraph 7.8
See paragraph 7.9
See paragraph 2.5
See paragraph 4.2
See paragraph 7.3
See paragraph 7.6
See paragraph 6.4 & 7.7
See paragraph 7.7
See paragraph 7.3
Use SAE 20W50 Motor Oil.
See paragraph 7.2
See paragraph 7.5
See paragraph 7.3
See paragraph 7.2
See paragraph 7.4
Use SAE 20W50 Motor Oil.
See paragraph 7.2
See paragraph 6.7