Generac Power Systems 02010-2, 04164-3 Installation And Owner's Manual page 47

ITEM PART NO. QTY. DESCRIPTION
1 0C9675 1
2 0A5649H 1
3 0A5646H 1
4 073159 1
5 031971 1
6 0C9674 1
7 0A6529 4
8 052858 4
9 066386 1
10 066849 3
11 0A8475 3
12 0C3818 1
13 075234 1
14 022473 2
15 022097 5
16 055816 1
17 090141 2
18 0A1658 2
19 074906 4
20 094039 1
21 0E9881 1
22 022129 4
23 027756 4
24 086316 1
25 053650 1
26 0C4258 1
27 075244 1
28 094071 1
29 094070 1
30 075476 3
31 022264 4
32 065795 1
33 090987 2
34 086317A 1
Section 6 — Exploded Views and Parts Lists
Alternator and Panel (Model 04164-3) – Drawing No. 0D1776-F
LOWER BEARING CARRIER
ROTOR ASSEM.
STATOR ASSEM.
BALL BEARING
BALL BEARING
UPPER BEARING CARRIER
STUD-STATOR
M8-1.25 FLANGE LOCK NUT
BRUSH HOLDER
M5-0.8 X 16 LG. TAPTITE
SPECIAL LOCK WASHER, M5
GENERATOR TOP HOUSING
RESISTOR1R 5% 25 WLVG
¼"/ M6-FLAT WASHER
¼"/ M6-LOCK WASHER
M6-1.0 X 70 LG. CAPSCREW
GROUND CABLE
SPECIAL LOCK WASHER, M6
M6-1.0 X 20 LG. TAPTITE
CONTROLLER P.C.B.
DECAL, UNIT
5/16" –M8 LOCK WASHER
NYLON WASHER
PANEL SHEET METAL
4-PIN CONNECTOR
CONDUIT ASSEMBLY
ASSEMBLY, REMOTE CABLE
M5-.08 X 110 LG. PPHMS
SPACER-PLASTIC
M4-0.7 X 16 LG. CAPSCREW
#8/ M4-LOCK WASHER
BATTERY CHARGE RECTIFIER
M3-0.5 X 12 LG. PPHMS
PANEL SUPPORT BRACKET
Recreational Vehicle Generator
ITEM PART NO. QTY. DESCRIPTION
35 075235 2
36 082737 4
37 049813 4
38 055440 2
39 043182 2
40 045771 4
41 053623 1
42 023484S 1
43 0F9719 1
44 022152 5
45 051716 3
46 090144 1
47 090145 1
48 025105 4
49 086315 1
50 090734 4
51 022985 1
52 032300 1
53 022676 1
54 087798 1
55 092113 1
56 075210A 1
57 0A8475A 1
58 051715 1
59 090157 1
60 090156 1
61 074908 2
62 031791 1
63 023897 2
64 0D2724 2
65 031879 2
66 049815 1
M5-0.8 X 30 LG. CAPSCREW
VIBRATION MOUNT
M6-1.0 HEX NUT
M5-08 X 25 LG. HEX HD. CAPSCR.
M3-LOCK WASHER
HEX NUT, M8
C/BREAKER 2.5A.-ON
BUSHING
REGULATOR VOLTAGE
LOCKWASHER, #10
M5-0.8 HEX NUT
C/BREAKER 20A.
C/BREAKER 30A. ALL UNITS
#6-32 SCREW W/LOCK WASHER
PANEL COVER
M4-0.7 X 12 LG. CAPSCR.W/LOCK-
WASHER & FLAT WASHER
#6-FLAT WASHER
FUSE HOLDER
FUSE AGC-15A.
SWITCH S.P.D.T. (START-STOP)
SWITCH S.P.D.T.-(FUEL PUMP)
TERMINAL BLOCK
SPECIAL LOCK WASHER, M4
M4-0.7 HEX NUT
DECAL, CB RATING 30A.
DECAL, CB RATING 20A.
M5-0.8 X 10 LONG TAPTITE
CLAMP, HOSE
#10/ M5-FLAT WASHER
BOOT, ROCKER SWITCH
WASHER FLAT #4
HHCS M5-0.8 X 16
45