Page 1: Table Of Contents
Automatic temperature control Auxiliary passenger climate control Rear window defroster Lights Driver Controls Windshield wiper/washer control Steering wheel adjustment Power windows Mirrors Speed control Message center Locks and Security Keys Locks Anti-theft system 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 2 Roadside Emergencies Getting roadside assistance Hazard flasher switch Fuel pump shut-off switch Fuses and relays Changing tires Lug Nut Torque Jump starting Wrecker towing Customer Assistance Reporting safety defects (U.S. only) Cleaning 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 4: Introduction
State of California to cause cancer and birth defects or other reproductive harm. CONGRATULATIONS Congratulations on acquiring your new Ford. Please take the time to get well acquainted with your vehicle by reading this handbook. The more you know and understand about your vehicle, the greater the safety and pleasure you will derive from driving it.
Page 5 Do not add friction modifier compounds or special break-in oils during the first few thousand miles (kilometers) of operation, since these additives may prevent piston ring seating. See Engine oil in the Maintenance and Specifications chapter for more information on oil usage. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 6 In order to properly diagnose and service your vehicle, Ford Motor Company, Ford of Canada, and service and repair facilities may access vehicle diagnostic information through a direct connection to your vehicle when diagnosing or servicing your vehicle.
Page 7 • where the driver was positioning the steering wheel. To access this information, special equipment must be directly connected to the recording modules. Ford Motor Company and Ford of Canada do not access event data recorder information without obtaining consent,...
Page 8 Your vehicle is not equipped with a snowplowing package. Using your vehicle as an ambulance Do not use this vehicle as an ambulance. Your vehicle is not equipped with the Ford Ambulance Preparation Package. 2006 Explorer (exp) Owners Guide (post-2002-fmt)
Page 9 By referring to the pages in the provided supplement, you can properly identify those features, recommendations and specifications that are unique to your vehicle. Refer to this Owner’s Guide for all other required information and warnings. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 10 Brake Fluid - Anti-Lock Brake System Non-Petroleum Based Powertrain Malfunction Speed Control Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Wash/Wipe Windshield Rear Window Defrost/Demist Defrost/Demist 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 11 Battery Acid or Sparks Explosive Gas Fan Warning Maintain Correct Fluid Power Steering Fluid Level Emission System Engine Air Filter Passenger Compartment Jack Air Filter Low Tire Pressure Check Fuel Cap Warning 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 12: Instrument Cluster
A warning light may illuminate when a problem exists with one of your vehicle’s functions. Many lights will illuminate when you start your vehicle to make sure the 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 13 Powertrain malfunction indicator: Illuminates when a powertrain or a 4x4 fault has been detected. Contact your authorized dealer as soon as possible. • Standard instrument cluster • Optional instrument cluster 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 14 Safety belt: Reminds you to fasten your safety belt. A chime will also sound to remind you to fasten your safety belt. Charging system: Illuminates when the battery is not charging properly. • Standard instrument cluster 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 15 When the ignition is first turned to ON, the light will illuminate for 3 seconds to ensure the bulb is working. If the light does not turn ON, have the system inspected by your authorized dealer. For more 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 16 Driving chapter for more information. Four wheel drive low (if equipped): Illuminates when four-wheel drive low is engaged. If the light fails to illuminate when the 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 17 Headlamps on warning chime: Sounds when the headlamps or parking lamps are on, the ignition is off (the key is not in the ignition) and the driver’s door is opened. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 18: Gauges
Message center activation chime: Sounds when the following warnings DOOR AJAR, LOW FUEL LEVEL or LOW TIRE PRESSURE appear in the message center display for the first time. GAUGES Speedometer: Indicates the current vehicle speed. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 19 TRIP A feature. Press the control again to select the TRIP B feature. To reset the trip, press and hold the control again until the trip reading is 0.0 miles. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 20 Refer to Filling the tank in the Maintenance and Specifications chapter for more information. The FUEL icon and arrow indicates which side of the vehicle the fuel door is located. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 21: Entertainment Systems
Category Mode under Menu for further information. Satellite radio is available only in the continental United States. 2. MUTE/Phone: Press to mute the playing media. Press again to return to the playing media. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 22 Press MENU to access and use to adjust. The recommended level is 1–3. Level 0 (SPEED OFF) turns the feature off and level 7 is the maximum setting. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 23 When a CD or DVD is playing in the FES system, press this control to play or pause the current CD or DVD. The CD/DVD status will display in the radio display. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 24 In Satellite radio mode (if equipped), press and release to enter TEXT MODE and display the current song title. While in TEXT MODE, press again to scroll through the current song title, artist, channel category and the SIRIUS long channel name. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 25 CD play will begin where it ended last. If no CD is loaded, NO DISC will appear in the display. 17. CD eject: Press to eject a CD. 18. CD slot: Insert a CD label side 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 26: Am/Fm Stereo Cassette With Cd
Sirius channel Categories (Pop, Rock, News, etc.). Refer to Category Mode under Menu for further information. Satellite radio is available only in the continental United States. 2. SEEK: In radio mode, press to access the previous/next strong station. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 27 When the six strongest stations are filled, the station stored in preset 1 will begin playing. If there are less than six strong stations, the system will store the last one in the remaining presets. Use to turn on/off. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 28 If equipped with Satellite Radio, press AUX to cycle through SAT1, SAT2 and SAT3 modes. Satellite radio is available only in the continental United States. 6. Tape eject: Press to eject a tape. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 29 Satellite radio is available only in the continental United States. 14. Tape: Insert a tape facing to the right. 15. Tape direction: Press to enter tape mode. Press while in play mode to change which side of the tape is playing. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 30 In TEXT MODE, sometimes the display requires additional text to be displayed. When the “>” indicator is active, press SEEK to view the additional display text. When the “>” indicator is active, press SEEK to view the previous display text. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 31: Am/Fm Stereo With In-Dash Six Cd
Sirius channel Categories (Pop, Rock, News, etc.). Refer to Category Mode under Menu for further information. Satellite radio is available only in the continental United States and with a valid SIRIUS subscription. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 32 (Inform). RBDS is only available in FM mode. Autoset: Allows you to set the strongest local radio stations without losing your original manually set preset stations for AM/FM1/FM2 . to turn on/off. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 33 NO AUX AUDIO will be displayed.. To return to radio mode, press AM/FM. If equipped with Satellite Radio, press AUX to cycle through SAT1, SAT2 and SAT3 modes. Satellite radio is available only in the continental United States. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 34 MP3 discs, if available. 10. FF (Fast forward): Press to manually advance in a CD track. 11. REW (Rewind): Press to manually reverse in a CD track. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 35 If the volume is set above a certain level and the ignition is turned off, the volume will come back on at a “nominal” listening level when the ignition switch is turned back on. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 36 • Allow tapes which have been subjected to extreme heat, humidity or cold to reach a moderate temperature before playing. • Clean the cassette player head with a cassette cleaning cartridge after 10–12 hours of play to maintain good sound/operation. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 37 Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD players. Dirty, warped or damaged CDs, irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the CD player.
Page 38 Note: SIRIUS reserves the unrestricted right to change, rearrange, add or delete programming including canceling, moving or adding particular channels, and its prices, at any time, with or without notice to you. Ford Motor Company shall not be responsible for any such programming changes.
Page 39 The system is working properly. NO TEXT Song title information Song title information not not available. available at this time on this channel. The system is working properly. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 40 (FES). This is a DVD system for the rear seat passengers which includes a DVD player, wireless infrared headphones and a remote control. For more information, please refer to the Family Entertainment System supplement. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 41: Climate Controls
• To reduce humidity build up inside the vehicle, do not drive with the air flow selector in the O (OFF) position. • Do not put objects under the front seats that will interfere with the airflow to the rear seats. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 42 2. Set temperature control to maintain comfort. 3. Set fan to highest setting. Do not place objects on top of the instrument panel as these objects may become projectiles in a collision or sudden stop. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 43: Automatic Temperature Control
DUAL. The passenger temperature will appear in the display. 4. Rear defroster control: Removes ice and fog from the rear window. Press to turn on/off. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 44 To return to fully automatic control, press AUTO. 14. Driver’s side temperature control: Controls the temperature of the vehicle cabin. When DUAL zone is pressed, controls the driver’s side temperature. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 45 4. Set the fan speed to the highest setting. 5. Direct the outer instrument panel vents towards the side windows. To increase airflow to the outer instrument panel vents, close the vents located in the middle of the instrument panel. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 46: Auxiliary Passenger Climate Control
3. Fan control: Determines fan speed levels. If your vehicle is equipped with the front Dual Automatic Temperature Control (DATC) system, when the front system is turned off, the fan and heat mode will operate and A/C will be unavailable. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 47: Rear Window Defroster
The defroster turns off automatically after 10 minutes or when the ignition is turned to the 1 (OFF/LOCK) or 2 (ACC) position. To manually turn off the defroster before 10 minutes have passed, push the control again. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 48: Lights
Pull headlamp control towards you to turn foglamps on. The foglamp indicator light below the icon will illuminate when foglamp is activated. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 49 High beams Push the lever toward the instrument panel to activate. Pull the lever towards you to deactivate. Flash to pass Pull the lever toward you to activate. Release the lever to deactivate. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 50 (2) and mark an 8 foot (2.4 meter) long horizontal line on the plain surface (1) at this height (masking tape works well). 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 51 6. Horizontal aiming is not required for this vehicle and is non-adjustable. TURN SIGNAL CONTROL • Push down to activate the left turn signal. • Push up to activate the right turn signal. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 52 The headlamps are vented to equalize pressure. When moist air enters the headlamp(s) through the vents, there is a possibility that condensation can occur. This condensation is normal and will clear within 45 minutes of headlamp operation. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 53 Front door courtesy lamp Map lamps 168 (T10) Ashtray lamp All replacement bulbs are clear in color except where noted. To replace all instrument panel lights - see your authorized dealer . 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 54 Grasp the bulb only by its plastic base and do not touch the glass. The oil from your hand could cause the bulb to break the next time the headlamps are operated. Reverse steps to reinstall bulb(s). 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 55 Reverse steps to reinstall bulb(s). Replacing tail/brake/turn/backup lamp bulbs 1. Turn the headlamp switch to OFF and open the liftgate. 2. Remove the two bolts from the lamp assembly. 3. Remove the lamp assembly. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 56 3. Remove the bulb socket from the lamp assembly by turning counterclockwise and pull the bulb straight out. Reverse steps to reinstall bulb(s). 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 57 2. Remove the bulb holder from the lamp assembly by depressing the snaps. 3. Pull the bulb straight out of the socket and push in the new bulb. Reverse steps to reinstall bulb(s). 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 58: Driver Controls
OFF — Rear wiper and washer off. For rear wash cycle, rotate (and hold as desired) the rear wiper/washer control to either position. From either position, the control will automatically return to the INT 2 or OFF position. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 59: Steering Wheel Adjustment
Never adjust the steering column when the vehicle is moving. ILLUMINATED VISOR MIRROR (IF EQUIPPED) Lift the mirror cover to turn on the visor mirror lamps. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 60 OVERHEAD CONSOLE (IF EQUIPPED) The appearance of your vehicle’s overhead console will vary according to your option package. Storage compartment Press the latch to open the storage compartment. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 61 Do not hang any type of accessory or accessory bracket from the plug. Improper use of the power outlet can cause damage not covered by your warranty. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 62 The rear side of the console may incorporate the following features: • Air vents 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 63: Power Windows
They may seriously injure themselves. When closing the power windows, you should verify they are free of obstructions and ensure that children and/or pets are not in the proximity of the window openings. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 64 With accessory delay, the window switches, audio system and moon roof (if equipped) may be used for up to ten minutes after the ignition switch is turned to the OFF position or until either front door is opened. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 65: Mirrors
2. Move the control in the direction you wish to tilt the mirror. 3. Return to the center position to lock mirrors in place. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 66: Speed Control
With speed control set, you can maintain a speed of 30 mph (48 km/h) or more without keeping your foot on the accelerator pedal. Speed control does not work at speeds below 30 mph (48 km/h). 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 67 • If the vehicle speed decreases more than 10 mph (16 km/h) below your set speed on an uphill, your speed control will disengage. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 68 1 mph (1.6 km/h). • Depress the brake pedal until the desired vehicle speed is reached, press the SET + control. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 69 Audio control features Press MEDIA to select: • AM, FM1, FM2 • TAPE (if equipped) • CD (if equipped) • DVD (if equipped) • SAT1, SAT2 or SAT3 (Satellite Radio mode if equipped). 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 70 • Press SEEK to select the next selection on the CD or press and hold to forward or reverse the CD. In any mode: • Press VOL + or − to adjust volume. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 71 The moon roof is equipped with an automatic, one-touch, express opening feature. Press and release the rear portion of the control. To stop motion at any time during the one-touch opening, press the control again. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 72 This feature will learn the radio frequency codes of most transmitters to operate garage doors, entry gate operators, security systems, entry door locks, and home or office lighting. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 73 2. Position the end of your hand-held transmitter 1–3 inches (2–8 cm) away from the HomeLink button you wish to program (located on your overhead console) while keeping the indicator light in view. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 74 HomeLink should now activate your rolling code equipped device. To program additional HomeLink buttons begin with Step 2 in the “Programming” section. For questions or comments, please contact HomeLink at www.homelink.com or 1–800–355–3515. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 75 For convenience, the hand-held transmitter of the device may also be used at any time. In the event that there are still programming difficulties, contact HomeLink at www.homelink.com or 1–800–355–3515. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 76: Message Center
The system will also notify you of potential vehicle problems with a display of system warnings followed by an indicator chime. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 77 500 miles (800 km). This value is not the same as the average fuel economy display. The running average fuel economy is reinitialized to a factory default value if the battery is disconnected. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 78 Briefly press the TRIP/RESET control switch to scroll through the SETUP MENU display sequence. If the TRIP/RESET control switch is not pressed within 4 seconds, the message center returns to the Info Menu. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 79 To reset the oil monitoring system to 100% after each oil change [approximately 5,000 miles (8,000 km) or 180 days] perform the following: 1. Enter SYSTEM CHECK to display “HOLD RESET IF NEW OIL”. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 80 3. Press the TRIP/RESET control switch for the next SETUP MENU item or wait for more than 4 seconds to return to the INFO MENU. Autolamp This feature keeps your headlights on for up to three minutes after the ignition is switched off. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 81 Reverse Sensing System (Park Aid) (if equipped) This feature sounds a warning tone to warn the driver of obstacles near the rear bumper, and functions only when R (Reverse) gear is selected. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 82 This variation is up to four degrees between adjacent zones and will become noticeable as the vehicle crosses multiple zones. A correct zone setting will eliminate this error. Refer to Compass calibration adjustment. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 83 Perform compass calibration in an open area free from steel structures and high voltage lines. For optimum calibration, turn off all electrical accessories (heater/air conditioning, wipers, etc.) and make sure all vehicle doors are shut. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 84 • They will not reappear until an ignition OFF-ON cycle has been completed. • They reappear if the condition clears then reoccurs within the same ignition ON-OFF cycle. This acts as a reminder that these warning conditions still exist within the vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 85 CHECK BRAKE SYSTEM. Displayed when the braking system is not operating properly. If the warning stays on or continues to come on, contact your authorized dealer as soon as possible. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 86 OIL CHANGE REQUIRED. Displayed when the engine oil life remaining is 0%. An oil change is required whenever indicated by the message center and according to the recommended maintenance schedule. USE ONLY RECOMMENDED ENGINE OILS. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 87 Your display can show up to 6 reconfigurable telltales at one time. What ever is displayed in the top left corner has the highest priority. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 88 The DTE function will display LOW FUEL LEVEL and sound a tone for one second when you have approximately 50 miles (80 km) to empty. If you RESET this warning message, this display and tone will return within 10 minutes. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 89 Your vehicle must be moving to calculate instantaneous fuel economy. When your vehicle is not moving, this function shows one or no bars illuminated. Instantaneous fuel economy cannot be reset. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 90 • System Check INFO SETUP RESET • Units (English/Metric) • Language • Autolamp • Autolock • Autounlock • Easy Entry/Exit Seat • Park Aid (if equipped) • Compass Zone 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 91 To reset the oil monitoring system to 100% after each oil change [approximately 5,000 miles (8,000 km) or 180 days] perform the following: • From the SETUP MENU enter SYSTEM CHECK to display “HOLD RESET IF NEW OIL”. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 92 3. Press the RESET control for the next SETUP MENU item or wait for more than 4 seconds to return to the INFO menu. Autolamp This feature keeps your headlights on for up to three minutes after the ignition is switched off. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 93 2. Press the RESET control to turn the autounlock ON or OFF. 3. Press the RESET control for the next SETUP MENU item or wait for more than 4 seconds to return to the INFO menu. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 94 If the compass still appears to be inaccurate, a manual calibration may be necessary. Refer to Compass zone/calibration adjustment. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 95 6. Press the RESET control repeatedly until the correct zone setting for your geographic location is displayed on the message center. The range of zone values are from 01 to 15 and “wraps” back to 01. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 96 (less than 3 mph [5 km/h]) until the CIRCLE SLOWLY TO CALIBRATE display changes to CALIBRATION COMPLETE. It will take up to five circles to complete calibration. 4. The compass is now calibrated. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 97 • They will not reappear until an ignition OFF-ON cycle has been completed. • They reappear if the condition clears then reoccurs within the same ignition ON-OFF cycle. This acts as a reminder that these warning conditions still exist within the vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 98 CHECK BRAKE SYSTEM. Displayed when the braking system is not operating properly. If the warning stays on or continues to come on, contact your authorized dealer as soon as possible. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 99 OIL CHANGE REQUIRED. Displayed when the engine oil life remaining is 0%. An oil change is required whenever indicated by the message center and according to the recommended maintenance schedule. USE ONLY RECOMMENDED ENGINE OILS. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 100 (right side first) in the trim panels behind the second row seat. To reduce the risk of injuries, the cargo area cover must be properly installed on the rear trim panels. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 101 REAR LIFTGATE The liftgate area is only intended for cargo, not passengers. You can open and close the liftgate from outside the vehicle. It cannot be opened from inside the cargo area. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 102 Your vehicle is equipped with a roof rack. The maximum recommended load is 100 lbs (45 kg), evenly distributed. Use the tie down loops on the thumbwheels (if equipped) to secure the load. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 103 Avoid sharp turns, excessive speed and abrupt maneuvers in these vehicles. Failure to drive cautiously could result in an increase risk of loss of vehicle control, vehicle rollover, personal injury and death. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 104: Locks And Security
With the key in any ignition position, the driver’s door will automatically unlock if it is locked using the lock control on the driver’s door panel while the driver’s door is open. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 105 (one short and one long chirp) if trim switch inhibit was activated. 7. Turn the ignition to the 1 (OFF/LOCK) position. The horn will chirp once to confirm the procedure is complete. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 106 33 feet (10 meters). A decrease in operating range could be caused by: • weather conditions, • nearby radio towers, • structures around the vehicle, or • other vehicles parked next to your vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 107: Anti-Theft System
(refer to the Illuminated entry feature later in this section), if the control on the overhead lamp is not set to the off position and the perimeter alarm system (if equipped) will deactivate. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 108 The remote entry system can also control the memory seat /adjustable pedals/easy entry-exit feature. Press to automatically move the seat and adjustable pedals to the desired memory position (the seat position corresponds to the transmitter being used). 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 109 1. Twist a thin coin between the two halves of the remote entry transmitter near the key ring. DO NOT TAKE THE RUBBER COVER AND CIRCUIT BOARD OFF THE FRONT HOUSING OF THE REMOTE ENTRY TRANSMITTER. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 110 You must have all remote entry transmitters (maximum of six) available before beginning this procedure. If all remote entry transmitters are not present during the programming procedure, the transmitters that are not present during programming will no longer operate the vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 111 • the remote transmitter lock control is pressed, or • after 25 seconds of illumination. The dome lamp control (if equipped) must not be set to the off position for the illuminated entry system to operate. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 112 4. Press 1 • 2, 3 • 4 or 5 • 6 to indicate which of the three personal entry code positions you wish to use. 5. The doors will again lock then unlock to confirm that your personal key code has been programmed to the module. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 113 To lock all doors, liftgate and liftgate window, press the 7 • 8 and the 9 • 0 at the same time. Note: The driver’s door must be closed. You do not need to enter the keypad code first. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 114 1. Turn the ignition to the 3 (ON) position. 2. Press the power door unlock control three times. 3. Turn the ignition from the 3 (ON) to the 1 (OFF/LOCK) position. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 115 Note: The doors will not autounlock if the vehicle has been electronically locked before the driver door is opened. Deactivating/activating autounlock Your vehicle comes with the autounlock feature activated. There are four methods to enable/disable this feature: 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 116 6. Release the 3 • 4. The user should receive a horn chirp to indicate the system has been disabled or a chirp followed by a honk to indicate the system has been enabled. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 117 Note: The SecuriLock passive anti-theft system is not compatible with non-Ford aftermarket remote start systems. Use of these systems may result in vehicle starting problems and a loss of security protection. Note: Large metallic objects, electronic devices that are used to purchase gasoline or similar items, or a second coded key on the same key chain may cause vehicle starting issues.
Page 118 • If two previously programmed coded keys are not available, you must take your vehicle to your authorized dealer to have the spare key(s) programmed. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 119 Steps 1 through 5. If failure repeats, bring your vehicle to your authorized dealer to have the new key(s) programmed. To program additional new unprogrammed key(s), wait twenty seconds and then repeat this procedure from Step 1. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 120: Seating And Safety Restraints
The seats in your vehicle have adjustable head restraints. Adjust your head restraint so that it is located directly or as close as possible behind your head. The head restraints can be moved up and down (on first row seats only). 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 121 An unlatched seat may become dangerous in the event of a sudden stop or collision. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 122 Always sit upright against your seatback, with your feet on the floor. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 123 Press front to raise or lower the front portion of the seat cushion. Press rear to raise or lower the rear portion of the seat cushion. Press the control to move the seat forward, backward, up or down. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 124 To program the memory feature to a remote entry transmitter and for more information on how to use the keypad, refer to Remote entry system and Keyless entry system in the Locks and Security chapter. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 125 Ensure that the head restraint is in the down position and no objects such as books, purses or briefcases are on the floor in front of the second row seats before folding them down. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 126 To return the seat to the upright position: 1. Lift the seatback toward the rear of the vehicle. 2. Rotate the seatback until you hear a click, locking it in the upright position. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 127 1. Fold down the 2nd row seat. 2. Pull the cargo mode lever up to release the seat into a kneel down load floor position. A moderate force may be required to move the seat forward and down. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 128 2. Pull the handle up again until the seat releases from the floor. 3. Push the seat upward and fold it away from the third row. Always return the seat to the fully latched position before operating the vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 129 2. Follow the directions above to return the seatback from the load floor and to the upright position. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 130 3rd row power folding seat (if equipped) Note: Be sure that head restraints are folded down before powering the 3rd row seat down. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 131 3rd row seat is disabled after 30 minutes, the seat can be enabled by opening any door, pressing the unlock control on the remote entry transmitter, pressing any keyless keypad button (if equipped), or turning the ignition key. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 132: Safety Restraints
Restraints Control Module (RCM). During a crash, the RCM activates the safety belt pretensioners and/or either one or both stages of the dual-stage airbag supplemental restraints based on crash severity and occupant conditions. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 133 The most effective way to reduce the risk of unnecessary injuries is to make sure all occupants are properly restrained. Accident statistics suggest that children are much safer when properly restrained in the rear seating positions than in the front. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 134 This helps reduce the risk of force-related injuries to the occupant’s chest by limiting the load on the occupant. Refer to Safety restraints section in this chapter. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 135 The passenger cannot protect the child from injury in a collision. All occupants of the vehicle, including the driver, should always properly wear their safety belts, even when an airbag supplemental restraint system (SRS) is provided. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 136 Failure to replace the Belt and Retractor assembly could increase the risk of injury in collisions. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 137 For example, if the driver brakes suddenly or turns a corner sharply, or the vehicle receives an impact of approximately 5 mph (8 km/h) or more, the combination safety belts will lock to help reduce forward movement of the driver and passengers. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 138 How to use the automatic locking mode • Buckle the combination lap and shoulder belt. • Grasp the shoulder portion and pull downward until the entire belt is pulled out. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 139 Safety Canopy (if equipped), and safety belt pretensioners. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 140 This guide is attached to the quarter trim panel and is used to adjust the comfort of the shoulder belt for smaller occupants in the outboard second row seats. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 141 Safety belt warning light and indicator chime The safety belt warning light illuminates in the instrument cluster and a chime sounds to remind the occupants to fasten their safety belts. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 142 If the BeltMinder warnings have expired (warnings for approximately 5 minutes) for one occupant (driver or front passenger), the other occupant can still activate the BeltMinder feature. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 143 3 mph (5 seconds, repeating for approximately km/h) and more than 1-2 5 minutes or until the safety belts are minutes have elapsed since the buckled. ignition switch has been turned to ON... 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 144 “The people I’m with don’t Set the example, teen deaths occur 4 wear belts” times more often in vehicles with TWO or MORE people. Children and younger brothers/sisters imitate behavior they see. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 145 Read Steps 1 - 4 thoroughly before proceeding with the deactivation/activation programming procedure. Note: The driver and front passenger BeltMinder features must be disabled/enabled separately. Both cannot be disable/enabled during the same key cycle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 146 4 times per second for 3 seconds, followed by 3 seconds with the light off, then followed by the restraint system warning light flashing 4 times per second for 3 seconds again. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 147: Airbags
(if equipped), shoulder belt guide on seatback (if equipped), child safety seat LATCH and tether anchors, and attaching hardware, should be inspected after a collision. Ford Motor Company recommends that all safety belt assemblies in use in vehicles involved in a collision be replaced.
Page 148 Do not put anything on or over the airbag module. Placing objects on or over the airbag inflation area may cause those objects to be propelled by the airbag into your face and torso causing serious injury. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 149 Modifications to the front end of the vehicle, including frame, bumper, front end body structure and non-Ford tow hooks may effect the performance of the airbag sensors increasing the risk of injury. Do not modify the front end of the vehicle with anything other than authorized Ford accessories for your vehicle.
Page 150 Thus, it is extremely important that occupants be properly restrained as far away from the airbag module as possible while maintaining vehicle control. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 151 The sensors are designed to detect the presence of a properly seated occupant and determine if the front passenger’s frontal airbag should be enabled (may inflate) or disabled (will not inflate). 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 152 The front passenger sensing system is designed to enable (may inflate) the front passenger’s frontal airbag anytime the system senses that a person of adult size is sitting properly in the front passenger seat. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 153 Always sit upright against your seatback, with your feet on the floor. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 154 The person in the front passenger seat may appear heavier or lighter due to the conditions described in the list above. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 155 If it is necessary to modify an advanced front airbag system to accommodate a person with disabilities, contact the Ford Customer Relationship Center at the phone number shown in the Customer Assistance section of this Owner’s Guide.
Page 156 Do not lean your head on the door. The side airbag could injure you as it deploys from the side of the seatback. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 157 The airbag was designed to inflate between the door panel and occupant to further enhance the protection provided occupants in side impact collisions. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 158 Safety Canopy . Failure to follow these instructions may increase the risk of personal injury in the event of a collision. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 159 Canopy ). The Safety Canopy system consists of the following: • An inflatable nylon curtain with an inflator concealed behind the headliner and above the doors (one on each side of the vehicle). 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 160 Several Safety Canopy system components get hot after inflation. Do not touch them after inflation. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 161: Child Restraints
SAFETY RESTRAINTS FOR CHILDREN See the following sections for directions on how to properly use safety restraints for children. Also see Airbag supplemental restraint system (SRS) in this chapter for special instructions about using airbags. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 162 Refer to Second row comfort guide earlier in this chapter. Do not leave children, unreliable adults, or pets unattended in your vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 163 To improve the fit of both the lap and shoulder belt on children who have outgrown child safety seats, Ford Motor Company recommends use of a belt-positioning booster. Booster seats position a child so that safety belts fit better. They lift the child up so that the lap belt rests low across the hips and the knees bend comfortably.
Page 164 Either type can be used at any seating position equipped with lap/shoulder belts if your child is over 40 lb. (18 kg). 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 165 Never put the shoulder belt under a child’s arm or behind the back because it eliminates the protection for the upper part of the body and may increase the risk of injury or death in a collision. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 166 60 pounds (27 kg) in a child restraint, and to provide upper torso restraint for children up to 80 lb. (36 kg) using an upper torso harness and a belt-positioning booster. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 167 Seating and Safety Restraints Ford recommends the use of a child safety seat having a top tether strap. Install the child safety seat in a seating position with LATCH and tether anchors. For more information on top tether straps and anchors, refer to Attaching safety seats with tether straps in this chapter.
Page 168 Make sure the tongue is latched securely by pulling on it. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 169 (you should not be able to pull more belt out). If the retractor is not locked, unbuckle the belt and repeat Steps 2 through 9. Check to make sure the child seat is properly secured before each use. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 170 The tether strap may not work properly if attached somewhere other than the correct tether anchor. Do not tie down cargo with anchors if the anchors are in use as child tethers. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 171 5 passenger vehicle, the tether straps may be attached to either of the tether anchors located at the rear of the cargo area. • Behind 2nd row seat • At the rear of the cargo area 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 172 See Attaching child safety seats with tether straps in this chapter. Your vehicle has LATCH anchors for child seat installation at the seating positions marked with the child seat symbol: 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 173 Never attach two LATCH child safety seats to the same anchor. In a crash, one anchor may not be strong enough to hold two child safety seat attachments and may break, causing serious injury or death. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 174 The guides hold the seat trim away to expose the anchor and make it easier to attach some child seats. Attach LATCH lower attachments of the child seat only to the anchors shown. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 175 Also try to tug the seat forward. Check to see if the anchors hold the seat in place. If the safety seat is not anchored properly, the risk of a child being injured in a crash greatly increases. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 176: Tires, Wheels And Loading
A vehicle equipped with AWD or 4WD (when selected) has the ability to use all four wheels to power itself. This increases traction which may enable you to safely drive over terrain and road conditions that a conventional two-wheel drive vehicle cannot. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 177 All other things held equal, a shorter wheelbase may make your vehicle quicker to respond to steering inputs than a vehicle with a longer wheelbase. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 178: Tire Information
10 to 12 inches or limited production tires as defined in Title 49 Code of Federal Regulations Part 575.104(c)(2). U.S. Department of Transportation-Tire quality grades: The U.S. Department of Transportation requires Ford Motor Company to give you the following information about tire grades exactly as the government has written it.
Page 179 Glossary of tire terminology • Tire label: A label showing the OE (Original Equipment) tire sizes, recommended inflation pressure and the maximum weight the vehicle can carry. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 180: Tire Inflation
Every day before you drive, check your tires. If one looks lower than the others, use a tire gauge to check pressure of all tires and adjust if required. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 181 (if equipped), at least monthly and before long trips. You are strongly urged to buy a reliable tire pressure gauge, as automatic service station gauges may be inaccurate. Ford recommends the use of a digital or dial type tire pressure gauge rather than a stick type tire pressure gauge.
Page 182 This information identifies and describes the fundamental characteristics of the tire and also provides a U.S. DOT Tire Identification Number for safety standard certification and in case of a recall. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 183 These speed ratings may need to be adjusted for the difference in conditions. The ratings range from 81 mph (130 km/h) to 186 mph (299 km/h). These ratings are listed in the following chart. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 184 Refer to the Safety Compliance Certification Label, which is located on the B-Pillar or the edge of the driver’s door, for the correct tire pressure for your vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 185 The cold inflation pressure should never be set lower than the recommended pressure on the vehicle label. The tire suppliers may have additional markings, notes or warnings such as standard load, radial tubeless, etc. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 186 4. Maximum Load Single lb. (kg) at psi (kPa) cold: Indicates the maximum load and tire pressure when the tire is used as a single; defined as two tires (total) on the rear axle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 187 Vehicle loading — with and without a trailer section. TIRE CARE Inspecting your tires Periodically inspect the tire treads for uneven or excessive wear and remove objects such as stones, nails or glass that may be wedged in the 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 188 Heat caused by hot climates or frequent high loading conditions can accelerate the aging process. You should replace the spare tire when you replace the other road tires due to the aging of the spare tire. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 189 Only use replacement tires and wheels that are the same size and type (such as P-metric versus LT-metric or all-season versus all-terrain) as those originally provided by Ford. Use of any tire or wheel not recommended by Ford can affect the safety and performance of your vehicle, which could result in an increased risk of loss of vehicle control, vehicle rollover, personal injury and death.
Page 190 Tire and wheel alignment A bad jolt from hitting a curb or pothole can cause the front end of your vehicle to become misaligned or cause damage to your tires. If your 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 191 Sometimes irregular tire wear can be corrected by rotating the tires. Note: If your tires show uneven wear ask an authorized dealer to check for and correct any wheel misalignment, tire imbalance or mechanical problem involved before tire rotation. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 192: Tire Pressure Monitoring System (Tpms)
(at least monthly) using a tire gauge, see Inflating your tires in this chapter. Failure to properly maintain your tire pressure could increase the risk of tire failure, loss of control, vehicle rollover and personal injury. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 193 Even if the light turns ON and a short time later turns OFF, your tire pressure still needs to be checked. In short, once the light has turned ON, at least one tire may be underinflated. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 194 It can also warn you in the event the system is no longer capable of functioning as intended. Please refer to the following chart for information concerning your Tire Pressure Monitoring System: 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 195 1. Check your tire pressure to under-inflated ensure tires are properly inflated; refer to Inflating your tires in this chapter. Ford Motor Company recommends the use of a digital or dial-type tire pressure gauge rather than a stick-type tire pressure gauge for increased accuracy.
Page 196 (32 km/h) for the light to turn OFF after you have filled your tires to the recommended tire pressure. For these reasons, the low tire pressure warning light is NOT a substitute for using an accurate tire gauge when checking and filling your tires. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 197 USING SNOW TIRES AND TRACTION DEVICES Snow tires must be the same size and grade as the tires you currently have on your vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 198: Vehicle Loading
The tires on your vehicle have all-weather treads to provide traction in rain and snow. However, in some climates, using snow tires or traction devices may be necessary. Ford offers tire cables as a Ford approved accessory and recommends use of these or SAE class “S” tire cables. See your authorized dealer for more information on tire cables for your vehicle.
Page 199 Overloading or improperly loading your vehicle can contribute to loss of vehicle control and vehicle rollover. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 200 GAW (Gross Axle Weight) – is the total weight placed on each axle (front and rear) – including vehicle curb weight and all payload. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 201 Note: For trailer towing information refer to Trailer towing found in this chapter or the RV and Trailer Towing Guide provided by your authorized dealer. GVW (Gross Vehicle Weight) – is the Vehicle Curb Weight + cargo + passengers. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 202 GCW of the towing vehicle plus the trailer exceed the GVWR of the towing vehicle. The GCW must never exceed the GCWR. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 203 150 lb. passengers in your vehicle, the amount of available cargo and luggage load capacity is 650 lbs. (1400–750 (5 x 150) = 650 lb.). In metric units (635–340 (5 x 68) = 295 kg.) 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 204 Front or the Rear Gross Axle Weight Rating specified for your vehicle on the Safety Compliance Certification Label found on the edge of the driver’s door. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 205: Trailer Towing
Trailer towing puts additional loads on your vehicle’s engine, transmission, axle, brakes, tires, and suspension. For your safety and to maximize vehicle performance, be sure to use the proper equipment while towing. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 206 Towing trailers beyond the maximum recommended gross trailer weight exceeds the limit of the vehicle and could result in engine damage, transmission damage, structural damage, loss of vehicle control, vehicle rollover and personal injury. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 207 * -When towing maximum loads under high outside temperatures and on steep grades, the A/C system may cycle on and off to protect the engine from overheating. This may result in a temporary increase of interior temperatures. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 208 10–15% of the total weight of the trailer is on the tongue, not to exceed the maximum tongue loads as stated: • Class II receiver: 350 lb. (159 kg) • Class III/IV receiver: 500 lb. (227 kg) (weight carrying); 740 lb. (336 kg) (weight distributing) 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 209 Never connect any trailer lighting to the vehicle’s taillamp circuits, because it may damage the electrical system resulting in fire. Contact your authorized dealer for assistance in proper trailer tow wiring installation. Additional electrical equipment may be required. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 210 • If you are driving down a long or steep hill, shift to a lower gear. Do not apply the brakes continuously, as they may overheat and become less effective. • The trailer tongue weight should be 10–15% of the loaded trailer weight. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 211 Replace the rear axle lubricant any time the axle has been submerged in water. Rear axle lubricant quantities are not to be checked or changed unless a leak is suspected or repair required. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 212: Recreational Towing
• Maximum distance is 50 miles (80 km). If a distance of 50 miles (80 km) or a speed of 35 mph (56 km/h) must be exceeded, you must disconnect the driveshaft. Ford recommends the driveshaft be removed/installed only by a qualified technican at an authorized dealer.
Page 213: Driving
1. Make sure all occupants buckle their safety belts. For more information on safety belts and their proper usage, refer to the Seating and Safety Restraints chapter. 2. Make sure the headlamps and electrical accessories are off. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 214 • the front wheels are turned • a front wheel is against the curb 2. Turn the key to 4 (START), then release the key as soon as the engine starts. Excessive cranking could damage the starter. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 215: Brakes
If the vehicle has continuous vibration or shudder in the steering wheel while braking, the vehicle should be inspected by an authorized dealer. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 216 Parking brake Apply the parking brake whenever the vehicle is parked. To set the parking brake, press the parking brake pedal down until the pedal stops. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 217: Traction Control/Advancetrac
Roll Stability Control (RSC), Electronic Stability Control (ESC) and Traction Control (TCS) for certain driving situations. The system includes an AdvanceTrac with RSC on/off button, and a “sliding car” icon in the instrument cluster. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 218 AdvanceTrac with RSC stability enhancement feature will restore full engine power and will enhance momentum through the obstacle. During Traction Control events the “sliding car” icon in the instrument cluster will flash momentarily. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 219 Driving conditions that may activate AdvanceTrac with RSC include: • Emergency lane-change • Taking a turn too fast • Quick maneuvering to avoid an accident, pedestrian or obstacle 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 220 In R (Reverse), ABS and the Traction Control feature will continue to function, however ESC and RSC are disabled. All these conditions are normal during AdvanceTrac with RSC operation. Refer to the following table. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 221 To prevent damage to the power steering system: • Never hold the steering wheel at its furthest turning points (until it stops) for more than a few seconds when the engine is running 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 222 Avoid sharp turns, excessive speed and abrupt maneuvers in these vehicles. Failure to drive cautiously could result in an increased risk of loss of vehicle control, vehicle rollover, personal injury and death. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 223: Transmission Operation
Always set the parking brake fully and make sure the gearshift is latched in P (Park). Turn the ignition to the LOCK position and remove the key whenever you leave your vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 224 This learning process could take several transmission upshifts and downshifts; during this learning process, slightly firmer shifts may occur. After this learning process, normal shift feel and shift scheduling will resume. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 225 Hold the brake pedal down while in this position. D (Drive) with Overdrive The normal driving position for the best fuel economy. Transmission operates in gears one through five. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 226 1 (First) • Provides maximum engine braking. • Allows upshifts by moving gearshift lever. • Will not downshift into 1 (First) at high speeds; allows for 1 (First) when vehicle reaches slower speeds. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 227 Transmission Control Module (TCM) located within the transmission assembly. When the battery is disconnected for any type of service or repair, the Adaptive Transmission Control Strategy parameters will be unaffected. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 228 D (Drive) with Overdrive The normal driving position for the best fuel economy. Transmission operates in gears one through six except in 4WD Low where transmission operates in gears two through six. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 229 Transmission operates in 2nd gear only. Use 2 (Second) to start-up on slippery roads or to provide additional engine braking on downgrades. 1 (First) • Transmission operates in 1st gear only. • Provides maximum engine braking. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 230 The system is designed to provide a warning to assist the driver in detecting large stationary objects to avoid damaging the vehicle. The system may not detect smaller objects, particularly those close to the ground. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 231 RSS. If your vehicle sustains damage to the rear bumper/fascia, leaving it misaligned or bent, the sensing zone may be altered causing inaccurate measurement of obstacles or false alarms. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 232 4X4 LOW (4WD Low) will not engage while the vehicle is moving; this is normal and should be no reason for concern. Refer to Shifting to/from 4X4 LOW (4WD Low) for proper operation. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 233 • Do not use 4WD High or 4WD Low on dry, hard surfaced roads. Doing so will produce excessive noise, increase tire wear and may damage drive components. 4WD modes are only intended for consistently slippery or loose surfaces. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 234 Do not rock the vehicle for more than a few minutes or damage to the transmission and tires may occur or the engine may overheat. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 235 P (Park) or the manual transmission is in gear. Do not leave the vehicle unattended with the transfer case in the N (Neutral) position. Always set the parking brake fully and turn off the ignition when leaving the vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 236 Note: If your vehicle is equipped with the Tire Pressure Monitoring System (TPMS), the system indicator light may illuminate depending on how much air is released from your tires and/or how long you drive the vehicle under these conditions. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 237 Ford Motor Company joins the U.S. Forest Service and the Bureau of Land Management in encouraging you to help preserve our national forest and other public and private lands by “treading lightly.”...
Page 238 Rapid pumping of the brake pedal will help you slow the vehicle and still maintain steering control. If your vehicle has anti-lock brakes, apply the brakes steadily. Do not “pump” the brakes. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 239 Ford Motor Company recommends that caution be used with any vehicle equipped with a high load or device (such as ladder racks or pickup box cover).
Page 240 Once through the water, always dry the brakes by moving your vehicle slowly while applying light pressure on the brake pedal. Wet brakes do not stop the vehicle as quickly as dry brakes. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 241: Roadside Emergencies
50,000 miles (80,000 km) on Lincoln vehicles. Roadside assistance will cover: • a flat tire change with a good spare (except Ford GT which has a tire inflation kit) • battery jump start • lock-out assistance (key replacement cost is the customer’s responsibility) •...
Page 242 1–800–241–3673; Lincoln vehicle customers call 1–800–521–4140. Canadian customers who require roadside assistance, call 1–800–665–2006. If you need to arrange roadside assistance for yourself, Ford Motor Company will reimburse a reasonable amount. To obtain reimbursement information, U.S. Ford or Mercury vehicles customers call 1–800–241–3673;...
Page 243: Hazard Flasher Switch
After a collision, if the engine cranks but does not start, the fuel pump shut-off switch may have been activated. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 244 4. Turn the ignition to the ON position. Pause for a few seconds and return the key to the OFF position. 5. Make a further check for leaks in the fuel system. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 245: Fuses And Relays
Blue — — Yellow Yellow Yellow Blue Natural Natural — — Green Green Green Pink — — Orange Green — — — — Blue Yellow — — — — — Natural — 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 246 To remove a fuse use the fuse puller tool provided on the fuse panel box. The fuses are coded as follows: Fuse/Relay Fuse Amp Passenger Compartment Fuse Location Rating Panel Description Moonroof, Adjustable pedals, DSM, Memory lumbar motor Microcontroller power (SJB) Radio OBD II connector Moonroof 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 247 — Not used Manual climate, DEATC, Brake shift — Not used Brake switch, Bi-color stop lamps, CHMSL all turn Power mirrors, Interior lamps, Puddle lamps, Battery saver, Instrument illumination, Homelink 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 248 The following relays are located on either side of the passenger compartment fuse panel. See your authorized dealer for service of these relays. Fuse/Relay Location Description Relay 1 Delayed ACC Relay 2 Rear defrost Relay 3 Park lamps Relay 4 RUN/START 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 249 To reduce risk of electrical shock, always replace the cover to the Power Distribution Box before reconnecting the battery or refilling fluid reservoirs. If the battery has been disconnected and reconnected, refer to the Battery section of the Maintenance and Specifications chapter. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 250 Third row seat (left) 40A** IVD module 40A** Powertrain Control Module (PCM) — Not used — Not used 30A** Power seat (right) 30A** Starter 30A** Third row seat (right) 30A** Trailer tow battery charger 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 251 IVD module 20A* Headlamps (left) 10A* AC clutch — Not used 30A* Front wiper 15A* 5R Transmission 15A* PCM power 15A* Fan clutch, PCV valve, AC clutch relay, GCC fan 15A* SDARS/DVD 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 252: Changing Tires
Note: The tire pressure monitoring system (TPMS) indicator light will illuminate when the spare is in use. To restore the full functionality of the monitoring system, all road wheels equipped with tire pressure monitoring sensors must be mounted on the vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 253 Ford. If the dissimilar spare tire or wheel is damaged, it should be replaced rather than repaired.
Page 254 • Comfort and noise • Ground clearance and parking at curbs • Winter weather driving capability • Wet weather driving capability • All-Wheel driving capability (if applicable) • Load leveling adjustment (if applicable) 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 255 Note: Passengers should not remain in the vehicle when the vehicle is being jacked. 4. Block the wheel that is diagonally opposite of the flat tire using the wheel chock provided with your vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 256 4. Remove the chock and jack tools from the provided bag and rotate the wrench socket out from the handle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 257 1. Open the cover from the carpeting on cargo floor to expose the winch drive nut. 2. Insert the lug wrench on the winch drive nut. The wrench will stop moving and forward resistance to turning will be felt when properly engaged. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 258 2. Loosen each wheel lug nut by half a turn, but do not remove them until the wheel is raised off the ground. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 259 4. Position the jack according to the illustrated guides and turn the jack handle clockwise until the tire is a maximum of 1 inch (25 mm) off the ground. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 260: Stowing Flat/Spare Tire
Pull on the cable to align the components at the end of the cable. 3. Turn the lug wrench clockwise until the tire is raised to its stowed position underneath the vehicle. The effort to turn the jack handle 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 261: Re-Stowing Jack And Tools
Lug nut socket size: ⁄ ” (19 mm) hex Bolt size: ⁄ x 20 * Torque specifications are for nut and bolt threads free of dirt and rust. Use only Ford recommended replacement fasteners. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 262: Jump Starting
4. Check all battery terminals and remove any excessive corrosion before you attach the battery cables. Ensure that vent caps are tight and level. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 263 Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery. 2. Connect the other end of the positive (+) cable to the positive (+) terminal of the assisting battery. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 264 Do not use fuel lines, engine rocker covers or the intake manifold as grounding points. Ensure that the battery shield is properly installed before jump starting the vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 265 Remove the jumper cables in the reverse order that they were connected. 1. Remove the jumper cable from the ground metal surface. 2. Remove the jumper cable on the negative (-) connection of the booster vehicle’s battery. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 266 4. Remove the jumper cable from the positive (+) terminal of the disabled vehicle’s battery. After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle conditions. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 267: Wrecker Towing
It is recommended that your vehicle be towed with a wheel lift or flatbed equipment. Do not tow with a slingbelt. Ford Motor Company has not approved a slingbelt towing procedure. If the vehicle’s battery is discharged, refer to Automatic transmission operation in the Driving chapter for directions on how to move the gearshift lever out of the P (Park) position, for proper towing.
Page 268: Customer Assistance
Center at 1-800-392-3673 (FORD). Away from home If you own a Ford or Mercury vehicle and are away from home when your vehicle needs service, or if you need more help than the authorized dealer could provide, after following the steps described above, contact the Ford Customer Relationship Center to find an authorized dealer to help you.
Page 269 Better Business Bureau (BBB) AUTO LINE program (U.S. only). In some states (in the U.S.) you must directly notify Ford in writing before pursuing remedies under your state’s warranty laws. Ford is also allowed a final repair attempt in some states.
Page 270 Dearborn, MI 48126 THE BETTER BUSINESS BUREAU (BBB) AUTO LINE PROGRAM (U.S. ONLY) Your satisfaction is important to Ford Motor Company and to your dealer. Experience has shown that our customers have been very successful in 2006 Explorer (exp) Owners Guide (post-2002-fmt)
Page 271 You are not bound by the decision but may choose to accept it. If you choose to accept the BBB AUTO LINE decision then Ford must abide by the accepted decision as well. If the arbitrator has decided in...
Page 272 United States and Canada, provided by a network of more than 4,600 participating authorized dealers. If you did not take advantage of the Ford Extended Service Plan at the time of purchasing your vehicle, you may still be eligible. Since this...
Page 273 The use of leaded fuel in your vehicle without proper conversion may damage the effectiveness of your emission control system and may cause engine knocking or serious engine damage. Ford Motor Company/Ford of Canada is not responsible for any damage caused by use of improper fuel.
Page 274: Reporting Safety Defects (U.s. Only)
Obtaining a French owner’s guide French Owner’s Guides can be obtained from your authorized dealer or by writing to Ford Motor Company of Canada, Limited, Service Publications, P.O. Box 1580, Station B, Mississauga, Ontario L4Y 4G3. REPORTING SAFETY DEFECTS (U.S. ONLY)
Page 275: Cleaning
• Never use abrasive materials such as steel wool or plastic pads as they can scratch the chrome surface. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 276 • Do not use hydrofluoric acid-based or high caustic-based wheel cleaners, steel wool, fuels or strong household detergent. • To remove tar and grease, use Motorcraft Bug and Tar Remover (ZC-42), available from your authorized dealer. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 277 • Spray Motorcraft Engine Shampoo and Degreaser (ZC-20) on all parts that require cleaning and pressure rinse clean. • Cover the highlighted areas to prevent water damage when cleaning the engine. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 278 If the wipers do not wipe properly, substances on the vehicle’s glass or the wiper blades may be the cause. These may include hot wax treatments used by commercial car washes, water repellant 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 279 INTERIOR TRIM • Clean the interior trim areas with a damp cloth, then with a clean, dry cloth. • Do not use household or glass cleaners as these may damage the finish. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 280 If this occurs, the leather should be cleaned immediately to avoid permanent staining. UNDERBODY Flush the complete underside of your vehicle frequently. Keep body and door drain holes free from packed dirt. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 281 Cleaning FORD AND LINCOLN MERCURY CAR CARE PRODUCTS Your Ford or Lincoln Mercury authorized dealer has many quality products available to clean your vehicle and protect its finishes. These quality products have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and appearance of your vehicle.
Page 282: Maintenance And Specifications
2. Block the wheels. To reduce the risk of vehicle damage and/or personal burn injuries do not start your engine with the air cleaner removed and do not remove it while the engine is running. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 283 2. Go to the front of the vehicle and release the auxiliary latch that is located under the front center of the hood. 3. Lift the hood. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 284: Engine Compartment
2. Engine oil dipstick (out of view) 3. Brake fluid reservoir 4. Power distribution box 5. Battery 6. Power steering fluid reservoir 7. Radiator cap 8. Engine coolant reservoir 9. Air filter assembly 10. Washer fluid reservoir 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 285 2. Engine oil filler cap 3. Engine oil dipstick 4. Brake fluid reservoir 5. Power distribution box 6. Battery 7. Power steering fluid reservoir 8. Radiator cap 9. Engine coolant reservoir 10. Windshield washer fluid reservoir 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 286 In very cold weather, do not fill the reservoir completely. Only use a washer fluid that meets Ford specification WSB-M8B16–A2. Do not use any special washer fluid such as windshield water repellent type fluid or bug wash. They may cause squeaking, chatter noise, streaking and smearing.
Page 287: Engine Oil
3. Set the parking brake and ensure the gearshift is securely latched in P (Park). 4. Open the hood. Protect yourself from engine heat. 5. Locate and carefully remove the engine oil level indicator (dipstick). 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 288 • If the oil level is between the lower and upper holes, the oil level is acceptable, DO NOT ADD OIL. • If the oil level is below the lower hole, add enough oil to raise the level within the lower and upper holes. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 289 (dipstick). 4. Install the indicator and ensure it is fully seated. 5. Fully install the engine oil filler cap by turning the filler cap clockwise until three clicks can be heard. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 290 To protect your engine’s warranty use Motorcraft SAE 5W-30 or an equivalent 5W-30 oil meeting Ford specification WSS-M2C929-A. Do not use supplemental engine oil additives, cleaners or other engine treatments. They are unnecessary and could lead to engine damage that is not covered by Ford warranty.
Page 291 Change your engine oil according to the appropriate schedule listed in the scheduled maintenance information. Ford production and aftermarket (Motorcraft) oil filters are designed for added engine protection and long life. If a replacement oil filter is used that does not meet Ford material and design specifications, start-up engine noises or knock may be experienced.
Page 292: Battery
Therefore, do not allow flames, sparks or lighted substances to come near the battery. When working near the battery, always shield your face and protect your eyes. Always provide proper ventilation. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 293 This operation is considered normal and will not affect function or durability of the transmission. Over time the adaptive learning process will fully update transmission operation to its optimum shift feel. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 294: Engine Coolant
• Boiling protection up to 265°F (129°C). • Protection against rust and other forms of corrosion. • Enables calibrated gauges to work properly. When the engine is cold, check the level of the engine coolant in the reservoir. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 295 Refer to Adding engine coolant in this chapter. Note: Automotive fluids are not interchangeable; do not use engine coolant, antifreeze or windshield washer fluid outside of its specified function and vehicle location. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 296 Motorcraft Premium Gold Engine Coolant from yellow to golden tan. • Do not add/mix an orange-colored, extended life coolant such as Motorcraft Specialty Orange Engine Coolant, meeting Ford specification WSS-M97B44-D, with the factory-filled coolant. Mixing Motorcraft Specialty Orange Engine Coolant or any orange-colored extended life product with your factory filled coolant can result in degraded corrosion protection.
Page 297 Your cooling system may have a leak. Operating an engine with a low level of coolant can result in engine overheating and possible engine damage. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 298 Maintenance and Specifications Recycled engine coolant Ford Motor Company does NOT recommend the use of recycled engine coolant in vehicles originally equipped with Motorcraft Premium Gold Engine Coolant since a Ford-approved recycling process is not yet available. Used engine coolant should be disposed of in an appropriate manner.
Page 299 The instrument cluster has no separate oil temperature indicator. Along with the (Engine coolant temperature) indicator, the engine coolant temperature gauge will read in the Hot (H) area. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 300 Replace the fuel filter with an authorized Motorcraft part. The customer warranty may be void for any damage to the fuel system if an authorized Motorcraft fuel filter is not used. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 301: Fuel Information
• Avoid getting fuel liquid in your eyes. If fuel is splashed in the eyes, remove contact lenses (if worn), flush with water for 15 minutes and seek medical attention. Failure to seek proper medical attention could lead to permanent injury. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 302 • Stay outside your vehicle and do not leave the fuel pump unattended when refueling your vehicle — this is against the law in some places; • Keep children away from the fuel pump; never let children pump fuel 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 303 The customer warranty may be void for any damage to the fuel tank or fuel system if the correct genuine Ford or Motorcraft fuel filler cap is not used. 2006 Explorer (exp) Owners Guide (post-2002-fmt)
Page 304 (R+M)/2 octane rating of 87. We do not recommend the use of (R+M)/2 METHOD gasolines labeled as “Regular” that are sold with octane ratings of 86 or lower in high altitude areas. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 305 Ask your fuel supplier about gasolines that meet the World-wide Fuel Charter. Cleaner air Ford endorses the use of reformulated “cleaner-burning” gasolines to improve air quality. Running out of fuel Avoid running out of fuel because this situation may have an adverse effect on powertrain components.
Page 306 • Use the same side of the same pump and have the vehicle facing the same direction each time you fill up. • Have the vehicle loading and distribution the same every time. Your results will be most accurate if your filling method is consistent. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 307 65 mph [105 km/h]). • Revving the engine before turning it off may reduce fuel economy. • Using the air conditioner or defroster may reduce fuel economy. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 308 • Close windows for high speed driving. EPA window sticker Every new vehicle should have the EPA window sticker. Contact your authorized dealer if the window sticker is not supplied with your vehicle. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 309 If other than Ford, Motorcraft or Ford-authorized parts are used for maintenance replacements or for service of components affecting emission control, such non-Ford parts should be equivalent to genuine Ford Motor Company parts in performance and durability.
Page 310 Readiness for Inspection/Maintenance (I/M) testing In some localities, it may be a legal requirement to pass an I/M test of the on-board diagnostics system. If the indicator is on, refer to the 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 311 6. If the fluid is low, add fluid in small amounts, continuously checking the level until it reaches the correct operating range. Be sure to put the cap back on the reservoir. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 312 Do not use supplemental transmission fluid additives, treatments or cleaning agents. The use of these materials may affect transmission operation and result in damage to internal transmission components. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 313: Air Filter(S)
Use only fluid that meets Ford specifications. Refer to Lubricant specifications in this chapter. DRIVELINE UNIVERSAL JOINT AND SLIP YOKE If the original universal joints are replaced with universal joints equipped with grease fittings, lubrication will be necessary.
Page 314: Part Numbers
PCV valve. Replace the PCV valve with one that meets Ford material and design specifications for your vehicle, such as a Motorcraft or equivalent replacement part. The customer warranty may be void for any damage to the emissions system if such a PCV valve is not used.
Page 315: Refill Capacities
Replace the spark plugs with ones that meet Ford material and design specifications for your vehicle, such as Motorcraft or equivalent replacement parts. The customer warranty may be void for any damage to the engine if such spark plugs are not used.
Page 316 13.9 quarts without (13.2L) auxiliary climate control 4.6L V8 engine 15.7 quarts with auxiliary (14.9L) climate control Front axle Motorcraft SAE 2.7 pints (1.3L) lubricant (if 80W-90 equipped) Premium Rear Axle Lubricant 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 317 Add the coolant type originally equipped in your vehicle. Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only have the API Certification mark and meet the requirements of Ford specification WSS-M2C929-A (4.0L) or WSS-M2C930-A (4.6L). 2006 Explorer (exp) Owners Guide (post-2002-fmt)
Page 318: Lubricant Specifications
Motorcraft VC-7–A (except WSS- Premium Gold CA, OR and NM), M97B51-A1 Engine Coolant VC-7-B (CA, OR (yellow-colored) and NM) Motorcraft Cooling system Cooling System VC-6 WSS-M99B37-B6 stop leak pellets Stop Leak Pellets 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 319 MERCON V XT-5-QM MERCON V (5R55S) Automatic Motorcraft transmission MERCON SP XT-6–QSP MERCON SP (6R60) Motorcraft Power steering MERCON XT-2-QDX MERCON fluid Multi-Purpose Motorcraft 75W-140 Rear axle XY-75W140–QL WSL-M2C192–A Synthetic Rear Axle Lubricant 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 320 MERCON SP may cause transmission damage. Use of a transmission fluid other than the recommended fluid may cause transmission damage. Refer to your scheduled maintenance information to determine the correct service interval. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 321 (3) Maximum height* 72.8 (1849.1) (4) Wheelbase 113.7 (2888.7) (5) Track width, front 60.9 (1547.5) (5) Track width, rear 62 (1574.3) * Height includes roof rack and cross bars with P235/65R18 tire 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 322 Maintenance and Specifications 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 323 XXXX is representative of your vehicle identification number.) 1. World manufacturer identifier 2. Brake type and gross vehicle weight rating (GVWR) 3. Vehicle line, series, body type 4. Engine type 5. Check digit 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 324 You can find a transmission/transaxle code on the Safety Compliance Certification Label. The following table tells you which transmission or transaxle each code represents. Description Code Five-speed automatic (5R55S) Six-speed automatic (6R60) 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 325: Accessories
GENUINE FORD ACCESSORIES FOR YOUR VEHICLE A wide selection of Genuine Ford Accessories are available for your vehicle through your local Ford or Ford of Canada dealer. These quality accessories have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and aerodynamic appearance of your vehicle.
Page 326 • Electrical or electronic accessories or components that are added to the vehicle by the authorized dealer or the owner may adversely affect battery performance and durability. 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 327: Index
......167 in rear seat ......167 Axle lubricant specifications ..318, 321 Cleaning your vehicle refill capacities ......315 engine compartment ....277 instrument panel ....279 interior ........280 interior trim ......279 Battery ........292 plastic parts ......278 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 328 Getting the service you cleaning ........277 need .........268 coolant ........294 Ordering additional owner’s fail-safe cooling .......299 literature .........273 idle speed control ....292 Utilizing the lubrication Mediation/Arbitration specifications ....318, 321 Program ........271 refill capacities ......315 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 329 ......301, 303, 306 system ..........72 filter, specifications ..300, 314 fuel pump shut-off switch ..243 Hood ..........283 improving fuel economy ..306 octane rating ....304, 321 quality ........305 running out of fuel ....305 Ignition .......213, 321 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 330 Liftgate ........101 remote release ......108 Parking brake ......216 Lights, warning and indicator ..12 anti-lock brakes (ABS) ..216 Parts (see Motorcraft parts) ..314 Load limits .........198 Passenger Occupant Loading instructions ....205 Classification Sensor ....133 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 331 ....8 Specification chart, Safety Belt Maintenance ..147 lubricants ......318, 321 Safety belts (see Safety Speed control ......66 restraints) ....132, 135–140 Starting your vehicle ..213–214 Safety Canopy ...156, 158–159 jump starting ......262 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)
Page 332 Windshield washer fluid and treadwear ......178, 188 wipers ..........58 checking and adding fluid ..286 Towing ........205 liftgate reservoir .....286 recreational towing ....212 replacing wiper blades ...287 trailer towing ......205 wrecker ........267 Wrecker towing ......267 2006 Explorer (exp) Owners Guide (post-2002-fmt) USA (fus)

This manual is also suitable for:

2006 explorer

Ford Explorer Owner's Manual

Introduction

Instrument Cluster

Entertainment Systems

Climate Controls

Lights

Driver Controls

Locks and Security

Seating and Safety Restraints

Tires, Wheels and Loading

Driving

Roadside Emergencies

Customer Assistance

Cleaning

Maintenance and Specifications

Accessories

Index

Quick Links

Table of Contents

Related Manuals for Ford Explorer

Summary of Contents for Ford Explorer

This manual is also suitable for:

Table of Contents