Page 1 ’04 Solara_U (L/O 0402) SECTION OPERATION OF INSTRUMENTS AND CONTROLS Overview of instruments and controls Instrument panel overview ........Instrument cluster overview .
Page 2: Instrument Panel Overview
’04 Solara_U (L/O 0402) Instrument panel overview DCoupe 1. Side defroster outlets 2. Side vents 3. Instrument cluster 4. Center vents 5. Personal lights 6. Electric moon roof switch 7. Garage door opener 8. Auxiliary box 9. Power door lock switches 10.
Page 3 ’04 Solara_U (L/O 0402) DConvertible 1. Side defroster outlets 2. Side vents 3. Instrument cluster 4. Garage door opener 5. Convertible top latch handles 6. Center vents 7. Personal lights 8. Power door lock switches 9. Power window switches 10. Glove box 11.
Page 4 ’04 Solara_U (L/O 0402) DWith manual air conditioning controls 1. Headlight, turn signal and front fog light switches 2. Audio remote control switches 3. Multi- information display control switch 4. Wiper and washer switches 5. Multi- information displays 6. Front passenger’s occupant classification indicator light/front passenger seat belt reminder light 7.
Page 5 ’04 Solara_U (L/O 0402) DWith automatic air conditioning controls 1. Headlight, turn signal and front fog light switches 2. Audio remote control switches 3. Multi- information display control switch 4. Wiper and washer switches 5. Multi- information displays 6. Front passenger’s occupant classification indicator light/front passenger seat belt reminder light 7.
Page 6: Instrument Cluster Overview
’04 Solara_U (L/O 0402) Instrument cluster overview D2AZ- FE engine 1. Tachometer 4. Engine coolant temperature gauge 7. Odometer and two trip meters 2. Service reminder indicators and 5. Fuel gauge 8. Trip meter reset knob/instrument panel indicator lights light control knob 6.
Page 7 ’04 Solara_U (L/O 0402) D3MZ- FE engine 1. Tachometer 4. Engine coolant temperature gauge 7. Automatic transmission shift position indicator lights 2. Service reminder indicators and 5. Fuel gauge indicator lights 8. Odometer and two trip meters 6. Automatic transmission shift range 3.
Page 8: Table Of Contents
’04 Solara_U (L/O 0402) Indicator symbols on the instrument panel Low fuel level warning light Brake system warning light Anti- lock brake system warning light Driver’s seat belt reminder light Open door warning light Front passenger’s seat belt reminder light SRS warning light Discharge warning light Low tire pressure warning light...
Page 9 ’04 Solara_U (L/O 0402) : For details, see “Service reminder indicators and warning buzzers” on page 129 in Section 1- 6. Engine oil replacement reminder light : If this light flashes, see “Cruise control” on page 155 in Sec- tion 1- 7. Front passenger occupant classification indicator light Turn signal indicator lights...
Page 10 ’04 Solara_U (L/O 0402) 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 11 ’04 Solara_U (L/O 0402) SECTION OPERATION OF INSTRUMENTS AND CONTROLS Keys and Doors Keys ............Engine immobilizer system .
Page 12: Keys
These keys work in every lock. Your precautions: Toyota dealer will need one of them to z When starting the engine, do not make a new key with a built- in trans- use the key with a key ring resting ponder chip.
Page 13 ’04 Solara_U (L/O 0402) z Do not cover the key grip with any material that cuts off electromagnet- ic waves. z Do not knock the key hard against other objects. z Do not leave the key exposed to high temperatures for a long period, such as on the dashboard and hood under direct sunlight.
Page 14: Engine Immobilizer System
Toyota dealer. need additional keys, duplicates can be the electronic code in the chip corre- made by a Toyota dealer using the key The indicator light stays on except sponds to the registered ID code for number.
Page 15: Wireless Remote Control
FCC Rules. Operation is subject to the following two conditions: For your Toyota dealer to make you a new key with built- in transponder chip, (1) This device may not cause harmful your dealer will need your key number interference, and (2) this device must and master key.
Page 16 The wireless remote control transmitter is If you lose your transmitter, contact your an electronic component. Observe the fol- Toyota dealer as soon as possible to lowing instructions in order not to cause avoid the possibility of theft, or an acci- damage to the transmitter.
Page 17 ’04 Solara_U (L/O 0402) —Opening trunk lid To lock and unlock both doors, push Coupe—When unlocking a door when both the switches of the transmitter slowly doors are locked, the interior light and and securely. ignition switch light come on. The lights remain on for about 15 seconds unless To lock: Push the “...
Page 18 If this procedure is not followed exactly, equivalent type recommended by a and interior light (coupe) or personal the beep will not operate as expected. Toyota dealer. lights (convertible). Check the beep ON/OFF operation by z Dispose of used batteries according The “...
Page 19 ’04 Solara_U (L/O 0402) 1. Using a coin or equivalent, open the 2. Remove the circuit board, then remove 3. Put in a new transmitter battery with transmitter case. the discharged transmitter battery. positive (+) side up. Install the circuit board into the transmitter case.
Page 20: Side Doors
(For further information, “Ignition tact your Toyota dealer. LOCKING AND UNLOCKING WITH KEY switch light and quarter trim courtesy light” on page 120 and “Personal lights” Insert the key into the keyhole and turn on page 121 in Section 1- 5.)
Page 21 Do not pull the inside handle of the doors while driving. The doors will open and an accident may occur. Toyota strongly recommends that all children be placed in the rear seat of the vehicle. Closing the door with the lock knob in the lock position will also lock the door.
Page 22 ’04 Solara_U (L/O 0402) —Automatic door locking and unlocking functions LOCKING UNLOCKING WITH You can set the following auto door Setting the functions POWER DOOR LOCK SWITCH locking and unlocking functions. 1. Close both doors. Push the switch. (a) Locking linked with the shift posi- 2.
Page 23: Power Windows
’04 Solara_U (L/O 0402) Power windows If you want to cancel a function, repeat the procedure. Each time you perform the procedure, the function is set or can- celled. Coupe The windows can be operated with the switch on each door. The power windows work when the ignition switch is in the “ON”...
Page 24 ’04 Solara_U (L/O 0402) Automatic operation: CAUTION Coupe—Push the switch completely down or pull it completely up, and then release Never try jamming any part of your it. The window will fully open or close. To body to activate the jam protection stop the window partway, lightly move the function intentionally.
Page 25 Toyota dealer. To open: Push on the lower side of the switch To close: Push on the upper side of the switch. The side windows will open slightly before closing if they are not fully opened.
Page 26: Trunk Lid
’04 Solara_U (L/O 0402) Trunk lid— CAUTION Be sure to remove the ignition key when you leave your vehicle. To avoid serious personal injury, you Never leave anyone (particularly a must do the following. small child) alone in your vehicle, Before you close the power win- especially with the ignition key still dows, always make sure there is...
Page 27 ’04 Solara_U (L/O 0402) —Luggage security system CAUTION Keep the trunk lid closed while driv- ing. This not only keeps the luggage from being thrown out but also pre- vents exhaust gases from entering the vehicle. This system prevents someone (with 2.
Page 28: Hood
’04 Solara_U (L/O 0402) —Internal trunk release handle Hood CAUTION Always lock the trunk lid and all doors, and keep away the vehicle keys out of children’s reach. Never leave children unattended in the vehicle. Unsupervised children may lock themselves in the vehicle or trunk and suffer serious injuries or death.
Page 29: Theft Deterrent System
’04 Solara_U (L/O 0402) Theft deterrent system 2. In front of the vehicle, pull up the To deter vehicle theft, the system is SETTING THE SYSTEM auxiliary catch lever and lift designed to sound an alarm if any of 1. Turn the ignition key to the “LOCK” hood.
Page 30 ’04 Solara_U (L/O 0402) The system will automatically be set after WHEN THE SYSTEM IS SET Stopping the alarm 30 seconds. When the system is set, the Activating the system The alarm will be stopped by the following indicator light will start flashing again. three ways: The system will sound the alarm under 4.
Page 31: Fuel Tank Cap
When refueling, turn off the engine. If the system does not work properly, have it checked by your Toyota dealer. CAUTION Do not smoke, cause sparks or al- low open flames when refueling.
Page 32 Make sure the cap is tightened securely. The indicator lamp goes off after driving several times. If the indicator lamp does not go off, contact your Toyota dealer as soon as possible. CAUTION 2. To remove the fuel tank cap, turn 3.
Page 33: Electric Moon Roof
’04 Solara_U (L/O 0402) Electric moon roof To operate the moon roof, use the Tilting operation— switch between the personal lights. To tilt up: Push and hold the switch for The moon roof works when the ignition 1 second on the “TILT UP” side. switch is in the “ON”...
Page 34 Never try jamming any part of your around the moon roof. You must by your Toyota dealer. body to activate the jam protection also make sure nobody places his function intentionally.
Page 35: Convertible Top
’04 Solara_U (L/O 0402) Convertible top— —Convertible top precautions NOTICE CAUTION Before you raise the convertible top, always make sure there is no- z Make sure there are no items or When raising or lowering the con- body near the top. You must also packages between the rear seatback vertible top, keep hands clear from make sure nobody places his or her...
Page 36 ’04 Solara_U (L/O 0402) —Before operating the convertible top —Lowering the convertible top 1. Park your vehicle on level ground. z When the convertible top is low- 2. Make sure the parking brake is applied ered, keep the rear window defog- firmly and the automatic transmission ger turned off to avoid damage to selector lever is in the “P”...
Page 37 ’04 Solara_U (L/O 0402) —Raising the convertible top If the convertible top does not lower dur- ing switch operation, see “If the convert- ible top does not rise or lower” on page 274 in Section 4 for instructions. 2. Push and hold the convertible top 1.
Page 38 ’04 Solara_U (L/O 0402) —Using the top boot 2. Pull down the convertible top by The top boot is used to conceal the The top boot is folded as shown in the grasping the handle under the con- lowered convertible top. illustration and stored in the trunk.
Page 39 ’04 Solara_U (L/O 0402) 1. Insert the top boot rear retainer un- 2. Insert the top boot front retainer be- 3. Tuck the top boot edge underside of derside of the body molding and tween the rear seatback and anchor the body moldings.
Page 40 ’04 Solara_U (L/O 0402) 4. Insert the tabs at the top boot ends 5. Tuck the top boot edge behind the into the slots on the quarter trims. rear seat belt slots and under the quarter trims. Make sure the tabs are set in the slots securely.
Page 41 ’04 Solara_U (L/O 0402) SECTION OPERATION OF INSTRUMENTS AND CONTROLS Occupant restraint systems Seats ............Front seats .
Page 42: Seats
’04 Solara_U (L/O 0402) Front seats— Seats —Front seat precautions While the vehicle is being driven, all ve- Driver seat Slightly recline the back of hicle occupants should have the seatback seat. Although vehicle designs vary, upright, sit well back in the seat and prop- CAUTION many drivers can achieve the 250 erly wear the seat belts provided.
Page 43 ’04 Solara_U (L/O 0402) —Seat adjustment precautions Front passenger seat Front seats (with SRS side airbags) CAUTION CAUTION CAUTION Do not adjust the seat while the vehicle is moving as the seat may The SRS front passenger airbag also The SRS side airbags are installed in unexpectedly move and cause the deploys with considerable force, and the driver and front passenger seats.
Page 44 ’04 Solara_U (L/O 0402) —Adjusting front seats (manual seat) 1. SEAT POSITION ADJUSTING LEVER While adjusting the seat, do not put Hold the center of the lever and pull it your hands under the seat or near up. Then slide the seat to the desired the moving parts.
Page 45 ’04 Solara_U (L/O 0402) —Adjusting front seats (power seat) 1. SEAT POSITION AND SEAT CUSHION CAUTION HEIGHT ADJUSTING SWITCH Move the control switch in the desired To reduce the risk of sliding under direction. the lap belt during a collision, avoid Releasing the switch will stop the seat at reclining the seatback any more than that position.
Page 46 ’04 Solara_U (L/O 0402) —Moving front seats for rear seat entry Coupe—Before access to the rear seat, CAUTION push the seat belt hanger down as far as it will go when it is in the raised To reduce the risk of sliding under position.
Page 47: Fold- Down Rear Seat
’04 Solara_U (L/O 0402) Fold- down rear seat (coupe) From the driver’s side— Pull up the seatback angle adjusting lever (manual seat) or seatback lock re- lease lever (power seat), and incline the seatback. After passengers are in, lift up on the seatback.
Page 48: Seat Heaters
’04 Solara_U (L/O 0402) Seat heaters CAUTION When returning the seatback to the upright position, observe the follow- ing precautions in order to prevent personal injury in a collision or sud- den stop: Make sure the seatback is securely locked by pushing forward and rear- ward on the top of the seatback and that the red mark at the button on the top of the seatback cannot...
Page 49: Head Restraints
’04 Solara_U (L/O 0402) Head restraints NOTICE CAUTION z Do not put unevenly weighed ob- Occupants must use caution when op- jects on the seat and do not stick erating the seat heater because it sharp objects (needles, nails, etc.) may make them feel too hot or cause into the seat.
Page 50: Seat Belts
’04 Solara_U (L/O 0402) Seat belts— —Seat belt precautions For your safety and comfort, adjust the Toyota strongly urges that the driver and Do not allow any children to stand up or head restraint before driving. passengers in the vehicle be properly re- kneel on either rear or front seats.
Page 51 ’04 Solara_U (L/O 0402) —Fastening front and rear seat belts CAUTION Be careful not to damage the belt webbing or hardware. Take care that Persons should ride in their seats they do not get caught or pinched properly wearing their seat belts in the seat or doors.
Page 52 ’04 Solara_U (L/O 0402) CAUTION Always make sure the shoulder belt is positioned securely across the shoulder, but kept away from neck. Use the seat belt guide to position the belt if necessary. Failure to properly position the belt may re- duce the amount of protection in an Buckle accident and could lead to serious...
Page 53 If the seat belt does not function normally, immediately contact your Toyota dealer. Do not use the seat until the seat belt is fixed, because it cannot protect an adult occupant or your child from injury.
Page 54 Toyota dealer free of charge. Please contact your local Toyota dealer to order the proper required length for the extender. Bring the heaviest coat you ex- pect to wear for proper measurement and selection of length.
Page 55 ’04 Solara_U (L/O 0402) Make sure the front passenger oc- Do not use the seat belt extender cupant classification indicator light when installing child restraint indicates “ON” when using the seat system on the front or rear passen- belt extender for the front passen- ger seat.
Page 56 If the seat belt does not function normally, immediately contact your Toyota dealer. Do not use the seat until the seat belt is fixed, because it cannot protect an adult occupant or your child from injury.
Page 57 Repairs made on or near the front system (ECU and sensors) result in death or serious injury. Con- fenders, front end structure or con- sult your Toyota dealer about any re- sole 5. Seat belt pretensioner assemblies pair and modification.
Page 58 129 in Sec- tion 1- 6.) This indicator comes on when the igni- In the following cases, contact your Toyota If any of the following conditions occurs, tion key is turned to the “ON” position.
Page 59: Srs Airbags
’04 Solara_U (L/O 0402) SRS airbags— —SRS driver airbag and front passenger airbag The front passenger airbag will not acti- CAUTION vate if there is no passenger sitting in the front passenger seat. However, the front The SRS front airbag system is de- passenger airbag may deploy if luggage is signed only as a supplement to the put in the seat, or the seat belt is buckled...
Page 60 The SRS front airbags will deploy if the child restraint system. Toyota severity of the impact is above the de- strongly recommends that all in- signed threshold level, comparable to an fants and children be placed in the...
Page 61 ’04 Solara_U (L/O 0402) 8. Driver’s seat position sensor 9. Airbag sensor assembly 10. Airbag module for driver Hitting a curb, edge Falling into or (airbag and inflator) of pavement or jumping over The airbag sensor assembly consists of a hard surface a deep hole safing sensor and airbag sensor.
Page 62 These ing airbag. Toyota strongly recommends that: are usually in the nature of minor burns or abrasions and swelling, but the force of The driver sit as far back as pos-...
Page 63 ’04 Solara_U (L/O 0402) Do not sit on the edge of the seat Toyota strongly recommends that all Do not put anything or any part of or lean against the dashboard when infants and children be placed in your body on or in front of the...
Page 64 “ON” position. can result in death or serious injury. It goes off after about 6 seconds. This ture Consult your Toyota dealer about any means the SRS front airbags are oper- z Attachment of a grille guard (bull repair and modification.
Page 65 “Service reminder indicators and warning buzzers” on page 129 in Sec- tion 1- 6.) In the following cases, contact your Toyota If any of the following conditions occurs, dealer as soon as possible: this indicates a malfunction of the airbags or seat belt pretensioners.
Page 66 ’04 Solara_U (L/O 0402) —SRS side airbags The SRS side airbag on the passenger CAUTION seat will not activate if there is no pas- senger sitting in the front passenger seat. The SRS side airbag system is de- However, the side airbag on the passen- signed only as a supplement to the ger seat may deploy if luggage is put in primary protection of the driver and...
Page 67 Toyota strongly recommends that all in- fants and children be placed in the Collision from the front rear seats of the vehicle and prop- erly restrained.
Page 68 ’04 Solara_U (L/O 0402) The SRS side airbag system is controlled Front seats may be hot for several min- by the airbag sensor assembly. The airbag utes, but the airbags themselves will not sensor assembly consists of a safing sen- be hot.
Page 69 When the side airbag in- Consult your Toyota dealer about any inflate with considerable speed and flates, the cup holder or any other repair and modification.
Page 70 Contact your z Modification of the side structure of tion key is turned to the “ON” position. Toyota dealer as soon as possible. It goes off after about 6 seconds. This the passenger compartment When the ignition key is turned to the...
Page 71 NOTICE Do not disconnect the battery cables before contacting your Toyota dealer. In the following cases, contact your Toyota The SRS (Supplemental Restraint Sys- dealer as soon as possible: tem) side airbags and curtain shield air- bags are designed to provide further...
Page 72 ’04 Solara_U (L/O 0402) In response to a severe side impact, the Your vehicle is equipped with a crash Do not allow anyone to lean his/her SRS side airbags and curtain shield air- sensing and diagnostic module, which will head or any part of his/her body bags work with the seat belts to help record the use of the seat belt restraint against the door or the area of the...
Page 73 Toyota strongly recommends that all in- fants and children be placed in the Collision from the front rear seats of the vehicle and prop- erly restrained.
Page 74 ’04 Solara_U (L/O 0402) 8. Front passenger’s seat belt buckle Deployment of the airbags happens in a switch fraction of a second, so the airbags must inflate with considerable force. While the 9. Airbag sensor assembly system is designed to reduce serious inju- The SRS side airbag and curtain shield ries, it may also cause minor burns or airbag system is controlled by the airbag...
Page 75 ’04 Solara_U (L/O 0402) Do not allow anyone to lean against Do not allow anyone to get his/her Do not allow anyone to kneel on the door when the vehicle is in use, head closer to the area where the the passenger seat, facing the pas- since the side airbag and curtain side airbag and curtain shield air-...
Page 76 ’04 Solara_U (L/O 0402) Do not allow anyone to get his/her Do not attach a cup holder or any Do not attach a microphone or any head hands windows other device or object on or around other device or object around the since curtain shield...
Page 77 Do not use seat accessories which Consult your Toyota dealer about any disc player cover the parts where the side air- repair and modification.
Page 78 “ON” position. or seat belt pretensioners. Contact your It goes off after about 6 seconds. This Toyota dealer as soon as possible. means the SRS side airbags and curtain When the ignition key is turned to the shield airbags are operating properly.
Page 79 ’04 Solara_U (L/O 0402) —Front passenger occupant classification system In the following cases, contact your Toyota Your vehicle is equipped with a front dealer as soon as possible: passenger occupant classification sys- tem. This system detects the conditions Any of the SRS side airbags and cur- 1—4 in the table on page 81 and based...
Page 80 ’04 Solara_U (L/O 0402) If the front passenger occupant classifica- The front passenger occupant classifi- tion system determines that a person of cation indicator light will indicate “ON” adult size sits in the front passenger seat and “OFF” when the ignition key is but the “OFF”...
Page 81 ’04 Solara_U (L/O 0402) Condition and operation in the front passenger occupant classification system Indicator/warning light Devices Condition detected by Front Curtain shield Front Side airbag Front the front passenger passenger Front airbag in the SRS warning passenger’s on the front passenger’s occupant classification occupant...
Page 82 ’04 Solara_U (L/O 0402) CAUTION Do not recline the front passenger Wear the seat belt properly. seatback so far that it touches a Make sure the front passenger’s To avoid potential death or serious rear seat. This cause seat belt tab has not been left in- injury when the front passenger occu- “OFF”...
Page 83: Child Restraint
’04 Solara_U (L/O 0402) Child restraint— —Child restraint precautions The front passenger occupant classifica- Toyota strongly urges the use of ap- Toyota strongly urges use of tion indicator light may indicate “ON” (the propriate child restraint systems for proper child restraint system which front passenger airbag and side airbag on children.
Page 84 ’04 Solara_U (L/O 0402) —Child restraint system A child restraint system for a small Only when it is unavoidable should Do not use the seat belt extender child or baby must itself be properly when installing child restraint a forward- facing child restraint sys- restrained on the seat with the lap por- system on the front or rear passen- tem be installed on the front pas-...
Page 85 ’04 Solara_U (L/O 0402) —Types of child restraint system Child restraint systems are classified into the following 3 types depending on the child’s age and size. (A) Infant seat (B) Convertible seat (C) Booster seat Install the child restraint system following the instructions provided by its manufac- turer.
Page 86 ’04 Solara_U (L/O 0402) —Installation with seat belt (A) INFANT SEAT INSTALLATION CAUTION Do not install a child restraint sys- An infant seat must be used in rear- tem on the rear seat if it interferes facing position only. Never install a rear- facing child re- with the lock mechanism of the straint system on the front passen- front seats.
Page 87 1. Run the lap and shoulder belt through 2. Fully extend the shoulder belt to put it Contact your Toyota dealer immedi- or around the infant seat following the in the lock mode. When the belt is ately.
Page 88 ’04 Solara_U (L/O 0402) 3. While pressing the infant seat firmly 4. To remove the infant seat, press the CAUTION against the seat cushion and seatback, buckle release button and allow the let the shoulder belt retract as far as belt to retract completely.
Page 89 ’04 Solara_U (L/O 0402) Install the child restraint system on the 6. While pressing convertible seat front passenger seat only when it is un- firmly against the seat cushion and avoidable. Your vehicle is equipped with a seatback, let the shoulder belt retract front passenger occupant...
Page 90 Remove the child restraint restraint system and the front pas- ger seat even if the front passenger system and contact your Toyota dealer. senger airbag and side airbag on occupant classification indicator...
Page 91 ’04 Solara_U (L/O 0402) Do not allow the child to lean his/ her head or any part of his/her body against the door or the area of the seat, front or rear pillar or roof side rail from which the side airbags or curtain shield airbags deploy even if the child is seated in the child restraint system.
Page 92 1. Run the lap and shoulder belt through 2. Fully extend the shoulder belt to put it Contact your Toyota dealer immedi- or around the convertible seat following in the lock mode. When the belt is ately.
Page 93 ’04 Solara_U (L/O 0402) 3. While pressing convertible seat 4. To remove the convertible seat, press CAUTION firmly against the seat cushion and the buckle release button and allow the seatback, let the shoulder belt retract belt to retract completely. The belt will Push and pull the child restraint sys- as far as it will go to hold the convert- move freely again and be ready to...
Page 94 ’04 Solara_U (L/O 0402) Do not allow the child to lean his/ her head or any part of his/her body against the door or the area of the seat, front or rear pillar or roof side rail from which the side airbags or curtain shield airbags deploy even if the child is seated in the child restraint system.
Page 95 Always make sure the shoulder belt child from death or serious injury. is positioned across the center of Contact your Toyota dealer immedi- child’s shoulder. The belt should be ately. install child kept away from child’s neck, but...
Page 96 ’04 Solara_U (L/O 0402) —Using a top strap (coupe) Symbol Anchor brackets 2. To remove the child restraint system, Follow the procedure below for a child Use the anchor bracket on the package press the buckle release button and restraint system that requires the use tray behind the rear seat to attach the top allow the belt to retract.
Page 97 ’04 Solara_U (L/O 0402) TO USE THE ANCHOR BRACKET: 2. Open the lid of the anchor bracket. 3. Securely fasten the child restraint system with the seat belt. 1. Outside anchor brackets only— Remove the head restraint. Latch hook onto the anchor bracket and tighten the top strap.
Page 98 ’04 Solara_U (L/O 0402) —Using a top strap (convertible) Anchor brackets Symbol 4. Outside anchor brackets only— Follow the procedure below for a child Use the anchor bracket on the back of the Replace the head restraint. restraint system that requires the use rear seat head restraint to attach the top of a top strap.
Page 99 ’04 Solara_U (L/O 0402) TO USE THE ANCHOR BRACKET: 2. Securely fasten the child restraint 3. Insert the lower hook into the hole system with the seat belt. on the head restraint and press the 1. Carefully remove the head restraint rear cover.
Page 100 ’04 Solara_U (L/O 0402) —Installation with child restraint lower anchorages (coupe) Lower anchorages for the child restraint systems complying with the FMVSS225 CMVSS210.2 specifications installed in the rear seat. The anchorages are installed in the clear- ance between the seat cushion and seat- back of both outside rear seats.
Page 101 ’04 Solara_U (L/O 0402) —Installation with child restraint lower anchorages (convertible) For owners in Canada For installation details, refer to the instruc- tion manual equipped with each product. The symbol on a child restraint system indicates the presence of a lower connec- CAUTION tor system.
Page 102 ’04 Solara_U (L/O 0402) For owners in Canada The symbol on a child restraint system indicates the presence of a lower connec- tor system. CHILD RESTRAINT SYSTEM INSTALLATION Type A— 1. Widen the clearance between seat cushion and seatback a little and confirm the position of the low- er anchorages near the button on the seatback.
Page 103 ’04 Solara_U (L/O 0402) For installation details, refer to the instruc- tion manual equipped with each product. CAUTION When using the lower anchorages for the child restraint system, be sure that there are no irregular ob- jects around the anchorages or that the seat belt is not caught.
Page 104 ’04 Solara_U (L/O 0402) 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 105 ’04 Solara_U (L/O 0402) SECTION OPERATION OF INSTRUMENTS AND CONTROLS Steering wheel and Mirrors Tilt and telescopic steering wheel ......Outside rear view mirrors .
Page 106: Tilt And Telescopic Steering Wheel
’04 Solara_U (L/O 0402) Tilt and telescopic steering wheel CAUTION Do not adjust the steering wheel while the vehicle is moving. Doing so may cause the driver to mishan- dle the vehicle and an accident may occur resulting in death or serious injuries.
Page 107: Outside Rear View Mirrors
’04 Solara_U (L/O 0402) Outside rear view mirrors— With auto anti- glare inside rear view mir- CAUTION ror— When the inside rear view mirror dark- Do not adjust the mirror while the ens in automatic function mode, the vehicle is moving. Doing so may driver’s outside rear view mirror also cause the driver to mishandle the darkens to reduce the reflection of the...
Page 108: Anti- Glare Inside Rear View Mirror
’04 Solara_U (L/O 0402) —Power rear view mirror Anti- glare inside rear view control mirror NOTICE If ice should jam the mirror, do not operate the control or scrape the mir- ror face. Use a spray de- icer to free the mirror.
Page 109: Auto Anti- Glare Inside Rear View Mirror
’04 Solara_U (L/O 0402) Auto anti- glare inside rear view mirror In automatic function mode, if the mirror CAUTION detects light from the headlights of the vehicle behind you, the mirror surface Do not adjust the mirror while the darkens slightly to reduce the reflected vehicle is moving.
Page 110: Sun Visors
’04 Solara_U (L/O 0402) Sun visors— To block out glare, move the sun visor. To block out glare from the front—Swing down the sun visor (position 1). To block out glare from the side—Swing down the sun visor, remove it from the hook and swing it to the lateral side (posi- tion 2).
Page 111 ’04 Solara_U (L/O 0402) —Vanity mirrors To use the vanity mirror, swing down the sun visor and open the cover. The vanity lights come on when you open the cover. 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 112 ’04 Solara_U (L/O 0402) 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 113 ’04 Solara_U (L/O 0402) SECTION OPERATION OF INSTRUMENTS AND CONTROLS Lights, Wipers and Defoggers Headlights and turn signals ........Emergency flashers .
Page 114: Headlights And Turn Signals
If you feel that the automatic light control Position 2—Headlights comes into operation too early or too late, above have the sensor adjusted by your Toyota dealer. 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 115 ’04 Solara_U (L/O 0402) Automatic light cut off system To turn off the DRL system, twist the knob NOTICE to position 3 (“DRL OFF”) or turn the Position 1 or “AUTO” position with the ignition switch off. To prevent the battery from becoming tail lights on—...
Page 116 ’04 Solara_U (L/O 0402) Headlights and turn signals (for Canada) High- Low beams—For high beams, turn TURN SIGNALS HEADLIGHTS the headlights on and push the lever away To signal a turn, push the headlight/ To turn on the following lights: Twist from you (position 1).
Page 117 If you feel that the automatic light control driving. comes into operation too early or too late, To prevent the battery from becoming have the sensor adjusted by your Toyota discharged, do not leave the lights on dealer. for a long period when the engine is not running.
Page 118: Emergency Flashers
’04 Solara_U (L/O 0402) Emergency flashers High- Low beams—For high beams, turn TURN SIGNALS To turn on the emergency flashers, the headlights on and push the lever away push the switch. To signal a turn, push the headlight/ from you (position 1). Pull the lever to- turn signal lever up or down to position All the turn signal lights will flash.
Page 119: Instrument Panel Light Control
’04 Solara_U (L/O 0402) Instrument panel light control Front fog lights NOTICE To prevent the battery from becoming discharged, do not leave the switch on longer than necessary when the engine is not running. To adjust the brightness of the instru- To turn on the front fog lights, twist ment panel lights, turn the knob.
Page 120: Interior Light
’04 Solara_U (L/O 0402) Ignition switch light and Interior light quarter trim courtesy light ILLUMINATED ENTRY SYSTEM When the switch is in the “DOOR” posi- tion, the interior light comes on and re- mains on for about 15 seconds before fading out in the following cases: Open and close any of the doors.
Page 121: Personal Lights
’04 Solara_U (L/O 0402) Personal lights For easy access to the ignition switch, Coupe— the ignition switch light comes on when To turn on the front personal light, any of the doors are opened or when push the lens. To turn the light off, the ignition switch is turned to the push the lens once again.
Page 122: Windshield Wipers And Washer
’04 Solara_U (L/O 0402) Windshield wipers and washer ILLUMINATED ENTRY SYSTEM With interval adjuster: The “INT TIME” (convertible) band lets you adjust the wiping time inter- val when the wiper lever is in the intermit- When the switch is in the “DOOR” posi- tent position (position 1).
Page 123: Rear Window And Outside Rear View Mirror Defoggers
If a nozzle becomes blocked, The key must be in the “ON” position. contact your Toyota dealer to have the The thin heater wires on the inside of the vehicle serviced. rear window will quickly clear the sur- faces.
Page 124 ’04 Solara_U (L/O 0402) Make sure you turn the defoggers off when the surfaces are clear. Leaving the defoggers on for a long time could cause the battery to discharge, especially during stop- and- go driving. The defoggers are not designed for drying rain water or for melting snow.
Page 125 ’04 Solara_U (L/O 0402) SECTION OPERATION OF INSTRUMENTS AND CONTROLS Gauges, Meters and Service reminder indicators Fuel gauge ..........Engine coolant temperature gauge .
Page 126: Fuel Gauge
The indicator lamp goes off after driving several times. If the indicator lamp does not go off, contact your Toyota dealer as soon as possible. The gauge indicates the approximate The gauge indicates the engine coolant...
Page 127: Tachometer
’04 Solara_U (L/O 0402) Tachometer Odometer and two trip meters NOTICE z Do not remove the thermostat in the engine cooling system as this may cause the engine to overheat. The thermostat is designed to con- trol the flow of coolant to keep the temperature of the engine within the specified operating range.
Page 128 ’04 Solara_U (L/O 0402) 3. Trip meter reset knob—Resets the two trip meters to zero, and also change the meter display. To change the meter display, quickly push and release the knob. The meter display changes in the order from the odometer to trip meter A to trip meter B, then back to the odometer each time you push.
Page 129: Service Reminder Indicators And Warning Buzzers
’04 Solara_U (L/O 0402) Service reminder indicators and warning buzzers If the indicator or buzzer comes on... Do this. If parking brake is off, stop immediately and contact Toyota dealer. Fasten driver’s seat belt. (indicator and buzzer) Fasten front passenger’s seat belt.
Page 130 ’04 Solara_U (L/O 0402) If the indicator or buzzer comes on... Do this. Take vehicle to Toyota dealer. If brake system warning light is also on, stop immediately and contact Toyota dealer. Close all doors. Take vehicle to Toyota dealer immediately.
Page 131: Driver's Seat Belt Reminder Light
Have your vehicle checked your Toyota dealer in the following cases: In this case, not only the anti- lock If luggage or other load is placed on the front passenger seat, depending on its The light does not come on even if the brake system will fail but also the weight, the reminder light may come on.
Page 132: Malfunction Indicator Lamp
Light vehicle at low speeds. Have your vehicle Empty fuel tank This light warns that the engine oil pres- checked by your Toyota dealer as soon as If the fuel tank is empty, refuel immedi- sure is too low. possible.
Page 133: Low Fuel Level Warning Light
Contact your The light comes on with the ignition key the engine is accelerated slightly. Toyota dealer as soon as possible to turned to the “ON” position. If the anti- service the vehicle. The light may come on when the oil level lock brake system works properly, the is extremely low.
Page 134: Open Door Warning Light
Contact your is turned to the “ON” position. If the anti- (j) SRS Warning Light Toyota dealer as soon as possible to lock brake system and the brake assist service the vehicle. This light will come on when the igni- system work properly, the light turns off tion key is turned to the “ON”...
Page 135: Low Tire Pressure Warning Light
’04 Solara_U (L/O 0402) If either of the following conditions occurs, If the light blinks rapidly (every 0.25 sec- In the following cases, contact your Toyota this indicates a malfunction somewhere in onds), the low tire pressure warning sys- dealer: the parts monitored by the warning light tem needs to be initialized.
Page 136 127 in this Sec- ing buzzer does not function as described tion.) above, have it checked by your Toyota 2. Turn the ignition key to the “ON” posi- dealer as soon as possible. tion while holding down the trip meter reset knob.
Page 137 ’04 Solara_U (L/O 0402) SECTION OPERATION OF INSTRUMENTS AND CONTROLS Ignition switch, Transmission and Parking brake Ignition switch with steering lock ......Automatic transmission .
Page 138: Ignition Switch With Steering Lock
’04 Solara_U (L/O 0402) Ignition switch with steering lock “START”—Starter motor on. The key When starting the engine, the key may will return to the “ON” position when seem stuck at the “LOCK” position. To released. free it, first be sure the key is pushed all the way in, and then rock the steering For starting tips, see page 247 in Section wheel slightly while turning the key gently.
Page 139: Automatic Transmission
’04 Solara_U (L/O 0402) Automatic transmission DStandard type (2AZ- FE engine) Your automatic transmission has a shift lock system to minimize the possibility of incorrect operation. This means you can only shift out of “P” position when the Selector lever brake pedal is depressed (with the ignition switch in the “ON”...
Page 140 ’04 Solara_U (L/O 0402) (b) Normal driving (c) Using engine braking CAUTION 1. Start the engine as instructed in “How To use engine braking, you can downshift to start the engine” on page 248 in the transmission as follows: Be careful when downshifting on a Section 3.
Page 141 ’04 Solara_U (L/O 0402) (f) Parking NOTICE CAUTION 1. Bring the vehicle to a complete stop. z Be careful not to over- rev the en- 2. Pull the parking brake lever up fully to Always keep your foot on the brake gine.
Page 142 ’04 Solara_U (L/O 0402) DMulti- mode type (3MZ- FE engine) Your automatic transmission has a shift lock system to minimize the possibility of incorrect operation. This means you can only shift out of “P” position when the Selector lever brake pedal is depressed (with the ignition switch in the “ON”...
Page 143 ’04 Solara_U (L/O 0402) (b) Normal driving (c) Driving in “S” mode 1. Start the engine as instructed in “How You can change the shift range position to start the engine” on page 248 in in the “S” mode. The shift range posi- Section 3.
Page 144 (fifth) gears according to the vehicle Toyota dealer as soon as possible. In this speed or driving conditions. If you attempt to downshift the transmis- case, you can drive in the same condition sion when it is not possible to downshift “4”...
Page 145 ’04 Solara_U (L/O 0402) Move the selector lever down to the (e) Backing up (g) Good driving practice “- ” side to select the “3” range. The 1. Bring the vehicle to a complete stop. If the transmission repeatedly shifts up transmission will downshift...
Page 146: Manual Transmission
’04 Solara_U (L/O 0402) Manual transmission For the best compromise between fuel NOTICE economy and vehicle performance, you should upshift or downshift at the following Do not downshift if you are going speeds: faster than the maximum allowable speed for the next lower gear. gear km/h (mph) 1 to 2 or 2 to 1...
Page 147: Traction Control System
“ON”. If the indicator light does not maintained, even though the traction come on when the ignition is turned on, control system is in operation. Do not contact your Toyota dealer. NORMAL DRIVING MODE drive the vehicle under any speed or maneuvering conditions which may...
Page 148 “ON”. It will come on again when you push the “TRAC OFF” switch to turn off the system. In the following cases, contact your Toyota dealer: The indicator light does not come on when the ignition key is turned “ON”.
Page 149: Vehicle Stability Control System
’04 Solara_U (L/O 0402) Vehicle stability control system In the following cases, contact your Toyota vehicle stability control system CAUTION dealer: helps provide integrated control of the systems such as anti- lock brake sys- The warning light does not come on...
Page 150 ’04 Solara_U (L/O 0402) In the following cases, contact your Toyota dealer: The warning light does not come on after the ignition key is turned to “ON”. The warning light remains on after the ignition key is turned to “ON”.
Page 151: Tire Pressure Warning System
The low tire pressure warning system may specified size are used, or if tires of dif- If the low tire pressure warning light be malfunctioning. Contact your Toyota ferent sizes or constructions are mixed, comes on or blinks while driving, do dealer.
Page 152 ’04 Solara_U (L/O 0402) The tire pressure warning system does The pressure of two or more tires Note: The tire pressure monitoring not function properly under certain cir- drops at the same time. system on your vehicle will warn you cumstances.
Page 153 ’04 Solara_U (L/O 0402) To initialize the system, perform the fol- lowing: 1. Park the vehicle at a safe place and apply the parking brake. Stop the en- gine. 2. Adjust the pressure of all the installed tires to the specified level. (See “Tires” on page 330 in Section 8.) 3.
Page 154: Parking Brake
To set: Pull up the lever. For better hold- ing system checked at your Toyota dealer. ing power, first depress the brake pedal When the warning light blinks every 0.25...
Page 155: Cruise Control
’04 Solara_U (L/O 0402) Cruise control The cruise control allows you to cruise the vehicle at a desired speed over 40 km/h (25 mph) even with your foot off the accelerator pedal. Your cruising speed can be maintained up or down grades within the limits of engine performance, although slight...
Page 156 Toyota deal- with the cruise control on, engine braking the set speed. When you release it, the er at the earliest opportunity.
Page 157 The indicator light does not come on. The indicator light flashes again. The indicator light goes out after it comes on. If this is the case, contact your Toyota dealer and have your vehicle inspected. 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 158 ’04 Solara_U (L/O 0402) 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 159 ’04 Solara_U (L/O 0402) SECTION OPERATION OF INSTRUMENTS AND CONTROLS Car audio system Reference ..........Using your audio system .
Page 160: Reference
Using your audio system— Reference —Some basics This section describes some of the basic features on Toyota audio systems. Some information may not pertain to your sys- tem. Your audio system works when the ignition key is in the “ACC” or “ON” position.
Page 161 How to subscribe: Satellite tuner technology notice: You must enter into a separate service Toyota’s satellite radio tuners are awarded Push “AM”, “FM1”, “FM2”, “FM”, “SAT” , agreement with the XM radio in order to Type Approval Certificates from XM Satel- “TAPE”...
Page 162 ’04 Solara_U (L/O 0402) TONE AND BALANCE YOUR RADIO ANTENNA YOUR COMPACT DISC PLAYER (type 1) For details about your system’s tone and Coupe—Your vehicle antenna When you insert a disc, gently push it in balance controls, see the description of printed on the inside of the rear window.
Page 163 ’04 Solara_U (L/O 0402) YOUR COMPACT DISC PLAYER WITH CHANGER (type 2) When you insert a disc, push the “LOAD” button and gently push the disc in with the label side up. (The player will auto- matically eject a disc if the label side is down.) The compact disc player will play from track 1 through the end of the disc.
Page 164 ’04 Solara_U (L/O 0402) —Controls and features DType 1 Details of specific buttons, controls and features are described in the alphabetical list that follows. 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 165 DISC (Compact disc) If the malfunction still exists, take your (Reverse/Fast- forward button) vehicle to your Toyota dealer. Push the “DISC” button to play a compact Push and hold “ ” (preset button 6) or disc.
Page 166 ’04 Solara_U (L/O 0402) " DISC RAND (Random) RPT (Repeat) With compact disc changer only— There are two random features—you can There are two repeat features—You can either listen to the tracks on one compact either replay a disc track or a whole com- Use these buttons to select a disc you disc in random order, or listen to the pact disc.
Page 167 ’04 Solara_U (L/O 0402) SCAN Compact disc player SEEK/TRACK (Seeking/Track up/down) Radio There are two scan features—you can ei- Radio ther scan the tracks on a specific disc or You can either scan all the frequencies on In the seek mode, the radio finds and scan the first tracks of all the discs in the a band or scan only the preset stations plays the next station up or down the...
Page 168 ’04 Solara_U (L/O 0402) TEXT This button is used to change the display for the compact disc that contains text data. To change the display, quickly push and release the “TEXT” button while the com- pact disc is playing. The display changes in the order from the elapsed time to disc title track...
Page 169 ’04 Solara_U (L/O 0402) DType 2 Details of specific buttons, controls and features are described in the alphabetical list that follows. 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 170 : Use of satellite radio requires XM tuner the other side of a cassette tape. The and service. Contact your Toyota deal- To recall a preset station: Push the button display indicates which side is currently er for details.
Page 171 ” (preset button 5) to fast forward or disc. If the malfunction still exists, take your reverse within a compact disc. When you vehicle to your Toyota dealer. When the audio system is set into com- release the button, the compact disc play- " DISC pact disc operation, the display shows the er will resume playing.
Page 172 ’04 Solara_U (L/O 0402) If no compact disc is inserted, the shutter RAND (Random) Dolbyr B NR will close after 15 seconds. There are two random features—you can If you are listening to a tape that was To load multiple compact discs, push and either listen to the tracks on one compact recorded with Dolbyr B Noise Reduction, hold the button (until you hear a beep...
Page 173 The XM antenna is not connected. button again. Check whether the XM antenna cable is attached securely. A short- circuit occurs in the antenna or the surrounding antenna cable. See a Toyota certified dealer. 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 174 : Use of satellite radio requires XM tuner and then scan again to the next station. same channel category up the band, stay and service. Contact your Toyota deal- To stop scanning, push this button again. there for 5 seconds, and then scan again.
Page 175 Push the “SCAN” button until you hear a : Use of satellite radio requires XM tuner recordings. and service. Contact your Toyota deal- beep. “ ·SCAN” will appear on the dis- Compact disc player er for details.
Page 176 Push the “TAPE” button to play a cassette the display returns to the previous mode. : Use of satellite radio requires XM tuner tape. and service. Contact your Toyota deal- The message display will be canceled if er for details. TEXT you activate any function that affects the display.
Page 177 Turn the “TUNE” knob clockwise to step up the channel. Turn the knob counter- clockwise to step down the channel. : Use of satellite radio requires XM tuner and service. Contact your Toyota deal- er for details. 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 178: Audio Remote Controls
Push and hold the “ ” or “"” side of the : Use of satellite radio requires XM tuner switch until you hear a beep. Do this and service. Contact your Toyota deal- again to find the next station. If you push er for details.
Page 179 ’04 Solara_U (L/O 0402) Cassette player When the tape reaches to the begin- Compact disc player ning, the player will automatically start This switch has the following features— Use this switch to skip up or down to a playing that side. different track in either direction.
Page 180: Car Audio System Operating Hints
’04 Solara_U (L/O 0402) Car audio system operating hints Here are some common reception prob- NOTICE lems that probably do not indicate a prob- Fading—AM broadcasts are reflected by lem with your radio: To ensure correct audio system op- the upper atmosphere—especially at night. erations: These reflected signals can interfere with z Be careful not to spill beverages...
Page 181 : Use of satellite radio requires XM tuner Do not use a cassette if it has been and service. Contact your Toyota deal- damaged or tangled or if its label is er for details. peeling off.
Page 182 ’04 Solara_U (L/O 0402) Avoid using cassettes with a total play- CARING FOR YOUR COMPACT DISC ing time longer than 100 minutes (50 PLAYER AND DISCS minutes per side). The tape used in Type 2 only—Your compact disc player these cassettes is thin and could get is intended for use with 12 cm (4.7 in.) stuck or tangled in the cassette player.
Page 183 ’04 Solara_U (L/O 0402) Correct Wrong Special shaped discs Labeled discs Handle compact discs carefully, espe- cially when you are inserting them. Hold them on the edge and do not NOTICE bend them. Avoid getting fingerprints on them, particularly on the shiny side. To prevent damage to the player or changer, do not use special shaped, Dirt, scrapes, warping, pin holes, or...
Page 184 ’04 Solara_U (L/O 0402) To clean a compact disc: Wipe it with a soft, lint- free cloth that has been damp- ened with water. Wipe in a straight line from the center to the edge of the disc (not in circles). Dry it with another soft, lint- free cloth.
Page 185 ’04 Solara_U (L/O 0402) SECTION OPERATION OF INSTRUMENTS AND CONTROLS Air conditioning system Manual air conditioning system Controls ..........Air flow selector settings .
Page 186: Manual Air Conditioning System Controls
’04 Solara_U (L/O 0402) Manual air conditioning system— —Controls 1. Fan speed selector 2. Air flow selector 3. Temperature selector 4. “A/C” button 5. Air intake selector 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 187 ’04 Solara_U (L/O 0402) Fan speed selector If you want to return the setting to RECIRCULATE mode, press the air in- Turn the knob to adjust the fan speed—to take selector button once again. the right to increase, to the left to de- crease.
Page 188 If this happens, take your ve- hicle to a Toyota dealer for service. Air intake selector Press the button to select the air source. 1. RECIRCULATE (indicator light is on)—...
Page 189: Air Flow Selector Settings
’04 Solara_U (L/O 0402) —Air flow selector settings —Operating tips To cool off your Toyota after it has been parked in the hot sun, drive with the windows open for a few minutes. This vents the hot air, allowing the air conditioning to cool the interior more quickly.
Page 190 ’04 Solara_U (L/O 0402) If following another vehicle on a dusty Heating Air conditioning road, or driving in windy and dusty For best results, set controls as follows: For best results, set controls as follows: conditions, it is recommended that the air intake selector be temporarily set to Fan speed—Any setting except “OFF”...
Page 191 ’04 Solara_U (L/O 0402) Defogging Defrosting The inside of the windshield The outside of the windshield For best results, set controls as follows: For best results, set controls as follows: Fan speed—Any setting except “OFF” Fan speed—Any setting except “OFF” Temperature—Towards WARM Temperature—Towards WARM (red zone) to heat;...
Page 192: Automatic Air Conditioning System Controls
’04 Solara_U (L/O 0402) Automatic air conditioning system— —Controls 1. Temperature selector 2. “AUTO” button 3. “OFF” button 4. Air intake selector 5. Windshield air flow button 6. “MODE” button (air flow selector) 7. “A/C” button 8. Fan speed selector 2004 SOLARA from Feb.
Page 193 ’04 Solara_U (L/O 0402) “AUTO” button Temperature selector For automatic operation of the air condi- To increase the temperature, press the tioning, press the “AUTO” button. “AUTO” “ ” side, to decrease it, press the “"” side. will appear on the display to show that the automatic operation mode has been “MAX.
Page 194 ’04 Solara_U (L/O 0402) For details about air flow selector settings, “—Air flow selector settings” scribed below. Windshield air flow button Air intake selector When this button is pressed, air flows Press the button to select the air source. mainly from the windshield vents and 1.
Page 195 If the “A/C” button indicator flashes, there is a problem in the air conditioning system conditioning automatically shuts off. If this happens, take your ve- hicle to a Toyota dealer for service. 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 196: Air Flow Selector Settings
’04 Solara_U (L/O 0402) —Air flow selector settings —Operating tips To cool off your Toyota after it has been parked in the hot sun, drive with the windows open for a few minutes. This vents the hot air, allowing the air conditioning to cool the interior more quickly.
Page 197 ’04 Solara_U (L/O 0402) If following another vehicle on a dusty Heating Air conditioning road, or driving in windy and dusty For best results, set controls as follows: For best results, set controls as follows: conditions, it is recommended that the For automatic operation—...
Page 198 ’04 Solara_U (L/O 0402) Ventilation Defogging and defrosting Press the “A/C” button for dehumidified heating or cooling. This setting clears the For best results, set controls as follows: —The inside of the windshield front view more quickly. For automatic operation— For best results, set controls as follows: On humid days, do not blow cold air —For automatic operation...
Page 199: Side Vents
’04 Solara_U (L/O 0402) Checking and replacing the Side vents air conditioning filter you want return the setting to RECIRCULATE mode, press the air intake selector button once again. Press the “A/C” button for dehumidified heating or cooling. This setting clears the front view more quickly.
Page 200 ’04 Solara_U (L/O 0402) To maintain the air conditioning efficiency, inspect and replace the air conditioning filter according to the maintenance sched- ule. In dusty areas or areas with heavy traffic flow, such as inner city or desert areas, early replacement may be required. (For scheduled maintenance information, please refer to the “Scheduled Mainte- nance Guide”...
Page 201 ’04 Solara_U (L/O 0402) 2. Push in each side of the glove box 3. Remove the filter case from the filter 4. Remove filter from the filter to disconnect the claws. outlet as shown in the illustration. case. 5. Inspect the filter on the surface. If it is dirty, it should be replaced.
Page 202 ’04 Solara_U (L/O 0402) 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 203 ’04 Solara_U (L/O 0402) SECTION OPERATION OF INSTRUMENTS AND CONTROLS Other equipment Multi- information displays ........Compass .
Page 204: Multi- Information Displays
’04 Solara_U (L/O 0402) Multi- information displays— The following information is displayed SELECTING UNIT on the multi- information displays. To select the unit A (English/U.S. cus- 1. Cruise information tomary system) or unit B (metric unit), push and hold the “H” and “M” buttons 2.
Page 205 ’04 Solara_U (L/O 0402) —Cruise information left side display indicates The displayed value is updated every 2 cruise information when the ignition seconds. switch is in the “ON” position. Note that an accurate figure may not be Each time you push the “DISP.” button shown in the following cases.
Page 206 ’04 Solara_U (L/O 0402) —Clock 3. Driving range 4. Average vehicle speed (“RANGE MI” or “RANGE KM”) (“AVG. MPH” or “AVG. KM/h”) The distance the vehicle can travel with Average vehicle speed is calculated and the remaining fuel is calculated and displayed based on total driving dis- displayed based on the quantity of re- tance and total driving time with the...
Page 207: Compass
The ignition switch is turned off imme- “- - ” appears on the display, contact your diately after turning. Toyota dealer. The vehicle is on an inclined surface. There may be a case that “- - ” appears momentarily when the ignition is quickly turned to “ON”.
Page 208 ’04 Solara_U (L/O 0402) The vehicle is in a place where the earth’s magnetic field is subject to in- terference by artificial magnetic fields (underground parking, under a steel tower, between buildings, roof parking, near a crossing, near a large vehicle, etc.).
Page 209 ’04 Solara_U (L/O 0402) After calibration, leaving the system for Hawaii: Samoa: 5 Guam: several seconds returns it to compass Saipan: Puerto Rico: mode. CAUTION Do not adjust the display while the vehicle is moving. Be sure to adjust the display only when the vehicle is stopped.
Page 210 ’04 Solara_U (L/O 0402) Perform circling calibration just after you have purchased your Toyota. And then always perform circling calibration after the battery has been removed, re- placed or disconnected. Do not perform circling calibration of the compass in a place where the earth’s magnetic field is subject to in-...
Page 211: Portable Ashtray
’04 Solara_U (L/O 0402) Portable ashtray CAUTION CAUTION When doing the circling calibration, To reduce the chance of injury in be sure to secure a wide space, case of an accident or sudden stop and watch out for people and ve- while driving, always completely close hicles in the neighborhood.
Page 212: Power Outlets
’04 Solara_U (L/O 0402) Power outlets Garage door opener The power outlets are designed for power supply for car accessories. The key must be in the “ACC” or “ON” position for the power outlet to be used. NOTICE z To prevent the fuse from being blown, do not use the electricity over the total vehicle capacity of...
Page 213 ’04 Solara_U (L/O 0402) Keep the indicator light on the HomeLink Programming a rolling code system The garage door opener ( in view while programming. Universal Transceiver) is manufactured your device “Rolling Code” under license from HomeLink and can equipped, is necessary follow 3.
Page 214 To program other devices such as home 1. Decide which of the 3 HomeLink but- security systems, home door locks or tons you want to program. lighting, contact your authorized Toyota dealer for assistance. 2. Place your hand- held gate/device transmitter 25 to 75 mm (1 to 3 in.)
Page 215: Glove Box
’04 Solara_U (L/O 0402) Glove box CAUTION This device complies with Part 15 of the FCC rules and with RSS- 210 of Indus- When programming the HomeLink try Canada. Universal Transceiver, you may be Operation is subject to the following two operating a garage door or other conditions.
Page 216: Auxiliary Boxes
’04 Solara_U (L/O 0402) Auxiliary boxes Rear console box To use the auxiliary box, open it as shown in the illustration. CAUTION To reduce the chance of injury in case of an accident or a sudden stop, always keep the auxiliary box closed while driving.
Page 217: Cup Holders
’04 Solara_U (L/O 0402) Cup holders UPPER TRAY To access the upper tray, raise the con- sole box lid while pushing the lock re- lease button. Front CONSOLE BOX To access the rear console box, pull up the lock release lever while raising the rear console box lid.
Page 218: Storage Box
’04 Solara_U (L/O 0402) Storage box Grocery bag hooks The cup holder is designed for holding cups or drink- cans securely. Front cup holder— To use the front cup holder, open the lid. To hold the cups or drink- cans securely, adjust the size with the adapter.
Page 219: Cargo Net
’04 Solara_U (L/O 0402) Cargo net Floor mat To secure belongings, hang the cargo Use a floor mat of the correct size. CAUTION net on the hooks. If the floor carpet and floor mat have 2 holes, then they are designed for use with Make sure the floor mat is properly NOTICE locking clips.
Page 220 ’04 Solara_U (L/O 0402) 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 221 INFORMATION BEFORE DRIVING YOUR TOYOTA Information before driving your Toyota Break- in period ..........
Page 222: Break- In Period
To help prevent gas station mix- ups, your 3MZ- FE engine: Select Octane Rating to the future economy and long life of Toyota has a smaller fuel tank opening. 87 (Research Octane Number 91) or your vehicle: The special nozzle on pumps with un- higher.
Page 223 If you els. In the U.S., category 4 has been Toyota, be sure that it has an octane continue to have unacceptable driveability, adopted. The WWFC improves air quali- rating no lower than 87.
Page 224: Fuel Pump Shut Off System
’04 Solara_U (L/O 0402) Fuel pump shut off system Operation in foreign countries The fuel pump shut off system stops sup- If you plan to drive your Toyota in NOTICE plying fuel to the engine to minimize the another country...
Page 225: Three- Way Catalytic Converters
’04 Solara_U (L/O 0402) Three- way catalytic converters The three- way catalytic converter is an NOTICE emission control device installed in the exhaust system. A large amount of unburned gases flowing into the three- way catalytic The purpose is to reduce pollutants in the converter may cause it to overheat exhaust gas.
Page 226: Engine Exhaust Cautions
If you smell exhaust fumes in the as possible. Remember, your Toyota time to time. If you hit something, vehicle, drive with windows dealer knows your vehicle and its or notice a change in the sound of open and the trunk lid closed.
Page 227: Facts About Engine Oil Consumption
It is normal that an engine should con- regularly. Toyota recommends that the oil A new engine consumes more oil, since sume some engine oil during normal level be checked every time you refuel its pistons, piston rings and cylinder walls engine operation.
Page 228: Iridium- Tipped Spark Plugs
’04 Solara_U (L/O 0402) Iridium- tipped spark plugs Brake system The tandem master cylinder brake system CAUTION is a hydraulic system with two separate sub- systems. If either sub- system should Do not pump the brake pedal if the fail, the other will still work. However, the engine stalls.
Page 229 ’04 Solara_U (L/O 0402) ANTI- LOCK BRAKE SYSTEM Depressing the brake pedal on slippery CAUTION road surfaces such as on a manhole cov- The anti- lock brake system is designed er, a steel plate at a construction site, to help prevent lock- up of the wheels overestimate anti- lock joints in a bridge, etc.
Page 230 Contact your tive wheels’ turning speeds. The use of tires other than specified may fail Toyota dealer as soon as possible to to detect the accurate turning speed service the vehicle. resulting in a longer stopping dis- The light does not come on when the tance.
Page 231 Contact your vehicle stability control system) parking brake system. This type of brake Toyota dealer as soon as possible to system needs bedding- down of the brake The light comes on when the ignition key service the vehicle.
Page 232: Brake Pad Wear Limit Indicators
This is the primary identification number checked and replaced by your Toyota for your Toyota. It is used in registering dealer as soon as possible. Expensive ro- the ownership of your vehicle. tor damage can result if the pads are not replaced when necessary.
Page 233 ’04 Solara_U (L/O 0402) —Engine number The engine number is stamped on the engine block as shown. 2AZ- FE engine The vehicle identification number (VIN) is also on the Certification Label. 3MZ- FE engine 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 234: Theft Prevention Labels
’04 Solara_U (L/O 0402) Theft prevention labels Suspension and chassis Your new vehicle carries theft preven- CAUTION tion labels which are approximately 56 mm (2.20 in.) by 16 mm (0.63 in.). Do not modify the suspension/chassis The purpose of these labels is to reduce with lift kits, spacers, springs, etc.
Page 235: Tire Information
’04 Solara_U (L/O 0402) Tire information— —Tire symbols This illustration indicates typical tire symbols. 1. Tire size—For details, see “—Tire size” on page 237. 2. DOT and Tire Identification Number (TIN)—For details, see “—DOT and Tire Identification Number (TIN)” on page 236. 3.
Page 236 ’04 Solara_U (L/O 0402) —DOT and Tire Identification Number (TIN) 7. “TUBELESS” “TUBE The “DOT” symbol certifies that the TYPE”—A tubeless tire does not tire conforms to applicable Federal have a tube inside the tire and air Motor Vehicle Safety Standards. is directly filled in the tire.
Page 237 ’04 Solara_U (L/O 0402) —Tire size —Name of each section of tire This illustration indicates typical tire 1. Section width 1. Bead size. 2. Tire height 2. Sidewall 1. Tire (P=Passenger car, 3. Wheel diameter 3. Shoulder T=Temporary use) 4. Tread 2.
Page 238 150 would wear conditions on specified government purchasers of Toyota vehicles with in- one and a half (1- 1/2) times as well test surfaces of asphalt and concrete. formation on uniform tire quality grad-...
Page 239 ’04 Solara_U (L/O 0402) Temperature A, B, C—The tempera- ture grades are A (the highest), B, and C, representing the tire’s resis- tance to the generation of heat and its ability to dissipate heat when tested under controlled conditions on a specified indoor laboratory test wheel.
Page 240 ’04 Solara_U (L/O 0402) —Glossary of tire terminology Tire related term Meaning the combined weight (in excess of those standard items which may be replaced) of automatic transmission, power steering, power brakes, power Accessory weight windows, power seats, radio, and heater, to the extent that these items are available as factory- installed equipment (whether installed or not) tire inflation pressure when the vehicle has been parked for at least 3 Cold tire inflation pressure...
Page 241 ’04 Solara_U (L/O 0402) Tire related term Meaning 68 kg (150 lb.) times the number of occupants specified in the second Normal occupant weight column of Table 1 that follows distribution of occupants in a vehicle as specified in the third column of Table Occupant distribution 1 that follows the combined weight of those installed regular production options weighing...
Page 242 ’04 Solara_U (L/O 0402) Tire related term Meaning the load on an individual tire that is determined by distributing to each axle Vehicle normal load on the tire its share of the curb weight, accessory weight, and normal occupant weight (distributed in accordance with Table 1 that follows) and dividing by two Weather side the surface area of the rim not covered by the inflated tire...
Page 243: Vehicle Load Limits
Locating the weight as far Towing capacity forward as possible helps maintain Convertible balance. Toyota does not recommend towing 342 kg (754 lb.) a trailer with your vehicle. Your ve- D For better fuel economy, do not Total load capacity means com- hicle is not designed for trailer towing.
Page 244 Or they your vehicle. may move during sharp vehicle Toyota does not recommend towing acceleration or turning, and im- a trailer with your vehicle. Your ve- pair the driver’s control of the hicle is not designed for trailer towing.
Page 245 ’04 Solara_U (L/O 0402) Convertible—In case that 2 people As shown in the above example, if the with the combined weight of 166 kg number of occupants increases, the (366 lb.) are riding in your vehicle with cargo and luggage load equaling the the total load capacity of 342 kg (754 combined weight of occupants who lb.), the available amount of cargo...
Page 246: Types Of Tires
’04 Solara_U (L/O 0402) Types of tires Determine what kind of tires your All season tires, however, do not have vehicle is originally equipped with. adequate traction performance compared with snow tires in heavy or 1. Summer tires loose snow. Also, all season tires fall Summer tires are high- speed capabil- short in acceleration and handling ity tires best suited to highway driving...
Page 247 ’04 Solara_U (L/O 0402) SECTION STARTING AND DRIVING Starting and driving Before starting the engine ........How to start the engine .
Page 248: Before Starting The Engine
’04 Solara_U (L/O 0402) How to start the engine— Before starting the engine (a) Before cranking (b) Starting the engine 1. Check the area around the vehicle be- 1. Apply the parking brake firmly. Before starting the engine, be sure to fol- fore entering it.
Page 249: Tips For Driving In Various Conditions
Other- work safely, pull to the side of the road wise, the impact could cause severe and call a Toyota dealer for assistance. damage to the tires and/or wheels. When parking on a hill, turn the front...
Page 250: Winter Driving Tips
Keep the door locks from freezing. high- speed capability tires. “Toyota Super Long Life Coolant” is a mix- Squirt lock de- icer or glycerine into the Driving over 140 km/h (85 mph) may ture of 50% coolant and 50% deionized locks to keep them from freezing.
Page 251: Dinghy Towing
’04 Solara_U (L/O 0402) Dinghy towing Dinghy towing (with automatic transmission) (with manual transmission) Do not use your parking brake when there is a possibility it could freeze. When parking, put the transmission into “P” (automatic) or into first or reverse (manual) and block the rear wheels.
Page 252: Trailer Towing
NOTICE To avoid the locking of the steering wheel, turn the ignition switch to the Toyota does not recommend towing a “ACC” position. NOTICE trailer with your vehicle. Your vehicle is not designed for trailer towing.
Page 253: How To Save Fuel And Make Your Vehicle Last Longer
’04 Solara_U (L/O 0402) How to save fuel and make your vehicle last longer Improving fuel economy is easy—just take Avoid long engine idling. If you have Keep front wheels in proper it easy. It will help make your vehicle last a long wait and you are not in traffic, alignment.
Page 254 ’04 Solara_U (L/O 0402) CAUTION Never turn off the engine to coast down hills. Your power steering and brake booster will not function with- out the engine running. Also, the emission control system operates properly only when the engine is run- ning.
Page 255 ’04 Solara_U (L/O 0402) SECTION IN CASE OF AN EMERGENCY In case of an emergency If your vehicle will not start ........If your engine stalls while driving .
Page 256: If Your Vehicle Will Not Start
Have converter may overheat and become a these positions for 15 seconds and re- the key checked at your Toyota dealer. If fire hazard. lease them. Then try starting the engine none of your keys work, there may be a with your foot off the accelerator pedal.
Page 257 ’04 Solara_U (L/O 0402) (c) Jump starting To avoid serious personal injury and JUMP STARTING PROCEDURE The gas normally produced by a damage to your vehicle which might re- 1. If the booster battery is installed in battery will explode if a flame or sult from battery explosion, acid burns, another vehicle, make sure the vehicles spark is brought near.
Page 258 ’04 Solara_U (L/O 0402) Jumper cable Discharged battery Booster battery Positive terminal Discharged battery Booster (“+” mark) battery Positive terminal Negative terminal Jumper cable (“+” mark) (“- ” mark) Connecting point for 2AZ- FE engine 4. Make the cable connections in the or- c.
Page 259: If Your Engine Stalls While Driving
Have your vehicle again. the battery or accidentally let the checked by your Toyota dealer as soon as jumper cables or clamps touch any- If the engine will not start, see “If your possible.
Page 260: If Your Vehicle Overheats
You should have it checked as soon as possible at your Toyota dealer. CAUTION 1. Pull safely off the road, stop the ve- hicle and...
Page 261: If You Have A Flat Tire
’04 Solara_U (L/O 0402) If you have a flat tire— 1. Reduce your speed gradually, D Make sure to set the jack prop- CAUTION keeping a straight line. Move cau- erly in the jack point. Raising tiously off the road to a safe place When jacking, be sure to observe the vehicle with jack improper- well away from the traffic.
Page 262 ’04 Solara_U (L/O 0402) The compact spare tire can be used NOTICE many times, if necessary. It has tread life of up to 4800 km (3000 miles) de- Do not continue driving with a pending on road conditions and your deflated tire.
Page 263 ’04 Solara_U (L/O 0402) —Required tools and spare tire D The standard tire should be re- paired and reinstalled as soon as possible. D Avoid sudden acceleration, sudden deceleration and sharp turns with the compact spare tire. NOTICE Your ground clearance is re- duced when the compact spare 1.
Page 264 ’04 Solara_U (L/O 0402) —Blocking the wheel To store the jack, align the hole of the To remove the spare tire: 2. Block the wheel diagonally op- jack head with the vehicle hook. Turn posite the flat tire to keep the 1.
Page 265 ’04 Solara_U (L/O 0402) —Removing wheel ornament (steel wheels) —Loosening wheel nuts CAUTION Never use oil or grease on the bolts or nuts. The nuts may loose and the wheels may fall off, which could cause a serious ac- cident. 3.
Page 266 ’04 Solara_U (L/O 0402) —Positioning the jack —Raising your vehicle CAUTION Never get under the vehicle when the vehicle is supported by the jack alone. 5. Position the jack at the correct 6. After making sure that no one jack point as shown. Rotate the is in the vehicle, raise it high load rest 90R from storage posi- enough so that the spare tire...
Page 267 ’04 Solara_U (L/O 0402) —Changing wheels —Reinstalling wheel nuts 7. Remove the wheel nuts and Before putting on wheels, remove any 8. Reinstall all the wheel nuts fin- change tires. corrosion on the mounting surfaces ger tight. with a wire brush or such. Installation Lift the flat tire straight off and put it Reinstall the wheel nuts (tapered end of wheels without good metal- to- met-...
Page 268 ’04 Solara_U (L/O 0402) —Lowering your vehicle CAUTION CAUTION D When lowering the vehicle, Never use oil or grease on the bolts or nuts. Doing so may lead make sure all portions of your to overtightening the nuts and body and all other persons damaging the bolts.
Page 269 ’04 Solara_U (L/O 0402) —Reinstalling wheel ornament (steel wheels) —After changing wheels 11. Check the air pressure of the re- CAUTION placed tire. Adjust the air pressure to the specifi- Take due care in handling the or- cation designed on page 330 in Sec- nament to avoid unexpected per- tion 8.
Page 270: If Your Vehicle Becomes Stuck
’04 Solara_U (L/O 0402) If your vehicle becomes stuck If your vehicle becomes stuck in snow, NOTICE CAUTION mud, sand, etc., then you may attempt to rock the vehicle free by moving it If you rock your vehicle, observe the Before driving, make sure all the forward and backward.
Page 271: If Your Vehicle Needs To Be Towed
If towing is necessary, we recommend TOWING PRECAUTIONS: (a) Towing with wheel lift type truck— you to have it done by your Toyota Use a safety chain system for all towing, dealer or a commercial tow truck ser- and abide by the state/provincial and local —From front...
Page 272 NOTICE If towing is necessary, we recommend transmission from the rear with the you to have it done by your Toyota front wheels on the ground, as this Do not tow with sling type truck, ei- dealer or a commercial tow truck ser- may cause serious damage to the ther from the front or rear.
Page 273: If You Cannot Shift Automatic Transmission Selector Lever
’04 Solara_U (L/O 0402) If you cannot shift automatic transmission selector lever NOTICE NOTICE z Only use specified towing eyelet; Use only a cable or chain specifically otherwise your vehicle may be dam- intended for use in towing vehicles. aged. Securely fasten the cable or chain to the towing eyelets provided.
Page 274: If The Convertible Top Does Not Rise Or Lower
“ACC” or “LOCK” position. Open ei- Be sure to have the system checked by ther door or wait for 43 seconds be- your Toyota dealer as soon as possible. fore raising convertible manually. 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 275: If You Lose Your Keys
Even if you lose only one key, contact hicle by your Toyota dealer as soon as your Toyota dealer to make a new key. If possible to avoid the possibility of theft or you lose all your master keys, you cannot an accident.
Page 276 ’04 Solara_U (L/O 0402) 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 277: Corrosion Prevention And Appearance Care
APPEARANCE CARE Corrosion prevention and appearance care Protecting your Toyota from corrosion ......Washing and waxing your Toyota .
Page 278 Now, it is up to be dry. to see all the mud and dirt. It will do you. Proper care of your Toyota can help more harm than good to simply wet the High ambient temperatures can cause ensure long- term corrosion prevention.
Page 279 Washing and waxing your Toyota Check the interior of your vehicle. Wa- Washing your Toyota Hand- washing your Toyota ter and dirt can accumulate under the Keep your vehicle clean by regular Work in the shade and wait until the floor mats and could cause corrosion.
Page 280 ’04 Solara_U (L/O 0402) 2. Wash with mild car- wash soap, Aluminum wheels: Use only a mild soap mixed according to the manufacturer’s or neutral detergent. instructions. Use a soft cotton mitt and Plastic bumpers: Wash carefully. Do not keep it wet by dipping it frequently into scrub with abrasive cleaners.
Page 281 (hand soap) in lukewarm when waxing. nozzle becomes water (below 38RC or 100RF). blocked, contact your Toyota dealer to 3. Rinse thoroughly to remove soap. have the vehicle serviced. NOTICE NOTICE z Do not use harsh or abrasive clean-...
Page 282 ’04 Solara_U (L/O 0402) Cleaning the interior Additional cleaning (for more difficult After cleaning, always make sure the top CAUTION is completely dry before you lower it. Low- stains)— ering the top while wet or damp may Follow the procedure shown below using Vehicles with side airbags and cur- cause interior water damage, water stains a mild cleaning solution composed of the...
Page 283 ’04 Solara_U (L/O 0402) First vacuum over the upholstery to re- Do not apply water—the best results are Air conditioning control panel, car au- move loose dirt. Then, using a sponge or obtained by keeping the carpet as dry as dio, instrument panel, console panel soft cloth, apply the soap solution to the possible.
Page 284 Toyota, your local cause discoloring. Toyota dealer will be pleased to answer them. z Use of a nylon brush or synthetic fiber cloth, etc. may scratch the fine grained surface of the leather. 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 285 ’04 Solara_U (L/O 0402) SECTION VEHICLE MAINTENANCE AND CARE Vehicle maintenance and care Maintenance requirements ........General maintenance .
Page 286: Maintenance Requirements
Simple instructions for how to per- or if you prefer, your Toyota dealer will be dating this warranty. See “Owner’s War- form them are presented on page 291 in pleased to do them at a nominal cost.
Page 287: General Maintenance
Booklet” or “Owner’s Manual Supple- should investigate the cause or take your information. ment” for the details. vehicle to your Toyota dealer or a quali- Radiator, condenser and hoses fied service shop immediately. It is recom- Check that the front of the radiator and...
Page 288 ’04 Solara_U (L/O 0402) Exhaust system Seats Parking brake If you notice any change in the sound of Check that all front seat controls such as Check that the lever has the proper travel the exhaust or smell exhaust fumes, have seat adjusters, seatback recliner, etc.
Page 289: Does Your Vehicle Need Repairing
Be on the alert for changes in perfor- If you notice any of these clues, take your mance, sounds, and visual tip- offs that vehicle to your Toyota dealer as soon as Check the pressure with a gauge ev- indicate service is needed. Some impor- possible.
Page 290: Emissions Inspection And Maintenance (I/M) Programs
Contact your Toyota dealer to even the malfunction indicator lamp does service the vehicle. not come on, contact your Toyota dealer Even if the malfunction indicator lamp to prepare the vehicle for re- testing. does not come on, your vehicle may not pass the I/M test as readiness codes have not been set in the OBD system.
Page 291 ’04 Solara_U (L/O 0402) SECTION DO- IT- YOURSELF MAINTENANCE Introduction Engine compartment overview ....... Fuse locations .
Page 292: Engine Compartment Overview
’04 Solara_U (L/O 0402) Engine compartment overview D2AZ- FE engine 1. Power steering fluid reservoir 2. Engine oil filler cap 3. Engine oil level dipstick 4. Brake fluid reservoir 5. Fuse block 6. Battery 7. Radiator 8. Electric cooling fans 9.
Page 293 ’04 Solara_U (L/O 0402) D3MZ- FE engine 1. Power steering fluid reservoir 2. Engine oil level dipstick 3. Engine oil filler cap 4. Brake fluid reservoir 5. Fuse block 6. Battery 7. Radiator 8. Electric cooling fans 9. Condenser 10. Windshield washer fluid tank 11.
Page 294: Fuse Locations
Read separate Toyota Warranty statement for details and suggestions. This Section gives instructions only for those items that are relatively easy for an owner to perform. As explained in Section 6, there are still a number of items that must be done by a qualified technician with special tools.
Page 295 Add only “Toyota Super Long Life plugs to prevent burning yourself. should be taken to avoid prolonged Coolant” or similar high quality eth- and repeated contact with it.
Page 296: Positioning The Jack
’04 Solara_U (L/O 0402) Positioning the jack When jacking up your vehicle with the z Use only spark plugs of the speci- jack, position jack correctly as fied type. Using other types will shown in the illustrations. cause engine damage, loss of per- formance or radio noise.
Page 297: Parts And Tools
Parts (if level is low): the vehicle is supported by the jack nance. Remember all Toyota parts are de- SAE J1703 or FMVSS No.116 DOT 3 alone; use vehicle support stands. signed in metric sizes, so your tools must brake fluid be metric.
Page 298 ’04 Solara_U (L/O 0402) CHECKING AND REPLACING FUSES Parts (if replacement is necessary): Genuine Toyota fuse or equivalent with same amperage rating as original ADDING WASHER FLUID Parts: Water Washer fluid containing antifreeze (for winter use) Tools: Funnel REPLACING LIGHT BULBS...
Page 299 ’04 Solara_U (L/O 0402) SECTION DO- IT- YOURSELF MAINTENANCE Engine and Chassis Checking the engine oil level ....... . . Checking the engine coolant level .
Page 300: Checking The Engine Oil Level
’04 Solara_U (L/O 0402) Checking the engine oil level With the engine at operating tempera- If the oil level is below or only slightly ture and turned off, check the oil level above the low level line, add engine oil Low level Full level on the dipstick.
Page 301 ’04 Solara_U (L/O 0402) ENGINE OIL SELECTION SAE 5W- 30 is the best choice for good fuel economy and good starting in cold “Toyota Genuine Motor Oil” is used in weather. your Toyota vehicle. Use Toyota approved “Toyota Genuine Motor Oil” or equivalent...
Page 302: Checking The Engine Coolant Level
Approval Committee) Certi- pump. specifically tested and approved for all fication Mark is displayed on the front of If you can find no leak, have your Toyota Toyota engines. the container. dealer test the cap pressure and check Please contact your Toyota dealer for fur- for leaks in the cooling system.
Page 303: Checking The Radiator And Condenser
If any of the above parts are extremely dirty or you are not sure of their condi- Use of improper coolants may damage tion, take your vehicle to a Toyota dealer. your engine cooling system. Only use “Toyota Super Long Life Coolant”...
Page 304: Checking Brake Fluid
’04 Solara_U (L/O 0402) Checking brake fluid Checking power steering fluid If the level is low, add SAE J1703 or FMVSS No.116 DOT 3 brake fluid to the If cold O.K. brake reservoir. If hot O.K. Remove and replace the reservoir cap by hand.
Page 305: Checking Tire Inflation Pressure
’04 Solara_U (L/O 0402) Checking tire inflation pressure Clean all dirt from the outside of the res- Keep your tire inflation pressures ervoir tank and look at the fluid level. If at the proper level. the fluid is cold, the level should be in the The recommended cold tire inflation “COLD”...
Page 306 ’04 Solara_U (L/O 0402) D Do not bleed or reduce tire The following instructions for Tire pressure gauge checking tire inflation pressure inflation pressure after driving. should be observed: It is normal for the tire inflation pressure to be higher after driving. D The pressure should...
Page 307 If a tire frequently needs refilling, have it checked by your Toyota deal- 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 308: Checking And Replacing Tires
’04 Solara_U (L/O 0402) Checking and replacing tires The tires on your Toyota have built- in Any tires which are over 6 years Tread wear indicator tread wear indicators to help you old must be checked by a qualified know when the tires need replace- technician even if damage is not ment.
Page 309 ’04 Solara_U (L/O 0402) REPLACING YOUR TIRES Toyota recommends all four tires, CAUTION or at least both of the front or rear When replacing a tire, use a tire of tires be replaced at a time as a set. the same size and construction,...
Page 310: Rotating Tires
’04 Solara_U (L/O 0402) Rotating tires To equalize the wear and help ex- tend tire life, Toyota recommends that you rotate your tires accord- ing to the maintenance schedule. (For scheduled maintenance infor- mation, please refer to the “Sched- uled Maintenance Guide” or “Own- er’s...
Page 311: Installing Snow Tires And Chains
’04 Solara_U (L/O 0402) Installing snow tires and chains WHEN SNOW TIRES SNOW TIRE INSTALLATION CAUTION CHAINS Snow tires should be installed on all Snow tires or chains are recommended wheels. Do not include a compact spare when driving on snow or ice. Installing snow tires on the front wheels tire when rotating the tires.
Page 312 ’04 Solara_U (L/O 0402) CHAIN INSTALLATION Avoid sharp turns or locked- wheel Side chain Install the chains on the front tires as braking, as use of chains may ad- tightly as possible. Do not use tire versely affect vehicle handling. chains rear tires.
Page 313: Replacing Wheels
When balancing your wheels, use only at your Toyota dealer. characteristics resulting in loss of Toyota balance weights or equivalent A wheel of a different size or type may control. Otherwise, an accident may and a plastic or rubber hammer.
Page 314 ’04 Solara_U (L/O 0402) 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 315 ’04 Solara_U (L/O 0402) SECTION DO- IT- YOURSELF MAINTENANCE Electrical components Checking battery condition ........Battery recharging precautions .
Page 316: Checking Battery Condition
’04 Solara_U (L/O 0402) Checking battery condition— —Precautions —Checking battery exterior Terminals CAUTION If electrolyte gets on your skin, Ground cable thoroughly wash the contact area. If BATTERY PRECAUTIONS you feel pain or burning, get medi- cal attention immediately. The battery produces flammable and explosive hydrogen gas.
Page 317: Battery Recharging Precautions
White “Power windows” on page 23 and “Electric checked by your NOTICE moon roof” on page 33 in Section 1- 2. Toyota dealer. Never recharge the battery while the Clear or Have battery engine is running. Also, be sure all...
Page 318: Checking And Replacing Fuses
’04 Solara_U (L/O 0402) Checking and replacing fuses Good Blown Good Blown Type A Type C the headlights or other electrical components do not work, check the fuses. If any of the fuses are blown, they must be replaced. See “Fuse locations” on page 294 in Sec- tion 7- 1 for locations of the fuses.
Page 319: Adding Washer Fluid
Have your Toyota dealer correct it as light comes on, the washer tank may be soon as possible. empty. Add washer fluid.
Page 320: Replacing Light Bulbs
Parking, front pooled inside light, contact your are hot. side marker and 3457NA 30/8 Toyota dealer. front turn signal Halogen bulbs have pressurized gas lights inside and require special handling. They burst shatter Rear turn signal 3156K scratched or dropped.
Page 321 ’04 Solara_U (L/O 0402) —Headlights Bulb Light bulbs Type High beam (inside) Vanity lights — Low beam (outside) (coupe) Vanity lights — (convertible) Glove box light — Quarter trim courtesy light Trunk light 2825 (coupe) Trunk light 1. Open the hood. Turn the bulb base 2.
Page 322 Stop/tail and rear side marker light tor and install it into the mounting c: Back- up light hole. Aiming is not necessary after replacing the bulb. When aiming adjustment is nec- essary, contact your Toyota dealer. 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 323 ’04 Solara_U (L/O 0402) —High mounted stoplight (coupe) —License plate lights Use a Flat- bladed screwdriver. 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 324 If either the left or right front fog, park- ing, front side marker and front turn signal lights burns out, contact your Toyota dealer. NOTICE Do not try to replace the front fog, parking, front side marker and front turn signal light bulbs by yourself.
Page 325 ’04 Solara_U (L/O 0402) SECTION SPECIFICATIONS Specifications Dimensions and weight ........Engine .
Page 326: Dimensions And Weight
’04 Solara_U (L/O 0402) Dimensions and weight Engine Model: Coupe Convertible 2AZ- FE and 3MZ- FE Overall length mm (in.) 4890 (192.5) 4890 (192.5) Type: 2AZ- FE engine Overall width mm (in.) 1815 (71.5) 1815 (71.5) 4 cylinder in line, 4 cycle, gasoline Overall height mm (in.) 1425...
Page 327: Fuel
Without filter 4.5 (4.8, 4.0) Spark plug type: mance, the use of premium unleaded DENSO SK20R11 “Toyota Genuine Motor Oil” is filled in gasoline with an Octane Rating of 91 IFR6A11 your Toyota vehicle. Use Toyota approved (Research Octane Number “Toyota Genuine Motor Oil”...
Page 328 : Voltage that is checked 20 minutes af- “Toyota Super Long Life Coolant” is ter the key is removed with all the lights filled in your Toyota vehicle at factory turned off fill. In order to avoid technical problems, only “Toyota...
Page 329 Supplement”. When 1.0 (0.04) changing the automatic transmission fluid, use only “Toyota Genuine ATF Type T- IV” Parking brake adjustment when pulled with (ATF JWS3309 or NWS6500) to aid in the force of 196 N (20 kgf, 44 lbf): assuring optimum transaxle performance.
Page 330: Tires
’04 Solara_U (L/O 0402) Tires Fuses Tire size and cold tire inflation pressure: kPa (kgf/cm or bar, psi) Tire size Front Rear Wheel size P215/60R16 94V 200 (2.0, 29) 200 (2.0, 29) 6 1/2 JJ P215/55R17 93V 220 (2.2, 32) 220 (2.2, 32) 7 JJ Compact spare tire...
Page 331 ’04 Solara_U (L/O 0402) 9. HEAD LH UPR 10 A: Left- hand head- 19. ABS No.2 25 A: Anti- lock brake sys- light (high beam) tem, vehicle stability control system, traction control system, brake assist 10. HEAD RH UPR 10 Right- hand system headlight (high beam)
Page 332 ’04 Solara_U (L/O 0402) 31. PANEL 10 A: Glove box light, multi- in- 39. ECU- B 10 A: Multiplex communication Fuses (type C) formation display, instrument cluster system (power door lock system, secu- 46. DEF 40 A: Rear window defogger, out- lights, instrument panel lights rity system, auto- door locking system, side rear view mirror defoggers...
Page 333 API grade SL “Energy- Conserving” or ILSAC multigrade engine oil is recommended. See page 301 for detailed information. Automatic transmission fluid: Toyota Genuine ATF Type T- IV Publication No. OM33640U Tire information: See pages 305 through 313. Part No. 01999-33640 Printed in Japan 01- 0402- 00 Tire inflation pressure: See page 330.
Page 334: Occupant Restraint Systems
None of these systems, either individ- Toyota encourages you and your family to take the time to ually or together, can ensure that there is no injury in the read Section 1- 3 of this Owner’s Manual carefully.
Page 335 The rapid deployment of the SRS air- bags makes the SRS airbags themselves potential sources Your new vehicle is covered by the following Toyota limited of serious injury if an occupant is too close to an airbag, warranties:...
Page 336 ’04 Solara_U (L/O 0402) Your responsibility for Important health and safety maintenance information about your Toyota It is the owner’s responsibility to make sure that the speci- CAUTION fied maintenance is performed. Section 6 gives details of these maintenance requirements. Also included in Section WARNING: Engine exhaust, some of its constitu- 6 is general maintenance.
Page 337: Installation Of A Mobile Two- Way Radio System
Toyota Toyota A wide variety of non- genuine spare parts and accessories The spark ignition system in your Toyota meets all require- for Toyota vehicles are currently available in the market. ments of the Canadian Interference- Causing Equipment You should know that Toyota does not warrant these prod- Standard.
Page 338 Be sure to have the systems of the SRS airbag and seat belt preten- sioner removed and disposed of by the qualified service shop or by your Toyota dealer before you dispose of your vehicle. 2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Page 339 ’04 Solara_U (L/O 0402) viii 2004 SOLARA from Feb. ’04 Prod. (OM33640U)

Toyota Solara 2004 Operating Manual

Table of Contents

1 3 Section -

1 4 Section -

1 5 Section -

1 6 Section -

1 7 Section -

1 8 Section -

1 9 Section -

1 10 Section -

2 Section

3 Section

4 Section

6 Section

7 1 Section -

7 2 Section -

Quick Links

Chapters

Related Manuals for Toyota Solara 2004

Summary of Contents for Toyota Solara 2004

Table of Contents