Doors (Self-Closing); Door Alignment And Adjustment; Door Reversability - U-Line U-CO29B-00 Use & Care Manual

Doors (Self-Closing)

Door Alignment and Adjustment

Align and adjust the door if it is not level, or is not sealing properly.
If the door is not sealed the unit may not cool properly, or
excessive frost may form in the interior.
NOTICE
• Properly aligned, the door's gasket should be firmly in
contact with the cabinet all the way around the door
(no gaps). Carefully examine the door's gasket to ensure
that it is firmly in contact with the cabinet. Also make
sure the door gasket is not pinched on the hinge side of
the door.
• The door will not be flush with the top of the cabinet.
The top edge of the door will be 1/8 in. (3.175 mm)
below the cabinet top.
1/8"
(3.175 mm)
To align and adjust the door:
1. Compare the top edge of the door (opposite the hinges) to the
top edge of the cabinet and note the type (up or down) of
adjustment needed.
2. Remove the top hinge pivot pin with a Phillips screwdriver and
lift door off bottom hinge pin. Be careful not to lose the door
closer insert sets.
3. Turn the door upside down and inspect the hinge plate mounting
holes. The plate has slotted mounting holes. Loosen but do not
remove the two hinge plate screws (1).
4. If door edge opposite the hinges needs to move up, move plate
toward outside of door (2). If door edge needs to move down,
move plate toward inside of door (3). Repeat until top edge of
10
1
2 3
1
2 3
door is parallel with top of cabinet and tighten screws (1)
securely.
5. After adjustment is complete, remove the door closers from the
bottom hinge, clean thoroughly and apply petroleum jelly to the
mating surfaces of the closers. Be sure that pins on closers align
with holes in the door and bottom cabinet hinge plates. Mount
door and install top hinge pivot pin.

Door Reversability

Location of the unit may make it desirable to mount the door on
the opposite side of the cabinet. Many doors are reversible. See
table below.
Model
U-ADA15IMB-00
U-ADA15IMS-00
U-ADA15IMS-01
U-BI2115B-00
U-BI2115B-20
U-BI2115S-00
U-BI2115S-01
U-BI2115S-20
U-BI2115S-22
U-BI2115SOD-00
U-BI2115SOD-01
U-BI2115SOD-20
U-BI2115SOD-22
U-BI2115W-00
U-BI2115W-20
U-CO1175B-00
U-CO1175B-20
U-CO1175S-00
U-CO1175S-01
U-CO1175S-20
U-CO1175S-22
U-CO29B-00
U-CO29B-03
U-CO29B-20
u-line.com
Reverse Model
Yes U-CO29BTP-20
No U-CO29FB-00
No U-CO29FWH-00
Yes U-CO29WH-03
Yes U-CO29WHTP-20
No ULN-BI95B-00
No ULN-BI95B-20
No ULN-BI95BTP-03
No ULN-BI95BTP-20
No ULN-BI95WH-00
No ULN-BI95WH-20
No ULN-BI98B-00
No ULN-BI98B-20
Yes ULN-BI98WH-00
Yes ULN-BI98WH-20
Yes ULN-SP18B-03
Yes ULN-SP18B-20
No ULN-SP18WH-03
No ULN-SP18WH-20
No
No
Yes
Yes
Yes
Reverse
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes