GENERAL SAFETY..................................................................... 3-4
TABLE OF CONTENTS .................................................................. 5
INTRODUCTION ............................................................................ 5
Water Piping .................................................................... 12-13
Gas Piping ............................................................................ 14
Venting .................................................................................. 15
Condensate........................................................................... 17
thank You for purchasing this water heater. Properly installed and
maintained, it should give you years of trouble free service.
Abbreviations Found In This Instruction Manual:
• ANSI - American National Standards Institute
• NFPA - National Fire Protection Association
• ASME - American Society of Mechanical Engineers
• GAMA - Gas Appliance Manufacturer's Association
• UL - Underwriters Laboratories Inc.
This gas-fired water heater is design certified by Underwriters
Laboratories Inc. under American National Standard for Gas Water
Heaters ANSI Z21.10.3 (current edition).
preparInG for the InstallatIon
1. Read the "General Safety" section, page 3 and 4 of this manual first
and then the entire manual carefully. If you don't follow the safety
rules, the water heater will not operate properly. It could cause
DEATH, SERIOUS BODILY INJURY AND/OR PROPERTY DAMAGE.
This manual contains instructions for the installation, operation, and
maintenance of the gas-fired water heater. It also contains warnings
throughout the manual that you must read and be aware of. All warnings
and all instructions are essential to the proper operation of the water
heater and your safety. Since we cannot put everything on the first
few pages, read the entIre Manual Before atteMptInG
to Install or operate the water heater.
2. The installation must conform with these instructions and the local
code authority having jurisdiction. In the absence of local codes,
taBle of contents
REPAIR PARTS ............................................................................ 29
TROUBLESHOOTING ............................................................30-32
WARRANTY ................................................................................. 35
IntroductIon
3. The water heater when installed must be grounded in accordance
4. If after reading this manual you have any questions or do not
5. Carefully plan the place where you are going to put the water
6. For California installation this water heater must be braced,
7. Massachusetts Code requires this water heater to be installed in
8. Complies with SCAQMD rule #1146 and districts having equivalent
5
Smoke/Odor .................................................................. 25
Strange Sounds ............................................................ 25
Smelly Water ................................................................. 25
Burner Cleaning .................................................................... 26
Housekeeping ..................................................................26-27
Draining................................................................................. 27
Service .................................................................................. 28
installations should comply with the National Fuel Gas Code (ANSI
Z223.1/NFPA 54) and the National Electrical Code (NFPA 70).
These publications are available from The National Fire Protection
Association, 1 Batterymarch Park, Quincy, MA 02269.
with the local codes, or in the absence of local codes: the National
Electrical Code (NFPA 70).
understand any portion of the instructions, call the local gas utility
or the manufacturer whose name appears on the rating plate.
heater. Correct combustion, vent action, and vent pipe installation
are very important in preventing death from possible carbon
monoxide poisoning and fires, see Figures 1 and 2.
Examine the location to ensure the water heater complies with
the "Locating the New Water Heater" section in this manual.
anchored, or strapped to avoid falling or moving during an
earthquake. See instructions for correct installation procedures.
Instructions may be obtained from California Office of the State
Architect, 400 P Street, Sacramento, CA 95814.
accordance with Massachusetts 248-CMR 2.00: State Plumbing
Code and 248-CMR 5.00. For more information see next page.
NOx requirements.