Page 1: Table Of Contents
www.GEAppfiances.com Safety Instructions ... Operating Instructions Air Direction ....Heat/Cool Model 2500 Auxiliary' Controls ..Heat Pum[J Modal _500 Controls ....Vent Control ....Care and Cleaning Air Filters ....Base Pan ....Outdoor Coils ....Room Cabinet and Case ..
Page 2 IMPORTANT SAFETY INFORMAtiON. READALLINSTRUCtiONSBEFORE USING. A WARNING! For your safe_ the information in this manual must be followed to minimize the risk of fire or explosion, electric shock, or to pre vent property damage, personal injury, or loss of life. _\ "_j____ SAFETY P RECAUTIONS Replacing an existing un#? must be properly...
Page 3 About the controlson yourZoneline. _.GEA..li..ces.com STOP° ° °'_2." AUTO A _f_ ' A AUTO HEAT" I I yCOOL HIGHAll HIGH HEAT w_,. COOL MODECONTROL TEMPCONTROL Mode Control Temp Control Co_trols HIGH COOL and AUTO COOL proxide The temp control is used to maintain cooling with different fire speeds.
Page 4: Air Direction
Otherfeatures yourZoneline may have. Ventilation Control xentilation control lexer is located at the upper left side of the Zoneline unit, behind cabinet, I'OOIll NOTE:Thevent door shipping hardware must be removed before using the vent control lever. See the Installation Instructions in this manual. X,_q_en set at CLOSE, OlflV the air inside...
Page 5 Auxiliary Controls on yourZoneline. .cEAp ,ia, oos.oom Auxiliary Controls- Dip Switches au_liary dip switch controls located behind room cabinet, through opening in the control panel. ToRemovethe Remove room cabinet. See the Room Cabinetsection, DOWN The ti_ctox) settings will be in the position.
Page 6 Auxi/iaq controlson yourZoneline. Remote Thermostat-Class 2 _4q_en this switch is enabled (UP), it allows °_IBBB_, BBBBIIBBBBBBI °_ unit to operate off of a Class 2 Remote Control _4*all Them_ostat. trait controls disabled. CLASS 2 (Remote Thermostat) Load Shedding (CDC) This teatm'e is active only if the trait is in °o'-'°IBBBBaB ] IBBBBBB]°o...
Page 7 www.GEPppliances.com Temperature Limiting fit_t three switches used to select Temperature limiting can reduce enex%_' costs by limiting lowest temperature that can be cooling limits remaining three switches set fl)r cooling highest temperature that used to control heating limits, This teature is not a\_filal)le with...
Page 8 Auxiliary controlson yourZoneline. Auxiliary Controls-Terminal Connections Tile ml_li_' cont_'ols _'e loc_ted behind tile owne_" is _'esponsible fi_" m_king _l)l)rOl)_i_te _'oom cabinet bene_th cont_'ol p_mel. com_ections _md setting tile dip switches. Remo_,e _'oom c_binet. See the ToRemovethe RoomCabinetsection. lnse_'t tile building hook-/_p wi_'es into tile...
Page 9 vvww.GEAppliances.com Door Sensor (Obtained locally) _]/en connected, tile door sensor will detect @@@@@@@@@@@@@@ when tile door tile i'OOill W_lS opened closed. This teatm'e must be used in coI_junction with tile motion senso_: The door and motion sensm_ work together " DoorSensor to automaticallx mrn tile refit ON or OFE...
Page 10: Careand Cleaning
Careand cleaning. Room Cabinet and Case Turn the Zoneline oiI and disconnect To clean, use water and a mild detergent. Do not use bleach or abrasives. Some commerdal power supply: cleane_ may damage the plastic parts. Outdoor Coils Tile coils on tile outdoor side of tile Zoneline should be checked...
Page 11 Replacement filte_ are available fl'om salesperson, GE deale_; GE Service Parts (_enter or authoYized (_ustomer Cai'e '_sei'vicei_.
Page 12: Installation Instructions
Zoneline Air Installation Conditioners Instructions I Ouestions?Call 800.GE.CARES (800.432.2737) or Visit www.GEAppliances.com our _bsJte BEFORE YOU BEGIN IMPORTANT ELECTRICAL SAFETY-READ CAREFULLY Read these instructions completely mid carefully. • IMPORTANT - S.,e_hese _k CAUTION: inst_ uctions tin" local inspector's use. • Follow...
Page 13: Replacing An Existing Unit
This unit is designed to be installed in a GE plastic insulated metal wall case. This minimizes condensation fl'om fimning on the room side ot the case. If the cmTent...
Page 14: Electrical Supply
Instructions HOW TO CONNECT 230/208 xolt models be installed using the following electrical subbases: 1 I_emove room cabinet. Branch Circuit and Proper GE Subbase Kit Connect to electrical power, Unit Amperage Bating 3 See special instructions below fi)r ai)plicable 15/20...
Page 15 A Electrical subbase kits are a\_filable to ixxwide a flexible enclosm'e fin" direct com]ection. Branch Circuit and Proper GE Unit Amperage Rating Subbase Kit 1_I(204E ILMq204E20 ILMq204E30 Junction boxcover instructions provided with selected subbase...
Page 16 Installation Instructions 265 VOLT ELECTRICAL SUPPLY [] MAKE WIRING CONNECTIONS disconnect inside the junction box. NOTE: (-)rder Kit RAK4002C_4 to enable a quick 1 Make all wire connections by using appropriate UL-lismd electrical connecto_ and mchniques (black to black, white to white and green to green).
Page 17: Installing The Zoneline
*dth tile grill. if present Insulated Wall Case This trait is designed to be installed in a GE plastic or an instflated steel wall case. This minimizes tile side of condensation fi'Ol// ik)ll//ing I'OOI// tile case.
Page 18 Installation Instructions [] iNSTALL THE UNiT iNTO THE [] REPLACE THE ROOM CABINET WALL CASE Reinstall roon_ cabinet by hooking oxer rail ahmg unit ( l ), then I)ushing, it in at Slide unit into the wall case and secure with ibm"...
Page 19: Optional Drain Kit
Installation Instructions OPTIONAL- DRAIN KIT INSTALLATION Dry Air 2500 Series models axe designed to improve dehumidification by 25%. Since more moisture will be removed from the air, there is a greater possibility that water will drip from wall case than with a stm_dard unit.
Page 20: Troubleshooting Tips
• Outdoor grille must have a minimum ot 65% fl'ee area. Non-GE grilles be too restrictive fi)r proper pe_timnance. Consult your salesperson fiw assistance. The temp control • Turn the control...
Page 21: Normal Operating Sounds
Thingsthat are normal www.GEAppliances.com Normal Operating Sounds You may hear a pinging noise caused by water being pI N G! POP' picked up and thrown against the condenser rainy days or when the lmmidiQ' is high. This design ti_attu'e helps remove moisture and improve efficiency.
Page 22 NOteS_ €_ €_...
Page 23 Notes,...
Page 24 NOteS_ €_ €_...
Page 25 Please place in envelope and mail to: General Electric Company Warranty Registration Department P.O. Box 32150 Louisville, KY 40232-2150...
Page 26 * F'l( asc F' _ v ( ( y 1 - (- a( ( -css to r( ceiv(, via (-mail, discounts, special offers mM other importam (ommuni(ations h-Oln GE Applian((s ((;1L",.). Ch((k h(r( if you do not v,ant to re(( ire (olnmuni(ations from (;EA's...
Page 27 (lefe('t in materials or workmanship, L)urh_g this originalpurchase full five-year sealed refrigerating system warranty, GE will also proxide, free of charge, all labor and on-site service to replace the (lete('ti\'e part. Five Years For the...
Page 28: Consumersupport
Caution must be exercised, since improper servicing may cause unsafe operation. Contact Us wwvv.GEAppliances.com If you are not satisfied with tile service you receive ti'om GE, contact us on our _'ebsite with all tile details including your phone number;...

This manual is also suitable for:

Zoneline 3500

GE Zoneline 2500 Owner's Manual And Installation Instructions

Quick Links

Related Manuals for GE Zoneline 2500

Summary of Contents for GE Zoneline 2500

This manual is also suitable for:

Table of Contents