Page 1: Table Of Contents
Safety Instruc_tions ... Operating Instructions Air Direction ....Heat/Cool Modal 2800 Auxiliary Controls ..Heat Pump Model 3800 Controls ....To Remo_e the Room Cabinet . .4 Vent Control ....Espa_ol For a Spanish version of this Care and Cleaning...
Page 2: Safety Instruc_Tions
IMPORTANT SAFETY INFORMATION. READALLINSTRUCTIONS BEFORE USING. WARNING! For your safe_ the information in this manual must be followed to minimize the risk of fire or explosion, electric shock, or to prevent property damage, personal injury, or loss of life. SAFETY P RECAUTIONS •...
Page 3 About the controlson yourZoneline. ge.com TEMPCONTROL MODECONTROL Temp Control Mode Control Co trols HIGH COOL and LOW COOLpr_vi(le cooling The temp control is used to maintain The coi/li)i'essoi" will with different tim speeds. I'00111 telllpei'attli'e. c_cle on and off to kee I) the room at the...
Page 4: Air Direction
Otherfeatures of yourZoneline. Ventilation Control Open xentilation control lexer is located at the position upper lett side of the Zoneline unit, behind room cabinet. _,_q_en set at the closed position, onE' inside room is circulated filtered. X,_]_en set at the open position, some...
Page 5: Auxiliary Controls
Puxi/iaq Controls on your Zonefine. ge.com Auxifiaq Controls--Dip Switches Tile au_liary dip switch controls located behind tile ro()m cabinet, through an opening in the control panel. Remove tile room cabinet. See tile 7"0Remove Room Cabinet section. Tile ti_ctoi y settings will be in tile DOWN position.
Page 6 Auxiliary controlson yourZoneline. Remote Thermostat--Class 2 _._q_en this switch is enabled (UP}, it allows the °_'_" BBBI_BBBBBBBBBBBB °_'_° unit to operate with a Class 2 Remote Control Wall Them_ostat. The refit controls are disabled. CLASS 2 (Remote Thermostat) Load Shedding (Central Desk Control) This featm'e is active...
Page 7 Temperature Limiting fit_t three switches used to select tile Temperature limiting can reduce energy' costs by limiting lowest temperature that can be cooling limits, remaining three switches set fl)r cooling highest temI)erature that used to control heating limits, This...
Page 8 Auxiliary controlson yourZoneline. Auxiliary Controls--Terminal Connections Tile auMlim_' controls are h)cated behind tile The owner is responsible fi)r making rooiil cabinet beneath tile access coxei; c(mnections and setting tile appropriate dip switches. _] Remoxe tile room cabinet, See tile ToRemove the Room Cabinet section. A CAUTION: Rei/loxe tile...
Page 9 Door Sensor (Obtained locally) _]/en connected, tile door sensor will detect when tile door tile i'OOill w;Is opened closed. This teatm'e must be used in coI_junction with tile motion sensor: Tile door i/lotion sensoi3 work together to automaticallx set back tile room temperature.
Page 10: Careand Cleaning
Careand cleaning. Room Cabinet and Case Turn the Zoneline otI and disconnect To clean, use water and a mild detergent. Do not use bleach or abrasives. Some commercial power supply: cleane_ may damage the plastic parts. Outdoor Coils The coils on the outdoor side of the Zoneline should be checked...
Page 11 Replacement filtex_ awfilable fl'om yore" salesperson, GE dealer, GE Service Parts Center or authorized Customer Care '_sec,'icers.
Page 12: Installation Instructions
Zoneline Air Installation Conditioners Instructions Questions ? Call 800.GE.CARES (800.432.2737) or Visit ge.com our Website BEFORE YOU BEGIN IMPORTANT ELECTRICAL SAFETY--READ CAREFULLY Read these instructions completely carefully. • IMPORTANT - S_,,e t hese _k CAUTION: inst_ uctions local inspector's use.
Page 13: Replacing An Existing Unit
A deflector kit, I_L_K40, may be used with grilles that were not designed t0r yore" new GE Zonelines. The ]L&K40 contains air deflect(ns and gaskets that motmt to the trait to direct the hot exhaust...
Page 14: Electrical Supply
Tandem Perpendicular Large Tandem electrical codes. 15Amp. 20 Amp. 30Amp. 230/208volt receptacle configuration. Branch Circuit and Proper GE Power Cord Unit Amperage Bating with LCDI Device RA1(3153 1_I(24203 ],L&K3303* ':Not approxed tor use on 7000 BTU models.
Page 15 This will help Mien the box is being reinstalled. These inodels must be installed using the api)ropriate GE power supi)l } kit tor the branch circuit amperage Unit connector and the electrical resistance heater wattage desired.
Page 16 Installation Instructions 265 VOLT ELECTRICAL SUPPLY [] ATTACH CONDUIT [] REINSTALL JUNCTION 1 Use the round knockout at the botttnn of the box by engaging • Reinstall the junction the left tabs junction box to attach conduit coming from the on the lower right tace oI the unit, aligning branch circuit.
Page 17 Installation Instructions POWER CONNECTION CHART 230/208 Volt Power Supply Kits with Leakage Current Detection Wall Plug Heater Wattage Device Circuit Protective Device @ 230/208 Volts Configuration RAK3153 2,55/2.09 K\,\ II d eI/l RAK3203 • .4:/2.82 Perpendicular 20 Amp Time Dela_ Fuse or Breaker 15 Amp...
Page 18: Installing The Zoneline
• Install the extel_ior grille from tile room side following instructions packed with tile gl-ille. Insulated Wall Case This unit is designed to be installed in a GE plastic or an insulated steel wall case. This minimizes tile skle condesisation fix)l// iksIs//illg (511 1"(5(5I// tile case.
Page 19 NOTE: There are several extra holes in the trait side flanges t0r installation in wall cases other than GE. To avoid damaging the flange insulation, the installer should use an awl or other shmp tool to puncture...
Page 20: Optional Drain Kit
Installation Instructions OPTIONAL--DRAIN KIT INSTALLATION Dry Air 25 Series models designed to improve dehumidification by 25%. Since more moisture will be removed from air, there is a greater possibility that water will drip from wall case thml with a standard mlit.
Page 21: Troubleshooting Tips
Before you carl for service.., ge.com TrOubleshooting -tips Save time and money! Review the charts on the following ages first and you may not need to call for service. Problem Possible Causes What To Do Zoneline does The unit is...
Page 22 Beforeyoucall forservice... Problem Possible Causes What To Do The air is notalwags The heat pump is not * Tiffs is normal. Tile he_=t pump will produce wm'm air cool or hot during producing hot air. but not _s hot as air produced _hen the higher-cost operation...
Page 23: Normal Operating Sounds
Things that are normal ge.com Normal Operating Sounds Y/u may hear a pinging noise caused by water being PING! POP: picked up and thrown against tile condenser rainy da_:s or when tile humidity is high. This design " feature helps remo\ e moisture and improve efl]cienQ,.
Page 24 NOteS_...
Page 25: Product Registration
Ct/t hel-e Please place in envelope and mail to: General Electric Company Warranty Registration Department P.O. Box 32150 Louisville, KY 40232-2150...
Page 26 FAILURI{ TO COMPI_ETE AND RETI RN Tt tlS CARI) DOES NOT DIMINISII h_)[ 7R Louisville, KY 40225 W.\I_LKN'IY RIGt ITS. ge.com For more information about G1LVs privacy and data usage polio; go to ge.com and (:lick on "Pri_acy Poli_y" or call 800.626.2224.
Page 27: Rranty
Authorized GE Service location for service. In Alaska, the warranty excludes the cost of shipping or service calls to your site.
Page 28: Consumersupport
ScheduleService ge.com Expert (;E repair setsice is onl) one step away fl'om xour door Get on-line and schedule your set\ice xour. conxenience 24 hours any (lax of tile year! Or call 800.GE.CARES (800.432.2737) during n{mnal business hours. RealLifeDesign Studio ge.com...

This manual is also suitable for:

Zoneline 3800

GE Zoneline 2800 Owner's Manual And Installation Instructions

Quick Links

Related Manuals for GE Zoneline 2800

Summary of Contents for GE Zoneline 2800

This manual is also suitable for:

Table of Contents