Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for International Harvester Company 102
Summary of Contents for International Harvester Company 102
- Page 1 ,CADET 71,1 22 ant TRACT0 iNTEFINATIONA, E AT ®...
- Page 2 u_r _:_ p y,_u pmr®d _m _,!eLmi Lo !e betl;em urcimrm_amd e@rr.@_ care a_:,::f ef icfes_ opera[ of yeur Yok:_r Iota] ! _te Ha_;w)_:R_t dealer Tr_)_ EOr }s4S i[: is :o_ain afmin_ k_st.r_._cdon ui ud, tkH:- r;_a.f:ni:_:_i_;;_U_: the _a< 8, r Disve£;ard _'}pAi't:}_ k:r{!
- Page 3 INTRODUCTION Illust. International Cub Cadet 122 Tractor. Illust. International Cub Cadet 102 Tractor.
-
Page 4: Table Of Contents
INTRODUCTION Illust. {nternational Cub Cadet 71 Tractor. De scription Page INTRODUC TION ......Inside cover, 1, Z CONTENTS ....... INSTRUMENTS AND CONTROJ._ ....3, 4 BEFORE OPERATING YOUR NEW TRACTOR ..OPERATING THE ENGINE ....5, 6 6, 7 FUEL SYSTEM ...... - Page 5 Illust. Instruments and controls on the International Cub Cadet 71, 102, and 122 Tractors. Brake pedal lock ......pages 8 and 9. Choke control button ..... page 6. Clutch and brake pedal ..... pages 21 and 22.
-
Page 6: Instruments And Controj
iNSTRUMENTS AND CONTROLS... -
Page 7: Before Operating
Fuel system ..Fill the fuel tank with gasoline. See page 6. Illust. Fuel system and controls on International Cub Cadet 123 Tractor. (international Cadet 102 and 122 Tractors are similar.) THROTTLE LEVER LIFTING THE HOOD This lever controls speed of the engine. -
Page 8: Operating The Engine
THE ENGINE OPERATING STARTING THE ENGINE control button choke enrich fuel mixture, except when necessary start engine. sure fuel shut-off valve open. Manual Starting: (Tractors without electric Pull the choke control button all the way starting). Raise the tractor hood. retract- out {see Illust. -
Page 9: Fuel System
FUEL SYSTEM Illust. Illust. Carburetor and fuel strainer. Carburetor and fuel strainer. (International Cub Cadet 71 Tractor) (International Cub Cadet 102, 122 and 123 Tractors) CARBURETOR ADJU STMENTS a final check of the high speed adjust- ment, operate engine under... - Page 10 Adjusting the seat. (International Cub Cadet 102 Tractor.) Illust. Adjusting the seat. (International Cub Cadet 71 Tractor.) Illust. Adjusting the seat. (International Cub Cadet 122 and 123 Tractors) Before starting tractor, adjust the seat to the most comfortable driving position...
-
Page 11: Driving The Tractor
DRIVING THE TRACTOR (International C ub Cadet 71, 102 and 122 Tractors) CLUTCH AND BRAKE PEDAL Note:Do not rest your foot on the pedal while driving the tractor, as this will result in excessive clutch lining wear. combination clutch and brake pedal is used to disengage the engine from the trans-... - Page 12 DRIVING THE TRACTOR (International C ub Cadet 123 Tractor) BRAKE PEDAL Note: rest your foot on the brake pedal while driving the tractor as this would brake pedal must q_e pressed cause speed control lever to return to the down activate safety starting...
-
Page 13: Hitching Trailing Equipment
HITCHING TRAILING EQUIPMENT TO THE TRACTOR Illust. Drawbar and three-point hitch. (International Cub Cadet 102, 122 and 123 Tractors) Illust. Drawbar and three-point hitch shown International Cub Cadet 71 Tractor. LIFT HANDLE Th.is handle used lift lower equip- ment used with tractor. -
Page 14: Rear Power Take-Off
(International C ub Cadet 71, 102 and 122 Tractors) Illust. Itlust. 12A Operating the Power Take-off. International Cub Cadet 71 Tractor Operating the Power Take-bff. International Cub Cadet 102 and 122 Tractors If your tractor equipped with a rear power take-off, following instructions precautions... - Page 15 FRONT POWER TAKEo, OFF OPERATING THE FRONT POWER TAKE-OFF After considerable clutch use, it may CLUTCH necessary to readjust the button clearance described below to assure proper clutch dis- i. Move the throttle lever back to medium engagement. or low idle speed. Move front power...
-
Page 16: And Air Cleaner
ENGINE AIR CLEANER ENGINE COOLING This tractor an air cooled engine. must be able to circulate freely around engine, through screen shroud, over fins of the cylinder head cylinder ..block. Keep these areas free of accumulated ..dirt trash or the engine will... -
Page 17: Electrical System
ELECTRICAL SYSTEM SPARK PLUG IGNITION TIMING Note: Remove dirt from base of the spark plug before removing spark plug. plug Remove the spark after every hours of operation for cleaning and checking the gap. See lllust. 15.When making this adjust- ment, always bend... -
Page 18: "Specifications
ELECTRICAL SYSTEM MOTOR-GENERATOR Removing and Replacing the Motor-Generator Belt The motor-generator (12-volt, negative Replace motor-generator belt when ground) will function as a cranking motor when becomes badly worn. To remove belt, the ignition key is turned to the "START" loosen motor-generator brace bolt... - Page 19 ELECTRICAL SYSTEM Illust. Electrical units on the right side of the tractor. Illust. Electrical units on the left side of the tractor.
- Page 20 [LECTR!<AL SYSTEM +H+s+. 18 ++++t+im+igh++++ w++++n9 +++gr+m+ [_ex 1+ +++++++++ + umb++s sh++,+ +++H+s++18+ De i_c =[p[ion L gh_ing s_ itch+ _ _;ic s w[ _oh+ C Ms_ e + ightin_; S++_+, tch £HSh_+ 'r+_l ++ }++t ++++s++ 1 8A S++ +++++++ ++{+,+m¢+_ n+m_+++ ++ p+g+ +%...
-
Page 21: De Scription
ELECTRICAL SYSTEM Index to reference numbers shown in Illust. 18. RofI De s c ription Description ignition switch. !Voltage regulator. '.Cable - ignition coil positive terminal ICable - regulator "GEN" terminal ignition switch "IGN" terminal ! generator terminal - light blue. - Page 22 FRONT WHEEL TOE-IN Illust. Front wheel adjustments. Illust. 20A Tie rod and drag llnk ball joints. lock nut, turn ball joint front wheel toe-in dimension 1-32- inch to 1/8-inch toe-in (1/3Z-inch to 1/8-inch required. closer in front than in the rear).
- Page 23 CLUTCH AND BRAKE (International Cub Cadet 71, 102 and 122 Tractors) Clutch disengaged: Clutching zone, ....C utch engaged tractor must be free to coast. Top surface of...
- Page 24 CLUTCH AND BRAKE (International C ub Cadet 71, 102 and 122 Tractors) the clutch brake both operated by the same pedal, care must be taken maintain a neutral zone so the clutch is dis- engaged when brake is applied. ADJUSTING THE CLUTCH important that a clearance...
- Page 25 BRAKE (InternationalCub Cadet 123 Tractor) Speed control lever centering zone when brake pedal is Top surfaceof pedal foot pad Pedal return stop Speed control lever is in "N" position Braking zone: Brake must be engaged when pedal is in this zone. Foot support 1- 5/16-inch maxim1...
- Page 26 STORAGE Store your tractor in a dry and protected battery at least once a month for water level place. Leaving your tractor outdoors, See page 19. amount of charge. posed to the elements, will result in materi- On the International Cadet ally shortening its life.
- Page 27 HARD TO START H,> gaso h+e £n :_:_{eI tA:rli o:r c_F uz_+t+u Fu_:I str_>_er or fuel line t;logg_d .... Water in gasoih_e ..... Ch+ked :_+++prope+£y+ Fiooded engf++e ..Defec+< v<+ £gmtiem +r foes+ wir_mg ..C_:eck and se+rvh:+; s++ +m++ i% or _eplact++ De_ec{iVe ba{_e ......
-
Page 28: See Pages 21 And
TROUBLE SHOOTING Possible Remedy Possible Cause LACK OF: POWER - Continued Incorrect timing or faultyignition ..on pages See "Breaker Points and Spark Plug" 15 and 16. Clutch slipping(Models 71, 10Z and 122) ..Adjust the free travel of the pedal; seepages21 and 22. - Page 29 -[RANSNJSSIONOiL F|LT'ER crankcase filler Lh_o: oi_ lto g_,e HJ_,w_ 26, Alway_ level g_uge a.tt_.ched keep level between uF'ULL _ and throw_w_w ca_-type _c,move filter _L_W _ mar_ gauge, When checking a _ew (_H_t_ 23A) replace [:Liter after rn_t with Erie oil level.
- Page 30 --@i...
- Page 31 LUBRICATION GUIDE (InternationalCub Cadet 71, 102 and 122 Tractors) - - After Every 10 Hours of Operation Check the oil (with the engine stopped) and add sufficient 1 - Oil filler cap and bayonet-type oil to bring it to the "FULL" mark on the gauge.
- Page 32 113 0,...
- Page 33 LUBRICATION GUIDE (InternationalCub Cadet 123 Tractor) _--After Every 10 Hours of Operation Check (with engine stopped) sufficient 1. Oil filler cap and bayonet-type to bring it to "FULL" mark gauge. oil level gauge. overfill. operate engine if the level below "LOW"...
- Page 34 Lubricate brake pedal shaft linkage with eight drop_ of engine oil, In crnadon;_l Into r n£t [ona_ Inte_na_.ional Cub Cadet Cadet C ade C_{de t 1 g5 Tractor Tractor i 0£ Trac£or Trac_er CAPA@TIE5 (APPROX_ATE;o U,_:5. _ £ASUR£} s qt.
- Page 35 h_te rnacb::n a! lnte r,natioaai ]nt;er national [rite r_a,tion:l Cub {3ade _: C _,: Cade[ Cadet Cub C _det 71 Tr actor Tractor :g3 Tracto: ENGINE Make t.nuO_eo Hohle: K 10l_:_ Koider H 24}AS {ele_N°:c star::aN)o Kohler 301AS Hoh£er K 301A5 Eohle: i61T (w_sual...
- Page 36 in _e :z o _:_at_o n :,t I:r_Ler na d o _-_ a ,1 In _e r _ a _ f an a i I:r_ts r _. a [ f o a l Cub Cadu_t Cadet Cad_<L (3ub Ca_et 71 Y_;actor i{}£Tractor _'% rZ'ac_ur Z_ Tracto_...
-
Page 37: Page No
De 6eriD_LOn sg." r {ptl_ _Page Zg, g:% Adjusting br ak_: ......hift],ng <he hood £z A6justing clutch ... Lig,hting switch button ..neat ... Adjusting, Light ....Adju_t_ng 5oeed contro_ lever hoek_ng bra_e ..Adjusting c_utch {fro_t Rower) .... - Page 38 MEMORANDA...
- Page 39 Accidents prevenfed with youK No accident-prevention program can be suc- industrial plant, can be safer than the man who cessful without the wholehearted co-operation is at the controls. If accidents are to be pre- of the person who is directly responsible for the vented...