Craftsman 944.601892 Owner's Manual
  1. Manuals
  2. Brands
  3. Craftsman Manuals
  4. Lawn Mower
  5. 944.601892
  6. Owner's manual
Craftsman 944.601892 Owner's Manual

Craftsman 944.601892 Owner's Manual

19.5 hp electric start 42" mower automatic lawn tractor
Hide thumbs
Table of Contents

Advertisement

Quick Links

8E/AR8
OWNER'S
MANUAL
MODEL NO.
944.601892
Caution:
Read and follow
all Safety Rules
and Instructions
Before Operating
This Eqmpment
ICRRFTSMRN°I
19.5 HP
ELECTRIC START
42" MOWER
AUTOMATIC
LAWN TRACTOR
• Assembly
• Operation
• Customer Responsibilities
• Service and Adjustments
• Repair Parts
Sears Canada, Inc., Toronto, Ontario M5B 2B8

Advertisement

Table of Contents
loading

Related Manuals for Craftsman 944.601892

Summary of Contents for Craftsman 944.601892

  • Page 1 8E/AR8 OWNER'S MANUAL MODEL NO. 944.601892 ICRRFTSMRN°I Caution: 19.5 HP Read and follow ELECTRIC START all Safety Rules and Instructions 42" MOWER Before Operating This Eqmpment AUTOMATIC LAWN TRACTOR • Assembly • Operation • Customer Responsibilities • Service and Adjustments •...

  • Page 2: Safety Rules

    SAFETY RULES AI_ Safe Operation Practices for Ride-On Mowers IMPORTANT: THIS CUTTtNG MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. I. GENERALOPERATION DO NOT: •...

  • Page 3: Table Of Contents

    SAFETY RULES _Safe Operation Practices for Ride-On Mowers Be sure the area is clear of other people before mowing. Slop machine if anyone enters the area. Look for this symbol to point out important safety precautions. It means CAUTION!!! Never carry passengers or children even with the blades off. BECOME ALERT!!! YOUR SAFETY IS IN- Do not mow in reverse unless absolutely necessary.

  • Page 4: Product Specifications

    Owner's Manual. 5. In Home service. Warranty service is available by returning the Craftsman Riding Equipment to the nearest Sears Service Centre/Department Canada. This warranty applies only while this product is in use in Canada.
  • Page 5 UNASSEMBLED PARTS Steering Wheel Seat Wheel Steering , Adapter (1) Washer 17/32 x 1-3/16 x 12 Gauge Extension Shaft Steering (1) Knob Wheel Steering Insert Battery Steering (1) Lockwasher 3/8 Boot (1) Locknut (2) Hex Bolts 1/4-20 x 3/4 (2) Keps Nuts 1/4-20 5/16-18 (1) Large Flat Washer...

  • Page 6: Assembly

    ASSEMBLY You r new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness.
  • Page 7 ASSEMBLY • Lift hood to raised position. SEAT • Open terminal access doors, remove terminal protec- tive caps and discard. • If this battery is put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps. SEAT PAN First connect RED battery cable to positive (+) battery LDER...
  • Page 8 ASSEMBLY INSTALL MULCHER PLATE CHECK PROPER POSITION OF ALL BELTS (If previously removed) (See Fig. 4) Raise and hold deflector shield in upright position. See the figures that are shown for replacing motion and • Place front of mulcher plate over front of mower deck mower blade drive belts in the Service and Adjustments opening and stide into place, as shown.

  • Page 9: Operation

    OPERATION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR REVERSE FORWARD FAST SLOW WARNING ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON FUEL CHOKE " MOWER HEIGHT PARKING BRAKE UNLOCKED MOWER LIFT...
  • Page 10 OPERATION KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR C_mpare the i__ustrati_ns with y_urtract_r t_ fami_iarize y_urse_fwith the __cati_ns_f Vari_us c_ntr__sand adjustments_ Save this manual for future reference. ATTACHMENT CLUTCH LEVER IGNITION LIGHT SWITCH SWITCH POSITION AMMETER...
  • Page 11 OPERATION The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard safety glasses.
  • Page 12 OPERATION TO ADJUST GAUGE WHEELS (See Fig. 7) TO OPERATE ON HILLS Gauge wheels are properly adjusted when they are slightty offthe ground when mower isat the desired cutting height in operating position. Gauge wheels then keep the deck in with slopes greater than 15 °...
  • Page 13 OPERATION BEFORE STARTING THE ENGINE • Insert key into ignition and turn key clockwise "START" position and release key as soon as engine starts. Do not run starter continuously for more than CHECK ENGINE OIL LEVEL fifteen seconds per minute. Ifthe engine does not start •...
  • Page 14 OPERATION • Sitting in the tractor seat, start engine. After the engine is running, move throttle control to slow position. With motion control lever in neutral (N) position, slowly disengage clutch/brake pedal. • Move motion control lever to full forward position and hold for five (5) seconds.
  • Page 15 CUSTOMER RESPONSIBILITIES MAINTENANCE SCHEDULE _,_/_/_ ./_'_/_/'* P,LL,NOATES ..-_"/£-q_"/£-4_'J£-_r_ S E R V I C E DATES Check Brake Operation Check Tire Pressure Check Operator Presence Interlock Systems Check for Loose Fasteners Lubrication Chart Check Battery Level Sharpen/Replace Mower Blades Clean Battery and Terminals Check Transaxle Cooling...
  • Page 16 CUSTOMER RESPONSIBILITIES TRACTOR TRAILING EDG EUP Always observe safety rules when performing any mainte- BLADE nance. CENTER BRAKE OPERATION If tractor requires more than six (6) feet stopping distance at HOLE high speed in highest gear, then brake must be adjusted. (See "TO ADJUST BRAKE"...
  • Page 17 CUSTOMER RESPONSIBILITIES TO CLEAN BATTERY AND TERMINALS * CAUTION: Air cooled engines run hotter than automotive engines. The use of non-synthetic multi-viscosity oils (5W30, Corrosion and dirt on the battery and terminals can cause the 10W30 etc.) in temperatures above 40 ° F (4° C) will result in battery to "leak"...
  • Page 18 CUSTOMER RESPONSIBILITIES CLEAN AIR SCREEN Air screen must be kept free of dirt and chaff to prevent engine damage from overheating. Clean with a wire brush or KNOB...--------"----'__ COVER compressed airto remove dirt and stubborn dried gum fibers. WING NUT _---_"_,_ CARTRIDGE (See Fig.
  • Page 19 SERVICE AND ADJUSTMENTS CAUTION: BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: Depress clutch/brake pedal fully and set parking brake. • Place motion control lever in neutral (N) position. • Place attachment clutch in "DISENGAGED" position. • Turn ignition key"OFF" and remove key. •...
  • Page 20 SERVICE AND ADJUSTMENTS SIDE-TO-SIDE ADJUSTMENT (See Figs. 19 and 20) BOTH FRONT LINKS MUST BE EQUAL IN LENGTH • Raise mower to its highest position. At the midpoint of both sides of mower, measure height from bottom edge of mower to ground. Distance"A" on both sides of mower should be the same or within 1/4"...
  • Page 21 SERVICE AND ADJUSTMENTS • While holding motion control lever in place, loosen the WITH PARKING adjustment bolt. NUT "A" BRAKE • Move motion control lever to the neutral (N) (lock gate) "ENGAGED" position. • Tighten adjustment bolt securely. NOTE: Ifadditionalclearanceisneededtogettoadjustment bolt, move mower deck height to the lowest position.
  • Page 22 SERVICE AND ADJUSTMENTS TO REPLACE FUSE .ET.,.,.o.,.o Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash. AX,E COVE. I\ Idr/rA- t\l TO REMOVE HOOD AND GRILL ASSEMBLY WASHERS (See Fig. 29) Raise hood. Unsnap headlight wire connector. FIG.
  • Page 23 SERVICE AND ADJUSTMENTS TO ADJUST CHOKE CONTROL (See Fig. 31) While still holding throttle lever against idle speed screw, turn idle mixture screw in (clockwise) until engine begins The choke control has been preset at the factory and to die and then turn out (counterclockwise) until engine adjustment should not be necessary.

  • Page 24: Storage

    STORAGE ENGINE Immediately prepa re you r tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. FUEL SYSTEM CAUTION: Never store the tractor with IMPORTANT: IT IS IMPORTANT PREVENT gasoline in the tank inside a building DEPOSITS...

  • Page 25: Troubleshooting

    TROUBLESHOOTING POINTS CAUSE CORRECTION PROBLEM Out of fuel. Fill fuel tank. Will not start Engine not "CHOKED" propedy. See "TO START ENGINE" in Operation section. Wait several minutes before attempting to start. Engine flooded. Bad spark plug. Replace spark plug. Dirty air filter.
  • Page 26 TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Faulty ope_to_safety presence cont_l system. 1. Check wiring,switches and connections. If not Engine continues to run corrected, contact an authorized service center/ when operator leaves seat with attachment department. clutch engaged Poor cut - uneven Worn, bent or loose blade.
  • Page 27 TRACTOR - - MODEL NUMBER 944.601892 SCHEMATIC BATFERY © FUSE STARTER BLACK WHITE SOLENOID CLUTCH / BRAKE (PEDAL UP) WHITE IGNITION (NOT OCCUPIED) SWITCH SEAT SWITCH BLACK Q___©,o AoK, Jl_ I ..BLACK 'MENT CLU METER HOUR BLACK (CLUTCH OFF) CONNECTOR -GIR ( ) I] ND]r4G SPARK...
  • Page 28 REPAIR PARTS TRACTOR -- MODEL NUMBER 944.601892 ELECTRICAL...
  • Page 29 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 ELECTRICAL PART DESCRIPTION 163465 Battery 12 Volt 28 Amp 74760412 Bolt Hex Hd 1/4-20unc X 3/4 7603J Tray Battery 145211 Bolt Btr Frt 1/4-20 x 7.5 Zinc 150109 Holddown Battery Mount 145769 Nut Push Nylon 1/4"...
  • Page 30 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 CHASSIS AND ENCLOSURES • p/64 20"/...
  • Page 31 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 CHASSIS AND ENCLOSURES PART DESCRIPTION 174619 Chassis Stl Stamping 176554 Drawbar, Stretch 17060612 Screw 3/8-16x3/4 155272 Bumper Hood/Dash 168337X011 Dash P/L STD533710 Bolt Carriage 3/8-16 x 1 155927 Panel Dash Lh 172107X010 Panel Dash Rh 17490608 Screw Thdrol 3/8-16 x 1/2...
  • Page 32 REPAIR PARTS TRACTOR DRIVE " " MODEL NUMBER 944.601892 36 35 • 15"_...
  • Page 33 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 DRIVE PART PART DESCRIPTION DESCRIPTION Transaxle (See Breakdown) 71170764 Bolt, Hex Hydro Gear Model 314-0510 STD551143 Washer 165866 Rod Shift 154778 Keeper Belt Engine STD561210 Pin Cotter 1/8 x 1 CAD 134683 Keeper Belt Engine 10040400 Washer Lock Hvy.
  • Page 34 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 STEERING ASSEMBLY ..• .." q- - - i ..
  • Page 35 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 STEERING ASSEMBLY PART DESCRIPTION 139768 Wheel Steering 175131 Axle Asm STMP Dropped STL 16984O Spindle Asm LH 169839 Spindle Asm RH 6266H Bearing Race Thrust Harden Washer 25/32 X 1-5/8 X 16 Ga 121748X 19272016 Washer 27/32 X 1-1/4 X 16 Ga...
  • Page 36 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 SEAT ASSEMBLY PART PART DESCRIPTION DESCRIPTION 140123 Seat 121248X Bushing Snap BIk Nyl 50 Id 140551 Bracket Pivot Seat 8 720 72050412 Bolt Rdhd Sqnk 1/4-20x1-1/2 71110616 Bolt Fin Hex 3/8-16unc X 1 134300 Spacer Split 28x 96 Yel Zinc 19131610...
  • Page 37 Decal Dash Pnl B&S 149517 Decal Bat Dan/Psn 170563 165800X428 Decal Waming Pad Footrest LH STLT 163204 Decal Craftsman 165799X428 Pad Footrest RH STLT 157140 138311 Decal Fender Danger Eng/Fr Decal Handle Lft Height Adjust 177253 Decal Hood Side Lt1000...
  • Page 38 REPAIR PARTS TRACTOR -- MODEL NUMBER 944.601892 ENGINE "_,<-,o ,.i! ---6 _-12 • OPTIONAL EQUIPMENT Spark Arrester...
  • Page 39 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 ENGINE PART DESCRIPTION 170547 Control Throt Paddle 17720408 Screw Hex Thd Cut 1/4-20xl/2 Engine (See Breakdown B&S 42E707-2275-E1 149723 Muffler Exhaust 144069 Exhaust Asm, Left 144068 Exhaust Asm. Right 138129 ClampTube Double Engine Bolt 5/16-18unc x 3/4 w/sems 171877 145552...
  • Page 40 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 MOWER DECK _147 106"_ 103 105 101/_ 104 106 102 _\ / 23 118_ " ,116...
  • Page 41 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 MOWER DECK PART PART DESCRIPTION DESCRIPTION 165892 Mower Deck Assembly, 42" 131845 Arm Assembly, Pad, Brake STD533107 Bolt 133943 Washer, Hardened 138017 Bracket Assembly,Sway Bar, 155046 Arm, Idler Front 165723 Spacer, Retainer 165460 Bracket Sway Bar 38/42"...
  • Page 42 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 MOWER LIFT...
  • Page 43 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 MOWER LIFT PART DESCRIPTION 159460 Wire Asm Inner W/Plunge5r Shaft Asm Lift 159471 105767X PinGroove STD581 O62 E Ring #5133-62 19211621 Washer 29/32 x 1-1/4 x 21 Ga. 120183X Bearing Nylon Btk .629 ID 125631X Grip Handle Fluted 122365X...
  • Page 44 119-. 120-, JL 1 28 10_. 9_-\ #> 0:13 I'lli rnl- 77 18 [ _*_' _"_ *r_'127...
  • Page 45 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 HYDRO GEAR TRANSAXLE - MODEL NUMBER 314-0510 PART PART DESCRIPTION DESCRIPTION 170351 Main Housing, Assembly 170408 Rotor, Brake 170352 Side Housing, Assembly 142883 Brake Puck 170353 Center Section, Assembly 142882 Puck Plate 170354 Swashplate, Trunion Machined 142887...
  • Page 46 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 BRIGGS & STRATTON ENGINE - MODEL NUMBER 42E707, TYPE NUMBER 2275-E1 691 e 552A_ 520_ 359_ 552_ 373_ 404 o +4iE 615o 1095 VALVE GASKET 220_;_ 868_ 11019 LABEL KIT I 1058 OWNER'S MANUAl_ 1 * REQUIRES SPECIALTOOLS...
  • Page 47 REPAIR PARTS TRACTOR -- MODEL NUMBER 944.601892 BRIGGS & STRA'I-rON ENGINE - MODEL NUMBER 42E707, TYPE NUMBER 2275-E1 51 ,_ 305_ 1221 307L 267 t 365_ 54_' 861 FUEL PUMP 425' 3071 121 CARBURETOR OVERHAUL 147,,_ 105_ 117,= 188_' 22211138 1136 1137 ,,_"...
  • Page 48 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 BRIGGS & STRATTON ENGINE - MODEL NUMBER 42E707, TYPE NUMBER 2275-E1 3091! 802 q 1051_ 697_ 797_ 7261 165_ 934_ 1006 695 i 1005_ I 1036 LABEL-EMISSION 358 ENGINE GASKET SET 524_ 691_ -"//J 1639...
  • Page 49 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 BRIGGS & STRAT-I'ON ENGINE - MODEL NUMBER 42E707, TYPE NUMBER 2275-E1 PART PART DESCRIPTION DESCRIPTION Shaft-Throttle 498583 Cylinder Assembly 693485 399265 Kit-Bushing/Seal (Magneto Side) 807923 Kit-Idle Speed 391086 • Seal-Oil (Magneto Side) 693509 Q Gasket-Carburetor Body...
  • Page 50 REPAIR PARTS TRACTOR - - MODEL NUMBER 944.601892 BRIGGS & STRATTON ENGINE - MODEL NUMBER 42E707, TYPE NUMBER 2275-E1 PART PART DESCRIPTION DESCRIPTION 89838 Wrench-Spark Plug 797A 693167 Nut (Starter Terminal) 693487 Body-Fuel Pump 691967 Cap-Drive 693491 I_+ Spring-Pump Diaphragm 497607 Cap-End 693489...
  • Page 51 SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION ONLY RIDE UP AND DOWN HILL, "" NOT ACROSS HILL SIGHTING "" --- ...cUT"ou.. GUIDE SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE. MAX. Operate your Tractor up and down the face of slopes (not...
  • Page 52 Get it fixed, at your home or ours! Just Call: 1-800-4-MY-HOME ® (1-800-469-4663) 24 hoursa day, 7 days a week For the repair of major brand appliances in your own home... no matter who made it, no matter who sold it! For your nearest Sears Parts and Service location, to bring in products like vacuums, lawn equipment and electronics.

Table of Contents