Page 1 ® ThinkPad T61 and T61p (15.4-inch widescreen) Hardware Maintenance Manual...
Page 2 175. Fifth Edition (September 2011) © Copyright Lenovo 2007, 2011. LIMITED AND RESTRICTED RIGHTS NOTICE: If data or software is delivered pursuant a General Services Administration “GSA” contract, use, reproduction, or disclosure is subject to restrictions set forth in Contract No. GS-35F-05925.
Page 3: Table Of Contents
Front view . . 121 Numeric error codes . . 39 Rear view . 122 Error messages . . 43 Bottom view . . 122 Beep symptoms . . 44 Parts list . . 123 © Copyright Lenovo 2007, 2011...
Page 4 Overall . 124 Recovery discs . . 165 LCD FRUs . . 151 Common service tools . 174 Keyboard . . 161 Miscellaneous parts . . 162 Notices ....175 AC adapters .
Page 5: About This Manual
ThinkPad products. Use this manual along with the advanced diagnostic tests to troubleshoot problems effectively. Before servicing a ThinkPad product, be sure to read all the information under “Safety information” on page 1 and “Important service information” on page 17. © Copyright Lenovo 2007, 2011...
Page 6 ThinkPad T61 and T61p (15.4-inch widescreen) Hardware Maintenance Manual...
Page 7: Safety Information
“Safety inspection guide” on page 5 v “Handling devices that are sensitive to electrostatic discharge” on page 6 v “Grounding requirements” on page 6 v “Safety notices: multilingual translations” on page 7 v “Laser compliance statement” on page 14 © Copyright Lenovo 2007, 2011...
Page 8: General Safety
General safety Follow these rules to ensure general safety: v Observe good housekeeping in the area of the machines during and after maintenance. v When lifting any heavy object: 1. Make sure that you can stand safely without slipping. 2. Distribute the weight of the object equally between your feet. 3.
Page 9: Electrical Safety
Electrical safety Observe the following rules when working on electrical equipment. Important: Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electrostatic discharges.
Page 10 v Do not touch live electrical circuits with the reflective surface of a plastic dental mirror. The surface is conductive; such touching can cause personal injury and machine damage. v Do not service the following parts with the power on when they are removed from their normal operating places in a machine: –...
Page 11: Safety Inspection Guide
Safety inspection guide The purpose of this inspection guide is to assist you in identifying potentially unsafe conditions. As each machine was designed and built, required safety items were installed to protect users and service personnel from injury. This guide addresses only those items.
Page 12: Handling Devices That Are Sensitive To Electrostatic Discharge
Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electrostatic discharge (ESD.) ESD damage can occur when there is a difference in charge between objects. Protect against ESD damage by equalizing the charge so that the machine, the part, the work mat, and the person handling the part are all at the same charge.
Page 13: Safety Notices: Multilingual Translations
Safety notices: multilingual translations The safety notices in this section are provided in English, French, German, Hebrew, Italian, Japanese, and Spanish. Safety notice 1 Before the computer is powered on after FRU replacement, make sure all screws, springs, and other small parts are in place and are not left loose inside the computer.
Page 14 Safety notice 2 DANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing.
Page 15 Safety notice 3 DANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack.
Page 16 Safety notice 4 DANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations.
Page 17 Safety notice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing.
Page 18 Safety notice 6 DANGER To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card. Afin d’éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d’alimentation. Aus Sicherheitsgründen die Kunststoffabdeckung, die den unteren Teil der Spannungswandlerplatine umgibt, nicht entfernen.
Page 19 Safety notice 8 DANGER Before removing any FRU, power off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables. Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension, débranchez tous les cordons d’alimentation des socles de prise de courant, retirez la batterie et déconnectez tous les cordons d’interface.
Page 20: Laser Compliance Statement
Laser compliance statement Some models of ThinkPad computer are equipped from the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.S.
Page 21 A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: DANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam.
Page 22 ThinkPad T61 and T61p (15.4-inch widescreen) Hardware Maintenance Manual...
Page 23: Important Service Information
Important: BIOS and device driver fixes are customer-installable. The BIOS and device drivers are posted on the customer support site http://www.lenovo.com/support Advise customers to contact the Customer Support Center at 800-426-7378 if they need assistance in obtaining or installing any software fixes, drivers, and BIOS downloads.
Page 24: Strategy For Replacing A Hard Disk Drive
v Some computers have both a processor board and a system board. If you are instructed to replace either the processor board or the system board, and replacing one of them does not correct the problem, reinstall that board, and then replace the other one.
Page 25: Strategy For Replacing Frus For Cto, Cmv, And Gav
MT and 3-digit model, where model = “CTO” (Example: 1829-CTO). Custom Model Variant (CMV) This is a unique configuration that has been negotiated between IBM or Lenovo and the customer. A unique 4-digit MT and 3-digit model is provided to the customer to place orders (Example: 1829-W15).
Page 26: Using Esupport
(this is the same record found in PEW). v eSupport can be accessed at the following Web site: http://www.lenovo.com/ support v To view the key commodities, click on PARTS INFORMATION, then PARTS LOOKUP.
Page 27: Important Information About Replacing Rohs Compliant Frus
FRU part numbers. Lenovo plans to transition to RoHS compliance well before the implementation date and expects its suppliers to be ready to support Lenovo’s requirements and schedule in the EU. Products sold in 2005 and 2006, will contain some RoHS compliant FRUs.
Page 28 ThinkPad T61 and T61p (15.4-inch widescreen) Hardware Maintenance Manual...
Page 29: General Checkout
FRU is defective, clear the error log and run the test again. If the error does not recur, do not replace the FRU. v Be careful not to replace a nondefective FRU. © Copyright Lenovo 2007, 2008...
Page 30: What To Do First
What to do first When you do return a FRU, you must include the following information in the parts exchange form or parts return form that you attach to it: __ 1. Name and phone number of servicer __ 2. Date of service __ 3.
Page 31: Checkout Guide
Checkout guide Use the following procedures as a guide in identifying and correcting problems with the ThinkPad computer. Note: The diagnostic tests are intended to test only ThinkPad products. The use of non-ThinkPad products, prototype cards, or modified options can lead to false indications of errors and invalid system responses.
Page 32: Diagnostics Using Pc-Doctor For Dos
PC-Doctor. This section is an overview of the procedure. For details that depend on model-unique functions, refer to “ThinkPad T61 and T61p (15.4-inch widescreen)” on page 47. Note: PC-Doctor for DOS is available at following Web site: http://www.lenovo.com/ support To create the PC-Doctor diagnostic diskette, follow the instruction on the Web site.
Page 33 On the first screen, select the model and press Enter. Follow the instructions on the screen. 2. The main panel of PC-Doctor appears. 3. Select Diagnostics with the arrow keys, and press Enter. A pull-down menu appears. (Its exact form depends on the model.) Note: PC-Doctor menu does not mean the formal support device list.
Page 34 5. Follow the instructions on the screen. If there is a problem, PC-Doctor shows messages describing it. 6. To exit the test, select Quit — Exit Diag. To cancel the test, press Esc. Note: After running PC-Doctor, check the time and date on the system and reset them if they are incorrect.
Page 35: Pc-Doctor For Windows
Select one of the categories listed below to display symptoms and solutions: v Check System Health v System and Device Tests v Lenovo Troubleshooting Center v System Reports v Updates and Support PC-Doctor for Rescue and Recovery ™...
Page 36: Power System Checkout
Power system checkout To verify a symptom, do the following: 1. Turn off the computer. 2. Remove the battery pack. 3. Connect the ac adapter. 4. Check that power is supplied when you turn on the computer. 5. Turn off the computer. 6.
Page 37: Checking Operational Charging
Checking operational charging To check whether the battery charges properly during operation, use a discharged battery pack or a battery pack that has less than 50% of the total power remaining when installed in the computer. Perform operational charging. If the battery status indicator or icon does not turn on, remove the battery pack and let it return to room temperature.
Page 38: Checking The Backup Battery
Checking the backup battery Do the following: 1. Power off the computer, and unplug the ac adapter from it. 2. Turn the computer upside down. 3. Remove the battery pack (see “1010 Battery pack” on page 62). 4. Remove the backup battery (see “1110 Backup battery” on page 80). 5.
Page 39: Related Service Information
Service Web site: When the latest maintenance diskette and the system program service diskette become available, they will be posted on http://www.lenovo.com/spm Restoring the factory contents by using Product Recovery discs When the hard disk drive (HDD) or solid state drive (SSD) is replaced because of a failure, no Product Recovery program is on the new drive.
Page 40: Passwords
5. You will then be prompted to insert Product Recovery Disk 1 into the optical drive. Insert the Product Recovery Disk 1 into the optical drive, and press OK. In similar fashion, you will be prompted to insert the remaining recovery discs until all the files are copied.
Page 41: Hard-Disk Password
If it has, it can be used for access to the hard disk drive. If no master HDP is available, neither Lenovo nor Lenovo authorized servicers provide any services to reset either the user or the master HDP, or to recover data from the hard disk drive.
Page 42: How To Remove The Hard-Disk Password
Attention: If User only mode is selected and the user HDP has been forgotten and cannot be made available to the servicer, neither Lenovo nor Lenovo authorized servicers provide any services to reset the user HDPs or to recover data from the hard disk drive.
Page 43: Power Management
Power management To reduce power consumption, the computer has three power management modes: screen blank, standby, and hibernation. Screen blank mode If the time set on the “Turn off monitor” timer in the operating system expires, the LCD backlight turns off. ®...
Page 44: Hibernation Mode
v The ring indicator (RI) is signaled by a serial device or a PC Card device. v The time set on the resume timer elapses. Note: The computer does not accept any input immediately after it enters standby mode. Wait a few seconds before taking any action to reenter operation mode.
Page 45: Symptom-To-Fru Index
Symptom-to-FRU index This section contains following information: v “Numeric error codes” v “Error messages” on page 43 v “Beep symptoms” on page 44 v “No-beep symptoms” on page 44 v “LCD-related symptoms” on page 45 v “Intermittent problems” on page 46 v “Undetermined problems”...
Page 46 Table 1. Numeric error codes (continued) Symptom or error FRU or action, in sequence 0187 System board. EAIA data access error—The access to EEPROM is failed. 0188 System board. Invalid RFID Serialization Information Area. 0189 System board. Invalid RFID configuration information area—The EEPROM checksum is not correct.
Page 47 Table 1. Numeric error codes (continued) Symptom or error FRU or action, in sequence 0250 1. Charge the backup battery for more System battery error—System battery is than 8 hours by connecting the ac dead. adapter. 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date.
Page 48 Warning: Your internal hard disk drive customer:If in the primary bay the customer (HDD) may not function correctly on this is using a non-IBM or non-Lenovo hard disk system. Ensure that your HDD is supported drive (HDD), or an old generation IBM...
Page 49: Error Messages
Error messages Table 2. Error messages Symptom or error FRU or action, in sequence Device address conflict. 1. Load “Setup Defaults” in the BIOS Setup Utility. 2. Backup battery. 3. System board. Allocation error for device. 1. Load “Setup Defaults” in the BIOS Setup Utility.
Page 50: Beep Symptoms
Beep symptoms Table 3. Beep symptoms Symptom or error FRU or action, in sequence One beep and a blank, unreadable, or 1. Reseat the LCD connector. flashing LCD. 2. LCD assembly. 3. External CRT. 4. System board. One long and two short beeps, and a blank 1.
Page 51: Lcd-Related Symptoms
QXGA Notes: v Lenovo will not provide replacement if the LCD is within specification as we cannot guarantee that any replacement LCD will have zero pixel defects. v A bright dot means a pixel is always on (white or color.) v A dark dot means a pixel is always off (black color.)
Page 52: Intermittent Problems
Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardware defect, such as cosmic radiation, electrostatic discharge, or software errors. FRU replacement should be considered only when a problem recurs.
Page 53: Thinkpad T61 And T61P (15.4-Inch Widescreen)
PCI Express bus v DMI Graphic memory chip v Intel PM965/GM965 graphics v nVIDIA NB8M-GS with 2x VRAM (128 MB) v nVIDIA NB8P-GL with 2x VRAM (128 MB) v nVIDIA NB8P-GL with 4x VRAM (256 MB) © Copyright Lenovo 2007, 2008...
Page 54: Specifications
Table 7. Specifications (continued) Feature Description v 15.4-inch, 16M colors, WXGA (1280 × 800 resolution) TFT Display color LCD v 15.4-inch, 16M colors, WSXGA+ (1680 × 1050 resolution) TFT color LCD v 15.4-inch, 16M colors, WUXGA (1920 × 1200 resolution) TFT color LCD v 512-MB DDR2-667 SDRAM SO-DIMM (PC2-5300) card ×...
Page 55 Table 7. Specifications (continued) Feature Description PCI Express Mini Card v ThinkPad 11a/b/g Wireless LAN Mini PCI Express Adapter v Intel PRO Wireless 3945ABG Mini-PCI Express Adapter v ThinkPad 11a/b/g/n Wireless LAN Mini-PCI Express Adapter v Intel Wireless WiFi Link 4965AGN v Sierra Wireless EV-DO Wireless WAN Mini PCI Express Adapter v Sierra Wireless MC8755 PCI Express MiniCard...
Page 56: Status Indicators
Status indicators The system status indicators show the status of the computer, as follows: ThinkPad T61 and T61p (15.4-inch widescreen) Hardware Maintenance Manual...
Page 57 Table 8. Status indicators Indicator Meaning Wireless status Green: The wireless feature (the IEEE 802.11 standard or IEEE 802.11n) is on, and the radio link is ready for use. Blinking green: Data is being transmitted. Wireless PAN Green: Wireless PAN (Bluetooth wireless or Wireless USB) is status operational.
Page 58 Table 8. Status indicators (continued) Indicator Meaning Ultrabay Slim Green: An Ultrabay Slim device is installed and in use. status Blinking green: An Ultrabay Slim device is in the process of being detached. Turn off: An Ultrabay Slim device is ready to be attached or detached.
Page 59: Fru Tests
FRU tests The following table shows the test for each FRU. Table 9. FRU tests Applicable test System board 1. Diagnostics --> CPU/Coprocessor 2. Diagnostics --> Systemboard 3. If the ThinkPad Advanced Dock, the ThinkPad Advanced Mini Dock or the ThinkPad Essential Port Replicator is attached to the ThinkPad computer, detach it.
Page 60 Table 9. FRU tests (continued) Applicable test Diskette drive 1. Diagnostics --> Diskette Drives 2. Interactive Tests --> Diskette DVD drive or 1. Diagnostics --> Other Devices--> Optical Drive DVD/CD-RW combo 2. Interactive Tests --> Optical Drive Test drive Memory 1.
Page 61: Fn Key Combinations
Fn key combinations The following table shows the function of each combination of Fn with a function key. Table 10. Fn key combinations Key combination Description Fn+F1 Reserved. Fn+F2 Reserved. Fn+F3 Select a power scheme that has been created by Power Manager. When you press this combination, a panel for selecting a power scheme appears.
Page 62 Table 10. Fn key combinations (continued) Key combination Description Fn+F7 Apply a presentation scheme directly, with no need to start Presentation Director. To disable this function and use the Fn+F7 key combination for switching a display output location, start Presentation Director, and change the settings.
Page 63 Table 10. Fn key combinations (continued) Key combination Description Fn+Spacebar Enable the FullScreen Magnifier function. Fn+PrtSc Has the same function as the SysRq key. Fn+ScrLk Enable or disable the numeric keypad. Fn+Pause Has the same function as the Break key. Fn+cursor keys These key combinations work with Windows Windows Media Player.
Page 64: Fru Replacement Notices
FRU replacement notices This section contains notices related to removing and replacing parts. Read this section carefully before replacing any FRU. Screw notices Loose screws can cause a reliability problem. In the ThinkPad computer, this problem is addressed with special nylon-coated screws that have the following characteristics: v They maintain tight connections.
Page 65: Retaining Serial Numbers
Retaining serial numbers This section includes the following descriptions: v “Restoring the serial number of the system unit” v “Retaining the UUID” v “Reading or writing the ECA information” on page 60 Restoring the serial number of the system unit When the computer was manufactured, the EEPROM on the system board was loaded with the serial numbers of the system and all major components.
Page 66 Reading or writing the ECA information Information on Engineering Change Announcements (ECA) are stored in the EEPROM of the system board. The electronic storage of this information simplifies the procedure to check if the ECA has been previously applied to a machine. The machine does not need to be disassembled to check for the ECA application.
Page 67: Removing And Replacing A Fru
Removing and replacing a FRU This section presents directions and drawings for use in removing and replacing a FRU. Be sure to observe the following general rules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts.
Page 68: 1010 Battery Pack
1010 Battery pack DANGER Use only the battery specified in the parts list for your computer. Any other battery could ignite or explode. Table 11. Removal steps of battery pack Unlock the battery release lever 1 . Holding the battery release lever in the unlocked position 2 , remove the battery pack in the direction shown by arrow When installing: Install the battery pack along the slide rails of the slot.
Page 69: 1020 Ultrabay Slim Device
1020 Ultrabay Slim device Note: Ultrabay Slim does not accept any of the following devices: ™ v Ultrabay Plus devices ™ v Ultrabay 2000 devices v Ultrabay Enhanced devices Table 12. Removal steps of Ultrabay Slim device When you release the switch in step 1 , the lever pops out. In step 2 , pull the lever a little to release the device from the bay.
Page 70: 1030 Hard Disk Drive (Hdd) Cover, Hdd And Hdd Rubber Rails Or Solid State Drive (Ssd) And Storage Converter
1030 Hard disk drive (HDD) cover, HDD and HDD rubber rails or solid state drive (SSD) and storage converter For access, remove this FRU: v “1010 Battery pack” on page 62 Attention: v Do not drop the hard disk drive or apply any physical shock to it. The hard disk drive is sensitive to physical shock.
Page 71 Table 13. Removal steps of HDD cover, HDD and HDD rubber rails or SSD and storage converter (continued) HDD and HDD rubber rails: When installing: The rubber rails on the hard disk drive must be attached to the replacement drive. Otherwise the drive cannot be installed properly. SSD and storage converter: ThinkPad T61 and T61p (15.4-inch widescreen)
Page 72: 1040 Palm Rest Or Palm Rest With Fingerprint Reader
1040 Palm rest or palm rest with fingerprint reader For access, remove this FRU in order: v “1010 Battery pack” on page 62 Note: In models with the fingerprint reader, the sensor is attached to the palm rest FRU. If the fingerprint reader has any defects, you can replace it by the procedures given in this section, which are the same for a palm rest with or without a fingerprint reader.
Page 73 Table 14. Removal steps of palm rest (continued) When installing: When you attach the palm rest, do as follows: Table 15. Installation of the palm rest 1. Attach the fingerprint reader connector firmly to the system board. 2. Attach the palm rest so that the two projections of the palm rest ( a ) firmly fit into the guide holes of the keyboard bezel as shown in this figure.
Page 74 Table 15. Installation of the palm rest (continued) 3. Push the front side of the palm rest until it clicks into place. 4. Close the LCD cover and turn the computer over. Then fasten the four screws to secure the palm rest. ThinkPad T61 and T61p (15.4-inch widescreen) Hardware Maintenance Manual...
Page 75: 1050 Dimm
1050 DIMM For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 Table 16. Removal steps of DIMM Note: If only one DIMM is used on the computer you are servicing, the card must be installed in SLOT-0 ( a ), but not in SLOT-1 ( b ).
Page 76: 1060 Keyboard
1060 Keyboard For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 Table 17. Removal steps of keyboard Step Icon Screw (quantity) Color Torque M2 ×...
Page 77 Table 17. Removal steps of keyboard (continued) When installing: Make sure that the keyboard edges a are under the frame as shown in this figure. ThinkPad T61 and T61p (15.4-inch widescreen)
Page 78: 1070 Modem Daughter Card (Mdc-1.5)
1070 Modem daughter card (MDC-1.5) For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 Table 18. Removal steps of MDC-1.5 Step Screw (quantity) Color...
Page 79 Table 18. Removal steps of MDC-1.5 (continued) Turn the card over 4 , and detach the modem connector 5 . When installing: Make sure that the modem connector and the connector on the underside of the card are attached firmly. ThinkPad T61 and T61p (15.4-inch widescreen)
Page 80: 1080 Pci Express Mini Card For 802.11 A/B/G Wireless Lan
1080 PCI Express Mini Card for 802.11 a/b/g wireless LAN For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 Table 19.
Page 81 Table 19. Removal steps of PCI Express Mini Card for 802.11 a/b/g wireless LAN (continued) When installing: Plug the gray cable into the jack labeled MAIN on the card, and the black cable into the jack labeled AUX. If the computer you are servicing has three cables, put the white cable in the cable bag in the card slot After you secured the card, make sure that the antenna cables are routed as shown in the following figure.
Page 82: 1090 Pci Express Mini Card For 802.11 A/B/G/N Wireless Lan
1090 PCI Express Mini Card for 802.11 a/b/g/n wireless LAN For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 Table 20.
Page 83 Table 20. Removal steps of PCI Express Mini Card for 802.11 a/b/g/n wireless LAN (continued) When installing: Plug the gray cable (MAIN) into the jack labeled TR1, the white cable (3rd) into jack labeled R0, and the black cable (AUX) into jack labeled TR2 on the card.
Page 84: 1100 Wireless Usb Adapter
1100 Wireless USB adapter For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 Table 21. Removal steps of wireless USB adapter In step 1 , unplug the jack by using the removal tool antenna RF connector (P/N: 08K7159) or pick the connector with your fingers and gently unplug it in direction of the arrow.
Page 85 Table 21. Removal steps of wireless USB adapter (continued) ThinkPad T61 and T61p (15.4-inch widescreen)
Page 86: 1110 Backup Battery
1110 Backup battery DANGER Use only the battery specified in the parts list for your computer. Any other battery could ignite or explode. For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard”...
Page 87: 1100 Sim Card Slot
1100 SIM card slot For access, remove these FRUs, in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 Note: If the SIM card has been inserted in the slot, remove it before you start the servicing.
Page 88: 1130 Keyboard Bezel
1130 Keyboard bezel For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 Table 24. Removal steps of keyboard bezel Step Screw (quantity) Color...
Page 89 Table 24. Removal steps of keyboard bezel (continued) In step 2 , release the wireless antenna cables from the cable guide. Step Screw (quantity) Color Torque M2 × 3 mm, small-head, nylon-coated (2) Silver 0.167 Nm (1.7 kgfcm) M2 × 3.5 mm, flatl-head, nylon-coated (2) Black 0.167 Nm (1.7 kgfcm)
Page 90: 1140 Pci Express Mini Card For Wireless Wan
1140 PCI Express Mini Card for wireless WAN For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 v “1130 Keyboard bezel”...
Page 91 Table 25. Removal steps of PCI Express Mini Card for wireless WAN (continued) Cable routing: When you install the the card, route the antenna cables as shown in this figure. ThinkPad T61 and T61p (15.4-inch widescreen)
Page 92: 1150 Speaker Assembly
1150 Speaker assembly For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 v “1130 Keyboard bezel” on page 82 Table 26.
Page 93 Table 26. Removal steps of speaker assembly (continued) For Vodafone wireless WAN models: When replacing the speakers, reuse the ferrite core a that has been attached to the old FRU. When installing: Make sure that the speaker connector is attached firmly, and the cables are routed as in this figure.
Page 94: 1160 Fan Assembly
1160 Fan assembly For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 v “1130 Keyboard bezel” on page 82 v “1150 Speaker assembly”...
Page 95 Table 27. Removal steps of fan assembly (continued) Step Screw (quantity) Color Torque M2 × 9.5 mm, flat-head, nylon-coated (3) Silver 0.167 Nm (1.7 kgfcm) In step 5 , release the wireless antenna cables from the cable guide of the fan assembly.
Page 96 Table 28. Installation of the fan assembly When installing: v Before you attach the fan assembly to the computer, apply thermal grease, at an amount of 0.2 grams, on the part marked a as in the following figure. Either too much or too less application of grease can cause a thermal problem due to imperfect contact with a component.
Page 97: 1170 Cpu
1170 CPU For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 v “1130 Keyboard bezel” on page 82 v “1150 Speaker assembly”...
Page 98: 1180 Lcd Assembly
1180 LCD assembly For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 v “1080 PCI Express Mini Card for 802.11 a/b/g wireless LAN” on page 74 v “1140 PCI Express Mini Card for wireless WAN”...
Page 99 Table 30. Removal steps of LCD assembly (continued) Step Screw (quantity) Color Torque M2 × 5 mm, flat-head, nylon-coated (2) Black 0.167 Nm (1.7 kgfcm) ThinkPad T61 and T61p (15.4-inch widescreen)
Page 100 Table 30. Removal steps of LCD assembly (continued) When installing: 1. Route the antenna cables along the cable guides and secure them with the tapes. As you route the cables, make sure that they are not subjected to any tension. Tension could cause the cables to be damaged by the cable guides, or a wire to be broken.
Page 101: 1190 Base Cover And Usb Sub Card With Cable
1190 Base cover and USB sub card with cable For access, remove these FRUs, in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 v “1080 PCI Express Mini Card for 802.11 a/b/g wireless LAN”...
Page 102 Table 31. Removal steps of base cover and USB sub card with cable (continued) Step Screw (quantity) Color Torque M2 × 9.5 mm, flat-head, nylon-coated (1) Black 0.167 Nm (1.7 kgfcm) M2 × 14 mm, flat-head, nylon-coated (2) Black 0.167 Nm (1.7 kgfcm) ThinkPad T61 and T61p (15.4-inch widescreen) Hardware Maintenance Manual...
Page 103 Table 31. Removal steps of base cover and USB sub card with cable (continued) For discrete graphics models: When you are servicing, make sure that the thermal rubber for FET is firmly attached on the system board as shown in a . When replacing the rubber, you need to peel the thin film off from the bottom, and attach it to the system board.
Page 104 Table 31. Removal steps of base cover and USB sub card with cable (continued) Attention: Before step 7 , be sure that the Ultrabay Slim device eject lever has not popped out. It must be housed in its position as shown in the figure a . Remove the USB sub card with cable and the security hole bracket as in this figure.
Page 105 When installing the PC Card slot bezel assembly, do as follows: Table 32. Installation of the PC Card slot bezel assembly For PC Card/ExpressCard slot bezel assembly For PC Card/Smart Card slot bezel assembly ThinkPad T61 and T61p (15.4-inch widescreen)
Page 106 Note: Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of several kinds. When you replace the base cover, you need to apply the following labels: Product label Homologation label Following labels need to be peeled off from the old base cover, and need to be put on the new base cover.
Page 107: 1200 Structure Frame
1200 Structure frame For access, remove these FRUs, in order: v “1010 Battery pack” on page 62 v “1020 Ultrabay Slim device” on page 63 v “1030 Hard disk drive (HDD) cover, HDD and HDD rubber rails or solid state drive (SSD) and storage converter”...
Page 108 Table 33. Removal steps of structure frame (continued) Remove the AC power jack cable a and the modem cable b . When installing: Make sure the connectors are attached firmly, and that the cables are routed as in the figure above. ThinkPad T61 and T61p (15.4-inch widescreen) Hardware Maintenance Manual...
Page 109 Table 33. Removal steps of structure frame (continued) Remove the CPU support plate. Step Screw (quantity) Color Torque M2 × 5 mm, flat-head, nylon-coated (1) Black 0.167 Nm (1.7 kgfcm) Step Screw (quantity) Color Torque M2 × 3.5 mm, flat-head, nylon-coated (9) Black 0.167 Nm (1.7 kgfcm)
Page 110 Table 33. Removal steps of structure frame (continued) Remove the system board and the PC Card/ExpressCard slots assembly from the structure frame together. When installing: For the models with the wireless WAN features, you need to attach the cushion a that is shipped with new structure frame. Peel off the covering film of the adhesive tape on bottom side of the cushion, and paste it on the new structure frame as shown in this figure.
Page 111: 1210 System Board, Pc Card/Expresscard Slots Assembly
1210 System board, PC Card/ExpressCard slots assembly Important notices for handling the system board: When handling the system board, bear the following in mind. v The system board has an accelerometer, which can be broken by applying several thousands of G-forces. Note: Dropping a system board from a height of as little as 6 inches so that it falls flat on a hard bench can subject the accelerometer to as much as 6,000 G’s of shock.
Page 112 Following components soldered on the top side of the system board are extremely sensitive. When you service the system board, avoid any kind of rough handling. ™ Accelerometer chip for the HDD Active Protection System Security chip Video chip MCH (Memory Controller Hub) ICH (I/O Controller Hub) Table 34.
Page 113 Table 34. Removal steps of system board, PC Card/ExpressCard slots assembly (continued) Turn the system board over, and then disconnect the PC Card/ExpressCard slots assembly a from the system board. When installing: Make sure that the connector of the PC Card/Express Card slot assembly is attached to the system board firmly.
Page 114: 2010 Lcd Front Bezel And Lcd Rear Cover (Lcd Cover Kit)
2010 LCD front bezel and LCD rear cover (LCD cover kit) For access, remove this FRU: v “1010 Battery pack” on page 62 Table 35. Removal steps of LCD front bezel and LCD rear cover (LCD cover kit) Step Screw cap Screw (quantity) Color Torque M2.5 ×...
Page 115 Table 35. Removal steps of LCD front bezel and LCD rear cover (LCD cover kit) (continued) Detach the left and right rear edges of the LCD rear cover 5 , and remove the cover in the direction of arrow 6 as shown in this figure. Detach the latches on the top, left, and right edge of the LCD front bezel in the direction of arrow 7 as shown in this figure.
Page 116 Table 35. Removal steps of LCD front bezel and LCD rear cover (LCD cover kit) (continued) Detach the latches on the front edge of the LCD front bezel in the direction of arrow 8 as shown in this figure. When installing: Attach the LCD cover kit as follows: Table 36.
Page 117 Table 36. Installation of the LCD front bezel and the LCD rear cover (LCD cover kit) (continued) 2. Attach all the latches on the top, left, and right edges of the bezel. 3. Attach the LCD rear cover from the top end. ThinkPad T61 and T61p (15.4-inch widescreen)
Page 118 Table 36. Installation of the LCD front bezel and the LCD rear cover (LCD cover kit) (continued) 4. Attach the latches of the LCD rear cover firmly. ThinkPad T61 and T61p (15.4-inch widescreen) Hardware Maintenance Manual...
Page 119: 2020 Inverter Card
2020 Inverter card For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “2010 LCD front bezel and LCD rear cover (LCD cover kit)” on page 108 Table 37. Removal steps of inverter card Step Screw (quantity) Color Torque...
Page 120: 2030 Bluetooth Daughter Card (Bdc-2)
2030 Bluetooth daughter card (BDC-2) For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “2010 LCD front bezel and LCD rear cover (LCD cover kit)” on page 108 Table 38. Removal steps of BDC-2 Step Screw (quantity) Color...
Page 121: 2040 Antenna Assembly
2040 Antenna assembly For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 v “1080 PCI Express Mini Card for 802.11 a/b/g wireless LAN” on page 74 v “1140 PCI Express Mini Card for wireless WAN”...
Page 122 Table 39. Removal steps of antenna assembly (continued) ThinkPad T61 and T61p (15.4-inch widescreen) Hardware Maintenance Manual...
Page 123: 2050 Lcd Magnesium Frame (Lcd Cover Kit) And Hinge Assembly
2050 LCD magnesium frame (LCD cover kit) and hinge assembly For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 v “1080 PCI Express Mini Card for 802.11 a/b/g wireless LAN”...
Page 124 Table 40. Removal steps of LCD magnesium frame (LCD cover kit) and hinge assembly (continued) Step Screw (quantity) Color Torque M2 × 3 mm, flat-head, nylon-coated (1) Silver 0.167 Nm (1.7 kgfcm) When installing: Attach the LCD panel so that the small hole on the right side of the panel fits into the small projection of the right hinge as shown in a .
Page 125 Table 40. Removal steps of LCD magnesium frame (LCD cover kit) and hinge assembly (continued) Remove the hinge assembly in step 8 . ThinkPad T61 and T61p (15.4-inch widescreen)
Page 126: 2060 Lcd Panel And Lcd Cable
2060 LCD panel and LCD cable For access, remove these FRUs in order: v “1010 Battery pack” on page 62 v “1040 Palm rest or palm rest with fingerprint reader” on page 66 v “1060 Keyboard” on page 70 v “1080 PCI Express Mini Card for 802.11 a/b/g wireless LAN” on page 74 v “1090 PCI Express Mini Card for 802.11 a/b/g/n wireless LAN”...
Page 127: Locations
Locations Front view ThinkLight Status indicators Note: For the description of each indicator, see “Status indicators” on page Stereo speakers Security key hole Universal serial bus (USB) connectors Ultrabay Slim status indicator Ultrabay Slim latch Ultrabay Slim device eject lever Ultrabay Slim Fingerprint reader (for some models) TrackPoint pointing stick...
Page 128: Rear View
Rear view Status indicators Note: For the description of each indicator, see “Status indicators” on page PC Card/ExpressCard slots eject buttons PC Card/ExpressCard slots USB connectors Stereo headphone jack Microphone jack RJ-45 (Ethernet) connector RJ-11 (modem) connector External monitor connector AC power connector Security key hole Bottom view...
Page 129: Parts List
Parts list This section contains following lists of the service parts. v “Overall” on page 124 v “LCD FRUs” on page 151 v “Keyboard” on page 161 v “Miscellaneous parts” on page 162 v “AC adapters” on page 163 v “Power cords” on page 164 v “Recovery discs”...
Page 130: Overall
Overall ThinkPad T61 and T61p (15.4-inch widescreen) Hardware Maintenance Manual...
Page 131 Table 42. Parts list—Overall FRU no. RoHS a - d See “Miscellaneous parts” on page 162. LCD unit (see “LCD FRUs” on page 151.) Keyboard bezel assembly 42W3660 SIM card slot 42X3919 Speaker assembly 42W3803 Modem daughter card (MDC-1.5) 39T0495 ThinkPad 11a/b/g Wireless LAN Mini PCI Express Adapter v 6457-CTO, 4Jx, 6Ex, DSx v 6458-CTO, 4Jx...
Page 132 Table 42. Parts list—Overall (continued) FRU no. RoHS ThinkPad 11a/b/g/n Wireless LAN Mini-PCI Express Adapter v 6463-CTO v 6464-CTO v 6465-CTO v 6466-CTO v 6467-CTO v 6468-CTO v 6470-CTO v 6471-CTO xxA, xxB, xxC, xxF, xxH, xxL, xxM, xxP, xxQ, xxS, 42T0825 xxU, xxY xxE, xxJ...
Page 133 Table 42. Parts list—Overall (continued) FRU no. RoHS Intel Wireless WiFi Link 4965AGN (11n disabled) v 6457-CTO, 4Ux, 4Xx, 5Kx, 6Nx, 6Px, 7Kx, 7Lx, 7Ux, 7Wx, 8Fx, 8Gx, 8Hx, 8Jx, 8Kx, 8Lx, B6x, B7x, BGx, BHx, BKx, BLx v 6458-CTO, 4Ux, 5Kx, 6Qx, BMx, BNx v 6459-CTO, 8Dx, 8Ex v 6460-CTO, 75x, 8Bx, 8Cx, 94x, AMx, CFx, CGx, CHx, CJx v 6461-CTO, 62x...
Page 134 Table 42. Parts list—Overall (continued) FRU no. RoHS Wireless USB adapter v 6457-CTO, 5Cx, 6Gx, 6Hx, 6Kx, 83x v 6458-CTO v 6459-CTO, 48x, 4Ax, 5Bx, 5Dx, 8Ax, C9x, CBx, CDx v 6460-CTO v 6461-CTO v 6462-CTO v 6463-CTO v 6464-CTO v 6465-CTO v 6466-CTO v 6467-CTO...
Page 135 Table 42. Parts list—Overall (continued) FRU no. RoHS SATA hard disk drive, 80 GB, 9.5 mm, 5,400 rpm v 6457-CTO, 4Sx, 4Ux, 4Wx, 4Zx, 5Px, 5Qx, 5Rx, 5Mx, 5Nx, 5Sx, 6Ex, 6Nx, 96x, B3x v 6458-CTO, 4Ux v 6460-CTO, 4Nx, 68x, 75x v 6461-CTO, 62x v 6462-CTO, 62x v 6463-CTO, 46x, 4Bx, 4Ex, 4Hx, 4Lx, 4Qx, 4Ux, 4Vx, 4Yx, 5Bx, 5Ex, 5Fx, 5Gx, 5Jx,...
Page 136 Table 42. Parts list—Overall (continued) FRU no. RoHS SATA hard disk drive, 160 GB, 9.5 mm, 5,400 rpm v 6457-CTO, 4Bx, 4Cx, 7Lx, 7Tx, 7Ux, 6Hx, 6Kx, 95x, 98x, B5x, B6x, BEx, BHx, CRx, CSx, CUx, CVx, CWx, CYx, DYx, E2x, E3x v 6458-CTO, B9x v 6459-CTO, DKx v 6460-CTO, 65x, 66x, 6Ax, 6Cx, 6Wx, 6Zx, 74x, 7Ex, 7Hx, 7Jx, 8Mx, 8Nx, 8Px, 8Qx,...
Page 137 Table 42. Parts list—Overall (continued) FRU no. RoHS SATA hard disk drive, 60 GB, 9.5 mm, 7,200 rpm v 6463-CTO v 6464-CTO v 6465-CTO, 53x v 6466-CTO v 6467-CTO v 6468-CTO v 6471-CTO HGST OP 42T1483 Seagate 39T2795 SATA hard disk drive, 100 GB, 9.5 mm, 7,200 rpm v 6457-CTO, 4Jx, 54x, 57x, 5Fx, 5Gx, 5Kx, 6Dx, 76x, 77x, 78x, 79x, 7Px, 7Qx, 7Rx, 7Sx, 7Yx, 82x, 85x, 87x, 8Fx, 8Gx, 8Hx, 8Kx, 8Lx, DSx, v 6458-CTO, 4Jx, 5Kx...
Page 138 Table 42. Parts list—Overall (continued) FRU no. RoHS SATA hard disk drive, 200 GB, 9.5 mm, 7,200 rpm (FDE) 42T1463 HGST v 6457-CTO, 7Vx, 7Xx, 83x, 84x, B7x, BLx, BQx v 6458-CTO, BNx v 6459-CTO, 8Ax, CDx, CEx v 6460-CTO, 8Bx, 8Xx, DGx, DHx, DPx, DQx v 6461-CTO v 6462-CTO v 6463-CTO...
Page 139 Table 42. Parts list—Overall (continued) FRU no. RoHS Battery pack, Li-ion (6 cell) v 6457-CTO, 42x, 44x, 45x, 47x, 49x, 4Dx, 4Hx, 4Lx, 4Sx, 4Ux, 4Wx, 4Zx, 5Mx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 6Ex, 6Nx, 76x, 77x, 78x, 79x, 7Bx, 7Kx, 7Lx, 7Mx, 7Px, 7Qx, 7Rx, 7Sx, 7Ux, 84x, 88x, 8Fx, 8Gx, 95x, 96x, 97x, B3x, B5x, B6x, BEx, BFx, BGx, BHx, BYx, CRx, CSx, CVx, CWx, DXx, DYx, DZx, E2x, E3x v 6458-CTO, 4Ux, B8x, B9x...
Page 140 Table 42. Parts list—Overall (continued) FRU no. RoHS DVD drive, 9.5 mm v 6463-CTO v 6464-CTO v 6465-CTO, 54x v 6466-CTO v 6467-CTO v 6468-CTO v 6471-CTO HLDS (GDR-80887N-C2 UBSS) 39T2683 PCC (UJDA775DVD UBSS) 39T2681 DVD/CD-RW combo drive, 9.5 mm v 6457-CTO, 4Lx, 4Sx, 4Ux, 4Zx, 5Mx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 6Ex, 6Nx, 7Kx, 94x, 96x, 9Rx, 9Xx, B3x, BGx v 6458-CTO, 4Ux...
Page 141 Table 42. Parts list—Overall (continued) FRU no. RoHS DVD-RAM/RW drive, 9.5 mm v 6457-CTO, 42x, 44x, 45x, 47x, 49x, 4Bx, 4Cx, 4Dx, 4Hx, 4Jx, 4Tx, 4Wx, 4Xx, 52x, 54x, 57x, 58x, 5Cx, 5Ex, 5Fx, 5Gx, 5Kx, 6Dx, 6Fx, 6Gx, 6Hx, 6Jx, 6Kx, 6Lx, 6Px, 76x, 77x, 78x, 79x, 7Ax, 7Bx, 7Cx, 7Dx, 7Lx, 7Mx, 7Px, 7Qx, 7Rx, 7Sx, 7Tx, 7Ux, 7Vx, 7Wx, 7Xx, 7Yx, 7Zx, 82x, 83x, 84x, 85x, 86x, 87x, 88x, 89x, 8Fx, 8Gx, 8Hx, 8Jx, 8Kx, 8Lx, 95x, 97x, 98x, B5x, B6x, B7x, BAx, BBx, BEx, BFx, BHx, BJx, BKx, BLx, BPx,...
Page 142 Table 42. Parts list—Overall (continued) FRU no. RoHS Base cover assembly for 6457 World-wide 42W3690 v 6457-CTO, xxA, xxB, xxC, xxE, xxF, xxG, xxH, xxJ, xxK, xxL, xxM, xxP, xxQ, xxS, xxT, xxU, xxY Taiwan 42W3704 v 6457-CTO, xxV Base cover assembly for 6458 World-wide 42W3691 v 6458-CTO, xxA, xxB, xxC, xxE, xxF, xxG, xxH, xxJ,...
Page 143 Table 42. Parts list—Overall (continued) FRU no. RoHS Base cover assembly for 6464 World-wide 42W3698 v 6464-CTO, xxA, xxB, xxC, xxE, xxF, xxG, xxH, xxJ, xxK, xxL, xxM, xxP, xxQ, xxS, xxT, xxU, xxY Taiwan 42W3712 v 6464-CTO, xxV Base cover assembly for 6465 World-wide 42W3699 v 6465-CTO, xxA, xxB, xxC, xxE, xxF, xxG, xxH, xxJ,...
Page 144 Table 42. Parts list—Overall (continued) FRU no. RoHS 512-MB DDR2-667 SDRAM SO-DIMM (PC2-5300) card 40Y8402 v 6457-CTO, 4Lx, 4Wx, 4Zx, 5Px, 5Qx, 5Sx v 6459-CTO, 4Mx v 6460-CTO, 4Nx, 4Rx, 68x, 75x v 6463-CTO, 43x, 46x, 4Ax, 4Bx, 4Cx, 4Ex, 4Hx, 4Lx, 4Sx, 4Tx, 4Ux, 4Vx, 4Wx, 5Ex, 5Jx, 5Nx, 6Ax, 94x, 9Vx, 9Wx v 6464-CTO...
Page 145 Table 42. Parts list—Overall (continued) FRU no. RoHS 2-GB DDR2-667 SDRAM SO-DIMM (PC2-5300) card 40Y8404 v 6457-CTO, 45x, 4Hx, 5Fx, 5Gx, 5Kx, 6Dx, 6Hx, 6Kx, 7Mx, 7Wx, 7Xx, 7Zx, 84x, 86x, 8Jx, 8Lx, 95x, BAx, BBx, BJx, BLx, BPx, BQx, BYx, BZx, CTx, CXx, DXx, DYx, DZx, E2x v 6458-CTO, 5Kx, BNx v 6460-CTO, 4Px, 5Hx, 74x, 7Hx, 8Nx, 8Sx, 8Tx, 8Ux,...
Page 146 Table 42. Parts list—Overall (continued) FRU no. RoHS System board assembly, nVIDIA NB8M-GS with AMT 42W7652 v 6457-CTO, 42x, 44x, 45x, 47x, 49x, 4Bx, 4Cx, 4Dx, 4Hx, 4Jx, 4Lx, 4Sx, 4Tx, 4Ux, 4Wx, 4Xx, 4Zx, 5Mx, 5Nx, 5Px, 5Qx, 5Rx, 5Sx, 6Dx, 6Ex, 6Fx, 6Gx, 6Jx, 6Nx, 6Px, 76x, 77x, 78x, 79x, 7Ax, 7Bx, 7Kx, 7Lx, 7Mx, 7Px, 7Qx, 7Rx, 7Sx, 7Tx, 7Ux, 8Fx, 8Gx, 95x, 96x, 97x, v 6458-CTO, 4Jx, 4Ux, 6Qx...
Page 147 Table 42. Parts list—Overall (continued) FRU no. RoHS CPU assembly, Intel Core 2 Duo processor T7100 (1.8 42W7654 GHz) v 6457-CTO, 4Tx, 4Zx, 5Px, 5Qx v 6458-CTO v 6459-CTO v 6460-CTO, 4Rx, 64x, 6Tx, 6Ux, 6Vx v 6461-CTO v 6462-CTO v 6463-CTO, 46x, 4Ax, 4Bx, 4Cx, 4Ex, 4Lx, 4Sx, 4Tx, 5Ex, 5Fx, 5Jx, 5Kx, 5Xx v 6464-CTO...
Page 148 Table 42. Parts list—Overall (continued) FRU no. RoHS CPU assembly, Intel Core 2 Duo processor T7500 (2.2 42W7656 GHz) v 6457-CTO, 47x, 49x, 4Bx, 4Cx, 4Xx, 52x, 54x, 5Ex, 6Dx, 6Gx, 6Hx, 6Jx, 6Px, 76x, 7Ax, 7Bx, 7Cx, 7Lx, 7Px, 7Qx, 7Rx, 7Sx, 7Yx, 82x, 85x, 87x, 8Fx, 8Gx, 8Hx, 8Kx, 97x, 98x v 6458-CTO, 6Qx...
Page 149 Table 42. Parts list—Overall (continued) FRU no. RoHS CPU assembly, Intel Core 2 Duo processor T7700 (2.4 42W7657 GHz) v 6457-CTO, 57x, 58x, 5Cx, 5Fx, 5Gx, 5Kx, 6Hx, 6Kx, 6Lx, 7Dx, 7Tx, 7Vx, 7Wx, 7Zx, 84x, 86x, 8Jx, 8Lx v 6458-CTO, 5Kx v 6459-CTO, 55x, 5Bx, 5Dx, 5Jx v 6460-CTO, 5Hx, 74x, 7Hx, 8Tx, 8Ux, 8Vx, 8Wx, 8Xx v 6461-CTO, 63x...
Page 150 Table 42. Parts list—Overall (continued) FRU no. RoHS CPU assembly, Intel Core 2 Duo processor T8100 (2.1 42W7881 GHz) v 6457-CTO, B3x, B5x, BEx, BGx, BHx v 6458-CTO v 6459-CTO, C8x v 6460-CTO, D5x, D7x, D9x, DCx, CFx, DWx v 6461-CTO v 6462-CTO v 6463-CTO, 94x, 97x, 98x, 99x, 9Ax, 9Lx, 9Vx, 9Xx v 6464-CTO, 9Cx...
Page 151 Table 42. Parts list—Overall (continued) FRU no. RoHS CPU assembly, Intel Core 2 Duo processor T9500 (2.6 42W7878 GHz) v 6457-CTO, BLx, BPx, BQx, BXx, BYx, BZx v 6458-CTO, B9x, BNx v 6459-CTO, CDx, CEx v 6460-CTO, DHx, DJx, DPx, DQx, DRx v 6461-CTO v 6462-CTO v 6463-CTO...
Page 152 Table 42. Parts list—Overall (continued) FRU no. RoHS PC Card/ExpressCard slot 42X3827 v 6457-CTO, 42x, 44x, 45x, 47x, 49x, 4Bx, 4Cx, 4Dx, 4Jx, 4Lx, 4Sx, 52x, 54x, 57x, 58x, 5Cx, 5Gx, 5Mx, 5Px, 5Qx, 5Rx, 5Sx, 6Ex, 6Fx, 6Gx, 6Hx, 6Jx, 6Kx, 6Lx, 76x, 78x, 7Ax, 7Cx, 7Dx, 7Kx, 7Lx, 7Mx, 7Px, 7Qx, 7Rx, 7Sx, 7Tx, 7Ux, 7Vx, 7Wx, 7Yx, 7Zx, 82x, 83x, 84x, 85x, 86x, 87x, 88x, 8Fx, 8Gx, 8Hx, 8Jx, 8Kx, 95x, 97x, 98x, B3x,...
Page 153 Table 42. Parts list—Overall (continued) FRU no. RoHS PC Card/Smart Card slot 42X3829 v 6457-CTO, 4Hx, 4Tx, 4Ux, 4Wx, 4Xx, 4Zx, 5Ex, 5Fx, 5Kx, 5Nx, 6Dx, 6Nx, 6Px, 77x, 79x, 7Bx, 7Xx, 89x, 8Lx, 96x, B6x, B7x, DZx, E3x, BJx, BKx, BLx, BZx v 6458-CTO, 4Ux, 5Kx, 6Qx, BMx, BNx v 6459-CTO v 6460-CTO...
Page 154 Table 42. Parts list—Overall (continued) FRU no. RoHS KDDI Wireless WAN Modem Adapter 42T0909 v 6457-CTO v 6458-CTO v 6459-CTO v 6460-CTO v 6461-CTO v 6462-CTO v 6463-CTO v 6464-CTO v 6465-CTO v 6466-CTO v 6467-CTO v 6468-CTO v 6470-CTO v 6471-CTO Intel Turbo Memory, 1GB 42T0907...
Page 155 Table 42. Parts list—Overall (continued) FRU no. RoHS Palm rest assembly without fingerprint reader, with 42W2958 IBM logo v 6457-CTO, 42x, 7Ux (for xxB, xxC, xxH, xxV) v 6458-CTO v 6459-CTO v 6460-CTO v 6463-CTO v 6464-CTO v 6465-CTO v 6466-CTO v 6467-CTO v 6468-CTO v 6470-CTO...
Page 156 Table 42. Parts list—Overall (continued) FRU no. RoHS Palm rest assembly with fingerprint reader, with 42W3822 ThinkPad logo (T series) v 6457-CTO, 42x, 45x, 47x, 49x, 4Dx, 4Hx, 4Jx, 4Sx, 4Ux, 4Xx, 52x, 54x, 5Cx, 5Fx, 5Gx, 5Kx, 5Mx, 5Nx, 5Rx, 6Dx, 6Ex, 6Fx, 6Gx, 6Hx, 6Jx, 6Kx, 6Lx, 6Nx, 6Px, 76x, 77x, 78x, 79x, 7Ax, 7Bx, 7Cx, 7Dx, 7Mx, 7Wx, 7Xx, 7Yx, 7Zx, 82x, 83x, 84x, 85x, 86x, 87x, 8Hx, 8Jx, 8Kx,...
Page 157: Lcd Frus
LCD FRUs In ThinkPad T61 and T61p (15.4-inch widescreen), there are following types of LCDs. v “15.4-in. WXGA TFT” on page 152 v “15.4-in. WSXGA+ TFT” on page 155 v “15.4-in. WUXGA TFT” on page 158 ThinkPad T61 and T61p (15.4-inch widescreen)
Page 158 15.4-in. WXGA TFT Table 43. Parts list—15.4-in. WXGA TFT FRU no. RoHS LCD cover kit with IBM logo 42W3652 v 6457-CTO, 5Px, 5Qx, 5Sx, 7Kx, 7Ux (for xxB, xxC, xxH, xxV) v 6458-CTO v 6459-CTO v 6460-CTO, 64x, 69x, 6Tx, 6Ux, 6Vx, 72x, 7Fx, 8Mx, 8Px, 8Qx, 8Rx v 6461-CTO v 6462-CTO...
Page 159 Table 43. Parts list—15.4-in. WXGA TFT (continued) FRU no. RoHS Wireless LAN/WAN antenna assembly 93P4516 v 6457-CTO, 6Ex, 6Jx, 7Ux, BEx v 6458-CTO v 6459-CTO v 6460-CTO, 6Tx, 6Ux, 8Px, 8Qx, D7x, DCx v 6461-CTO v 6462-CTO v 6463-CTO, 5Hx, 5Mx, 68x v 6464-CTO v 6465-CTO, 54x, 63x v 6466-CTO...
Page 160 Table 43. Parts list—15.4-in. WXGA TFT (continued) FRU no. RoHS Bluetooth daughter card (BDC-2) 39T0497 v 6457-CTO, 5Mx, 5Nx, 6Gx, 6Hx, 6Jx, 6Kx, 6Lx, 76x, 77x, 7Ux, B5x, B6x, BEx, BGx, CRx, CVx, DXx, DZx v 6458-CTO, B8x v 6459-CTO, DKx v 6460-CTO, 64x, 69x, 6Tx, 6Ux, 6Vx, 72x, 7Fx, 8Mx, 8Px, 8Qx, 8Rx, 94x, CFx, CGx, CKx, D5x, D7x, D9x, DCx, DEx...
Page 161 15.4-in. WSXGA+ TFT Table 44. Parts list—15.4-in. WSXGA+ TFT FRU no. RoHS LCD cover kit with IBM logo 42W3652 v 6457-CTO, 44x, 4Bx, 4Cx, 4Lx, 4Tx, 4Ux, 4Wx, 4Xx, 4Zx, 6Nx, 6Px, 7Lx, 8Lx (for xxB, xxC, xxH, xxV) v 6458-CTO, 4Ux, 6Qx (for xxB, xxC, xxH, xxV) v 6459-CTO, 48x, 4Ax, 4Mx, 8Dx, 8Ex v 6460-CTO, 46x, 4Nx, 4Px, 4Qx, 4Rx, 65x, 66x, 68x, 6Ax, 6Cx, 6Wx, 6Zx, 73x, 75x, 7Ex, 7Gx, 7Jx, 8Nx, 8Sx...
Page 162 Table 44. Parts list—15.4-in. WSXGA+ TFT (continued) FRU no. RoHS Wireless LAN/WAN antenna assembly 93P4516 v 6457-CTO, 6Gx, 6Hx, 6Jx, 6Kx, 7Ax, 7Bx, 7Lx, 7Mx, 7Px, 7Rx, 7Tx, 7Yx, 85x, 8Fx, 8Hx, 95x, 98x, B7x, BAx, BBx, BFx, BHx, BJx, CSx, CUx, CWx, CYx v 6458-CTO v 6459-CTO v 6460-CTO, 46x, 4Nx, 4Rx, 66x, 68x, 73x, 75x, 7Gx, 7Jx,...
Page 163 Table 44. Parts list—15.4-in. WSXGA+ TFT (continued) FRU no. RoHS Bluetooth daughter card (BDC-2) 39T0497 v 6457-CTO, 42x, 44x, 45x, 47x, 49x, 4Bx, 4Cx, 4Hx, 4Jx, 4Lx, 4Tx, 4Ux, 4Wx, 4Xx, 6Dx, 6Fx, 6Gx, 6Nx, 6Px, 78x, 79x, 7Ax, 7Bx, 7Lx, 7Mx, 7Px, 7Qx, 7Rx, 7Sx, 7Tx, 7Yx, 82x, 85x, 87x, 8Fx, 8Gx, 8Hx, 8Kx, 8Lx, 95x, 96x, 97x, 98x, B7x, BAx, BBx, BFx, BHx, BJx, BKx, CSx, CUx, CWx, CYx, DYx, DSx, E2x, E3x...
Page 164 15.4-in. WUXGA TFT Table 45. Parts list—15.4-in. WUXGA TFT FRU no. RoHS LCD cover kit with IBM logo 42W3652 v 6457-CTO, 57x, 58x, 5Ex, 5Kx, 7Lx, 7Ux, 7Vx, 7Wx, 88x, 89x (for xxB, xxC, xxH, xxV) v 6458-CTO, 5Kx (for xxB, xxC, xxH, xxV) v 6459-CTO, 5Bx, 5Dx, 5Jx, 8Ax v 6460-CTO, 5Hx, 67x, 6Bx, 6Xx, 6Yx, 74x, 7Hx, 8Bx, 8Cx, 8Tx, 8Ux, 8Vx, 8Wx, 8Xx...
Page 165 Table 45. Parts list—15.4-in. WUXGA TFT (continued) FRU no. RoHS Wireless LAN/WAN antenna assembly 93P4516 v 6457-CTO, 5Gx, 6Hx, 6Kx, 7Zx, 84x, 86x, 88x, 89x, 8Jx, BLx, BPx, BQx, BXx, BYx, BZx, CTx, CXx v 6458-CTO, BNx v 6459-CTO, 55x v 6460-CTO, 8Wx, 8Yx, CJx, CMx, D8x v 6461-CTO v 6462-CTO...
Page 166 Table 45. Parts list—15.4-in. WUXGA TFT (continued) FRU no. RoHS Bluetooth daughter card (BDC-2) 39T0497 v 6457-CTO, 52x, 54x, 57x, 58x, 5Cx, 5Ex, 5Fx, 5Gx, 5Kx, 6Hx, 6Kx, 6Lx, 7Cx, 7Dx, 7Vx, 7Wx, 7Xx, 7Zx, 83x, 84x, 86x, 88x, 89x, 8Jx, BLx, BPx, BQx, BXx, BYx, BZx, CTx, CXx v 6458-CTO, 5Kx, BNx v 6459-CTO, 55x, 5Bx, 5Dx, 5Jx, 8Ax, CBx, CCx, CDx,...
Page 167: Keyboard
Keyboard Language RoHS (ALPS) (Chicony) (NMB) Arabic 42T3212 42T3276 42T3146 Belgian 42T3213 42T3277 42T3147 Brazilian Portuguese 42T3240 42T3304 42T3174 Canadian French (058) 42T3211 42T3275 42T3145 Canadian French (Acnor) 42T3210 42T3274 42T3144 Czech 42T3214 42T3278 42T3148 Danish 42T3215 42T3279 42T3149 Dutch 42T3223 42T3287 42T3157...
Page 168: Miscellaneous Parts
Miscellaneous parts Table 46. Parts list—Miscellaneous parts RoHS Screw kit (including nylon-coated screws): 42X4676 v M2 × 4 mm (black), bind head (17) v M2 × 2.7 mm (black), flat head (2) v M2 × 2.8 mm (silver), flat head (14) v M2 ×...
Page 169: Ac Adapters
Table 46. Parts list—Miscellaneous parts (continued) RoHS System board miscellaneous parts: 42W3641 v Insulation sheet, docking v Insulation sheet, front louver v Insulation sheet, PC Card slot v Insulation sheet, front top v Insulation sheet, bottom CPU v Shield sheet for DC v Insulation sheet, NB v Insulation sheet for video v Insulation under 4-in-1...
Page 170: Power Cords
Power cords A ThinkPad power cord for a specific country or region is usually available only in that country or region: Table 48. Parts list—2-pin power cords Region RoHS (Longwell) (Volex) Argentina 42T5020 42T5105 v models -CTO, xxY Brazil 42T5180 42T5183 v models -CTO, xxP Canada, U.S.
Page 171: Recovery Discs
Recovery discs Windows XP Professional CDs Windows XP Professional is preinstalled as the operating system in the following models: v 6457-CTO, 42x, 49x, 4Dx, 52x, 54x, 5Cx, 6Nx, 6Px, 7Qx, 7Sx, 82x, 87x, 8Gx, 8Kx, CVx, CWx, CXx, CYx, E3x v 6458-CTO v 6459-CTO, 4Ax, 5Dx v 6460-CTO, 6Ux, 6Vx, 6Wx, 6Yx, 7Ex, 8Qx, 8Rx, 8Sx, 8Ux, 8Vx, 8Zx, D9x, DAx,...
Page 172 Table 50. Parts list—Windows XP Professional recovery CDs Language RoHS Arabic 43T8176 Brazilian Portuguese 43T8165 Czech 43T8172 Danish 43T8170 Dutch 43T8171 Finnish 43T8173 French 43T8161 German 43T8162 Greek 43T8180 Hebrew 43T8174 Hungarian 43T8179 Italian 43T8166 Japanese 43T8167 Korean 43T8184 Norwegian 43T8168 Polish 43T8175...
Page 173 Windows Vista Home Basic (32 bit) DVDs Windows Vista Home Basic (32 bit) is preinstalled as the operating system in the following models: v 6457-CTO v 6458-CTO v 6459-CTO v 6460-CTO v 6461-CTO v 6462-CTO v 6463-CTO v 6464-CTO v 6465-CTO, 44x, 45x v 6466-CTO v 6467-CTO v 6468-CTO...
Page 174 Windows Vista Home Premium (32 bit) DVDs Windows Vista Home Premium (32 bit) is preinstalled as the operating system in the following models: v 6457-CTO, 6Hx, 6Kx v 6458-CTO v 6459-CTO, 4Mx, 8Ex, C8x, DKx v 6460-CTO v 6461-CTO v 6462-CTO v 6463-CTO v 6464-CTO v 6465-CTO, 9Qx...
Page 175 Table 52. Parts list—Windows Vista Home Premium (32 bit) DVDs Language RoHS Brazilian Portuguese 44Y2496 Czech 44Y2503 Danish 44Y2501 Dutch 44Y2502 Finnish 44Y2504 French 44Y2493 German 44Y2494 Greek 44Y2509 Hebrew 44Y2515 Hungarian 44Y2508 Italian 44Y2497 Japanese 44Y2498 Korean 44Y2513 Norwegian 44Y2499 Polish 44Y2505...
Page 176 Windows Vista Business (32 bit) DVDs Windows Vista Business (32 bit) is preinstalled as the operating system in the following models: v 6457-CTO, 4Jx, 4Ux, 4Wx, 4Xx, 4Zx, 5Px, 76x, 77x, 78x, 79x, 7Ax, 7Bx, 7Kx, 7Lx, 7Mx, 7Px, 7Rx, 7Tx, 7Ux, 7Yx, 7Zx, 84x, 85x, 86x, 88x, 8Fx, 8Hx, 8Jx, 95x, 96x, B3x, B5x, B6x, BAx, BBx, BEx, BFx, BGx, BHx, CRx, CSx, CUx, DSx, DZx, E2x v 6458-CTO, 4Jx, 4Ux, 6Qx, B8x v 6459-CTO, 5Jx, C9x, CAx...
Page 177 Table 53. Parts list—Windows Vista Business (32 bit) DVDs Language RoHS Brazilian Portuguese 44Y2467 Czech 44Y2474 Danish 44Y2472 Dutch 44Y2473 Finnish 44Y2475 French 44Y2464 German 44Y2465 Greek 44Y2480 Hungarian 44Y2479 Italian 44Y2468 Japanese 44Y2469 Korean 44Y2484 Norwegian 44Y2470 Polish 44Y2476 Portuguese 44Y2487 Romanian...
Page 178 Windows Vista Business (64 bit) DVDs Windows Vista Business (64 bit) is preinstalled as the operating system in the following models: v 6457-CTO, 44x, 45x, 47x, 4Bx, 4Hx, 4Lx, 4Sx, 4Tx, 5Mx, 5Nx, 5Qx, 5Rx, 5Sx, 6Ex, 6Fx, 6Gx, 6Jx, 98x, B7x, BKx v 6458-CTO, B9x, BMx v 6459-CTO, 48x, 55x, 8Dx v 6460-CTO, 46x, 4Nx, 4Px, 68x, 75x, 8Cx, 8Xx...
Page 179 Windows Vista Ultimate (32 bit) DVDs Windows Vista Ultimate (32 bit) is preinstalled as the operating system in the following models: v 6457-CTO, 4Cx, 57x, 58x, 5Ex, 5Fx, 5Gx, 5Kx, 6Dx, 6Lx, 7Cx, 7Dx, 7Vx, 7Wx, 7Xx, 83x, 89x, 8Lx, BJx, BLx, BPx, BQx, BXx, BYx, BZx, CTx v 6458-CTO, 5Kx, BNx v 6459-CTO, 5Bx, 8Ax, CBx, CCx, CDx, CEx, DLx v 6460-CTO, 5Hx, 67x, 6Xx, 74x, 7Jx, 7Hx, 8Bx, 8Tx, 8Yx, CJx, CMx, D8x...
Page 180: Common Service Tools
USB floppy diskette drive tool kit 27L3452 Test card for integrated Smart Card 42W7820 ThinkPad Hardware Maintenance Diskette Version 1.73 or later — Note: Download the file from the following Web site: http://www.lenovo.com/ ThinkPad T61 and T61p (15.4-inch widescreen) Hardware Maintenance Manual...
Page 181: Notices
Lenovo representative for information on the products and services currently available in your area. Any reference to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo product, program, or service may be used. Any functionally equivalent product, program, or service that does not infringe any Lenovo intellectual property right may be used instead.
Page 182: Trademarks
Trademarks The following terms are trademarks of Lenovo in the United States, other countries or both: Lenovo Active Protection System Rescue and Recovery ThinkLight ThinkPad ThinkVantage TrackPoint Ultrabay Ultrabay 2000 Ultrabay Plus UltraNav The following terms are trademarks of the International Business Machines Corporation in the United States,...
Page 184 (1P) P/N: 42X3546_04...

This manual is also suitable for:

Thinkpad t61 Thinkpad t61p 64584uu - thinkpad t61 6458 64586qu - thinkpad t61 6458 6460efu - thinkpad t61 6460 646502u - thinkpad t61 6465 ... Show all

Lenovo 6457 - ThinkPad T61 - Core 2 Duo 2.5 GHz Hardware Maintenance Manual

About this Manual

Safety Information

Important Service Information

General Checkout

Related Service Information

Thinkpad T61 and T61P (15.4-Inch Widescreen)

2030 Bluetooth Daughter Card (BDC-2)

Notices

Quick Links

Related Manuals for Lenovo 6457 - ThinkPad T61 - Core 2 Duo 2.5 GHz

Summary of Contents for Lenovo 6457 - ThinkPad T61 - Core 2 Duo 2.5 GHz

This manual is also suitable for:

Table of Contents