The ( ) SRS (SOUND RETRIEVAL SYSTEM) is manu- Antenna factured by Sony Corporation under license from SRS 75 ohm external terminal for VHF/UHF Labs, Inc. It is covered by U.S. Patent No. 4,748,669. Other U.S. and foreign patents pending.
SECURITE DU FONCTIONNEMENT. NE LES REMPLACER QUE PAR DES OPERATION. REPLACE THESE COMPONENTS WITH COMPOSANTS SONY DONT LE NUMERO DE PIECE EST INDIQUE DANS SONY PARTS WHOSE PART NUMBERS APPEAR AS LE PRESENT MANUEL OU DANS DES SUPPLEMENTS PUBLIES PAR SHOWN IN THIS MANUAL OR IN SUPPLEMENTS SONY.
Page 5
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 2. DISPLAY OF STANDBY/TIMER LIGHT FLASH COUNT 2 times 4 times 5 times Lamp ON 0.3 sec. Lamp OFF STANDBY/SLEEP lamp Lamp OFF 0.3 sec. 3 sec.
Page 6
6. SELF-DIAGNOSTIC CIRCUIT IC301 IC541 IC001 IC003 Y/CHROMA JUNGLE V.OUT SYSTEM MEMORY FROM IO-BDAT B-DAT IK IN 17 I-PROT FROM IC521 HP/PROTECT PIN 7 O-LED SDAT +B overcurrent (OCP) Occurs when an overcurrent on the +B(115V) line is detected by pin 18 of IC301. If the voltage to pin 18 of IC301 is less than 1V when V.SYNC is more than seven verticals in a period, the unit will automatically turn off.
KV-27S40 / 27S45 / 27S65 / 29SL40 / 29SL40A / 29SL40C/ 29SL45 / 29SL65 / 29SL65C/ 29XL40M / 29XL40P / 29XT11A SAFETY CHECK-OUT After correcting the original service problem, perform the LEAKAGE TEST following safety checks before releasing the set to the The AC leakage from any exposed metal part to earth ground customer: and from all exposed metal parts to any exposed metal part having...
KV-27S40 / 27S45 / 27S65 / 29SL40 / 29SL40A / 29SL40C/ 29SL45 / 29SL65 / 29SL65C/ 29XL40M / 29XL40P / 29XT11A SECTION 1 GENERAL The instructions mentioned here are partial abstracts from the Operating Instruction Manual. The page numbers shown reflect those of the Operating Instruction Manual. Connecting and Installing the TV Making Connections Refer to the table below, it will direct you to the diagram suitable to the components you will be...
(Rear of TV) and normal (CATV) channels by pressing ANT on your remote control. scrambled TO CONVERTER channels Notes • Your Sony remote control can be programmed to operate your cable box. 75-ohm coaxial (signal) cable (not supplied) (see page 28) VHF/UHF •...
Page 10
KV-27S40 / 27S45 / 27S65 / 29SL40 / 29SL40A / 29SL40C/ 29SL45 / 29SL65 / 29SL65C/ 29XL40M / 29XL40P / 29XT11A Connecting and Installing the TV (continued) Disconnect all power sources before making any connections. DBS Connections For optimum picture quality, use S VIDEO (Rear of TV) Connecting a DBS (Direct instead of the yellow A/V cable.
KV-27S40 / 27S45 / 27S65 / 29SL40 / 29SL40A / 29SL40C/ 29SL45 / 29SL65 / 29SL65C/ 29XL40M / 29XL40P / 29XT11A Connecting and Installing the TV (continued) Disconnect all power sources before making any connections. Additional Connections For optimum picture quality, use S VIDEO The following connections are for accessories (Rear of TV) instead of the yellow A/V cable.
KV-27S40 / 27S45 / 27S65 / 29SL40 / 29SL40A / 29SL40C/ 29SL45 / 29SL65 / 29SL65C/ 29XL40M / 29XL40P / 29XT11A Basic Set up Inserting batteries Using the remote control, On-Screen Help/Instructions Move & Select buttons Insert two size AA (R6) batteries (supplied) by Several menu windows will provide prompts matching the + and –...
KV-27S40 / 27S45 / 27S65 / 29SL40 / 29SL40A / 29SL40C/ 29SL45 / 29SL65 / 29SL65C/ 29XL40M / 29XL40P / 29XT11A Using your New TV (continued) Watching the TV REFER TO THE ILLUSTRATION OF THE All of the TV features can be accessed via the REMOTE CONTROL ON THE remote control.
Page 14
KV-27S40 / 27S45 / 27S65 / 29SL40 / 29SL40A / 29SL40C/ 29SL45 / 29SL65 / 29SL65C/ 29XL40M / 29XL40P / 29XT11A Using your New TV (continued) Watching two programs at The sound of the main Input-source mode one time - PIP picture is received.
KV-27S40 / 27S45 / 27S65 / 29SL40 / 29SL40A / 29SL40C/ 29SL45 / 29SL65 / 29SL65C/ 29XL40M / 29XL40P / 29XT11A Using your Menus Press V or v to move to the desired option. Press V or v to make your selection and Learning menu selection press SET UP...
KV-27S40 / 27S45 / 27S65 / 29SL40 / 29SL40A / 29SL40C/ 29SL45 / 29SL65 / 29SL65C/ 29XL40M / 29XL40P / 29XT11A Using your Menus (continued) Using the AUDIO menu TREBLE Adjust left or right to decrease or increase higher pitched sound BASS Adjust left or right to decrease or increase low pitched sounds.
KV-27S40 / 27S45 / 27S65 / 29SL40 / 29SL40A / 29SL40C/ 29SL45 / 29SL65 / 29SL65C/ 29XL40M / 29XL40P / 29XT11A Using your Menus (continued) Using the TIMER menu Spring: Select YES to compensate for Daylight Saving Time. DAYLIGHT The current time automatically moves one hour ahead. SAVING TIMERŁ...
Page 18
KV-27S40 / 27S45 / 27S65 / 29SL40 / 29SL40A / 29SL40C/ 29SL45 / 29SL65 / 29SL65C/ 29XL40M / 29XL40P / 29XT11A Using your Menus (continued) Using the SET UP menu CHANNEL CAPTION: You will be able to label up to 12 CHANNEL CHANNEL CAPTIONŁ...
In this case, please use the Aiwa 338, 344 equipment’s own remote control. Broksonic 319, 317 • The code numbers for Sony VCR's are assigned at the Canon 309, 308 Operating a VCR Buttons on the factory as follows:...
• Ensure that you have set your VCR correctly. (see page 7) (KV-27S45, 27V45) • VCR may not be turned on. • Call your local Sony service center. A red light keeps flashing on the • Your TV may need service.
Page 21
• Check your CHANNEL FIX channel be correct. settings. (see page 23) If, after reading these operating instructions, you have additional questions related to the use of your Sony television, please call our Direct Response Center at 1-800-222-SONY (7669). — —...
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 2-5. PICTURE TUBE REMOVAL WARNING: BEFORE REMOVING ANODE CAP H.V. remains in the CRT even after the power is disconnected. Discharge CRT before attempting to remove the anode cap to avoid electrical shock. Short between anode and CRT coating earth ground strap.
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 SECTION 3 SET-UP ADJUSTMENTS Perform the adjustments in order as follows: The following adjustments should be made when a complete realignment is required or a new picture Beam Landing tube is installed.
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 3-2. CONVERGENCE If the blue dot does not converge with red and green dots, perform the following steps: Preparation: • Move BMC magnet (a) to correct insufficient H. Static convergence.
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 (3) Screen-corner Convergence 3-5. METHOD OF SETTING THE SERVICE ADJUSTMENT MODE (1) SERVICE MODE PROCEDURE Standby mode. (Power off) on the Remote Commander. (Press each button within a second.) Fig.
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 SECTION 4 SAFETY RELATED ADJUSTMENTS BOARD R584 CONFIRMATION METHOD (HV HOLD-DOWN CONFIRMATION) AND READJUSTMENTS The following adjustments should always be performed when Hold-down Readjustment replacing the following components which are marked with ] on the schematic diagram: If the current setting indicated in step 2-2 cannot be met, readjustment should be performed by altering the...
Page 28
DIGITAL MULTIMETER TP600 C574 R582 [A BOARD] T504 ABL 11 AMMETER DIGITAL POWER 3mA dc range MULTIMETER SUPPLY 1SS119 Figure 1.0 — 24 — — 28 —...
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 SECTION 5 CIRCUIT ADJUSTMENTS 5-1. ELECTRICAL ADJUSTMENT BY REMOTE COMMANDER 7. Press then on the Remote Commander to Use Remote Commander (RM-Y167) to perform circuit initialize.
Page 30
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 (4) Item of Adjustments INITIAL DATA DATA AVERAGE ITEM FUNCTION RANGE NTSC PAL-M PAL-N VIDEO DATA HSIZ HORIZONTAL AMP. ADJ. 0-63 HPOS HORIZONTAL POS. ADJ. 0-63 VBOW VRT LINE BOWING ADJ.
Page 31
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 INITIAL DATA DATA AVERAGE ITEM FUNCTION RANGE NTSC PAL-M PAL-N VIDEO DATA FIFR FIELD FREQUENCY SBAL SUB BALANCE 0-31 DISP OSD POSITION 0-127 PADJ POWER ADJUSTMENT 0-63 PSHP PIP SUB SHARPNESS...
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 (5) Feature ID Map 2 7 V 4 0 (US) 2 7 V 4 0 (CND) 2 7 V 4 5 (US) 2 7 V 4 5 (CND) 2 7 V 6 5 (US)
Page 33
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 V. CENTER ADJUSTMENT (VPOS) DISPLAY POSITION ADJUSTMENT (DISP) 1.Input a cross-hatch signal. 1. Input a color-bar signal. 2.Set to Service adjustment Mode. 2. Set to Service adjustment Mode. 3.Select VPOS with 3.
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 SECTION 7 EXPLODED VIEWS • Items with no part number and no • The component parts of an assembly • Items marked " " are not stocked description are not stocked because are indicated by the reference numbers in since they are seldom required for routine...
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 Note: Note: The components identified with gray shading and a critical Les composants identifies per un trame et une marque ¡ ¡ ¡ ¡ ¡ sont critiques pout la securite. Ne les remplacer que symbol ( ¡...
KV-27V40 / 27V45 / 27V65 / 29VL40 / 29VL65A / 29VL65C / 29VL85 / 29VL95 • Items with no part number and no • The component parts of an assembly • Items marked " " are not stocked description are not stocked because are indicated by the reference numbers in since they are seldom required for routine they are seldom required for routine service...
COMMON PARTS LISTING SECTION 8 ELECTRICAL PARTS LIST REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK PARTS LISTING TABLE OF CONTENTS Page A BOARD COMMON PARTS LIST: Parts common to all models listed in this manual............61 A BOARD VARIANT PARTS LIST: Parts that belong only to the model specified............
SECTION 7 COMMON PARTS LISTING ELECTRICAL PARTS LIST The components identified by [ in this manual RESISTORS Note: have been carefully factory-selected for each • All resistors are in ohms set in order to satisfy regulations regarding X- REF.NO. PART NO. DESCRIPTION REMARK REF.NO.
Page 47
Note: Note: The components identified Les composants identifies per un trame et une marque ¡ ¡ ¡ ¡ ¡ sont with shading and a critical symbol ( ¡ ¡ ¡ ¡ ¡ ) are critical for critiques pout la securite. Ne les COMMON PARTS LISTING safety.
Page 48
Note: Note: The components identified Les composants identifies per un trame et une marque ¡ ¡ ¡ ¡ ¡ sont with shading and a critical COMMON PARTS LISTING symbol ( ¡ ¡ ¡ ¡ ¡ ) are critical for critiques pout la securite. Ne les safety.
Page 49
Note: Note: The components identified Les composants identifies per un trame et une marque ¡ ¡ ¡ ¡ ¡ sont with shading and a critical symbol ( ¡ ¡ ¡ ¡ ¡ ) are critical for critiques pout la securite. Ne les COMMON PARTS LISTING safety.
Page 50
COMMON PARTS LISTING REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK Q601 8-729-119-78 TRANSISTOR 2SC2785-HFE TRANSISTOR Q604 8-729-119-78 TRANSISTOR 2SC2785-HFE Q608 VARIANT (SEE VARIANT PARTS LIST) Q001 8-729-216-22 TRANSISTOR 2SA1162-G Q650 8-729-111-55 TRANSISTOR 2SD1312-K Q002 8-729-422-27 TRANSISTOR 2SD601A-Q Q670 8-729-140-96 TRANSISTOR 2SD774-34 Q080...
Page 52
COMMON PARTS LISTING REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R277 1-216-295-91 SHORT R331 1-216-025-91 RES, CHIP 1/10W R333 1-216-049-91 RES, CHIP 1/10W R278 VARIANT (SEE VARIANT PARTS LIST) R334 VARIANT (SEE VARIANT PARTS LIST) R279 1-249-425-11 CARBON 4.7K 1/4W R280...
Page 53
Note: Note: The components identified by in this The components identified manual have been carefully factory-selected with shading and a critical for each set in order to satisfy regulations re- symbol ( ¡ ¡ ¡ ¡ ¡ ) are critical for COMMON PARTS LISTING garding X-ray radiation.
Page 54
Note: Note: The components identified Les composants identifies per un trame et une marque ¡ ¡ ¡ ¡ ¡ sont with shading and a critical symbol ( ¡ ¡ ¡ ¡ ¡ ) are critical for COMMON PARTS LISTING critiques pout la securite. Ne les safety.
BOARD VARIANT PARTS LIST The parts on this page belong to the following model(s) only: KV-27V40/29VL40 REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK COIL A BOARD VARIANT LIST: 27V40/29VL40 L350 1-412-029-11 INDUCTOR 10UH L351 1-412-029-11 INDUCTOR 10UH CAPACITOR C307 1-126-964-11 ELECT...
Page 56
BOARD VARIANT PARTS LIST Note: Note: The components identified Les composants identifies per The parts on this page belong to the following model(s) only: un trame et une marque ¡ ¡ ¡ ¡ ¡ sont with shading and a critical symbol ( ¡...
BOARD VARIANT PARTS LIST The parts on this page belong to the following model(s) only: KV-27V65/29VL95 REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK A BOARD VARIANT LIST: KV-27V65/29VL95 IC010 8-759-710-85 IC NJM2233BD CAPACITOR IC301 8-752-083-09 IC CXA2061S C200 1-126-959-11 ELECT 0.47MF...
Page 58
BOARD VARIANT PARTS LIST Note: Note: The components identified Les composants identifies per The parts on this page belong to the following model(s) only: un trame et une marque ¡ ¡ ¡ ¡ ¡ sont with shading and a critical symbol ( ¡...
BOARD VARIANT PARTS LIST Note: Note: The components identified Les composants identifies per The parts on this page belong to the following model(s) only: un trame et une marque ¡ ¡ ¡ ¡ ¡ sont with shading and a critical symbol ( ¡...
BOARD VARIANT PARTS LIST The parts on this page belong to the following model(s) only: KV-27V45/29VL85 REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK JACK A BOARD VARIANT LIST: KV-27V45/29VL85 J202 1-774-749-11 JACK BLOCK, PIN CAPACITOR C200 1-126-959-11 ELECT 0.47MF COIL C307...
BOARD VARIANT PARTS LIST Note: Note: The components identified Les composants identifies per The parts on this page belong to the following model(s) only: un trame et une marque ¡ ¡ ¡ ¡ ¡ sont with shading and a critical symbol ( ¡...
BOARD VARIANT PARTS LIST The parts on this page belong to the following model(s) only: KV-29VL65C REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK A BOARD VARIANT LIST: KV-29VL65C IC010 8-759-710-85 IC NJM2233BD CAPACITOR IC301 8-752-083-09 IC CXA2061S IC302 8-752-385-80 IC CXD2073S C200...
Page 63
BOARD VARIANT PARTS LIST The parts on this page belong to the following model(s) only: KV-29VL65C REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK THERMISTOR R320 1-247-807-31 CARBON 1/4W R321 1-216-025-91 RES, CHIP 1/10W THP601 1-809-827-11 THERMISTOR POSITIVE R322 1-216-025-91 RES, CHIP 1/10W...
BOARD VARIANT PARTS LIST Note: Note: The components identified Les composants identifies per The parts on this page belong to the following model(s) only: COMPLETE PARTS LISTING un trame et une marque ¡ ¡ ¡ ¡ ¡ sont with shading and a critical symbol ( ¡...
BOARD VARIANT PARTS LIST Note: Note: CV E The components identified Les composants identifies per The parts on this page belong to the following model(s) only: COMPLETE PARTS LISTING un trame et une marque ¡ ¡ ¡ ¡ ¡ sont with shading and a critical symbol ( ¡...
BOARD VARIANT PARTS LIST The parts on this page belong to the following model(s) only: COMPLETE PARTS LISTING REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK CONNECTOR CN1405 1-564-510-11 PLUG, CONNECTOR 7P CN1406* 1-564-506-11 PLUG, CONNECTOR 3P * A-1372-479-A HV BOARD, COMPLETE CN2001* 1-564-506-11 PLUG, CONNECTOR 3P (All Models) CN2200* 1-564-514-11 PLUG, CONNECTOR 11P...
BOARD VARIANT PARTS LIST Note: Note: HV HZ The components identified Les composants identifies per COMPLETE PARTS LISTING The parts on this page belong to the following model(s) only: un trame et une marque ¡ ¡ ¡ ¡ ¡ sont with shading and a critical symbol ( ¡...
Note: BOARD VARIANT PARTS LIST Note: The components identified Les composants identifies per The parts on this page belong to the following model(s) only: un trame et une marque ¡ ¡ ¡ ¡ ¡ sont COMPLETE PARTS LISTING with shading and a critical symbol ( ¡...
BOARD VARIANT PARTS LIST The parts on this page belong to the following model(s) only: COMPLETE PARTS LISTING REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK C3368 1-164-005-11 CERAMIC CHIP 0.47MF C3369 1-163-251-11 CERAMIC CHIP 100PF C3370 1-164-346-11 CERAMIC CHIP C3371 1-163-017-00 CERAMIC CHIP 0.0047MF...
Page 70
BOARD VARIANT PARTS LIST COMPLETE PARTS LISTING The parts on this page belong to the following model(s) only: REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK R3335 1-216-295-91 SHORT CRYSTAL R3337 1-216-033-00 RES, CHIP 1/10W R3338 1-216-033-00 RES, CHIP 1/10W X3302 1-760-095-21 VIBRATOR, CRYSTAL...
BOARD VARIANT PARTS LIST The parts on this page belong to the following model(s) only: ACCESSORIES AND PACKING MATERIALS REF.NO. PART NO. DESCRIPTION REMARK REF.NO. PART NO. DESCRIPTION REMARK KV-27V40/29VL40 KV-27V45/29VL85 ACCESSORIES AND PACKING MATERIALS ACCESSORIES AND PACKING MATERIALS 3-861-907-21 MANUAL INSTRUCTION (KV-27V40) 3-861-907-21 MANUAL INSTRUCTION (KV-27V45) 3-861-918-41 MANUAL INSTRUCTION (KV-29VL40) 3-861-918-41 MANUAL INSTRUCTION (KV-29VL85)