........Parts Ordering ..... Sack Cover LIMITED TWO YEAR WARRANTY ON CRAFTSMAN POWER MOWER For two years from date of purchase, when this Craftsman Lawn Mower is maintained, lubricated, and tuned up according to the operating and maintenance instructions the owner's manual, Sears will repair free of charge any defect in material or workman- ship.
Page 3
themower orunclogging thechute, • Be alert and turn machine off if children • Shut theengine ( motor) offandwait enter the area. until t heblade comes t ocomplete stop • Before and while walking backwards, before removing grass catcher. look behind and down for small •...
Page 4
_WARNING: Engine exhaust, some of its _l,Look for this symbol to point out constituents, and certain vehicle compo- important safety precautions. It means CAUTION!!! BECOMEALERT!!! YOUR nents contain or emit chemicals known to SAFETY IS INVOLVED. the State of California to cause cancer CAUTION: In order to prevent and birth defects or other reproductive...
Page 5
Read these instructions and this manual HOW TO SET UP YOUR LAWN in its entirety before you attempt to MOWER assemble or operate your new lawn TO UNFOLD HANDLE mower. IMPORTANT: Unfold handle carefully so IMPORTANT: This lawn mower is shipped WITHOUT OIL OR GASOLINE in the as not to pinch or damage control cables.
KNOWYOUR LAWN MOWER READ THIS OWNER'S MANUALAND SAFETY R ULES B EFORE OPERATING YOUR LAWN MOWER. Compare theillustrations withyourlawn mower tofamiliarize yourself withthelocation o fvarious c ontrols a ndadjustments, Save thismanual forfuture reference, These symbols may appear onyourlawn mower o rinliterature s upplied w iththe product.
Page 7
The operation of Lower Wheels any lawn mower can result in foreign for HighCut objects thrown into the _i_/ Wheel eyes, which can result in adjuster __'_i severe eye damage. Always wear safety glasses or eye lever shields while operating your lawn mower or performing any adjustments or repairs.
COMBI-CUT MOWERS TO CONVERT MOWER Your lawn mower was shippedready to Open be used as a mulcher. Toconvertto mulcher door bagging or discharging: REAR BAGGING • Open rear door and remove mulcher plug. Store mulcher plug in a safe Discharge deflector place.
Page 9
BEFORE STARTING E NGINE ADD OIL Your Engine oil cap l awnmower is shipped without oil in Gasoline the engine. Engine holds 20 oz. of oil. filler cap For type and grade of oil to use, see "ENGINE" in Maintenance section of this manual.
MOWING TIPS MULCHING MOWING TIPS • Under certain conditions, such as very IMPORTANT: For best performance, tall grass, it may be necessary to raise keep mower housing free of built-up the height of cut to reduce pushing grass and trash. See "Cleaning" in effort and to keep from overloading the MAINTENANCE section of this manual.
Page 11
MA,NTE.A.CESO.EDULE FILL 'N DATES REGULAR SERVICE J__O,_,_//._,'_._ I" SERVICE DATES Check for Loose Fasteners Clean/Inspect Grass Catcher (If Equipped) I1 / Clean Lawn Mower (Power-Propelled Mowers) Clean Under Drive Cover Check drive bell/pulleys (Power-Propelled Mowers) Check/Sharpen/Replace Blade Lubrication Chart Clean Battery/Rechar tElectric Start Mowers ! E Check Engine Oil Level Change Engine Oil...
PRODUCT SPECIFICATIONS SERIAL NUMBER DATE OF PURCHASE GASOLINE CAPACITY/TYPE: 1.6 QUARTS UNLEADED REGULAR OILTYPE (API-SF-SJ): SAE 30 (ABOVE 32°F) SAE 5W-30 (BELOW 32°F) OIL CAPACITY: 20 OZS. SPARK PLUG(GAP: .030") CHAMPION RJ19LM OR J19LM VALVE CLEARANCE: INTAKE: .004 - .008 EXHAUST: .004 - .008 BLADE BOLT TORQUE:...
Page 13
Blade Crank- Correct Incorrect adapler ._ shaft Wave Hasher Blade Blade _P"b..._S_, Oustcover Hardenbd" ' " \ _/,._,=,,.,,-.- Washer washer Trailing Blade keyway edge adapter GRASS CATCHER "Hubcap • The grass catcher may be hosed with ENGINE water, but must be dry when used, •...
Page 14
TO CHANGE ENGINE OIL Back NOTE: Before tipping lawn mower to drain oil, drain fuel tank by running Slots engine until fuel tank is empty. 1. Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with spark plug. 2.
Page 15
d_,CAUTION: Before performing any TO ASSEMBLE GRASS CATCHER service or adjustments: 1. Put grass catcher frame into grass bag 1. Release control bar and stop engine. with rigid part of bag on the bottom. 2. Make sure the blade and all moving Make sure the frame handle is outside parts have completely stopped.
Immediately prepare your lawn mower for High storage at the end of the season or if the unit will not be used for 30 days or more. LAWN MOWER When lawn mower is to be stored for a period of time, clean it thoroughly, remove all did, grease, leaves, etc.
OTHER • Cover your unit with a suitable pmtec. • tire cover that does not retain mois- Do not store gasoline from one season ture. Do not use plastic. Plastic cannot to another. breathe which allows condensation • Replace your gasoline can if your can form and will cause your unit to rust.
Page 18
TROUBLESHOOTINGCHART CAUSE CORRECTION PROBLEM 1. Engineflywheelbmkeison 'Starter rope hard 1. Depress control bar to whencontmlbaris ralease¢ topull upper handle before pulling starter rope. 2. Bent engine crankshaft, 2. Contact a qualified service center, 3. Blade adapter broken. 3. Replace blade adapter, 4.
Page 31
Get it fixed, at your home or ours! For repair of major brand appliances in your own home... no matter who made it, no matter who sold it! 1-800"4"MY'HO MEs" Anytime, dayornight (1.800-469-4663) www.sears.com To bring in products such as vacuums, lawn equipment and electronics for repair, call for the location of your nearest Sears Parts &...