Page 1 Conditions of Use: (1) Please use this information only for the purpose of performing repair, maintenance and/or configuration services of the Sony products (hereinafter the “Repair services”) under the service agreement entered into with the Sony group company (hereinafter the “Service agreement”).
Page 2 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 警告このマニュアルは，サービス専用です。お客様が，このマニュアルに記載された設置や保守，点検，修理などを行うと感電や火災，人身事故につながることがあります。危険をさけるため，サービストレーニングを受けた技術者のみご使用ください。 WARNING This manual is intended for qualiﬁed service personnel only. To reduce the risk of electric shock, ﬁre or injury, do not perform any servicing other than that contained in the operating instructions unless you are qualiﬁed to do so.
Page 3 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer FÖRSIKTIGHET! 注意指定以外の電池に交換すると，破裂する危険があります。 Fara för explosion vid felaktigt placerat batteri. Byt endast mot samma eller likvärdig typ av batteri, 必ず指定の電池に交換してください。 enligt tillverkarens rekommendationer. 使用済みの電池は，国または地域の法令に従って När du kasserar batteriet ska du följa rådande lagar 処理してください。...
Page 4 CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU PUBLISHED BY SONY.
Page 5 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer サービス，点検時には次のことにご注意ください。 1. 注意事項をお守りください。無鉛半田についてサービスのとき特に注意を要する個所については，キャ本機には無鉛半田が使用されています。ビネット，シャーシ，部品などにラベルや捺印で注意事無鉛半田を使用している基板には，無鉛（Lead Free）を意味項を表示しています。これらの注意書き及び取扱説明書するレッドフリーマークがプリントされています。等の注意事項を必ずお守り下さい。（注意：基板サイズによっては，無鉛半田を使用していても 2. 指定部品のご使用をレッドフリーマークがプリントされていないものがセットの部品は難燃性や耐電圧など安全上の特性を持っあります）たものとなっています。従って交換部品は，使用されていたものと同じ特性の部品を使用して下さい。特に回路：レッドフリーマーク図，部品表に0印で指定されている安全上重要な部品は無鉛半田は，下記の点に注意して使用してください。必ず指定のものをご使用下さい。 3. 部品の取付けや配線の引きまわしはもとどおりに・半田こてのこて先温度は約350℃に設定してください。安全上，チューブやテープなどの絶縁材料を使用したり温度調節が無理な場合は，高温短時間で作業を行ってくだ，プリント基板から浮かして取付けた部品があります。さい。...
Page 6 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 7 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Model Information Model DSC-RX100M6 Destination UC2, TW6, KR2, J1 CE3, CEH, RU3, E32, IN5, HK1, CN1 Color system NTSC Wi-Fi ✓ ✓ ✓ ✓ DSC-RX100M6 SYS SET...
Page 8 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 9: Table Of Contents
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Table of Contents Model Information Manual Structure Purpose of this manual........................3 Related manuals.
Page 10 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 4-2-6. EVF Assy Section..................... 4-19 4-2-7.
Page 11: Purpose Of This Manual
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Manual Structure Purpose of this manual This manual describes the information items that premise the service based on the components parts assuming use of system and service engineers. Related manuals Besides this manual, the following manuals are available.
Page 12 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 13 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 目次このマニュアルについて本書の目的..........................3 関連マニュアル.
Page 14 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 4-2-9. Lens Block Section....................4-24 4-3.
Page 15: 本書の目的
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer このマニュアルについて本書の目的本書は，システムエンジニアやサービスエンジニアの方々にご使用いただくことを想定し，本機の保守に関する情報，部品レベルまでのサービスを前提とした情報を記載しています。関連マニュアル本機には，この「サービスマニュアル」のほかに，下記のマニュアルが用意されています。 • 取扱説明書（本機に付属） • ヘルプガイド（Web 取扱説明書） Web 上のマニュアル「ヘルプガイド」もご覧ください。パソコンやスマートフォンでご覧いただけます。 • アジャストマニュアル（別途用意）本機の調整および各種動作確認を行うのに必要なサービス用の調整ソフトウェアです。 DSC-RX100M6 SYS SET...
Page 16 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 17: Trouble Shooting
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Section 1 Trouble Shooting 1-1. Self-diagnosis Function 1-1-1. Self-diagnosis Function If an error occurs in this unit, the self-diagnosis function starts working and a code consisting of one alphabet and a four- digit number appears on the LCD. Classification of persons in charge, classification of faulty blocks, and details of errors can be checked by referring to this indication of five alphanumeric characters in the self-diagnosis code table.
Page 18 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Self-diagnosis Code Symptom/State Correction Block Detailed Function Code Zoom operations fault Turn power off and turn power on again. When this error is (Cannot initialize zoom lens) not cleared, operate the zoom lever and check following items.
Page 19 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Self-diagnosis Code Symptom/State Correction Block Detailed Function Code GPS hardware error Check the signal line connection for GPS. When there is no problem with the connections, replace the board that contains this peripheral circuit.
Page 20: Process After Fixing Flash Error
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 1-2. Process after Fixing Flash Error 1-2-1. E:91:01 Flash Error When “FLASH error” (Self-diagnosis Code E:91:01) occurs, to prevent any abnormal situation caused by high voltage, setting of the flash is changed automatically to disabling charge and flash setting.
Page 21: Service Note
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Section 2 Service Note 2-1. Operation Notes 2-1-1. Flexible Board • Make sure that the conductive side of a flexible board does not have any stain or foreign materials. • Do not touch the conductive side of flexible boards with bare hands.
Page 22: Discharging Of The Flash Capacitor
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 2-1-3. Discharging of the Flash Capacitor The charging capacitor for the flash has been charged at high voltage. Therefore, there is a possibility of an electric shock if you directly handle this capacitor. The high-voltage charge will not be discharged by simply turning off the unit’s power. Make sure any remaining voltage is discharged by short-circuiting the flash capacitor with a Short Jig.
Page 23: Precaution On Replacing The Sy-1083 Board
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 2-2. Precaution on Replacing the SY-1083 Board The board for repair is not recorded the information unique to a model. Therefore the following data are needed to write. Note The [LOAD AND WRITE] function in “ADJUSTMENT DATA BACKUP” on the DATA tab in the Adjust Manual overwrites all data of the unit.
Page 24 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Applicable parts: • SY-1083 BOARD, COMPLETE (SERVICE) • MS-1038 BOARD, COMPLETE (SERVICE) Note After the replacement and repair, the MAC address is changed, and thus the re-setting for connection devices is required. Accordingly, download the Flyer of WLAN Reset (Flyer of WLAN Reset_9834752[][].pdf) and print out it, and attach it to the set when returning the set to customer.
Page 25: Notes On Replacing The Lens
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 2-3. Notes on Replacing the Lens When replacing the lens, read the QR code of the repair lens. To read the QR code, start the Adjust manual and press the QR code reader button.
Page 26: Notes On Removing/Installing The Imager Board (Cd-1009 Flexible Board)
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 2-4. Notes on Removing/Installing the Imager Board (CD-1009 Flexible Board) When the CD-1009 Flexible Board (Imager) is mounted to the lens, shift and tilt adjustment is made with Spacer Plates. When removing the CD-1009 Flexible Board, pay attention to the following.
Page 27: Checking The Wi-Fi Function
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 2-5. Checking the Wi-Fi Function After this unit has been disassembled and reassembled, check the Wi-Fi function. Required equipment: Windows PC or smartphone with Wi-Fi interface Procedure: Turn on the power of the unit and enable the Wi-Fi function.
Page 28: Precaution On Replacing The Ms-1038 Board
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 2-6. Precaution on Replacing the MS-1038 Board 2-6-1. Angular Velocity Sensor Before replacing the board with a repairing board, be sure to record the sensitivity indicated on the angular velocity sensor on the repairing board.
Page 29: Adjustment
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Section 3 Adjustment For adjusting these models, the Adjust Station and the Adjust Manual are required. Adjust Station It is the software to start up Adjust Manual for each model. The installer of the Adjust Station and the installation manual are attached, be sure to confirm the contents of them.
Page 30 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 31: トラブルシューティング
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 第 1 章トラブルシューティング 1-1. 自己診断機能 1-1-1. 自己診断機能について本機の動作に不具合が発生した場合，自己診断機能が働き，LCD 画面にアルファベット 1 文字と数字 4 桁が表示され点滅します。この 5 文字の表示を自己診断コード表と対照して，対応者分類，不具合の生じたブロックの分類および不具合の詳細を確認することができます。過去に発生した不具合の履歴は Adjust Manual の DATA タブにある“Usage and Diag record”で確認することができます。自己診断機能については取扱説明書にも掲載されています。 1-1-2. 基板について...
Page 32 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 自己診断コード対症状／状態対応／方法ブロック詳細応機能コード者ズーム動作の異常（ズームレン電源を入れ直す。復帰しない場合，ズームレバーを操ズの初期化ができない）作して以下の確認をする。 • ズーム動作をした場合，レンズブロックのズーム制御系信号の異常が考えられる。 • ズーム動作をしなかった場合，ズームモータ駆動回路の異常が考えられる。症状がレンズ・基板のどちらに起因するか確認し不具合があるものを交換する。ステッパ IRIS イニシャル時リ電源を入れてレンズバリアが開いている状態で，バッセット位置検出異常テリまたは電源ケーブルをはずして付け直す。その...
Page 33 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 自己診断コード対症状／状態対応／方法ブロック詳細応機能コード者地磁気センサハードウェア異常地磁気センサ周辺回路の異常が考えられる。（GPS ハードウェア異常）上記回路を有する基板を交換する。このコードの機能は本機には実装されていません。 DSC-RX100M6 SYS SET...
Page 34: フラッシュエラーの解除方法
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 1-2. フラッシュエラーの解除方法 1-2-1. E：91：01 フラッシュエラー本機はフラッシュエラー（自己診断コード E：91：01）が発生した場合，高電圧による異常を防止するために自動的にフラッシュ充電および発光禁止の設定に切り替わります。フラッシュエラー発生後はエラーの解除を行う必要があります。フラッシュエラーの解除方法： Flash Error Repair Tool Ver_[].[].exe を使用してフラッシュエラーを解除してください。 DSC-RX100M6 SYS SET...
Page 35: サービスノート
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 第 2 章サービスノート 2-1. 作業時の注意 2-1-1. フレキシブル基板 • フレキシブル基板の導電面に汚れやごみなどがないことを確認してください。 • フレキシブル基板の導電面を素手で触れないようにしてください。 • フレキシブル基板は，コネクターの奥までまっすぐに差し込んでください。 (奥までまっすぐに差し込んである) (斜めに差し込んである) (差し込み不十分) フレキシブルフレキシブルフレキシブルフレキシブル基板フレキシブル基板基板基板基板基準線基準線フレキシブル基板基準線コネクター...
Page 36: フラッシュ用充電コンデンサの放電について
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 2-1-3. フラッシュ用充電コンデンサの放電についてフラッシュ用充電コンデンサは非常に高い電圧で充電されています。そのため，フラッシュ用充電用コンデンサに手を触れた場合には, 感電する可能性があります。この高電圧は，本機の電源を切っただけでは放電されません。必ずショート治具をフラッシュ用充電コンデンサに接続して残留電圧を放電してください。ショート治具の準備ショート治具は 1 kΩ/1 W 程度の抵抗器の両端に小型のクリップを接続して作成します。抵抗器は絶縁テープで完全に覆い，感電しないように処理してください。 1 k Ω /1 W 程度の抵抗器 (部品コード:1‑215‑869‑11) 小型クリップ小型クリップ絶縁テープで巻く DSC-RX100M6 SYS SET...
Page 37: Sy-1083 基板交換時の注意
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 2-2. SY-1083 基板交換時の注意補修用基板には機種固有の情報が記録されていないため，下記のデータを書き込む必要があります。注意 Adjust Manual 内の DATA タブにある“ADJUSTMENT DATA BACKUP”の [LOAD AND WRITE] 機能は，セットのすべてのデータを上書きするので，下記の作業を行う前に実施してください。 2-2-1. 仕向データ補修用基板に書き込まれている仕向のデータは交換前の基板に書き込まれている仕向の設定と異なっている場合があります。補修用基板に交換した場合は，必ず仕向の設定を行ってください。仕向設定方法： Adjust Station から Adjust Manual を起動し， ADJUST タブにある“Destination data write”を実施して...
Page 38 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 対象部品： • SY-1083 BOARD, COMPLETE (SERVICE) • MS-1038 BOARD, COMPLETE (SERVICE) 注意交換修理後は MAC アドレスが変更されていますので，お客様に接続機器の再設定をしていただく必要があります。そのため，Flyer of WLAN Reset（Flyer of WLAN Reset_9834752[][].pdf）をダウンロードし，印刷したものを本機と一緒にお客様にお渡しください。 DSC-RX100M6 SYS SET...
Page 39: レンズ交換時の注意
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 2-3. レンズ交換時の注意レンズを交換する際は補修用レンズの QR コードを読み取ってください。 QR コードの読み取りは，Adjust manual を起動して QR コードリーダーボタンより実行してください。読み取ったデータは以下の工程において使用します。 • イメージャ基板取り付け時のあおり板の選択 • 交換終了後の調整時 QRコード 2-3-1. イメージャ基板取り付け時のあおり板の選択 QR コードリーダー画面にて読み込みを実行する。組み込むあおり板の厚みが表示される。画面の指示に合わせてあおり板を選択し，イメージャ基板を取り付ける。 2-3-2. 交換終了後の調整時 Adjust manual の ADJUST タブにある，「Lens data carry」より LOAD を実施してください。...
Page 40: イメージャ基板（Cd-1009 フレキシブル基板）の取り外し／取り付け時の注意
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 2-4. イメージャ基板（CD-1009 フレキシブル基板）の取り外し／取り付け時の注意 CD-1009 フレキシブル基板（イメージャ）は，レンズに取り付ける際，あおり板によりあおり調整されています。 CD-1009 フレキシブル基板を取り外すときは，下記の事に注意して作業してください。レンズを交換しない作業の場合例：分解清掃する場合， CD-1009 フレキシブル基板（イメージャ）を交換する場合など。 • 組み込まれているあおり板（3 箇所）のサイズを確認／記録し，失くさないように保管する。 • 組立時には，あおり板を必ず元通りの位置に取り付ける。 0.xx サイズ注意あおり板を紛失しないように注意してください。あおり板を紛失してしまったり，あおり板の元の位置がわからなくなってしまったときには実写して片ボケがないことの確認を繰り返し，適切なあおり板を選択する必要があります。...
Page 41: Wi-Fi 接続確認
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 2-5. Wi-Fi 接続確認本機の分解・組立を行った後は， Wi-Fi 機能の確認を行ってください。用意する機器： Wi-Fi 接続の可能なパソコンまたはスマートフォンなど手順：本機の電源を入れ，Wi-Fi 機能を有効にする。（Wi-Fi 接続準備が完了すると Wi-Fi 接続のためのパスワードが表示されます。）パソコンまたはスマートフォン側で接続可能な機器として，本機が検出されることを確認する。 DSC-RX100M6 SYS SET...
Page 42: Ms-1038 基板交換時の注意
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 2-6. MS-1038 基板交換時の注意 2-6-1. 角速度センサー補修用基板に交換する場合は，必ず補修用基板の角速度センサーに表記されている感度表示をメモなどに記録してください。記録した感度表示は補修用基板に書き込む必要があります。角速度センサー感度書き込み方法： Adjust Station から Adjust Manual を起動し，ADJUST タブにある“Angular velocity sensor sensitivity adj”を実施してください。注意角速度センサーの感度表示は補修用基板にのみ表記されています。量産用の基板には表記されていません。 DSC-RX100M6 SYS SET...
Page 43: 調整について
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 第 3 章調整についてこれらの機種で調整を行なうには， Adjust Station と Adjust Manual が必要です。 Adjust Station とは機種別の Adjust Manual を起動するためのソフトウェアです。 Adjust Station のインストーラと一緒に，インストレーションマニュアルが付いていますので，内容を必ず確認してください。 Adjust Manual とはデジタルカメラ及びカムコーダのサービス用の調整ソフトウェアで，調整及び各種動作確認を行うことが可能です。 Adjust Manual のインストーラと一緒に，インストレーションマニュアルが付いていますので，内容を必ず確認してください。...
Page 44 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 45: Replacement Of Main Parts
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Section 4 Replacement of Main Parts 4-1. Identifying Parts SY Heat Sink Assy Hinge (LCD) Block Assy SY-1083 Board • LC-1038 Flexible Board Control Switch Block MS-1038 Board (SW63900) BTH Assy • BT-2026 Flexible Board...
Page 46 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer View Position Top View Left View Back View Front View Right View Bottom View DSC-RX100M6 SYS SET...
Page 47: Disassembly
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 4-2. Disassembly 4-2-1. Bottom Cabinet Section • Refer to “Bottom Cabinet Section” on exploded view for Ref. No. SY Board and MS Board Section #368 (M1.4 X 3.0) (0.12 ± 0.01 N·m) Rear Cabinet Section...
Page 48 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Disassembly Places [1]: #352 x 5 → Open the Battery Lid {1} Bottom View #352 [2]: #368 x 2 → #368 x 2 → Tilt the LCD {2} → #247 x 2 Right View...
Page 49: Sy Board And Ms Board Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 4-2-2. SY Board and MS Board Section • Refer to “SY Board and MS Board Section” on exploded view for Ref. No. BTH Assy Section #209 (M1.4 X 3.5) (0.12 ± 0.01 N·m) {9,10}...
Page 50 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Note 2 This screw cannot be reused. Discard the screw removed once in servicing. Instead, use a new screw. このねじは再利用することができません。サービス対応時に一度でも外した場合は新品のねじと交換してください。 Note 3 This part cannot be reused. Discard the part removed once in servicing.
Page 51 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Disassembly Places [3]: Peel off the NFC antenna {1} → Pop up the EVF unit {2} → Disconnect the Flexible boards → Release the Flexible board from the projections → #27 x 1 → Open the ST Flexible board {3}→...
Page 52 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer [4]: #247 x 2 Back View #247 Notes on Assembling the SY Board Block-1 When assembling the SY Board Block, wiring the Flexible Board as follows. Extend the crease of the ST Flexible Board.
Page 53 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Attach the three adhesive sheets. 0.0 mm External form of the lens +0.5 mm +0.5 mm 0.0 mm Sheet LC (Pull Magnet) Adhesive Sheet (FL) (64200) Bending portion of the Interception Sheet (64200) Center of Screw...
Page 54 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Connect the FL Flexible Board to the connector, and make a crease to the ST Flexible Board again. Make a crease to the ST Flexible Boards again. FL Flexible Boards Connecors Notes on Assembling the SY Board Block-2 When assembling the SY Board Block, wiring the Flexible Board as follows.
Page 55 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Attach the FL Flexible Board to the Sheet LC (Pull Magnet). Adhesive Sheet (FL) (64200) Sheet LC (Pull Magnet) Sheet LC (Pull Magnet) Convex shape External form of the lens Boss Convex shape FL Flexible Board Notes on Assembling the RE Protection Sheet Attach the RE Protection Sheet as shown in the figure.
Page 56: Bth Assy Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 4-2-3. BTH Assy Section • Refer to “BTH Assy Section” on exploded view for Ref. No. ST Block Assy Section 106 105 #368 (M1.4 X 3.0) (0.08 ± 0.01 N·m) #189 (M1.4 X 3.5)(Tapping) (0.12 ±...
Page 57 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Notes on Assembling the EVF Block Assy After assembling the EVF Block Assy, check the following. • The gap between the Cabinet (Front) (Upper) and the top of the EVF being equal. • There is no level difference on the top of Cabinet (Front) (Upper) and the top of the EVF.
Page 58: St Block Assy Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 4-2-4. ST Block Assy Section • Refer to “ST Block Assy Section” on exploded view for Ref. No. Front Assy Section #247 (M1.4 X 2.5) (0.12 ± 0.01 N·m) (Note) #209 (M1.4 X 3.5) (M1.4 X 1.4)
Page 59 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Disassembly Places [2]: #97 x 2 Back View [3]: #209 x 2 Back View #209 Notes on Assembling the Flash Unit When assembling the Flash Unit, use the shoehorn jig so that the Flexible Board is not damaged.
Page 60 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Place the shoehorn jig on the bended portion of the Flexible Board. Shoehorn jig Shoehorn jig Flexible Board 22 mm 15 mm Hold the edge and bended portion of the FL Flexible Cable and the shoehorn jig, then insert them between the rib and the wall.
Page 61 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 4-2-5. Front Assy Section • Refer to “Front Assy Section” on exploded view for Ref. No. When assembling, adjust the position. #209 #239 (M1.4 X 3.5) (M1.4 X 1.4) (0.12 ± 0.01 N·m) (0.12 ± 0.01 N·m)
Page 62 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Notes on Assembling the Lens Ring Block Assy When assembling the Lens Ring Block Assy, Cabinet (Front) (Lower) and Cabinet (Front) (Upper), position with two pins and tighten the four screws. Cabinet (Front) (Lower)
Page 63: Evf Assy Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 4-2-6. EVF Assy Section • Refer to “EVF Assy Section” on exploded view for Ref. No. #276 (M1.4 X 3.0)(Tapping) (0.10 ± 0.01 N·m) (M1.4 X 2.0) (0.10 ± 0.01 N·m) C901 #276 (M1.4 X 3.0)(Tapping) #276 (0.10 ±...
Page 64 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Notes on Assembling the EVF Assy Arranging the VF Block Assy VF Block Assy Mountain fold Valley fold Arranging the ST-1044 Flexible Board ST-1044 Flexible Board Mountain fold Valley fold Notes on Assembling the Cover Block Assy When tightening the screw, be careful not to tilt the Cover Block Assy.
Page 65: Rear Cabinet Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 4-2-7. Rear Cabinet Section • Refer to “Rear Cabinet Section” on exploded view for Ref. No. LCD Panel Section #276 (M1.4 X 3.0)(Tapping) (0.12 ± 0.01 N·m) #196 (M1.7 X 2.0) FP-2421 (0.12 ± 0.01 N·m)
Page 66: Lcd Panel Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 4-2-8. LCD Panel Section • Refer to “LCD Panel Section” on exploded view for Ref. No. LCD901 #239 (M1.4 X 1.4) (0.12 ± 0.01 N·m) (Note) (M1.4 X 2.0) (0.12 ± 0.01 N·m) Note This screw cannot be reused.
Page 67 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Notes on Assembling the LC Flexible Retainer (64200) After assembling the LC Flexible Retainer (64200), check that the LC Flexible Retainer (64200) is not on the boss. LC Flexible Retainer (64200) LC Flexible Retainer (64200)
Page 68: Lens Block Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 4-2-9. Lens Block Section • Refer to “Lens Block Section” on exploded view for Ref. No. #305 (M1.4 X 4.0) (1.0 ± 0.10 N·m) #258 (M1.2 X 3.5)(Tapping) (0.50 ± 0.05 N·m) (Note 1)
Page 69 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Note 1 NOTES ON HOLDING THE LENS BLOCK Hold the Lens Block at the Do not hold the following part. center of both sides. G6 lens *Very weak Hold here. Zoom motor, Lens barrier...
Page 70: Lens Block
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 4-3. Lens Block 4-3-1. Ornamental Ring A or Barrier Block Assy Replacing Method Removal Turn on the power switch and extend the lens (TELE end). Detach the battery. Apply alcohol to the gap of the Ornamental Plate using tweezers or fine-tipped stick as shown below.
Page 71 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Installation Fit the four claws while inserting the barrier lever into the hole and attach the Barrier Block Assy. Claws Barrier Block Assy Hole Claws Barrier Lever Peel off the release paper of the Barrier Tape.
Page 72: Optical Dc Motor And Straight Cam Tube Replacing Method
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 4-3-2. Optical DC Motor and Straight Cam Tube Replacing Method Removal Peel off the Interseption sheet (64200), two lens cushion (64200) and lens blind sheet (64200). Lens blind sheet (64200) Lens cushion (64200) Interseption sheet (64200) Lens cushion (64200) Remove the three screws to detach the Spacer Plates and the CD-1009 Flexible Board.
Page 73 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Remove the two soldering points. Solders Remove the FG Retainer (1920). FG Retainer (1920) Claw Remove the two sensors. Sensors Remove the LF-2214 Flexible Board from the two claws and the boss. LF-2214 Flexible Board...
Page 74 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Remove the Z Seal. Claw Z Seal Remove the one sensor. Sensor 10. Disconnect the LF-2216 Flexible Board from the connector of the LF-2214 Flexible Board. LF-2216 Flexible Board Connector LF-2214 Flexible Board 11. Remove the LF-2214 Flexible Board from the boss and hole.
Page 75 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 12. Disconnect the LF-2215 Flexible Board from the connector of the LF-2214 Flexible Board. LF-2214 Flexible Board Connector LF-2215 Flexible Board 13. Remove the LF-2214 Flexible Board from the two holes. 14. Remove the solder of two places.
Page 76 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 16. Remove the Lubricating Block Assy (B), the Lubricating Block Assy (A) and the Wheel Lubricating Block Assy. Lubricating Block Assy (B) Lubricating Block Assy (A) Wheel Lubricating Block Assy 17. Insert a Lubricating Block Assy (B)* and turn it counterclockwise to the maximum extent.
Page 77 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 19. Pull out the LF-2216 Flexible Board and LF-2215 Flexible Board from the hole of the Stationary Tube. Stationary Tube Holes LF-2216 Flexible Board LF-2215 Flexible Board 20. Insert a Lubricating Block Assy (B)* and turn it clockwise to the maximum extent.
Page 78 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 22. Remove the Worm Gear and two screws to detach the Optical DC Motor. Stationary Tube Worm Gear Optical DC Motor 23. Remove the 5th/6th Group Assy. 5th/6th Group Assy Main Body 24. Remove the Main Body.
Page 79 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 25. Remove the six claws to detach the Ornamental Ring C and Light Shield Ring B. Hooks Hooks Ornamental Ring C Light Shield Ring B Hooks 26. Turn the counterclockwise to the Rotary Tube to detach the Rotary Tube from the Straight Cam Tube.
Page 80 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Install the Ornamental Ring C and Light Shield Ring B. Hooks Hooks Ornamental Ring C Light Shield Ring B Hooks Turn the Cam Tube in the direction of arrow A to align the positions of the three protrusions. Keep the state, align the marks and insert the Main Body into the Rotary Tube Assy.
Page 81 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Install the Optical DC Motor and tighten two screws in the order of the number. Install Worm Gear so that it is in the position shown in the figure. Check the do not stop on the way during operation/no abnormal noise, after the installing Optical DC Motor.
Page 82 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Pass the LF-2216 Flexible Board and LF-2215 Flexible Board through the holes of the Stationary Tube. Stationary Tube Holes Focus Flexible Board LF-2215 Flexible Board Install the LF-2216 Flexible Board to one claw and install the LF-2215 Flexible Board to the two claws and one hole in the order of the number.
Page 83 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 11. Install the Wheel Lubricating Block Assy, Lubricating Block Assy (A) and Lubricating Block Assy (B). Lubricating Block Assy (B) Lubricating Block Assy (A) Wheel Lubricating Block Assy 12. Install the Rear Tube Mirror Block Assy and tighten six screws in the order of the number.
Page 84 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 15. Solder the two soldering places. LF-2214 Flexible Board LF-2214 Flexible Board Soldering place Hole Hole 16. Connect the LF-2215 Flexible Board to the connector of the LF-2214 Flexible Board. LF-2214 Flexible Board Connector LF-2215 Flexible Board 17.
Page 85 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 19. Install the one sensor. Sensor 20. Install the Z Seal. Claw Z Seal 21. Install the LF-2214 Flexible Board to the two claw and boss. Claw LF-2214 Flexible Board Boss Claw 22. Install the two sensors.
Page 86 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 23. Install the FG Retainer (1920). FG Retainer (1920) Claw 24. Install the two soldering points. Solders 25. Install the Filter Mask (1920) and Seal Rubber (1920). Optical Filter Block Filter Mask (1920) Seal Rubber (1920) 26.
Page 87 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 27. Stick the lens blind sheet (64200), two lens cushion (64200) and Interseption sheet (64200). Lens blind sheet (64200) Lens cushion (64200) Interseption sheet (64200) Lens cushion (64200) 4-43 DSC-RX100M6 SYS SET...
Page 88 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 89: Repair Parts List
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Section 5 Repair Parts List 5-1. Note on Repair Parts (ENGLISH) NOTE: The components identified by mark or dotted line with • -XX, -X mean standardized parts, so they may have some mark are critical for safety.
Page 90: Exploded View
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 5-2. Exploded View Bottom Cabinet Section SY Board and MS Board Section #368 (M1.4 X 3.0) (0.12 ± 0.01 N·m) Rear Cabinet Section #368 #247 (M1.4 X 3.0) (M1.4 X 2.5) (0.12 ± 0.01 N·m) (0.12 ±...
Page 91: Sy Board And Ms Board Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY Board and MS Board Section BTH Assy Section #209 (M1.4 X 3.5) (0.12 ± 0.01 N·m) {9,10} (Note 3) Refer to (M1.4 X 2.0) “High-voltage Cautions” (0.12 ± 0.01 N·m) #247 #290 (M1.4 X 2.5) (M1.4 X 5.0)(Tapping)
Page 92: Bth Assy Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer BTH Assy Section ST Block Assy Section 106 105 #368 (M1.4 X 3.0) (0.08 ± 0.01 N·m) #189 (M1.4 X 3.5)(Tapping) (0.12 ± 0.01 N·m) BT901 BT900 (M1.4 X 4.0)(Tapping) (0.10 ± 0.01 N·m)
Page 93: St Block Assy Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer ST Block Assy Section Front Assy Section #247 (M1.4 X 2.5) (0.12 ± 0.01 N·m) (Note) #209 (M1.4 X 3.5) (M1.4 X 1.4) (0.12 ± 0.01 N·m) (Including MIC001 (0.12 ± 0.01 N·m) and MIC002) #333 (M1.4 X 1.4)
Page 94: Front Assy Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Front Assy Section When assembling, adjust the position. #209 #239 (M1.4 X 3.5) (M1.4 X 1.4) (0.12 ± 0.01 N·m) (0.12 ± 0.01 N·m) (Note) #189 (M1.4 X 3.5)(Tapping) (0.08 ± 0.01 N·m) #209 (M1.4 X 3.5)
Page 95: Evf Assy Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer EVF Assy Section #276 (M1.4 X 3.0)(Tapping) (0.10 ± 0.01 N·m) (M1.4 X 2.0) (0.10 ± 0.01 N·m) C901 #276 (M1.4 X 3.0)(Tapping) #276 (0.10 ± 0.01 N·m) (M1.4 X 3.0)(Tapping) (0.10 ± 0.01 N·m)
Page 96: Rear Cabinet Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Rear Cabinet Section LCD Panel Section #276 (M1.4 X 3.0)(Tapping) (0.12 ± 0.01 N·m) #196 (M1.7 X 2.0) FP-2421 (0.12 ± 0.01 N·m) FLEXIBLE BOARD (Note) Ref. No. or Q'ty Part No. SP Description...
Page 97: Lcd Panel Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer LCD Panel Section LCD901 #239 (M1.4 X 1.4) (0.12 ± 0.01 N·m) (Note) (M1.4 X 2.0) (0.12 ± 0.01 N·m) Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No.
Page 98: Lens Block Section
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Lens Block Section #305 (M1.4 X 4.0) (1.0 ± 0.10 N·m) #258 (M1.2 X 3.5)(Tapping) (0.50 ± 0.05 N·m) (Note 1) (including IC1003 (CMOS imager) and CD-1009 flexible board) (Claw) (Claw) (Claws) (Note 2) #176 (M1.2 X 2.0)
Page 99 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL Lens Block Section For Authorized Servicer Selection Parts Ref. No.417 These parts are provided for shift and tilt adjustment. Change the thickness (t) according to result of adjustment. Ref. No. or Q'ty Part No. SP Description 4-410-539-01 SPACER PLATE (A) (t=0.10)
Page 100: Accessories
2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 5-3. Accessories AC-UUD12 AC-UUE12 Ref. No. or Q'ty Part No. SP Description 1-493-083-14 AC Adaptor (AC-UUE12) (E32, IN5) 1-493-084-21 AC Adaptor (AC-UUD12) (CN1) 1-493-084-51 AC Adaptor (AC-UUD12) (KR2) 1-493-085-13 AC Adaptor (AC-UUD12) (UC2, TW6,...
Page 101 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Revision History Ver. Date History Contents S.M. Rev. issued 2018.06 Official Release ― ― DSC-RX100M6 SYS SET...
Page 102 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 103 2018/06/16 03:29:19 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 104 For Authorized Servicer DSC-RX100M6 (UC2) DSC-RX100M6 (CE3) DSC-RX100M6 (CEH) DSC-RX100M6 (RU3) DSC-RX100M6 (E32) DSC-RX100M6 (IN5) DSC-RX100M6 (TW6) DSC-RX100M6 (HK1) DSC-RX100M6 (CN1) DSC-RX100M6 (KR2) Printed in Japan Sony Imaging Products & Solutions Inc. DSC-RX100M6 (J1) 2018. 06 08 9-896-843-31 © 2018 SYS SET...
Page 105 Conditions of Use: (1) Please use this information only for the purpose of performing repair, maintenance and/or configuration services of the Sony products (hereinafter the “Repair services”) under the service agreement entered into with the Sony group company (hereinafter the “Service agreement”).
Page 106 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 警告このマニュアルは，サービス専用です。お客様が，このマニュアルに記載された設置や保守，点検，修理などを行うと感電や火災，人身事故につながることがあります。危険をさけるため，サービストレーニングを受けた技術者のみご使用ください。 WARNING This manual is intended for qualiﬁed service personnel only. To reduce the risk of electric shock, ﬁre or injury, do not perform any servicing other than that contained in the operating instructions unless you are qualiﬁed to do so.
Page 107 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer FÖRSIKTIGHET! 注意指定以外の電池に交換すると，破裂する危険があります。 Fara för explosion vid felaktigt placerat batteri. Byt endast mot samma eller likvärdig typ av batteri, 必ず指定の電池に交換してください。 enligt tillverkarens rekommendationer. 使用済みの電池は，国または地域の法令に従って När du kasserar batteriet ska du följa rådande lagar 処理してください。...
Page 108 CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU PUBLISHED BY SONY.
Page 109 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer サービス，点検時には次のことにご注意ください。 1. 注意事項をお守りください。無鉛半田についてサービスのとき特に注意を要する個所については，キャ本機には無鉛半田が使用されています。ビネット，シャーシ，部品などにラベルや捺印で注意事無鉛半田を使用している基板には，無鉛（Lead Free）を意味項を表示しています。これらの注意書き及び取扱説明書するレッドフリーマークがプリントされています。等の注意事項を必ずお守り下さい。（注意：基板サイズによっては，無鉛半田を使用していても 2. 指定部品のご使用をレッドフリーマークがプリントされていないものがセットの部品は難燃性や耐電圧など安全上の特性を持っあります）たものとなっています。従って交換部品は，使用されていたものと同じ特性の部品を使用して下さい。特に回路：レッドフリーマーク図，部品表に0印で指定されている安全上重要な部品は無鉛半田は，下記の点に注意して使用してください。必ず指定のものをご使用下さい。 3. 部品の取付けや配線の引きまわしはもとどおりに・半田こてのこて先温度は約350℃に設定してください。安全上，チューブやテープなどの絶縁材料を使用したり温度調節が無理な場合は，高温短時間で作業を行ってくだ，プリント基板から浮かして取付けた部品があります。さい。...
Page 110 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 111 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Table of Contents Repair Parts List 1-1. Note on Repair Parts......................1-1 1-2.
Page 112 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Printed Wiring Boards BT-2026..........................5-2 CD-1009.
Page 113 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 目次 Repair Parts List 1-1. Note on Repair Parts......................1-1 1-2.
Page 114 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Printed Wiring Boards BT-2026..........................5-2 CD-1009.
Page 115: Repair Parts List
2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Section 1 Repair Parts List 1-1. Note on Repair Parts (ENGLISH) NOTE: The components identified by mark or dotted line with • -XX, -X mean standardized parts, so they may have some mark are critical for safety.
Page 116: Electrical Parts List
2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer 1-2. Electrical Parts List FP-2423 FLEXIBLE BOARD BT-2026 FLEXIBLE BOARD Ref. No. or Q'ty Part No. SP Description Ref. No. 1-982-414-11 FP-2423 FLEXIBLE BOARD or Q'ty Part No. SP Description A-2216-239-A BT-2026 FLEXIBLE BOARD, COMPLETE...
Page 117: Ms-1038 Board
2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer MS-1038 BOARD MS-1038 BOARD Ref. No. or Q'ty Part No. SP Description Ref. No. or Q'ty Part No. SP Description R4616 1-240-678-91 METAL CHIP 33 5% 1/20W A-2219-773-A MS-1038 BOARD, COMPLETE (SERV- SE7701 Not supplied...
Page 118: Se-1016 Flexible Board
2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer RL-1051 BOARD ST-1044 FLEXIBLE BOARD Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description R0516 1-240-703-91 METAL CHIP 4.7K 5% 1/20W CN2401 1-821-857-71 CONNECTOR, FPC (LIF (NON-ZIF))
Page 119 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 BOARD SY-1083 BOARD Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description C2001 1-118-477-11 CERAMIC CHIP 2.2uF 10% 6.3V C5651 1-118-462-11 CERAMIC CHIP 1uF 10% 10V...
Page 120 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 BOARD SY-1083 BOARD Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description C6206 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V C6387 1-118-458-11 CERAMIC CHIP 0.1uF 10% 6.3V...
Page 121 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 BOARD SY-1083 BOARD Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description FB6020 Not supplied EMI FERRITE (SMD) (1005) L9003 Not supplied COMMON MODE CHOKE COIL15(0806)
Page 122 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 BOARD SY-1083 BOARD Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description R1377 Not supplied METAL CHIP 47K 1% 1/20W R4030 1-240-687-91 METAL CHIP 220 5% 1/20W...
Page 123: Block Diagrams
2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Section 2 Block Diagrams Overall (1/2) CD-1009 FLEXIBLE BOARD SY-1083 BOARD (1/2) FP-2421 LC-1038 FLEXIBLE BOARD LENS BLOCK LCD901 CN0103 FLEXIBLE (LCD MODULE) LCD_R_0 - 7, CN0203 CN3801 CN8041 BOARD LENS IRIS LCD_DG_0 - 7...
Page 124: Overall (2/2)
2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Overall (2/2) FP-2423 MS-1038 BOARD SY-1083 BOARD (2/2) FLEXIBLE CN0302 CN0104 BOARD CN0301 MSX_DATA0 - DATA7 MSX_DATA0 - DATA7 23 - 30 23 - 30 MSX_D0 - D7 MSX_CLK/BS MSX_CLK/BS MSX_CLK/BS 19, 21 19, 21...
Page 125: Power (1/3)
2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Power (1/3) BT-2026 SY-1083 BOARD (1/3) REG_UNREG FLEXIBLE REG_UNREG REG_UNREG D_1.2V_IC_6300 IC2002 BOARD A_1.2V_IC_6300 F2205 Q2201 BL_UNREG BL_UNREG DC/DC CONVERTER D_1.8V (1/2) (11/17) ST_UNREG POWER ST_UNREG BT901 L2002 SWITCH D_1.2V_DDR_IMG F2204 CN0701 CN0101 PVIN_A1...
Page 126: Power (2/3)
2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Power (2/3) FP-2423 SY-1083 BOARD (2/3) MS-1038 BOARD FLEXIBLE CN0104 BOARD CN0301 REG_UNREG CN0302 MEMORY SD_3.3V STICK SD_3.3V SD_3.3V PRO DUO D_1.2V_IC_6300 MS_VCC MS_VCC A_1.2V_IC_6300 MS_VCC D_1.8V D_1.2V_DDR_IMG D_3.3V D_3.3V D_3.3V A_3.3V_IC_6000_IC_6300 IC8020 D0301 D_3.3V_IC_6000_IC_6300...
Page 127: Power (3/3)
2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Power (3/3) LCD901 (LCD MODULE) FP-2421 LC-1038 FLEXIBLE BOARD SY-1083 BOARD (3/3) FLEXIBLE BOARD CN0203 CN3801 CN8041 ST_UNREG D_3.3V D_3.3V 10 - 12 40 - 42 3.0 INCH D_3.3V COLOR D_1.8V A_3.3V D_1.8V 13, 14 38, 39 D_1.8V...
Page 128 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 129: Frame Schematic Diagrams
2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Section 3 Frame Schematic Diagrams Frame Wiring FLASH UNIT FP-2424 FLEXIBLE BOARD BT900 LITHIUM BATTERY BT901 BATTERY SE-1016 TERMINAL FLEXIBLE BOARD EV-1017 EV-1017 MI2702 BOARD BOARD MI2701 RL-1051 BOARD MICROPHONE MICROPHONE UNIT (R) (SIDE A)
Page 130 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 131: Schematic Diagrams
2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Section 4 Schematic Diagrams Note For Schematic Diagrams 回路図ノート • All capacitors are in μF unless otherwise noted. • Constants of resistors, capacitors, ICs and etc with ・ケミコン，タンタルを除くコンデンサで，耐圧50V以下・抵抗，コンデンサ，ICなど定数にXXがあるものは， pF : μμF. 50 V or less are not indicated except for XX indicate that they are not used.
Page 132 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer BT-2026 LN0701 39 INT_MIC_L 38 INT_AUDIO_GND 37 INT_MIC_R 36 INT_AUDIO_GND 35 MICBIAS_L 34 MICBIAS_R 33 AUDIO_GND 32 REG_GND 31 XSTRB_POPUP_SENS 30 REG_GND 45 46 47 48 CN0701 29 MF_RING_B BATT_GND BATT_GND 28 MF_RING_A REG_GND3...
Page 133 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer CD-1009 C1016 C1018 2.2u 0.1u C1007 C1017 C1020 C1021 2.2u 1000p 1000p 0.1u C1024 C1026 C1029 4.7u 4.7u D_1.8V_IMGS C1025 D_1.8V_IMGN 0.1u C1027 0.1u C1022 C1030 4.7u 0.1u DDR_1.2VN VDDD1_1.1V_N CM1001 VDDD3_1.1V CM1002 LN1001 VDDD1_1.1V_S...
Page 134 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer EV-1017 EV-1017 (1/3) REG_GND REG_GND EVER_VDD REG_GND EVF_10V EVF_10V EVF_DD_EN EVF_DD_EN DD_1.8V DD_1.8V DD_1.8V REG_GND REG_GND REG_GND D0-_EVF D0-_EVF D0+_EVF D0+_EVF REG_GND CLK-_EVF CLK-_EVF CLK+_EVF FP-2422 CLK+_EVF FLEXIBLE REG_GND LND002 D1-_EVF D1-_EVF D1+_EVF D1+_EVF...
Page 135 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer EV-1017 (2/3) XPNL_EVF_RST_1.8V R3303 C3302 EVF_D_XVD EVF_D_XVD EVF_D_XHD EVF_D_XHD R3304 R3305 VF_PCLK EVF_D_CLK D2+_EVF D2+_EVF CM3302 CM3303 EVF_DB_0 D2-_EVF EVF_DB_6 D2-_EVF VDDLVDS_H5 EVF_DB_0 B6/R1 EVF_DB_1 EVF_DB_7 VDDLVDS_H2 EVF_DB_1 B7/R0 EVF_DG_0 EVF_DB_2 VDDPLLA EVF_DB_2 G0/G7...
Page 136 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer EV-1017 (3/3) EVF_GND REG_GND C8067 C8060 C8066 C8063 C8064 C8065 2.2u C8062 R8061 CN8060 CM3603 VCCP_I EVF_10V EVF_10V VDD2 R3601 VCATH VOFS VG255 AOUT R_IB CM3602 EVF_TEMP VCAL LN3601 EVF_1.8V DD_1.8V VDD1 R3602 VFUSE...
Page 137 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer FP-2421 FP-2422 LN002 LN001 LN001 BL_L BL_L REG_GND REG_GND BL_L BL_L REG_GND REG_GND EVER_VDD EVER_VDD BL_H BL_H REG_GND REG_GND BL_H BL_H REG_GND REG_GND EVF_10V EVF_10V LCD_DG_0 LCD_DG_0 EVF_DD_EN EVF_DD_EN LCD_DG_1 LCD_DG_1 DD_1.8V DD_1.8V LCD_DG_2 LCD_DG_2 DD_1.8V...
Page 138 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer FP-2423 FP-2424 IC_4001_2.8V IC_4001_2.8V TRIGGER GND GY_GND GY_GND ST-1044 LN0005 GYRO_VREF GYRO_VREF FLEXIBLE (2/4) YAW_AD YAW_AD XE-K XE_K CN2401 PITCH_AD PITCH_AD XE-K LN0006 REG_GND REG_GND XE-K LN0002 WLAN_CAL_IRQ WLAN_CAL_IRQ TRIGGER GND BT_UART_HOST_RXD BT_UART_HOST_RXD BT_UART_HOST_TXD...
Page 139 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer LC-1038 CN3801 CN8041 BL_L BL_L BL_L CM3804 REG_GND C3801 0.1u C3803 CM3802 C8048 2.2u C8047 BL_H BL_H R3801 VCOM R3803 BL_H PNL_XRES_3V RESET REG_GND D_1.8V VDDIO R3804 CL3809 LCD_DG_0 XCS_LCD_3V LCD_DG_0 R3805 LCD_DG_1 LCD_DG_1...
Page 140 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer MS-1038 MS-1038 (1/4) CN0301 R0301 CM0317 CN0302 SD_DATA_1 SDIO0_DATA1 R0302 CM0318 SD_DATA_2 DATA2 SDIO0_DATA2 SD_DATA_2 MSX_D4 DATA4 REG_GND R0303 CM0319 SD_DATA_3 CD/DATA3 SDIO0_DATA0 SD_DATA_0 R0304 CM0320 MSX_D5 DATA5 SD_DATA_3 SDIO0_DATA3 REG_GND SD_CMD SD_3.3V SD_3.3V MSX_BS SD_3.3V...
Page 141 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer MS-1038 (2/4) CM4101 GYRO_OUTX PITCH_AD R4101 CM4102 GYRO_OUTY YAW_AD R4102 C7703 0.0022u C7706 0.1u C4104 C4102 C7701 0.047u VDDIO CL7701 SE7701 GSU-C370D/N PITCH/YAW SENSOR C7702 0.047u DSEL C7705 VCC_GYRO_PY 0.0022u IC_4001_2.8V CL7703 C7704 GYRO_VREF 0.1u...
Page 142 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer MS-1038 (3/4) REG_UNREG C4401 C4408 P_GND_WLAN VREF_IC_2000 D_3.3V_WLAN L1_D3 VOUT_A1 CM4402 L1_D2 IC4401 VOUT_A2 R4403 TPS63024YFFR IC4402 560k L1_D1 3.3V REG VOUT_A3 MM3416A18RRE 1.8V REG PGND_C3 L2_B1 R4404 VOUT D_1.8V_WLAN 180k C4407 C4403 C4404...
Page 143 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer MS-1038 (4/4) FPC-2010 FLEXIBLE BOARD WIRELESS LAN ANTENNA ET4601 C4604 L4602 6.8nH R4603 L4601 C4602 R4617 0.2p C4606 L4603 CM7335 REG_GND R4611 CM4601 R4605 D_3.3V_WLAN D_3.3V D_1.8V_WLAN C7330 4.7u CM7336 R4610 XX WL_SDIO_CLK CM7334...
Page 144 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer RE-1002 SE2801 LCD ROTATION DETECT R2802 CN2801 XDIRECT_PB REG_GND KEY_AD2 REG_GND KEY_AD1 JOG_DIALB CONTROL SWITCH JOG_DIALA JOG_DIALA SY-1083 BLOCK JOG_DIALB KEY_AD1 (2/17) (SW63900) REG_GND DD_1.8V CN0202 D_1.8V KEY_AD2 SEN_GND XDIRECT_PB ROTATE_SENS_ON PNL_SENS_CLOSE LN2801 SE2802...
Page 145 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer RL-1051 RL-1051 (1/3) S0503 CN0501 IC_4001_2.8V IC_4001_2.8V IC_4001_2.8V XEYE_DET XEYE_DET REG_GND CM0501 ROLL_AD C0505 C0506 C0507 C0508 C0509 ROLL_AD CM0502 VST_C_RESET_R VST_C_RESET_R LN0501 CM0503 REG_GND STATIC_GND CM0504 ACC_SEL CM0505 MODE_DIAL_1 CM0506 S0504 MODE_DIAL_0 R0521...
Page 146 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer RL-1051 (2/3) ACCEL_INT1 LN2601 SE7731 3 AXIAL ACCELERATION SENSOR VCC_ACCEL A_3.3V NC_8 NC_15 C7731 NC_16 4.7u C7732 C7733 0.1u 0.1u REG_GND I2C_SCK I2C_SCK I2C_SDA I2C_SDA RL-1051 BOARD (2/3) 4-16 DSC-RX100M6 SYS SET...
Page 147 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer RL-1051 (3/3) GYRO_ROLL_AD_DIRECT LN4201 CM7701 SE7711 C7712 R7716 ROLL SENSOR C7718 470p VREF C7711 0.33u R7713 C7717 C7719 0.1u 0.1u R7711 C7713 CM7702 R7714 R7715 NC_8 NC_13 0.047u R7712 IC7711 150k VREF NJM3232MG2 (TE2)
Page 148 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SE-1016 SE2701 POP-UP DETECT XSTRB_POPUP_SENS XSTRB_POPUP_SENS REG_GND REG_GND EYE_SENS_VCC EYE_SENS_VCC LEDA LEDK EYE_SENS_GND C2701 SE2702 4.7u EYE_SENS_GND EYEPIECE SENSOR EYE_SENS_GND I2C_SCK I2C_SDA A_3.3V RL-1051 XEYE_SENS_OUT (1/3) REG_GND R2702 2.2k CN0502 POWER MICBIAS_L OUTPUT MI2701...
Page 149 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer ST-1044 ST-1044 (1/4) CN0601 CN0601 EVF_POPUP_SENS EVF_POPUP_SENS REG_GND REG_GND XPNL_EVF_RST XPNL_EVF_RST LN0601 LN0601 SET_TEMP3 SET_TEMP3 SET_TEMP3 SET_TEMP3 EVF_POPUP_SENS EVF_POPUP_SENS XCS_EVF XCS_EVF EVF_SO EVF_SO EVF_SI EVF_SI EVF_SCK EVF_SCK EVF_SCK EVF_SCK XCS_EVF XCS_EVF EVF_SO EVF_SO XPNL_EVF_RST...
Page 150 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer ST-1044 (2/4) T2401 XE_A T2402 T_HV XE_A FP-2424 XE_A FLEXIBLE LN0002 XE_A XE_A T_HV T_CENTER T_CENTER D5800 TRRIGER DA2JF6500L CN2401 R5804 DRAIN DRAIN CN2402 ST_TRIGGER TRRIGER GND ST_UNREG C5802 FP-2424 0.047u 350V FLEXIBLE DD_3.3V...
Page 151 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer ST-1044 (4/4) R4701 DD_3.3V CM4701 C7401 0.1u NFC_SCK C7404 C7403 C7402 SPICLK NFC_L1 TEST0 IC7401 NFC_L2 NFC_SIO DATA CXD9950AK NFC_SEL NFC INTERFACE CL7401 XNFC_RFDET NFC_IRQ XNFC_RFDET RFDET CL7400 NFC_SW CL4703 NFC_SCK NFC_SCK CL4704 NFC_SIO...
Page 152 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 SY-1083 (1/17) BT-2026 FLEXIBLE CN0701 CN0103 62 63 CN0104 CN0101 61 REG_GND 60 REG_GND SDIO0_DATA1 SDIO0_DATA1 BATT_UNREG BATT_UNREG BATT_UNREG D_1.2V_DDR_IMG 59 DDR_1.2VN SDIO0_DATA2 SDIO0_DATA2 AUDIO_2.8V IC_4001_2.8V IC_4001_2.8V AUDIO_2.8V 58 DDR_1.2VN REG_GND 57 DDR_1.2VN...
Page 153 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (2/17) 11 12 52 53 XEVF_POPUP_SENS PNL_SENS_CLOSE 10 PNL_SENS_CLOSE BL_L CM202 51 BL_L ROTATE_SENS_ON CN0201 ROTATE_SENS_ON C0204 52 53 R0201 XX 50 BL_L JOGDIAL_B REG_GND DUMMY Q0201 SET_TEMP3 51 SET_TEMP3 R0202 XX 49 NC...
Page 154 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (3/17) REG_UNREG REG_UNREG CM1012 VREF_IC_2000 CM1014 R1019 CM1011 CL1001 VREF_IC_2000 CM1018 C1012 R1004 C1002 D_1.0V_NOTASV_LDO CM1003 I2C_SDA AGND PGND_C2 D_1.0V_IC_6300 CL1002 IC1004 CM1004 NCP6343SFCCT1G PVIN_C1 AGND PGND_C2 DC/DC CONVERTER IC1001 R1408 PGND_B3 I2C_SCK...
Page 155 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (4/17) IC6000 (2/8) AMZ16NN02A IC6000 (1/8) CPU, CAMERA DSP, AV SIGNAL PROCESS, AMZ16NN02A LENS CONTROL, MODE CONTROL, HDMI PROCESS CPU, CAMERA DSP, AV SIGNAL PROCESS, GCS2DPHY_RX_AVDP_AVD GCS2_RXDP[7] LENS CONTROL, MODE CONTROL, HDMI PROCESS A_0.9V_NOTASV_GCS2...
Page 156 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (5/17) IC6000 (3/8) AMZ16NN02A IC6000 (4/8) CPU, CAMERA DSP, AV SIGNAL PROCESS, AMZ16NN02A LENS CONTROL, MODE CONTROL, HDMI PROCESS CPU, CAMERA DSP, AV SIGNAL PROCESS, VDAC_AVDH VDAC_AVOUT LENS CONTROL, MODE CONTROL, HDMI PROCESS...
Page 157 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (6/17) A_1.8V_IC_6000_IC_6300 Q1301 SSM3K15ACT DC PLATE JUDGE SWITCH BATT_TEMP IC6000 (5/8) IC6000 (6/8) AMZ16NN02A AMZ16NN02A CPU, CAMERA DSP, AV SIGNAL PROCESS, CPU, CAMERA DSP, AV SIGNAL PROCESS, LENS CONTROL, MODE CONTROL, HDMI PROCESS...
Page 158 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (7/17) IC6000 (7/8) AMZ16NN02A CPU, CAMERA DSP, AV SIGNAL PROCESS, LENS CONTROL, MODE CONTROL, HDMI PROCESS IC6000 (8/8) CM6186 CM6180 AC25 R6183 VDE12 AMZ16NN02A D_1.2V_IC_6000 VDE12_002_AG1 DDRA_MZQ4 CPU, CAMERA DSP, AV SIGNAL PROCESS,...
Page 159 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (8/17) NC_M7 NC_H1 NC_M8 NC_G14 NC_M9 NC_G13 NC_M10 NC_G12 NC_M11 RFU_G10 NC_M12 VSS_G5 NC_M13 RFU_G3 NC_M14 NC_G2 NC_N1 NC_G1 VSS_N2 NC_F14 NC_N3 NC_F13 VDD_N4 NC_F12 C6281 0.1u VSS_N5 RFU_F10 NC_N6 VDDF_F5 C6287 0.1u...
Page 160 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (9/17) IC6300 (2/5) LNZ8GNN11A IC6300 (3/5) CAMERA SIGNAL PROCESS LNZ8GNN11A VDDE_H FSP_ADDR_20 CAMERA SIGNAL PROCESS D_1.8V_IC_6000_IC_6300 VDDE_H_G22 HB_ADDR20 REG_GND CIS0_HD VDDE_E FSP_ADDR_19 D_1.8V_IC_6000_IC_6300 VDDE_E_AB5 CIS0_HD CIS0_HD FSP_ADDR_19 C6326 VDDE_H_G23 HB_ADDR19 CIS0_VD C6341 C6343 0.1u...
Page 161 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (10/17) IC6300 (5/5) IC6300 (5/5) LNZ8GNN11A LNZ8GNN11A R6388 R6388 CAMERA SIGNAL PROCESS CAMERA SIGNAL PROCESS IC6300 (4/5) IC6300 (4/5) VDDE_DDR_POPVDD12 VDDE_DDR_POPVDD12 R6360 R6360 LNZ8GNN11A LNZ8GNN11A D_1.2V_IC_6300 D_1.2V_IC_6300 VDDE_DDR_J24 VDDE_DDR_J24 VREFCA VREFCA CAMERA SIGNAL PROCESS...
Page 162 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (11/17) MS_VCC R2011 D_3.3V C2018 REG_UNREG CM2008 CM2032 A_3.3V CM2009 DD_3.1V REG_GND A_3.3V_IMG CM2010 CM2004 LN2001 D_3.3V_IC_6000_IC_6300 CM2012 CABC_PWM CABC_PWM XSYS_RESET A_3.3V_IC_6000_IC_6300 CM2013 XSYS_RESET XRESET_REQ A_3.3V_IC_6000_LDO CM2029 XRESET_REQ R2019 IC_6000_SI_DD IC_6000_SI_DD D_3.3V_MEDIA CM2028...
Page 163 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (12/17) Q2201 RW1A030APT2CR POWER SWITCH CM2201 BATT_UNREG BATT_UNREG_FET REG_UNREG BATT_UNREG CM5651 C2201 F2205 (0.63A/32V) C5650 C2204 C2205 BL_UNREG R2203 R2204 100k F2204 (1A/32V) F2206 UNREG_MAXIM_OUT ST_UNREG (2.5A/32V) USB_VBUS USB_VBUS USB_LED USB_CN_DP XUSB_LED USB_CN_DP...
Page 164 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (13/17) D_3.3V_MEDIA CM2301 IC2301 NX5P2924CUKZ SD_3.3V SD0_3.1_PWR_ON VOUT_B1 B+ SWITCH R2307 R2304 4.7k C2301 Q2301 SSM3J56MFV B+ SWITCH R2305 C2304 220k SDIO0_18SW IC2302 RP114K181B-TRB 1.8V REG SDIO0_VDD D_3.3V_MEDIA VOUT SD0_1.8_PWR_ON C2303 R2303 C2302...
Page 165 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (14/17) BATT_UNREG Q3002 SSM3J35MFV,L3SOF Q3001, Q3002 VOLTAGE DETECT BATT_SENS R3007 Q3001 XSYS_RESET SSM3K15ACT REG_GND CM3015 R3010 C3015 MIC_L MIC_IN_L 0.022u INT_MIC_L R3011 MIC_IN_R MIC_R C3016 0.022u INT_MIC_R CM3016 MICBIAS_L MICBIAS_L MICBIAS_R MICBIAS_R CL3002...
Page 166 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (15/17) D0-_PARASIRI_VF CM3201 D0-_VF CM3209 D0+_PARASIRI_VF CM3202 D0+_VF R3205 CLK-_PARASIRI_VF CLK-_VF L3202 CLK+_PARASIRI_VF C3202 CLK+_VF R3206 CM3203 D1-_PARASIRI_VF D1-_VF CM3204 D1+_PARASIRI_VF CM3208 D_1.8V CL3201 D1+_VF D2-_PARASIRI_VF D2-_VF C3201 CM3205 0.1u D2+_PARASIRI_VF D2+_VF CM3206...
Page 167 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (16/17) LCD_B_0 LCD_B_0 FB3401 LCD_DB_0 LCD_B_0 LCD_DB_0 R3401 LCD_B_1 LCD_B_1 FB3402 LCD_DB_1 LCD_B_1 LCD_DB_1 R3402 LCD_B_2 LCD_B_2 LCD_DB_2 FB3403 LCD_B_2 LCD_DB_2 R3403 LCD_B_3 LCD_B_3 FB3404 LCD_DB_3 LCD_B_3 LCD_DB_3 R3404 LCD_B_4 LCD_B_4 LCD_B_5 LCD_B_4...
Page 168 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 (17/17) CN4001 ZOOM- ZOOM- ZOOM- CL4001 ZOOM+ ZOOM+ DUMMY LN401 ZOOM+ DUMMY LN402 Z_FG0/1_K/E CL4002 ZM_DC_FG_B R4040 Z_FG0_C YAW_AD Z_FG0_A ZM_DC_FG_A PITCH_AD Z_FG1_C R4041 C4040 Z_FG1_A C4041 IC4001 R2J30503LG#W2 FOCUS- OIS DRIVE, IRIS/ZOOM/SHUTTER MOTOR DRIVE...
Page 169 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Section 5 Printed Wiring Boards Note For Printed Wiring Boards プリント図ノート • : Uses unleaded solder. • Chip parts. • Chip parts. ・：無鉛半田を使用しています。 • : Circuit board Transistor Transistor ・：基板...
Page 170 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer BT-2026 EV-1017 BT-2026 FLEXIBLE BOARD EV-1017 BOARD (SIDE A) EV-1017 BOARD (SIDE B) R8061 CL3605 CL3301 CL3604 BT901 R3304 R3305 BATTERY TERMINAL R0401 LN0702 LN0703 CL3304 CL3305 IC3301 CL3303 BT900 CL3601 CN0401 LITHIUM C8067...
Page 171 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer MS-1038 RE-1002 MS-1038 BOARD (SIDE A) MS-1038 BOARD (SIDE B) RE-1002 FLEXIBLE BOARD CM4601 R4605 CM4402 43 42 CM7330 R4404 R4406 R4405 CM7331 CP7330 CL4601 B4 C4 D4 C4103 C4101 CL7703 CM7332 A3 B3 C3 D3 E3...
Page 172 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SE-1016 ST-1044 ST-1044 FLEXIBLE BOARD SE-1016 FLEXIBLE BOARD R2702 R2701 CN0601 R5334 R5335 C5327 C3502 C5331 C5330 C5329 CL4706 CL4703 CL4704 CL4705 CL4707 IC7401 R5338 C3501 MI2701 (MICROPHONE) (L) CL7401 C7402 CL7400 C7403 C0601 C0602...
Page 173 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SY-1083 SY-1083 BOARD (SIDE A) SY-1083 BOARD (SIDE B) F2204 Q2201 C2205 L3001 C5650 C3012 C3017 C3016 R3011 R105 C105 CM2201 C8409 IC8400 C5655 D2201 F2205 CL3005 CL2202 C2201 C3015 R3010 CL3002 CN0101 C2202...
Page 174 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 175 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer Revision History Ver. Date History Contents S.M. Rev. issued 2018.06 Official Release ― ― DSC-RX100M6 SYS SET...
Page 176 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 177 2018/06/16 03:36:24 (GMT+09:00) Sony CONFIDENTIAL For Authorized Servicer SYS SET...
Page 178 For Authorized Servicer DSC-RX100M6 (UC2) DSC-RX100M6 (CE3) DSC-RX100M6 (CEH) DSC-RX100M6 (RU3) DSC-RX100M6 (E32) DSC-RX100M6 (IN5) DSC-RX100M6 (TW6) DSC-RX100M6 (HK1) DSC-RX100M6 (CN1) DSC-RX100M6 (KR2) Printed in Japan Sony Imaging Products & Solutions Inc. DSC-RX100M6 (J1) 2018. 06 08 9-896-843-11 © 2018 SYS SET...

Sony DSC-RX100M6 Service Manual

/06/16 03:29:19 (Gmt+09:00) Sony Confidential

/06/16 03:29:19 (Gmt+09:00) Sony Confidential 目次

/06/16 03:36:24 (Gmt+09:00) Sony Confidential

Quick Links

Chapters

Related Manuals for Sony DSC-RX100M6

Summary of Contents for Sony DSC-RX100M6

Table of Contents