Page 1
ORDER NO. MD0704048CE CD Stereo System SA-AK350E SA-AK350EB SA-AK350EG Colour (S)... Silver Type Notes: This model’s CD mechanism changer unit is CRS1. Please refer to the original Service Manual (Order No. MD0509368C0) for this mechanism. Specifications RMS output power n CASSETTE DECK SECTION...
SA-AK350E / SA-AK350EB / SA-AK350EG Sampling frequency Dimensions (W x H x D) 250 x 330 x 323 mm 32 kHz, 44.1 kHz, 48 kHz Mass 7.1 kg CD-DA 44.1 kHz Operating temperature range +5 to +35°C Decoding 16 bit linear...
Page 3
SA-AK350E / SA-AK350EB / SA-AK350EG 14 Measurement And Adjustments 19.5. (E) Power Circuit 14.1. Cassette Deck Section 19.6. (F) Deck Circuit 15 Voltage and Waveform Chart 19.7. (H) Transformer Circuit 15.1. CD Servo P.C.B. 20 Printed Circuit Board 15.2. Deck P.C.B. & Deck Mechanism P.C.B.
SA-AK350E / SA-AK350EB / SA-AK350EG 1 Safety Precautions 1.1. General Guidelines 1. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit. 2. After servicing, ensure that all the protective devices such as insulation barriers and insulation papers shields are properly installed.
SA-AK350E / SA-AK350EB / SA-AK350EG 1.2. Caution for AC Mains Lead 1.3. Before repair and adjustment Disconnect AC power, discharge Power Capacitors C5101, C5104, C5171, C5172, C5920, C5940 and C5950 through a 10Ω, 5W...
SA-AK350E / SA-AK350EB / SA-AK350EG resistor to ground. DO NOT SHORT-CIRCUIT DIRECTLY (with a screwdriver blade, for instance), as this may destroy solid state devices. After repairs are completed, restore power gradually using a variac, to avoid overcurrent. Current consumption at AC 220-240V, 50 Hz in NO SIGNAL mode (volume min at CD mode) should be ~ 350mA.
Page 7
SA-AK350E / SA-AK350EB / SA-AK350EG 3. Use only a grounded-tip soldering iron to solder or unsolder ES devices. 4. Use only an anti-static solder remover device. Some solder removal devices not classified as “anti-static (ESD protected)” can generate electrical charge to damage ES devices.
SA-AK350E / SA-AK350EB / SA-AK350EG 3 Handling Precautions For Traverse Deck The laser diode in the traverse deck (optical pickup) may break down due to potential difference caused by the static electricity of clothes or our human body. So, be careful of electrostatic breakdown during repair of the traverse deck (optical pickup).
SA-AK350E / SA-AK350EB / SA-AK350EG 4 Precaution of Laser Diode Caution : This product utilizes a laser diode with the unit turned "ON", invisible laser radiation is emitted from the pick up lens. Wavelength : 780 nm Maximum output radiation power from pick up : 100 µW/VDE Laser radiation from pick up unit is safety level, but be sure the followings: 1.
SA-AK350E / SA-AK350EB / SA-AK350EG 5 About Lead Free Solder (PbF) 5.1. Service caution based on legal restrictions 5.1.1. General description about Lead Free Solder (PbF) The lead free solder has been used in the mounting process of all electrical components on the printed circuit boards used for this equipment in considering the globally environmental conservation.
SA-AK350E / SA-AK350EB / SA-AK350EG 8 New Features 8.1. Using the Music Port This feature enables you to enjoy music from a portable audio equipment. With reference to page 15 of the operating instruction manual.
SA-AK350E / SA-AK350EB / SA-AK350EG 9 Self diagnosis and special mode setting This unit is equipped with functions for checking and inspecting namely: Self-Diagnostic and Test Mode. 9.1. Service Mode Summary Table The service modes can be activated by pressing various button combination on the main unit and remote control unit. Below is the...
SA-AK350E / SA-AK350EB / SA-AK350EG Below are the procedures for this mode. Step 1: Enter into Doctor mode (for more information, refer to section 9.2 on the key operation to enter into this mode. Step 2: Check for firmware version and EEPROM checksum (By pressing STOP button on main unit followed by “4” and “7” on remote control).
SA-AK350E / SA-AK350EB / SA-AK350EG 9.4. Error code Table Display Self-Diagnosis Function (refer Section 9.2) provides information on any problems occuring for the unit and its respective components by displaying the error codes. These error code such as U**, H** and F** are stored in memory and held unless it is cleared.
Page 21
SA-AK350E / SA-AK350EB / SA-AK350EG 9.4.2. Error Code Table For CD Changer Block...
Page 24
SA-AK350E / SA-AK350EB / SA-AK350EG 9.4.3. Error Code Table For Power Supply 9.4.4. CRS1 Error Code display CRS1 Error Code display 1. The errors that occured in CRS1 Mechanism can be recalled and displayed, in the order of the occurence under self-diagnostic for procedures to enter this mode.
SA-AK350E / SA-AK350EB / SA-AK350EG 10 Assembling and Disassembling 10.1. Caution Special Note: This model uses a new CD changer unit CRS1. In this following section does not contain the necessary disassembly & assembly information for the CD changer unit (CRS1) except the disasembly & assembly of traverse unit. Kindly refer to the original service manual for the CD changer unit.
SA-AK350E / SA-AK350EB / SA-AK350EG 10.2. Disassembly flow chart The following chart is the procedure for disassembling the casing and inside parts for internal inspection when carrying out the servicing. To assemble the unit, reverse the steps shown in the chart as below.
SA-AK350E / SA-AK350EB / SA-AK350EG 10.4. Disassembly of Top Cabinet Step 1 Remove 3 screws on both sides on top cabinet. Step 2 Remove 5 screws at the rear. Step 3 Lift the sides of top cabinet outwards. Step 4 Push the top cabinet backwards to release catches.
SA-AK350E / SA-AK350EB / SA-AK350EG · Disassembly of Mecha Chassis Step 5 Remove 2 screws. Step 6 Remove the Mecha Chassis. Note: For disassembly & assembly of traverse unit, please refer to section 10.15 of this service manual. Please refer to original Service Manual for the Disassembly and Assembly of the CD Changer Unit (CRS1).
SA-AK350E / SA-AK350EB / SA-AK350EG Step 3 Remove up the heat sink sub assembly (with IC5501). Step 4 Remove screw and IC clip. Step 5 Remove IC5501 from the sub assembly. Caution: During assembly of the heat sink sub assembly (with IC5501) all soldering points is touch-up to avoid dry- joints.
SA-AK350E / SA-AK350EB / SA-AK350EG 10.13. Disassembly of Deck mechanism unit · Follow the (Step 1) - (Step 5) of Item 10.4 · Follow the (Step 1) - (Step 4) of Item 10.5 · Follow the (Step 1) - (Step 5) of Item 10.10 Step 1 Remove the 4 screws.
Page 35
SA-AK350E / SA-AK350EB / SA-AK350EG Step 3: Remove the traverse unit as arrow shown. · Assembly of Traverse Unit Step 1: Press and hold the plunger lever and rotate the gear as arrows shown until it stop. Step 1: Turn over the unit and install the traverse unit.
SA-AK350E / SA-AK350EB / SA-AK350EG Step 2: Push the traverse slide plate as arrow shown to lock the traverse unit. 10.16. Disassembly for Deck Mechanism · Follow the (Step 1) - (Step 4) of Item 10.4 · Follow the (Step 1) - (Step 4) of Item 10.5 ·...
Page 37
SA-AK350E / SA-AK350EB / SA-AK350EG 10.16.2. Replacement of Motor, Capstan Belt A, Capstan Belt B, and Winding Belt...
Page 40
SA-AK350E / SA-AK350EB / SA-AK350EG Step 2 Push the lever upward and open the cassette lid. Remove the cassette tape. Note: Follow 10.18 Disassembly of cassette lid (Step1) to (Step 3). Remove the cassette tape.
SA-AK350E / SA-AK350EB / SA-AK350EG 11 Service Fixture and Tools Service Tools Extension FFC (A) Deck P.C.B. - Main P.C.B. REEX0485 (14 Pins) 12 Service Positions Note: For description of the disassembly procedures, see the Section 10. 12.1. Checking and Repairing of Main P.C.B.
SA-AK350E / SA-AK350EB / SA-AK350EG 13 Procedure for Checking Operation of Individual Parts of Deck Mechanism Unit 13.1. Operation Check with Cassette Tape 1. Pull up the EJECT lever using a rubber band. (Fig. 6) 2. Supply DC5V to MOTOR. (→ MOTOR rotates.) (Fig. 5) 3.
SA-AK350E / SA-AK350EB / SA-AK350EG 14 Measurement And Adjustments 14.1. Cassette Deck Section 14.1.1. Requirements · Test tape (QZZCFM) (QZZCWAT) · Normal blank cassette tape (QZZCRA) · Digital frequency counter · Oscilloscope · Electrical voltmeter · Headphone jack output jig (Fig 8) 14.1.2.
Page 47
SA-AK350E / SA-AK350EB / SA-AK350EG Fig. 10 Fig. 11 14.1.5. Bias Voltage Check 1. Connect an electrical voltmeter. (Fig 12) (Fig 9 for location of test points) 2. Set the function to “TAPE” position. 3. Insert a normal blank cassette tape (QZZCRA).
SA-AK350E / SA-AK350EB / SA-AK350EG 15 Voltage and Waveform Chart Note: Circuit voltage and waveform described herein shall be regarded as reference information when probing defect point, because it may differ from an actual measuring value due to difference of Measuring instrument and its measuring condition and product itself.
SA-AK350E / SA-AK350EB / SA-AK350EG 16 Wiring Connection Diagram 9 ..1 CN3601 H5104 CN2810 TUNER PACK MOTOR CN2809 POWER P.C.B. SOLDER SIDE CN2801 MAIN P.C.B. SOLDER SIDE LEFT SPEAKERS TO CRS1 JK5101 (CN1) RIGHT SPEAKERS...
SA-AK350E / SA-AK350EB / SA-AK350EG 18 Notes Of Schematic Diagram (All schematic diagrams may be modified at any time with : FM/AM Signal line the development of new technology) : Tape Record Signal line Notes: S971: Mode switch. : Tape Playback Signal line S972: Half switch.
SA-AK350E / SA-AK350EB / SA-AK350EG 19 Schematic Diagram 19.1. (A) CD Servo Circuit SCHEMATIC DIAGRAM - 1 CD SERVO CIRCUIT OPTICAL PICKUP CIRCUIT : + B SIGNAL LINE : CD DA SIGNAL LINE : CD SIGNAL LINE (FOR REFERENCE ONLY)
SA-AK350E / SA-AK350EB / SA-AK350EG 19.2. (B) Main Circuit SCHEMATIC DIAGRAM - 2 MAIN CIRCUIT : TAPE PLAYBACK SIGNAL LINE : FM/AM SIGNAL LINE : MAIN SIGNAL LINE : AUX SIGNAL LINE : +B SIGNAL LINE : CD SIGNAL : TAPE RECORD SIGNAL LINE...
Page 65
SA-AK350E / SA-AK350EB / SA-AK350EG SCHEMATIC DIAGRAM - 3 MAIN CIRCUIT : +B SIGNAL LINE : MAIN SIGNAL LINE R2335 R2331 R2334 W587 C2333 3.3k C2331 Q2317,Q2417 3300P R2333 B1ABCF000176 6.8k MUTING SWITCH CN2809 F_HOP R2316 2.2k T-GND R2433 TO MAIN SECTION (1/4) MUTE-D-AMP 6.8k...
Page 66
SA-AK350E / SA-AK350EB / SA-AK350EG SCHEMATIC DIAGRAM - 4 MAIN CIRCUIT : +B SIGNAL LINE : CD SIGNAL LINE : FM/AM SIGNAL LINE : MAIN SIGNAL LINE : AUX SIGNAL LINE R2284 W658 R2285 D2811 B0ADCJ000020 R2894 R2121 3.3k TO MAIN SECTION (1/4)
Page 67
SA-AK350E / SA-AK350EB / SA-AK350EG SCHEMATIC DIAGRAM - 5 MAIN CIRCUIT : +B SIGNAL LINE : MAIN SIGNAL LINE TO MAIN SECTION (2/4) IDCDET C2940 Q2942 R2940 B1ACKD000006 820k FAN MOTOR ON/OFF SWITCH Q2942 MOT_12V POSITIVE TO FAN TO MAIN SECTION (3/4)
SA-AK350E / SA-AK350EB / SA-AK350EG 19.3. (C) Panel Circuit SCHEMATIC DIAGRAM - 6 PANEL CIRCUIT :+B SIGNAL LINE : MAIN SIGNAL LINE : AUX SIGNAL LINE TRANSFORMER CIRCUIT (CN5951) IN SCHEMATIC DIAGRAM-11 H6555 R6631 W924 D6301 B0ACCK000005 GND2 SYS6V R6632...
SA-AK350E / SA-AK350EB / SA-AK350EG 19.5. (E) Power Circuit SCHEMATIC DIAGRAM - 8 POWER CIRCUIT : +B SIGNAL LINE : +B SIGNAL LINE : MAIN SIGNAL LINE Q5154 2SB0709AHL Q5173 R5154 W679 PCONT SWITCH B1ABCF000176 R5153 SWITCH R5148 IC5301 IC5401...
Page 71
SA-AK350E / SA-AK350EB / SA-AK350EG SCHEMATIC DIAGRAM - 9 POWER CIRCUIT : MAIN SIGNAL LINE : +B SIGNAL LINE : -B SIGNAL LINE L5604 C5335 0.015 G0B9R5K00001 C5343 0.015 C5334 0.015 C5344 LEFT LOW + 0.015 LEFT LOW - LEFT HIGH +...
SA-AK350E / SA-AK350EB / SA-AK350EG 20 Printed Circuit Board Note: Circuit board diagrams may be modified at any time with the development of new technology.
SA-AK350E / SA-AK350EB / SA-AK350EG 22 Terminal Function of IC's 22.1. IC7001 (MN6627954MA) Servo Processor,Digital Signal Processor/Digital filter and D/A Converter Pin No. Mark Function Pin No. Mark Function DRAM address signal O/P 11 IREF Reference I/P DRAM address signal O/P 9...
SA-AK350E / SA-AK350EB / SA-AK350EG 22.2. IC7002 (BA5948FPE2) IC 4CH Drive Pin No. Mark Function Pin No. Mark Function Motor Driver 92 Input Motor Drive (3) reverse - action output Turntable Motor Drive Signal (“L”:ON) Motor Drive (3) forward -...
Page 86
SA-AK350E / SA-AK350EB / SA-AK350EG Pin No. Mark Function MDATA_OUT CD Command Data Output MCLK CD Command Clock Output /RESET_SW CD Limit Switch Input for the most Inner Point (Active Low) HOME_SW Home Switch for CRS1 CD_RST CD Reset output...
SA-AK350E / SA-AK350EB / SA-AK350EG 24 Replacement Parts List Notes: · Important safety notice: Components identified by mark have special characteristics important for safety. Furthermore, special parts which have purposes of fire-retardent (resistors), high-quality sound (capacitors), low noise (resistors), etc are used.
Page 92
SA-AK350E / SA-AK350EB / SA-AK350EG Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks RXQ0412-3 HEAD PANEL ASS’Y Q2501 B1ABCF000176 TRANSISTOR 133-1 RMB0405-1 FR ROD SPRING Q2511 B1GDCFJJ0047 TRANSISTOR 133-2 RMM0132-1...
Page 93
SA-AK350E / SA-AK350EB / SA-AK350EG Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks D5157 B0JAME000119 DIODE CN5951 K1KA09AA0193 9P CONNECTOR D5158 B0JAME000119 DIODE CN6601 K1MN30AA0004 30P CONNECTOR D5159 B0JAME000119 DIODE...
Page 94
SA-AK350E / SA-AK350EB / SA-AK350EG Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks FP5920 K5G702A00009 FUSE PROTECTOR W628 ERJ6GEY0R00V CHIP JUMPER FP5940 K5G702Z00004 FUSE PROTECTOR W629 ERJ3GEY0R00V CHIP JUMPER FP5950...
Page 95
SA-AK350E / SA-AK350EB / SA-AK350EG Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks W901 ERJ6GEY0R00V CHIP JUMPER K2CT3CA00004 AC CORD [M]EB W903 ERJ6GEY0R00V CHIP JUMPER RQTV0193-1E O/I BOOK (Sp/ Po/ Cz)
Page 96
SA-AK350E / SA-AK350EB / SA-AK350EG Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks R2146 D0GB102JA008 1K 1/16W R2426 D0GB103JA008 10K 1/16W R2149 D0GB332JA008 3.3K 1/16W R2428 D0GB153JA007 15K 1/16W R2151...
Page 97
SA-AK350E / SA-AK350EB / SA-AK350EG Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks R2844 D0GB222JA041 2.2K 1/16W R5146 D0GB102JA008 1K 1/16W R2845 D0GB101JA007 100 1/16W R5147 D0AF2R2JA039 2.2 1/4W R2846...
Page 98
SA-AK350E / SA-AK350EB / SA-AK350EG Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks R6303 D0GB102JA008 1K 1/16W C1204 F1H1E273A002 0.027 25V R6304 D0GB122JA008 1.2K 1/16W C1205 F1H1H471A219 470P 50V R6305 D0GB182JA008 1.8K 1/16W...
Page 99
SA-AK350E / SA-AK350EB / SA-AK350EG Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks C2321 F1H1A105A025 1 10V C2965 ECJ1VC1H102J 1000P 50V C2323 F1H1H153A219 0.015 50V C2967 ECJ1VC1H330J 33P 50V C2325...
Page 100
SA-AK350E / SA-AK350EB / SA-AK350EG Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks C5324 ECQV1H474JL3 0.47 50V C6552 F1H1H103A219 0.01 50V C5325 ECJ1VB1H104K 0.1 50V C6553 F1H1H103A219 0.01 50V C5326...