Table of Contents
Advertisement
Quick Links
Pagoda² 6x6m Instruction Manual
Before assembling or putting up your marquee, read this manual and follow all instructions.
Failure to do so can result in damage to the marquee, serious injury and/or death
The warnings, cautions, and instructions discussed in this instruction manual cannot cover all possible
conditions and situations that may occur. It must be understood by the user that common sense and caution
are factors which cannot be built into this product, but must be considered by the installer and/or user.
Tent, canopy, structure, and shelter products are manufactured for use as temporary structures and do not meet
structural code unless specified. Since weather is unpredictable, the installer/end user must incorporate their
own good judgment, common sense and knowledge of local conditions with the installation instruction guide-
lines. The installer is responsible for anticipating weather severity for proper time and method of installation
This is the safety alert symbol. It is used to alert you to potential personal injury hazards.
Obey all safety messages that follow this symbol to avoid possible injury or death.
Indicates a hazardous situation which, if not voided, could result in death or serious injury.
Indicates a hazardous situation which, if not voided, could result in minor or moderate injury.
v2.1
CROWN CANOPIES
WARNING SYMBOLS AND DEFINITIONS
NOTICE
Advertisement
Table of Contents
Summary of Contents for Crown Pagoda2 6x6m
- Page 1 CROWN CANOPIES Pagoda² 6x6m Instruction Manual Before assembling or putting up your marquee, read this manual and follow all instructions. Failure to do so can result in damage to the marquee, serious injury and/or death NOTICE The warnings, cautions, and instructions discussed in this instruction manual cannot cover all possible conditions and situations that may occur.
-
Page 2: Product Specifications
550gsm Fabric Translucency Blockout Water Repellency Waterproof Flame Resistant UV Resistant Mold and Mildew Resistant Aluminum Frame / Pole Material 9’3”/2.82 m Longest Component Persons required for setup Occupancy 40 Sit Down Dinner-67 Cathedral Seatin © 2020 Crown Canopies PG.2... -
Page 3: Site Analysis
Some soils require additional staking or securing methods than what may be/have been purchased with the standard tent package. Crown Canopies instructions summarize all the functions of each product, the rules for using them and suggestions for their use. However, field situations, site conditions, weather and local experience may mandate other methods. - Page 4 Crown Canopies responsibility is limited to the manufacture of the tent parts and materials. It is the installer’s responsibility, not Crown Canopies, to determine the appropriate number of stakes to meet the necessary wind loads on the installation site.
-
Page 5: Required Hardware
50mm White external ratchet per leg Ratchet Strap Add 2x. stakes per foot 750mm Gutter to 6m Pagoda (12m Hex) Gutter to another Pagoda UHD 3 Way Stake Puller Atlas Marquee Lifter (TBD 2020) © 2020 Crown Canopies PG.5 www.crowncanopies.co.uk... - Page 6 RATCHET PLACEMENT A. 50mm ratchet 50mm Ratchet at 45 degrees Rope ratchet B. Rope ratchet from floor down leg -> 50mm ratchets should be facing away from the centre and 1.5m away from the foot PARTS / MINIMUM STAKING LAYOUT Tent Top Flag Pole Center Pole...
-
Page 7: Installation Instructions
O ring is the last strap to be secured. This ring and strap will allow for better grip when securing the top over the last knuckle. IMPORTANT: The roof should be gently lifted over the wires to avoid excessive rubbing. Crown Canopies is not liable for holes made when dragging the top without due care. Corner Knuckle... - Page 8 INSTALLATION INSTRUCTIONS 8. There are 3 straps for each side that connect the eave pole to the PVC top. There are a total of 18 straps. Buckle them around the eave pole and tighten them so they are taut, but not too tight. IMPORTANT: Having these straps too tight or too loose can result in water pooling on the roof.
- Page 9 Move the center mast pole to the center of the tent making sure it rests on both cross cables. Once in place, put the clip back on the bottom of the center mast pole making sure it is under both cables to keep it in place. Top Cable © 2020 Crown Canopies PG.9 Pagoda www.crowncanopies.co.uk...
- Page 10 INSTALLATION INSTRUCTIONS 15. Install the remaining 2 legs and rope ratchets; be sure the feet are all pointing towards the center as shown in step 14. IMPORTANT: The last 2 legs are the most difficult and will require 2-3 people to lift and insert the legs.
- Page 11 INSTALLATION INSTRUCTIONS Walls Setup Instructions (This step in optional) The sidewalls are designed to hang around the outside of the legs with the ratchet assembly on the exterior of the sidewalls. a. Hang each sidewall by buckling the straps on the top of the side wall around the eave pole that runs around the perimeter of the tent.
- Page 12 INSTALLATION INSTRUCTIONS Taking the tent down 1. Loosen all ratchets. 2. Remove stakes from the feet. If you find this tedious consider the UHD 3 Way stake puller. 3. Remove the rope ratchets down the legs. 4. Remove 2 legs from one side of the tent and carefully set the tent frame on the ground. 5.
- Page 13 FIRE PROOF CERTIFICATE Crown Canopies PVC has passed UK fireproof tests to BS7837. Open flames should never be used under any tent, canopy, structure, or shelter. The below fireproof certificate can be shown to fire officers at public events. PG.13...
-
Page 14: Repair Work
TENT CARE For maximum life of the PVC, Crown Canopies recommends regular cleaning with the use of a soft brush with neutral soaps or cleaners, such as dish soap, or warm water. Thorough rinsing and drying is required before storing the fabric.