Norcold 322 Series Installation And Owner's Manual
Thetford 322: user guide
Hide thumbs
Also See for 322 Series:
- Installation and owner's manual (30 pages) ,
- Repair manual (24 pages) ,
- Replacement manual (2 pages)
Table of Contents
Advertisement
Installation and Owner's Manual
The model numbers of 3-way refrigerators contain ".3". The model numbers of 2-way
refrigerators do not.
The letter "X", in the model number above, stands for a letter or a numeral which means a
refrigerator option.
WARNING:
nance can cause personal injury or property damage. Refer to this
manual. For assistance or additional information, contact a qualified
installer, service agency, or the gas supplier.
FOR YOUR SAFETY
Do not store or use gasoline or other flammable vapors and liquid in the
vicinity of this or any other appliance.
FOR YOUR SAFETY
If you smell gas:
1. Open windows
2. Don't touch electrical switches.
3. Extinguish any open flame.
4. Immediately call your gas supplier.
WARNING: DO NOT install this refrigerator in below deck
marine applications. Do not install this refrigerator in fixed indoor
cabin or other dwelling applications. This refrigerator must use
only NORCOLD designed and approved outside air intake and
exhaust ventilation for correct and safe operation. Any other
ventilation could cause lethal combustion exhaust fumes and/or
propane gas fumes to be present in the living area and/or below
deck.
NORCOLD, Inc.
P.O. Box 4248
Sidney, OH 45365-4248
For model 322X - a 1.7 cu. ft., 2-way refrigerator.
For model 323X - a 1.7 cu. ft., 3-way refrigerator.
Improper installation, adjustment, alteration, service or mainte-
English
Norcold Customer Suport Dept.
Telephone: 800-543-1219
Fax: 937-497-3183
Web Site: www.norcold.com
Part No. 622828G (5-07)
Advertisement
Table of Contents
Related Manuals for Norcold 322 Series
Summary of Contents for Norcold 322 Series
- Page 1 Installation and Owner’s Manual For model 322X - a 1.7 cu. ft., 2-way refrigerator. For model 323X - a 1.7 cu. ft., 3-way refrigerator. The model numbers of 3-way refrigerators contain “.3”. The model numbers of 2-way refrigerators do not.
-
Page 2: Table Of Contents
4. In order to obtain the remedy of repair and replacement, the refrigerator must be brought to any Norcold Service Center for warranty service. The end consumer is responsible for all expenses resulting from any remote service call if the refrig- erator cannot be brought into the Norcold service center. -
Page 3: Gas Absorption Warranty Information
What will the refrigerator owner do? To obtain warranty service, the refrigerator owner responsibilities are: - To use, service, and maintain the refrigerator as specified in the Installation/Owner’s Manuals. - To deliver the warranted product to an authorized Norcold Service Center for warranty repair. -
Page 4: Safety Awareness
Be aware of possible safety hazards when you see the safety alert symbol on the refrigerator and in this manual. A signal word follows the safety alert symbol and identifies the danger of the hazard. Carefully read the descriptions of these signal words to fully know their meanings. -
Page 5: Operating The Refrigerator Controls
- Do not open the door any longer than necessary. Operating the Refrigerator Controls Controls: The refrigerator control panel [1] is located on the rear of the refrigerator (See Art00954). Unlike refrigerators with electric controls, this refrigerator will operate on one energy source, independently of the others. -
Page 6: Do A Test The Gas Safety Valve
(house) battery. The 12 volt system of the vehicle supplies DC power only to the refrigerator but also to any other DC appli- ances of the vehicle. When operating on DC, the refrigerator has a high current draw and can cause a rapid battery discharge. -
Page 7: Refrigerator Care Checklist
- Allow the refrigerator to cool down. - Return all food to the refrigerator. Cleaning A good time to clean the refrigerator is just after you defrost it. To avoid food odors, clean the inside of the refrigerator as often as necessary: - Remove all food from the refrigerator. -
Page 8: Refrigerator Maintenance Checklist
10.5 - 15.4 volts. - Adjust if needed. - Make sure the thermocouple tip is clean and secure. - Make sure the area at the rear of the refrigerator is free from any combustible materials, especially gasoline and other flammable vapors and liquids. -
Page 9: Remove The Refrigerator
- Mark the DC wires so you can put them back in the correct location. - Remove the DC wiring from the refrigerator. 4. Remove the screws which fasten the rear of the refrigerator to the floor. 5. Remove the screws which fasten the refrigerator to the wall. -
Page 10: Refrigeration Failure
9. Connect the AC power cord to the receptacle. Refrigeration Failure If the refrigerator does not cool, it does not mean that the cooling system is defective. Other items which effect the refrigerator operation may be the cause of the problem. -
Page 11: Installation Manual
Be aware of possible safety hazards when you see the safety alert symbol on the refrigerator and in this manual. A signal word follows the safety alert symbol and identifies the danger of the hazard. Carefully read the descriptions of these signal words to fully know their meanings. -
Page 12: Ventilation Requirements
The breathing of carbon monoxide fumes can cause dizziness, nausea, or in extreme cases, death. - Make sure the refrigerator is completely isolated from its heat generating components by the correct use of baffles and panel construction. Certified installation needs one lower intake vent and one upper exhaust vent. -
Page 13: Reverse The Door Swing (Optional)
- Make sure the baffle is the full width of the inside of the enclosure. - If the distance from the back of the refrigerator to the wall of the vehicle is more than one inch, install a baffle [7] between the back of the refrigerator to the wall of the vehicle. -
Page 14: Connect The 120 Volts Ac Supply
If you use compressed air for the test: - The pressure at the gas control of the refrigerator must not be more than 1/2 psig (14 inches Water Column). - If the air pressure is more than 1/2 psig (14 inches Water Column), remove the gas supply line from the bulkhead fitting of the refrigerator before the test.