Page 2
If and when new materials and production techniques are developed that can improve the quality of its product, or material substitutions are necessary due to availability, Airstream reserves the right to make such changes.
However, should you ever feel equipment. that you may be in need of assistance, please consult your Airstream dealer for advice on repairs that may be NOTE required. A note is used to address practices not related A brief explanation of the operation of the appliances to personal injury.
Safety Safety Precautions Appliances and Equipment The appliances (stove, refrigerator, etc�) and equipment Many things can be construed as safety related, but (hot water heater, furnace, etc�) typically operate on the most important is your common sense� If you are liquefied petroleum LP gas.
WARNING Airstream strongly suggests that you take measures to properly ventilate your trailer on a regular basis� If you Smoke alarms have a limited life. The unit should have any questions with respect to proper ventilation...
The alarm will only indicate the presence Carbon Monoxide alarm user’s manual, please contact of carbon monoxide gas at the sensor. Carbon the manufacturer, your dealer, or Airstream Customer monoxide gas may be present in other areas. Service� Important Safety Precautions •...
Safety The following conditions can result in potentially Liquid Propane Gas (LPG) Detector dangerous CO situations 1� Excessive spillage or reverse-venting of fuel- burning appliances caused by outdoor conditions, such as: • Wind direction and/or velocity, including high gusts of wind� •...
Safety Detector Test Fire Extinguisher The Test/Reset button is used to verify proper alarm function� Executing the test function sounds the alarm and illuminates the red LED� The test will sound the alarm twice, with four beeps in 1 second, followed by 5 seconds of silence�...
(1) within 10 days of your discovery (ii) ONLY those portions of a NEW travel trailer not of a defect you notify Airstream OR an authorized excluded under the section “What is Not Covered”, dealership of the defect; AND (2) you deliver your when sold by an authorized dealership;...
7� Travel trailers not purchased through an authorized penses such as transportation to and from dealerships dealer of Airstream and travel trailers purchased and Airstream repair facilities, loss of time, loss of pay, directly or indirectly through auction, salvage, loss of use, inconvenience, commercial loss (includ- repossession, or other non-customary sale means;...
Abuse Attention: Owner Relations Department Lack of customer care and/or improper maintenance will result in early failure for which Airstream cannot be Airstream may direct you to an authorized Airstream held responsible� dealer, or may request that you bring your travel trailer...
Warranty is available through our nationwide network the exterior caulking and sealer of your unit� It is the of Airstream Dealer Service Centers� An up-to-date list responsibility of the owner to use reasonable, prudent of Dealer Service Centers will be sent to you with an care to prevent foreseeable secondary damage from Owner’s Survey shortly after your trailer is delivered�...
2� Turn off gas at LP tanks� Safety Administration (NHTSA), in addition to notifying 3� Retract stabilizing jacks� Airstream Inc� 4� Check hitch for proper attachment� If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists 5�...
All you need to do to enjoy the self-contained luxury roadside locations by turning off the main highway and of your Airstream is to turn on the LP and light any exploring� appliance pilot lights�...
General Information Extended Stay WARNING Making a long trip in your Airstream is not very different from making a weekend excursion� Since everything Whenever the trailer must be lifted with a jack, as you need is right at hand, you are at home wherever when changing a tire or leveling on very rough you go�...
General Information Tips To Control Condensation Molds Allow excess moisture to escape to the outside when: Molds are microscopic organisms that naturally occur in virtually every environment, indoors and • Bathing, washing dishes, hair drying, etc� out� Outdoors, mold growth is important in the •...
General Information Waste Water Systems 23-ft. D Model The main parts of the waste water system are the toilet, dual holding tanks, and tank dump valves (see Section 8 - Maintenance for dump valve information)� The system is designed to provide complete self- contained toilet facilities, while on the road or parked, without being connected to a sewage line�...
Page 23
General Information 25-ft. Model 27-ft. FB Model 1� Galley Drain 1� Lavatory Drain 2� Lavatory Drain 2� Black Water Tank (Toilet) 3� Shower Drain 3� Galley Drain 4� Toilet Drain 4� Gray Water Tank 5� Shower Drain 28-ft. Model 25-ft. FB Model 1�...
General Information 30-ft. Model Winter Traveling Traveling in sub-freezing temperatures will require certain precautions to protect the plumbing system and your personal belongings from being damaged by freezing� Whenever possible, the heat should be kept set to a constant temperature� It is easier for the furnace to keep a constant room temperature than allow the trailer temperature to drop to 50°F, and then attempt to raise it to room temperature�...
General Information Safety As always, safety should be a top priority� Ensure you and everyone traveling with you can operate the main door and emergency exit window rapidly, without light� Contemplate other means of escape in case the designated exits are blocked� The escape windows(s) are identified by their red release handles�...
Page 26
General Information NOTES 3-14 2017 International...
RA-400 Patcher for UD Section 4 FLOOR PLANS AND SPECIFICATIONS FLOOR PLANS AND SPECIFICATIONS FLOOR PLANS 19’ International Signature/Serenity 23D International Signature/Serenity 23FB International Signature/Serenity 25’ International Signature/Serenity 25FB International Signature/Serenity 27FB International Signature/Serenity 28’ International Signature/Serenity 30’ International Signature/Serenity SPECIFICATIONS Specification Chart Specification Tags...
Floor Plans And Specifications Floor Plans 19’ International Signature/Serenity WARD ROBE GALLEY SHOWER DINETTE/BED 4.0 CU. FT. FRIDGE/ LED TV ABOVE 23D International Signature/Serenity LAVY 5 CU.FT. FRIDGE/ MICROWAVE LOUNGE/BED OVERHEAD SHOWER DINETTE/BED GALLEY 23FB International Signature/Serenity WARD 5 CU. FT. ROBE FRIDGE GALLEY...
Page 29
Floor Plans And Specifications 25FB International Signature/Serenity 7 CU. FT. WARD TWIN BED FRIDGE LOUNGE/BED SHOWER ROBE NIGHT DINETTE/BED STAND QUEEN BED TWIN BED GALLEY 27FB International Signature/Serenity 7 CU. FT. NIGHTSTAND WARDROBE TWIN BED FRIDGE LOUNGE/BED SHOWER DINETTE/BED QUEEN BED NIGHT STAND TWIN BED...
Floor Plans And Specifications Specifications Specification Chart NOTE All weights listed in the Specification Chart are checked and updated throughout the model year. Your production trailer may vary from weights listed. International Signature/Serenity Model 19’ 23’ D 23’ FB 25’ 25’...
Page 31
Floor Plans And Specifications Measuring Hitch Ball Height The UBW and NCC weights listed in the Specification Chart are for the base unit with no options and fluids. The proper height will vary according to the weight you Gross Vehicular Weight Rating (GVWR) is the carry and the tires you use.
Page 32
Floor Plans And Specifications NOTES 2017 International...
General Information and Cleaning Interior Aluminum Skin Interior aluminum skin can be cleaned by washing with The interior of all Airstream trailers has been designed any mild non-abrasive soap or detergent� Cleaning for comfort, convenience, durability, and appearance� should be followed by a thorough clean water rinse�...
Interior Sinks Telephone Shower Head The telephone shower head is designed to give Cleaning can be accomplished using a mild liquid maximum flexibility in usage, and provides for water- detergent on a soft cloth� A complete home owner’s saving techniques when using your trailer on self- guide for your sinks is supplied in your owner’s packet�...
For some time, the open faucet will only sputter� This is because the water heater is being filled and All lighting in the Airstream trailer is LED and most will air is being pushed out through the lines� Once the require a replacement fixture should it go out.
Toilet Drain and Waste System The RV toilet in your Airstream is a design that has Your trailer has a drain and waste system that includes been used for many years� There is either one or two waste-holding tanks made from corrosion-free, molded pedals depending on your model�...
Faucet Cleaning and Care All that is needed to clean your faucet is a soft, damp Lavatory Faucet cloth� Airstream does not recommend the use of scour pads, cleansers, or chemicals� The abrasive nature of these substances could damage the faucet’s finish. A non-abrasive car wax will help to protect the finish.
Interior Battery Disconnect Switch Converter The disconnect switch is used to separate the batteries All International models have the converter installed from the 12-volt distribution panel and converter on the front lower portion of the pantry, at the base charging system� of the bed, or at the front of the L-lounge�...
Interior 12-Volt Power Circuits 120-Volt AC Panel Board The current in the converter system is 12 volts direct The AC panel board section of the power converter current (12 VDC) negative grounded� Power sources contains the 120 VAC branch circuit breakers for your that supply 12-VDC current to the system are as RV�...
If that does not solve the there will be no problems with proper polarity or problem, consult an Airstream Service Center� grounding with a properly wired shoreline outlet. The 120-volt electrical system provides power to...
NOTE All GFCI breakers implement an auto self-test WARNING function, however, Airstream recommends a The GFCI circuit breaker provides protection only manual test be conducted every month. to the circuit to which it is connected. It does NOT Use the following chart for recording GFCI breaker and provide protection to any other circuit.
Solar Panel ultraviolet shield� Clean only with mild soap and water� Use no solvents, alcohol, or cleaning fluids. Airstream utilizes the Zamp Solar 80 watt solar panel and the Sun Explorer Charger Controller/Display TV and Blu-Ray Player System� Cut the cord to expensive daily shore power International trailers are equipped with Samsung LED hook-ups with the 12-volt solar charging system�...
Interior Appliances WARNING All appliances are delivered to Airstream Inc� with in- depth owner’s manuals� Those manuals are included in Most LPG appliances used in recreational vehicles the delivery case supplied by your dealer� The manuals are vented to the outside of the vehicle. When...
If they should become misplaced, new literature can be ordered directly Never place Lindeen™ or a like cover over ceiling from the manufacturer or your Airstream dealer� The fan. Greatly restricted airflow and increased sound manufacturer also offers a detailed service guide for levels will occur.
The fan increases the cooling efficiency of the section� If the refrigerator is operated out-of-level refrigerator; therefore Airstream recommends leaving when the vehicle is not moving, liquid ammonia will the switch on whenever possible� Please note that accumulate in portions of the evaporator tubing�...
Interior SeeLevel II Monitor Panel 3� To continuously display a reading, press and release the desired button, and then press the same button a second time� When the button is released, the display will be on hold mode, which is indicated by the decimal point on the right hand side turning on�...
Interior Thermostat WARNING Hydrogen gas can be produced in a hot water system served by this heater if it has not been used for a long period of time (generally two weeks or more). Hydrogen gas is extremely flammable. To reduce the risk of injury under these conditions, it is recommended that the hot water faucet be opened for several minutes at the galley sink...
If a substance is found on the coating that cannot be cleaners or polishes on coated aluminum wheels� removed by normal washing procedures, Airstream recommends using DX 330 Acryli-Clean, made by PPG Industries� Follow all directions and warnings on the product container�...
Exterior General Information and Operation Screen Door The screen door is secured to the main door by a slide Step bolt-type latch� It can be operated independently by releasing the slide bolt and swinging the screen door away from the main door� Emergency Escape Windows To remove the screen, pull out the screen cord by the cord loop at the bottom portion of the window�...
When ON this switch will disconnect the power to the awning� Airstream recommends the awning lock switch be turned ON while traveling� If the 7-way plug is connected the power awning will automatically lockout the first time the tow vehicles brakes are applied.
NOTE struck at an angle� Rear axles are occasionally damaged when people are attempting to park beside a Use only power cords recommended by Airstream. curb while backing up their trailer� Many campgrounds provide less than 30-amp service, The trailer axle(s) is bent upward in the middle� This and your hookup may blow their fuse or circuit breaker�...
Exterior Power Jack Hitch/Coupler A switch located on the bottom of the housing operates the power jack� When the jack is fully extended or retracted, internal limit switches automatically shut off the motor� The jack is wired directly to the battery and has an in-line fuse between the battery and the power head�...
Exterior Liquid Petroleum Gas (LPG) Bypass flow is extremely important in the proper operation of this connection. The flow-limiting device Fill Valve may activate if the cylinder valve is opened quickly� When all appliances are off, the bypass flow allows the pressure downstream from the flow-limiting device to equalize.
Exterior Automatic Gas Regulator 3� Turn the large clamping T-handle counterclockwise until the hold-down bracket is loosened enough to be able to remove the tank� If your trailer is equipped with a gas tank cover, the T-handle must be removed, and then the cover removed before removing the bottle WARNING Do not remove the center hold-down rod.
Exterior Exterior LPG Port WARNING An exterior LPG port quick-connect is installed on the hitch A-frame of your trailer� An LPG supply line is Do not store LPG tanks within a vehicle. LPG shipped with the trailer in the loose parts box� This can tanks are equipped with safety devices that vent be used to connect a lantern or other appliance that gas should the pressure become excessive.
Towing Tow Vehicle Brakes When buying a new vehicle to tow your trailer, we All trailers are equipped with Dexter Nev-R-Adjust suggest including towing options offered by most tow brakes� Please follow all maintenance procedures vehicle manufacturers� These include such things as a in the Dexter user’s manual provided in the owner’s heavy-duty alternator and radiator, heavy-duty springs packet�...
A full load of water equals XXX kg or XXX lbs of cargo @ 1 kg/L (8.3 lb/gal) WARNING Airstream weighs the trailer as finished to arrive at the Do not use the breakaway switch as a parking trailer’s weight� That number is subtracted from the brake.
Towing Weighing Your Trailer Place a piece of wood of approximately the same thickness as the bathroom scale on the ground in line The illustration below shows how to weigh the trailer on with the trailer hitch jack as shown� It should be so scales�...
Towing Tips and Information radiator overflow outlet. Ensure all drive belts are intact We want every Airstream owner to be a safe and and the radiator fan is turning� If you have a problem, courteous driver� A few hours of towing practice in a have it fixed at the next opportunity.
Towing Downhill and Non-level Driving Passing When going downhill in dry weather, downshift so that On freeways or expressways, pick the lane you want engine compression will slow the whole rig down� Take and try to stay in it� Always maintain plenty of space dips and depressions in the road slowly and do not between you and the car ahead, at least the length of resume normal driving speeds until you are sure that...
Sway Control Device in this section for more manufacturer’s field of expertise and performed formal information� testing, we find the vast majority of Airstream owners Tongue weight purchase sway-control devices� Refer to Weighing Your Trailer and, Equalizing Hitch When passed by large trucks or when exposed Load Distribution in this section�...
Maintenance Maintenance Schedule Every 5,000 miles or 90 days Hitch Ball Latch Lubricate with non-detergent WARNING motor oil. Hitch Ball Lubricate with hitch ball lube or Failure to maintain your trailer can cause pre- wheel bearing grease. mature and unexpected parts breakage and/or Range Exhaust Clean fan blades and wash erratic operation that may be hazardous.
Maintenance Suggested Maintenance and Replacement Parts (Part numbers listed are Airstream part numbers and can be ordered by calling a Certified Airstream Dealer.) WARNING Always replace the bulb or light fixture with the correct bulb for that light or matching fixture. Failure to heed this warning could cause fire, property damage, personal injury, or death.
The following exterior care products are recommended (PN - 365330-03 [10 oz tube-Gray]) - Use anywhere a by Airstream. Read and follow label directions. Exterior thicker bead of Gray sealant is required. sealant should be checked and resealed once a year.
Most Airstream dealers cannot make Never attempt to change any tire on the trailer adjustments to tires. An Airstream or tire dealer that without securely chocking the trailer’s remaining handles that particular brand must do this. If you wheels.
Maintenance Tire Load and Inflation Information How Overloading Affects Your Tires Tire pressure is what enables your trailer tire to Maintaining proper tire inflation pressure is essential for support loads, thus, overloading can have serious both tire safety and performance. consequences.
Maintenance 6� Never drive on smooth tires. Tires should be Most trailers are towed at or near maximum loads removed when 2/32 in. of tread depth remains. In during hot weather and then are left idle for months. In most states, it is illegal to drive with less than 2/32 normal use, oils in the tire come to the surface during in.
Maintenance Spare Tire Carrier Refer to the following table for wheel specifications. Wheel Specifications The spare tire for Airstreams is stored under the front of the trailer. The front handle of the tire carrier is a Size/Center Size Lug Pattern Model 1-in.
Dolly wheels are not Maintenance Manual enclosed in your owner’s recommended. Always retract stabilizing jacks packet. Airstream recommends these procedures be before using your jack under load. performed by a qualified Dexter service technician, due Breakaway Switch the need of specialized tools and training.
Battery (Lead Acid) Battery Cleaning Battery maintenance is an important issue. Maintain a Your Airstream trailer is factory equipped with an clean battery top and check terminals and cables for Interstate battery (SRM-24). When solar panel tightness and cleanliness. A dirty battery will dissipate equipped an AGM GPL-24 battery will be installed.
Maintenance Water Pump Fresh Water Tanks and Draining Water Pump Access Locations Drain Valves The 19 ft. - has the water pump located under the roadside front dinette seat. Access is gained by removing the wood panel under the seat cushion. The 23 ft.
Maintenance Fresh Water Tank Draining 23 ft. Front Bed - is inside the removable bedroom wardrobe cabinet lower face panel. The panel is held Pumping the water out with the self-contained water on by two pressure catches and can be removed by pump can empty the fresh water tank.
Maintenance Black Water Tank Dumping When you are in a park and connected to a sewer outlet, keep the main holding tank dump valve closed and empty the tank every few days, or whenever it becomes almost full. Only by sending a large volume of liquid, all at once, through the main holding tank will toilet paper and other solids completely wash away.
Maintenance Winterizing and Storage 9� Lower the front of the trailer as far as the jack will allow until water ceases to drain, and then crank When storing your trailer for short or long periods, the jack up as high as it will go and allow any use the same precautions as you would in your own remaining water to drain out.
* When using the stabilizers (for eliminating movement- not leveling) on your Airstream, be sure to check 5� Dilute the antifreeze solution in accordance with the fit of your main door before and after extending the manufacturer’s instructions.
Maintenance 120-Volt/30- and 50-Amp Diagrams The following electrical diagrams are representative of the National Electric Code (NEC) and Canadian Standards Association (CSA). All circuits are NEC with the exception of CSA circuits as specified in each respective table. 8-18 2017 International...
Maintenance 27FB International Main Area TV Receptacle 1.5 Amps Main Circuit, 30 Amp Main Area TV Receptacle - CSA 1.0 Amps Circuit 1, 20 Amp Dinette Receptacle 1.5 Amps Air Conditioner 16.0 Amps Dinette Receptacle - CSA 1.0 Amps Circuit 2, 20 Amp (15 Amp - CSA) Blu-Ray Player Receptacle 1.5 Amps Converter (Wired Direct)
Maintenance Standard 30 Amp Circuit Breaker Layout Standard 50 Amp Circuit Breaker Layout NEUTRAL BUSS 20 20 20 20 GROUND BUSS 8GA BARE COPPER • Circuit 6 - 20 Amp - Converter, Bedroom, Blu-Ray Player Receptacles PLACE BREAKER LABEL HERE. •...
Page 100
The following diagram depicts the way Airstream wires bar to an area just behind the Seelevel Monitor display. the solar system on factory-installed units and is the The best way to reach the Cat 5 cable is to remove recommended wiring for use of the pre-wire system.
Plumbing may harm the system. 1. While parked at my site, do you recommend 3. I was told my Airstream is pre-wired for solar leaving my dump valves open? panels. What does this mean? Answer: You cannot leave your black water valve open.
Walbernize Superseal is a product that was designed 1. I am planning for a trip in my Airstream. How specifically for Airstream and provides good wax should I get the refrigerator cooled down? protection�...
Page 103
Aerospace Protectant 303 to the seals. Clean edge of glass also. 10. The mattress in my Airstream is an odd shape, where can I buy sheets? Answer: Airstream has a selection of sheets for your Airstream and can be purchased by calling (937) 596- 6111 extension 7400 or 7418.