Page 1
ORDER NO.VMD0004016C8 Digital Video Camera/Recorder NV-DS15EG / NV-DS15B / NV-DS15EGM / NV-DS15EN / NV- DS15ENC / NV-DS15A / NV-DS150EG / NV-DS150B VOL.1 Q3-MECHANISM SPECIFICATIONS...
Page 2
1. INTRODUCTION 1.1. INTRODUCTION1 This service manual contains technical information which will allow service personnel's to understand and service this model.Please place orders using the parts list and not the drawing reference numbers. If the circuit is changed or modified, this information will be followed by supplement service manual to be filed with original service manual.
1. Schematic Diagram, Block Diagram and C.B.A. layout of Main C.B.A. 2. Parts List for individual parts of Main C.B.A. 3. Exploded View and Parts List for individual parts of Mechanism Unit. When a part replacement is required for repairing Main C.B.A. and/ or mechanism block, replace the assembly parts.
If you lose the fuse cover, the plug must not be used until a replacement cover is obtained. A replacement fuse cover can be purchased from your local Panasonic Dealer. If the fitted moulded plug is unsuitable for the socket outlet in your home then the fuse should be removed and the plug cut off and disposed of safety.
coloured markings identifying the terminals in your plug, proceed as follows: The wire which is coloured BLUE must be connected to the terminal in the plug which is marked with the letter N or coloured BLACK. The wire which is coloured BROWN must be connected to the terminal in the plug which is marked with the letter L or coloured RED.
5. SERVICE MODE When undesirable conditions occurred, the error code is displayed on the EVF or LCD Monitor. Also, the Camera LED is flashed according to the error code as follows.
6. HOW TO REPLACE THE LITHIUM BATTERY (PROCEDURE) 1. Remove the Power Flex. from Rear Case Unit. (Refer to Disassembly Procedures.) 2. Unsolder the Lithium Battery“ML920S” and then replace the new one. (See Fig. B1.) Fig. B1...
Note: The lithium battery is a critical component. (Type No.: ML920S Manufactured by Panasonic.) It must never be subjected to excessive heat or discharge. It must therefore only be fitted in equipment designed specifically for its use. Replacement batteries must be of the same type and manufacture.
8.1. DISASSEMBLE FLOW CHART This flow chart indicates the disassembly steps the cabinet parts, C.B.A. and Mecha. Unit in order to access to be serviced. When reinstalling, perform the steps in the reverse order. Fig. F1 8.2. DISASSEMBLY PROCEDURES Flow-Chart for Disassembly Procedure...
Page 12
No. Item/Part Fig. Removal(Screw& Other) 1. Front Fig. 1- 5-Screws(A/B/C) Case Unit& Bottom Fig. 1- 6-Screws(D/E) Case Unit Fig.1- 1-Screw(F) 1-Screw(G) Fig.1- Unlock---(a) Remove the Bottom Case Unit. Unlock---(b) Remove the Front Case Unit. 2. Side Case Fig. 2- 4-Screws(H/I/J) (R) Unit Fig.
Page 13
No. Item/Part Fig. Removal(Screw& Other) 8. LCD Unit Fig. 5- 5-Screws(O/P) Remove the LCD Unit from Side Case (R) Unit. Fig. 5- 2-Screws(Q) Unlock---(e) Remove the LCD Case(Upper). Disconnect the following connectors. FP901/FP903/FP904/FP905 Unsolder read wire from Back Light Unit. Fig.
Fig. 6-5 8.3. DISASSEMBLY PROCEDURES OF CAMERA LENS UNIT The following flowchart describes order or steps for removing the Camera lens unit and certain printed circuit boards in order to make access to the item needing service. / To reassemble the unit follow the steps in reverse order.
11.3. POWER SCHEMATIC DIAGRAM 11.4. MIC UNIT SCHEMATIC DIAGRAM 11.5. MONIITOR& HALL SENSOR FLEX. CARD SCHEMATIC DIAGRAM 11.6. E.V.F. (A)& E.V.F. (B) SCHEMATIC DIAGRAM 11.7. FRONT JACK SCHEMATIC DIAGRAM 11.8. SIDE CASE (R) OPERATION SCHEMATIC DIAGRAM / (Included in Side Case (R) U.) 11.9.
14. REPLACEMENT PARTS LIST 14.1. FRAME& CASING SECTION (1) PARTS LIST...
Page 30
Ref. No. Part No. Part Name& Description Pcs Remarks 1 (1) VKF3240 EVF COVER 2 (1) N9ZZ00000028 SIDE CASE (R) U. 3 (1) VEK8948 SPEAKER U. 4 (1) VGQ3457 BARRIER 5 (1) VMC1575 SPEAKER FIXING SPRING 6 (1) VMG1158 PROTECT RUBBER 7 (1) VYK9507 FRONT CASE U.
14.2. FRAME& CASING SECTION (2) PARTS LIST Ref. No. Part No. Part Name& Description Pcs Remarks 103 (2) VYQ1914 LENS FRAME U. 104 (2) N9ZZ00000034 REAR CASE U. 105 (2) VGQ5669 GRIP BELT PIECE (A) 106 (2) VGQ5754 GRIP BELT PIECE (B) 107 (2) VKF3239 JACK COVER...
Ref. No. Part No. Part Name& Description Remarks 413 (5) VYF2700 HOOD CAP U. 14.6. ELECTRICAL REPLACEMENT PARTS LIST Ref. No. Part No. Part Name& Description Remarks VEP03F47A VTR MAIN C.B.A. (RTL) NV- DS15EG/B/EGM NV-DS150B VEP03F47B VTR MAIN C.B.A. (RTL) NV-DS15EN /ENC/A NV-DS150EG VEP01869A...
Page 44
Ref. No. Part No. Part Name& Description Remarks D6804 SLR738AV50AC FP4903 VJS3498A026 CONNECTOR (FEMALE) 26P IC4801 NJM2112V IC4802 NJM2172V IR6401 PNA4611M05VT IR RECEIVER JK2501 VJJ0580 JACK JK4501 VJJ0567 EDIT-E JACK (5P) JK4502 VJJ0695 S JACK JK4503 VJJ0666 DV JACK JK4901 VJJ0414 MIC JACK JK4902...
Page 54
MONITOR C.B.A. FP6301 FP905 POWER SW RVS GND HALL SENSOR REAR CASE UNIT D GND RVS VCC FLEX. CARD C.B.A. OPEN SCAN2 OPEN GND MODE SELECT SCAN1 OPEN VCC CAM LED PHOTO SHOT POWER VTR LED CAM LED FP901 CAM VTR ST H1 VTR LED OE H...
Page 60
:VIDEO MAIN SIGNAL PATH MONITOR LCD PANEL LB904 FP901 C926 POWER VLQ0584-T 6V10 FP903 ST H1 FP602-16 M 5V C952 OE H C927 QR902 FP602-16 M 5V LB902 VLQ0584-T Q2 H FP602-15 M 12V UN9111J CLK1 FP602-14 M -15V (AMP) R903 R904 CL901...
Page 61
CCD C.B.A. CAMERA LENS UNIT VIDEO AUDIO RS232C SPEAKER FOCUS M. IRIS ZOOM M. OP AMP MIC UNIT VIDEO 1 VIDEO 2 HEAD/REC AMP CAMERA HEAD VIDEO OUT AUDIO I/F SP AMP CDS/AGC/AD VIDEO 3 PB Y/C CAM Y/C GIPSY VIOLA LUPIN LCD RGB...
Page 66
POWER SW PHOTO SHOT VCR MODE CAM LED VTR LED MAIN CONNECTION POWER SW SCAN2 SCAN1 PHOTO SHOT CAM LED CAM/VTR VTR LED ZOOM AD V REF ZOOM...
Page 67
MENU AF/MF STOP/FADE REW/SER(-) FF/SER(+) PLAY/BACKLIGHT PAUSE/WB MAIN CONNECTION D GND CAM MOD CAM MNL MENU AF MF SCAN3 REW/SER(-) FF/SER(+) FP6302 STOP/FADE PAUSE/WB PLAY/BACKLIGHT SCAN4 ENC SW D GND ENC- ENC+ CAM MODE AUTO/MNL AUTO CAM MODE TRUTH TABLE POS.
Page 70
INITIAL/LOGO ABBREVIATIONS INITIAL/LOGO ABBREVIATIONS A GND Analogue GND ALC MAIN Auto Level Control Drive A HASW Audio Head Amp Switching Pulse Address Latch Enable A HSW Audio Switching Pulse A-LOCK Full Auto Switch A MUTE Audio Mute A-MUT(H) Audio Mute (H) A ORP Audio Overlap Pulse ANLPTH...
Page 71
INITIAL/LOGO ABBREVIATIONS INITIAL/LOGO ABBREVIATIONS BLKZ Blanking Pulse for Zoom Encorder Channel 1 (Odd Field) Balance Modulator Character BQUIET Bus Out Control Signal CHR BACK Character Back-up BUF IN/OUT Buffer In/Out CHR MIX Character Mix B-Y KB B-Y Carrier Balance CI, CO Buffer In/Out B-YO B-Y Signal Out...
Page 72
INITIAL/LOGO ABBREVIATIONS INITIAL/LOGO ABBREVIATIONS Pre Apature Gain Control DISCS Dis Chip Select CRST Camera Reset DISP Display Chip Select Delay Line CS 0-7 Chrominance Signal Out 0-7 DOBCK Audio A/D Convertor Bit Clock CSEL Clock Phase Select DOCTL Data Output Control Signal CSI 0-7 Chrominance Signal In 0-7 DODAT...
Page 73
INITIAL/LOGO ABBREVIATIONS INITIAL/LOGO ABBREVIATIONS Equalizer Horizontal Drive Pulse Electric View Finder HDTV High Definition TV EXT DC External DC (AC Adaptor) Hexadecimal EXT DC(H) AC Adaptor DC (H) Hall Gain EXT NOREG AC Adaptor 6V Head Switching Pulse EXT S DATA Serial Data for Edit High Bright Signal EXT SCK...
Page 74
INITIAL/LOGO ABBREVIATIONS INITIAL/LOGO ABBREVIATIONS LPF Switch for Auto Focus P SW Power Switch PB1-3 PNP Base 1-3 M M1-3 Motor Coil Terminal 1 to 3 PBCTL Play Back Control MA0-5 Microprocessor Address Data 0-5 PBCTL Pre-Branking Control Mbps Megahertz Bit Per Second Head Amp Switch Modulation PBLK...
Page 75
INITIAL/LOGO ABBREVIATIONS INITIAL/LOGO ABBREVIATIONS RENCF Lens Control (Forward) Switching Pre-Drive Pulse RENCR Lens Control (Reverse) SYL EC Cylinder Torque Control RERASE Rotary Erase Head SYL FG Cylinder FG RGBIV1-2 1V Inverted Signal 1-2 RGO R/G OFF Offset Voltage for AWT R T PHOT Take-up Photo Transistor Capstan Direction (Reverse / Stop / Forward)
Page 76
INITIAL/LOGO ABBREVIATIONS INITIAL/LOGO ABBREVIATIONS VMODE NTSC/PAL Select Switch VMVH VH Filter Switching VORP Video Overlap Voltage Refference Bottom VRBS Voltage Refference Bottom Output VREF1R3V Refference Voltage 1.3V VREF3R3V Refference Voltage 3.3V VREFH Refference Voltage High Side VREFL Refference Voltage Low Side Refference Voltage Input Refference Voltage Output Voltage Refference Top...
Page 77
IC901-11 STOP IC901-14 STOP IC901-16 STOP IC901-2 STOP IC901-48 STOP 10.8 Vp-p (20µsec./div.) 10.8 Vp-p (20µsec./div.) 10.8 Vp-p (20µsec./div.) 3.4 Vp-p (5msec./div.) 3.4 Vp-p (5msec./div.) COLOUR BAR COLOUR BAR COLOUR BAR COLOUR BAR COLOUR BAR FP802-6 STOP IC901-1 STOP IC901-47 STOP IC901-46 STOP FP802-7 STOP 8.0 Vp-p (20µsec./div.)
Page 78
CASSETE DOWN S6301 MAIN CONNECTION VSP0584-1 C DOWN EJECT FP6303 S6302 VSP0584-1 EJECT NOTE: DO NOT USE ANY PART NUMBER SHOWN ON THIS SCHEMATIC DIAGRAM FOR ORDERING.WHEN YOU ORDER A PART,PLEASE REFER TO PARTS LIST.
Page 80
:VIDEO MAIN SIGNAL PATH MAIN CONNECTION PS291 TL251 PP201 -6.5V C296 -6.3 11.7 D291 MA143 IC291 ICX221AKJ-6 (CCD) R292 -7.2 -7.2 -0.3 -0.3 11.8 1800 11.8 C295 C292 Q291 35V2.2 11.7 2SC3930 (AMP) 11.0 NOTE: NOTE: DO NOT USE ANY PART NUMBER SHOWN ON THIS SCHEMATIC THE MEASUREMENT MODE OF THE DC VOLTAGE ON THIS DIAGRAM FOR ORDERING.WHEN YOU ORDER A PART,PLEASE DIAGRAM IS STOP MODE.
Page 84
:VIDEO MAIN SIGNAL PATH MAIN CONNECTION EVF LCD PANEL FP802 FP803 R806 1K FP801-26 EVF HD R826 1K FP801-25 EVF VD CK V1 R844 1K FP801-24 CLAMP CK V2 FP801-23 E PLL V VDD FP801-22 EVF R FP801-21 EVF G X STV R837 10K FP801-20...
Page 85
FP2203 FP2202 S TAB FG(+) D GND D GND NOREG GND SNS LED MIC CLK CYLINDER MECHA. UNIT VH(-) T REEL(-) T REEL(+) D GND VH(+) PG(+) LOADING MOTOR S-TAB SW MIC DT MIC VDD POSITION SW SENS LED S REEL(-) FP5001 S REEL(+) S/T-REEL...