Page 1
Additional manuals are available from your WELLS DEALER. THIS MANUAL MUST BE READ AND UNDERSTOOD BY ALL PERSONS USING OR INSTALLING THIS APPLIANCE. Contact your WELLS DEALER if you have any questions concerning installation, operation or maintenance of this equipment.
THE FOLLOWING WILL NOT BE COVERED UNDER WARRANTY. products to be free from defects in material or workmanship, under normal Wells’ sole obligation under this warranty is limited to either repair or and proper use and maintenance service as specified by Wells and upon...
TABLE OF CONTENTS WARRANTY Thank you for purchasing this SPECIFICATIONS Wells Bloomfield appliance. FEATURES & OPERATING CONTROLS PRECAUTIONS & GENERAL INFORMATION Proper installation, profes- AGENCY LISTING INFORMATION sional operation and consistent INSTALLATION maintenance of this appliance OPERATION will ensure that it gives you the...
FEATURES & OPERATING CONTROLS ITEM COMMENT TEMPERATURE CONTROL The char-broiler is INFINITE SWITCH CONTROLLED. Power is ap- plied to the heating elements based on the control knob position and the amount of energy used. INDICATOR LIGHT Light will glow when the infinite switch is in any position other that OFF. HEATING ELEMENT AS- The char-broiler element assembly may be raised for cleaning, or to SEMBLY...
Page 5
FEATURES & OPERATING CONTROLS (continued) Fig. 1 Built-In Electric Charbroiler Fig. 2 Wellsloks...
PRECAUTIONS AND GENERAL INFORMATION WARNING: Broilers are intended for use to cook food products for human consump- Electric Shock tion. No other use is recommended or authorized by the manufacturer Hazard or its agents. All servicing requir- ing access to non-insulated Broilers are intended for use in commercial establishments, where all electrical components must users are familiar with the appliance limitations, use and associated...
INSTALLATION UNPACKING & INSPECTION NOTE: DO NOT discard the carton or other packing Carefully remove the appliance from the carton. Remove all protec- materials until you have tive plastic film, packing materials and accessories from the appliance inspected the appliance for before connecting electrical power or otherwise performing any installa- hidden damage and tested it tion procedure.
Page 8
INSTALLATION (continued) ELECTRCAL HOOK-UP WARNING: Risk of per- Refer to the nameplate. Verify the electrical service power. Voltage sonal injury and phase must match the nameplate specifications. Connecting the Installation procedures must griddle to the wrong voltage can severely damage the unit or cause be performed by a qualified noticeable decreased performance.
OPERATION PREPARE THE CHAR-BROILER FOR USE CAUTION: Hot Surface When using the broiler for the first time, wipe the entire unit with a clean Exposed surfaces damp cloth or sponge and mild deter- can be hot to the touch and gent.
Page 10
OPERATION (continued) CAUTION: TEMPERATURE CONTROLS Hot Surface Each section of the broiler is equipped with an individual temperature control. The desired temperature is controlled by rotating the TEM- PERATURE CONTROL KNOB. Any time the control is turned “ON”, the Exposed surfaces can be hot adjacent indicator light will glow.
OPERATION (continued) BROILER CHART RECOMMENDED COOKING TIMES AND DIAL SETTINGS NOTE: The times and dial settings in this chart are suggestions only. Your own experience with your own menu items will be your best guide to achieving the best food product. PRODUCT THICKNESS COOKING...
240V unit run on 208V Verify proper voltage Damaged component or wiring Contact an Authorize Temperature control not set Set temperature control knob to Wells Service Agency desired temperature for repairs 208V unit run on 240V Verify proper voltage Damaged component or wiring...
CLEANING INSTRUCTIONS CAUTION: PREPARATION Turn both temperature control knobs OFF. Electric Shock Allow broiler to cool completely. Hazard Disconnect broiler from electric power. FREQUENCY Disconnect appliance Daily. from electric power before cleaning. TOOLS Steel Brush with Scraper CAUTION: Plastic Scouring pad, Soft-Bristled Fiber Brush Mild Detergent, Non-Abrasive Cleanser Burn Hazard Clean Soft Cloth / Sponge...
Page 15
B406 Electric Charbroiler Fig No Part No Description Application WS-21707 BROILER GRATE B40 / B406 H6-32728 COVER RR ELEM ASSY B40 / B406 WS-57509 CASTING ASSY ELEM REAR 2P-32428 SPRING SUPPORT ROD 2A-32729 ROD HEAD SUPPORT B40 / B406 H6-35594...
Page 17
PARTS LIST: MODEL 446 B446 Electric Charbroiler Fig No Part No Description Application H6-38623 GRATE MACH BROILER ASSY H6-32740 COVER RR ELEM ASSY WS-57507 CASTING ASSY ELEM REAR 2P-32428 SPRING SUPPORT ROD 2A-34061 ROD HEAD SUPPORT H6-35593 PAN GREASE B44-50 2A-32840 PIVOT BRKT LF SIDE B40 2A-32841...
Page 19
PARTS LIST: MODEL B506 B446 Electric Charbroiler Fig No Part No Description Application H6-38623 GRATE MACH BROILER ASSY H6-32740 COVER RR ELEM ASSY WS-57507 CASTING ASSY ELEM REAR 2P-32428 SPRING SUPPORT ROD 2A-34061 ROD HEAD SUPPORT H6-35593 PAN GREASE B44-50 2A-32840 PIVOT BRKT LF SIDE B40 2A-32841...
B-506 (2 PER UNIT) H6-35593 For factory authorized GREASE PAN, B-406 H6-35594 service, or to order factory authorized replacement parts, contact your Wells authorized GRATE, B-446 (1 PER UNIT) service agency, or call: B-506 (2 PER UNIT) 2F-30025 Wells Bloomfield, LLC GRATE, B-406 WS-21707 265 Hobson St.