Gas Connections - Napoleon BUILT-IN Series Owner's Manual

g c
aS onnectionS
Gas Cylinder
Use a propane cylinder of minimum 6 kg or a butane cylinder of 13 kg
constructed and marked in accordance with national and regional codes. Ensure
that the cylinder can provide enough fuel to operate the appliance. If in doubt,
check with your local gas supplier.
Note: For optimal performance, operate the grill on propane gas.
Only cylinders connected to the appliance may be stored in the enclosure. Only
place cylinders within the maximum width and height dimensions in the built
in enclosure. Spare cylinders must not be stored in the enclosure, or in close
proximity with an operating unit.
Gas Hose
Use a gas pressure regulator and hose supplied by Napoleon; if not included, use
a regulator and hose that meet national and regional codes.
The recommended length of the hose is 0.9 m. The hose must never be longer
than 1.5 m.
Check the hose regularly for rips melting or wear. Replace if needed.
Note: The hose should be replaced before the expiry date printed on it.
WARNING! The connectors must be of rigid pipe, copper tube or approved flexible metal which must comply
with national and regional codes.
Hook-up and Installation
1. Check the cylinder for dents or rust, and have it inspected by your
propane supplier. Never use a cylinder with a damaged valve.
2. Place the cylinder in its designated area in the enclosure.
3. Ensure the gas regulator hose has no twists or kinks.
4. Remove the cap or plug from the cylinder fuel valve.
5. Tighten the regulator to the cylinder valve.
6. Ensure the hose does not contact with the drip pan or any high
temperature surfaces of the grill because it will melt and cause a
fire.
7. Ensure the cylinder is not left exposed to extreme heat or direct
sunlight.
8. Leak test all joints prior to operating the grill. See "Leak Test".
WARNING! Do not store a spare gas cylinder below the grill head or side burners.
WARNING! Never use a gas cylinder that is beyond 80% full.
WARNING! Follow all specifications and instructions exactly to prevent fire, explosion, property damage, personal
injury, or death.
WARNING! Disconnect the grill and its individual shutoff valve from the gas supply piping system during any
pressure testing.
Napoleon.com | BUILT-IN Series
N415-0601CE-GB.indd 7 N415-0601CE-GB.indd 7
Applicable to:
(BIG 44/38/32)
(BIB 18/12/10)
Applicable to:
(BIB 18/12/10)
!
Applicable to:
(BIB 18/12/10)
!
7
Getting Started |
3/18/2021 4:04:35 PM 3/18/2021 4:04:35 PM