Advertisement
Quick Links
MONITOR WITH DVD RECEIVER
KVT-514/524DVD/534DVD
/534DVDM/54DVDR/554DVD
SERVICE MANUAL
Illustrations is KVT-524DVD
*
DC cord
(E30-6815-15)
REV: 5m
PRK: 2m
BU,GND: 1m
Escutcheon
(B07-3159-02)
The IC3, and IC11 in the DVD unit (X37-1250-00) are not replaceable components.
When these ICs are defective, replace the whole DVD mechanism assembly (X92-6400-00).
You cannot replace only the board.
TEST MODE is the same as DDX5022's.
Please refer to the service manual (DDX5022's: B53-0620-00).
ADJUSTMENT is the same as KVT-50DVDRY's.
Please refer to the service manual (KVT-50DVDRY's: B53-0621-00).
*
Depends on the models. Refer to the parts list.
VOLUME
ATT
TI
*
DC cord
(E30-6816-15)
Mounting hardware assy
(J21-9716-03)
MONITOR WITH DVD RECEIVER
KVT-524DVD
OFF
SCAN
TEL
V.OFF
OPEN
/CLOSE
S
F
SRC
NAV
AUTO
+FM
Cord with pinplug
(E30-6813-05)
Lever
Screw set
(D10-7012-04) x2
(N99-1758-15)
This product complies with the
© 2008-11 PRINTED IN JA PAN
B53-0694-00 ( N ) 429
EJECT
*
Remote controller
(A70-2083-15)
Illustrations is RC-DV340
*
SIZE AAA BATTERY
(NOT SUPPLIED)
This product uses Lead Free solder.
RoHS
directive for the European market.
*
Advertisement
Related Manuals for Kenwood KVT-514DVD
Summary of Contents for Kenwood KVT-514DVD
- Page 1 MONITOR WITH DVD RECEIVER KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD SERVICE MANUAL © 2008-11 PRINTED IN JA PAN B53-0694-00 ( N ) 429 MONITOR WITH DVD RECEIVER KVT-524DVD SCAN V.OFF OPEN /CLOSE VOLUME EJECT AUTO Illustrations is KVT-524DVD Remote controller DC cord DC cord Cord with pinplug (A70-2083-15) (E30-6815-15)
- Page 2 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD CAUTIONS IN ASSEMBLING PANEL DRIVE MECHANISM (A10-5171) Observe the instructions described in this document when you are going to replace the parts or components that are shown in this document. 1. Replacement of motor fl at spring • When mounting the flat spring that shall be in contact with the worm gear, press the spring toward the direction shown with an arrow so that there will be no gap be- tween the tip of the gear and the spring and then mount...
-
Page 3: Cautions In Assembling Panel Drive Mechanism (A10-5171)
KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD CAUTIONS IN ASSEMBLING PANEL DRIVE MECHANISM (A10-5171) 2. Phase matching among gears • Monitor tilt is driven under the control of the rotary sensor and the phase matching among gears and sensor is required. The procedure for the phase matching is de- scribed in the rest of this subsection. - Page 4 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD CAUTIONS IN ASSEMBLING PANEL DRIVE MECHANISM (A10-5171) 3. Insertion of slider (Slider -Slide section inside of the unit) • This subsection describes cautions for inserting the slider (slide section inside of the unit) into the outer chassis. 1) On the rail at the left side of the slider, there is a part called a stabilizer that is used to minimize play in right and left sides.
-
Page 5: Gear Position In A Dvd Mechanism
KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD GEAR POSITION IN A DVD MECHANISM In assembling the Traverse UD arm, Drive cam assembly, Traverse UD arm Drive gear 5 and Drive gear 4C, align register marks on these components. Drive cam assembly Inscriptions (register marks) on gears Align 6 marks as shown in the figure... - Page 6 (X15-) (A/2) P ON BU14V SW+14V u-COM P ON P PWM ACC DET MCNT BU DET P GOOD PARKING P ON SIR PON P START u-COM A8.5V BU5V SIR SW14V u-COM DCDC DCDC u-COM REVERSE ILLUMI (X35-) (B/2) W REMO P CON ANT CON BE A5V...
-
Page 7: Components Description
KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD COMPONENTS DESCRIPTION ● VIDEO CONTROL UNIT (X15-127x-xx) Ref. No. Application / Function Operation / Condition / Compatibility 3-terminal regulator 9V→5V regulator 3-terminal regulator For AUDIO8.5V DC/DC converter IC MECHA7.5V/D5V control DC/DC converter IC USB5V/D3.3V control Motor driver Slide Motor driver Tilt 3.3V regulator... - Page 8 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD COMPONENTS DESCRIPTION Ref. No. Application / Function Operation / Condition / Compatibility Q4-7 PCON output Q8,9 ANT_CON output ACC detection Q12-20 Over voltage/Voltage reduction/BU_DET Q21-25 BU5V circuit Q26-28 BU3.3V circuit Q29,30 T_P+5V circuit Q35-37 P_ON SW+14V control P_ON SW+14V ON/OFF A8.5V circuit Q40-42 A5V circuit...
- Page 9 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD COMPONENTS DESCRIPTION Ref. No. Application / Function Operation / Condition / Compatibility Q361,362 ON when AM (TUNNER8.5V) Q370 KAB_RX error connection protection Q371-373 Tuner_Mute circuit (during ejection) Q451 BUFFER Q452 NT_PAL Q453 BUFFER DVD_V Q454,455 For KAB_TX control Q654,655 DVD AUDIO neutral point circuit Q681...
- Page 10 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD COMPONENTS DESCRIPTION Ref. No. Application / Function Operation / Condition / Compatibility IC14 3.3V power supply 5V→3.3V Register integrated transistor SL. MUTE control Register integrated transistor For FG signal Register integrated transistor LO.MUTE control Register integrated transistor DRMU control Transistor for APC Laser diode brightness control for CD Transistor for APC...
-
Page 11: Microcomputer's Terminal Description
KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD MICROCOMPUTER’S TERMINAL DESCRIPTION ● SYSTEM MICROCOMPUTER: 30878MJBA31GP (X15-127: IC9) Pin No. Pin Name Application Processing Operation Description EVOL_SDA I/O Communication data with E-VOL EVOL_SDA/E2P_SDA Communication data with E2P Touch panel control SIR_PON SAT power supply ON/OFF H: ON, L: OFF VSYNC_DET Video external input detection Detects if there is VSYNC signal or not. - Page 12 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD MICROCOMPUTER’S TERMINAL DESCRIPTION Pin No. Pin Name Application Processing Operation Description PRE_MUTESW Pre-out mute (SW) H: OFF, L: ON POWER_PWM Frequency control of DC-DC_IC NAVI_RX Communication with navigation system NAVI_TX Communication with navigation system Data output to TV μ-com TV_MC_DATA/TV_MC_DATA (For other destination than K and R) TV_MC_DATA/NC...
- Page 13 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD MICROCOMPUTER’S TERMINAL DESCRIPTION Pin No. Pin Name Application Processing Operation Description OPEN_CLOSE Z-MECHA OPEN/CLOSE Touch panel control INV_SW Inverter free run frequency switching BL_ENA Back light ON/OFF control H: ON, L: OFF TYPE4 Destination settings H: 5V pre-out, L: 2V pre-out Z_SWT Detection of panel mechanism SW_C...
- Page 14 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD MICROCOMPUTER’S TERMINAL DESCRIPTION Pin No. Pin Name Application Processing Operation Description ILL_G ON/OFF of other GREEN illumination than variable illumination H: ON, L: OFF ILL_R ON/OFF of other RED illumination than variable illumination H: ON, L: OFF MCNT Switching of power supply voltage to the panel drive mechanism H: 7.5V, L: 5V PGOOD DC-DC power supply error detection...
- Page 15 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD MICROCOMPUTER’S TERMINAL DESCRIPTION Destination settings of KVT/DDX/DNX KEY1 Settings MODEL Destination TYPE2 TYPE1 TYPE0 Power supply voltage Number of keys Pull up resistor μ-com setup value Name of Resister value KEY1 SCRN/ 0.00 0.69 KEY2 FNC/■ 0.70 1.92 KEY3 SRC/SRC 1.93...
- Page 16 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PC BOARD (COMPONENT SIDE VIEW) VIDEO CONTROL UNIT X15-127x-xx A/2 (J76-0505-32) CN351 C376 D367 R402 R385 R489 C379 C455 D369 D366 IC351 R453 D413 C424 D396 R452 C423 C425 D401 R454 D384 C456 R439 R428 R438 CN352 D385 R429 R437 R436...
- Page 17 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD X15 B/2 D574 D552 SPDIF RESET R581 R579 D590 D561 R580 D589 D591 S551 R694 VOL- R693 D551 D572 D D D D CN353 D571 D681 S S S G R193 D382 Q350 R479 X15-127x-xx C426 R426 Ref. No. Address Ref.
- Page 18 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PC BOARD (FOIL SIDE VIEW) X15 B/2 VIDEO CONTROL UNIT X15-127x-xx A/2 (J76-0505-32) TP556 R583 CN551 TP551 TP555 TP558 TP557 TP560 R471 R470 R33 R38 C428 C429 R472 C432 Q12 Q13 IC10 IC11 R203 C202 IC12 R103 R102 R108 C602 C605...
- Page 19 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD R369 R372 C368 C369 D362 D361 C371 X15-127x-xx R353 R352 R357 C381 R360 R363 C363 C364 C382 Ref. No. Address Ref. No. Address C351 R351 R378 R381 C373 C374 Q351 Q357 D359 D355 R447 R448 C422 D363 D389 R446 C421 D390...
- Page 20 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PC BOARD (COMPONENT SIDE VIEW) X35 B/2 VIDEO UNIT X35-4960-10 A/2 (J76-0519-12) R214 C206 Q202 C223 R210 CN104 X300 C204 R207 R208 C202 D302 R201 C333 R346 L302 C325 C326 C334 R336 C338 C314 C134 C310 R202 C309 C135 C307 R310...
- Page 21 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PC BOARD (FOIL SIDE VIEW) X35 B/2 VIDEO UNIT X35-4960-10 A/2 R119 (J76-0519-12) C505 C500 NAVI D409 R404 Q203 R341 D410 R342 R222 C356 D505 C316 C344 D506 C319 VCOM C355 C320 R369 C321 STHL R370 L304 C348 STVR L305 L312...
- Page 22 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PC BOARD (COMPONENT SIDE VIEW) DVD UNIT X37-1230-00/1250-00 (J76-0620-02) IC14 C103 IC13 CP11 C100 C297 R162 R163 C220 C219 C207 C208 C221 C214 C222 C223 C213 C224 R151 R150 R152 R153 R257 IOP+ R279 C436 R158 R256 R159 R160 R255 IC15...
- Page 23 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PC BOARD (FOIL SIDE VIEW) DVD UNIT X37-1230-00/1250-00 (J76-0620-02) DGND IC11 AGND SW EJEND CP5 CP6 CP7 CP8 D3.3V CP10 VREF1 SW LOST MON1 1.5V MON5 R289 MON4 RFENV CD LD DVD LD JITOUT VREF2 WBLIN C452 JLINE OFTR STDI X37-1230-00/1250-00...
- Page 24 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD (X15-127x-xx) (A/2) to DC CORD TP24 C203 TP36 1000P VGND C150 0.1 C151 0.01 C152 0.1 C153 0.01 C154 0.1 P-CON 6.2K C155 0.01 R10 4.7K C156 0.1 R12 1K 6.2K C157 0.01 C5 0.01 1/2W 4.7K R19 1K C2 0.01 1/2W R20 1K...
- Page 25 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD X35- A/2- CN101 C163 0.01 C164 C161 DGND SW5V BL GND 0.01 C162 BL GND VGND ESDGND C167 C169 C171 S.M-DRV T.M-DRV R174 R177 R180 2.7K 4.3K 4.3K C168 C170 C172 220P 220P 220P R176 R179 R182 SW5V SW3.3V SW3.3V 5.0V...
- Page 26 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD BU5V-1 BU5V-1 BU3.3V-1 BU3.3V-1 REMO C187 C188 R212 47K PGOOD 3.3V P START NC((LX MUTE)) REVERSE R231 100 PARKING R201 100K R202 10K SIR DET C202 0.01 R203 10K ANT CON P CON ILLUMI ∗ R207 NC((LX REQ M)) NC(SAT CON(LX)) C183 MODEL...
- Page 27 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD FM/AM F/E ANT. W351 CN357 CN356 CN351 1 2 3 1 2 3 4 5 8 9 10 11 12 13 14 16 17 BU5V-1 BU3.3V-1 TP383 R411 Q362 C397 C392 C391 C390 0.01 0.01 0.01 MUTE 3.3V IC13 Q361 DGND...
- Page 28 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD iPod CN351 CN352 C389 1000P C385 D372 1000P ESDGND D373 D374 D375 D376 R409 D370 ESDGND 3.3V D353 D358 D357 D362 D361 R402 AVIN-L CDCHL 3.3V ESDGND ESDGND AVIN-G CDCHCOM VGND AGND AGND D371 3.3V AVIN-R CDCHR R363 R369 R372 R378...
- Page 29 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD DVD-AR DVD-AL 8.1V P-FL P-FR C447 4.0V GND2 PREF C477 RIN+7 PGND 3.3V RIN+1 DVD-AR LDOUT1L 2.5V 2.5V C478 CAD1 LIN+1 DVD-AL 3.3V 3.3V LDOUT1R C479 LDOUT2L P-RL GND1 LDOUT2R P-RR ROUT3 CAD0 LOUT3 ROUT2 SUB-R 0.2V IC358 8.1V IC357 LOUT2...
- Page 30 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD VD-AR R669 R670 W801 VD-AL L811 TP801 L804 3.3V REG 1.8V REG 3.4V IC804 3.4V 5.1V IC805 IC806 ESDGND 5.1V 5.1V VOUT 3.3V 1.8V L805 TP819 TP818 CSLEW D801 VOUT VOUT ENABLE FAULT D802 C803 C804 VBUS SW DGND C229 0.01...
- Page 31 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD 1.8V-1 TP751 L804 5.0V NOT USED C701 C719 C791 0.1 VOUT IC791 CSLEW MS 3.3V FAULT R798 PLLGND 1 SCL2 IOGND 10 DGND BUS SW R799 SDA2 UART I/F DGND R732 3.3V 3.3V ATA RST 1.8V 1.8V TP776 IO VI 9 IO3V3 10 C827...
- Page 32 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD MS 3.3V MS 3.3V 1.8V-1 1.8V-1 23 24 25 TP766 TP774 TP772 TP770 TP768 UART I/F 12C I/F ROM I/F IC701 MPEG DECODER MAGNUM SEMICONDUCTOR GENERAL PORT OPEN GPIO DVD(20:0) GPIO HST(27:0) GPIO VIS(10:0) GPIO MIS(21:0) MA11 141PIN I2C SEL MA12 HARDWARE CONTROL...
- Page 33 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD MS 3.3V L741 MS3.3V DGND R712 IC703 SDRAM 128M R774 ALE SEL R772 TYPE 3 CP714 22 R765 SIR RST 3 CP708 22 R797 CP715 22 C712 IO3V3 5 L751 R713 IOGND 5 CP713 22 C711 CP707 22 DIG1V8 2 IC704 CP706 22...
- Page 34 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD X15- A/2- (X15- ) (B/2) DTA114EE TA75W558FU-F CN551 : XC6201P502PR : M5237ML-CF0J DTA124EE IC3,4 : LTC3728LEGN IC5,6 : LB1836M-TLM-E DTA143XE : R1114N331B-TR DTA143ZE REMO : 74AHC1G08GW : 30878MJBA31GP DTA144EE IC551 IC10 ∗ 5.0V IC11 NOT USED DTB123YK IC12 : S-80835CNNB-G DTC114YE IC13...
- Page 35 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD (X35-4960-10) (A/2) TP+5V C121 4.9V D103 D104 L105 IC102 0.01 R118 10uH IC103 750K 4.9V D101 DC/DC R100 RX/CX IC101 C120 4.9V TP156 4.9V TP155 C115 L103 SHDN L100 D102 4.7uH 18.0V MONO MULTI 5.0V TP157 F100 10uH 1.3V 0.63A 18.0V...
- Page 36 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD +12.5V +12.5V TP+5V TP+5V -12.0V TP204 L105 R204 TP205 10uH TP202 TP216 TP500 CN502 Q102 IC200 Q101 TP200 TP201 R225 R212 R207 C200 2.2K -12.1V Q200 DGND R210 R208 STVR TP203 R216 R209 STVL C204 VR200 12.8V Q202 R205 VCOM STHL...
- Page 37 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD (X35- ) (B/2) CN503 TP500 DGND TP501 STVR STVL VCOM S401 S402 S403 S404 S405 VCOM TP510 R402 R403 R404 3.9K 8.2K TP511 STHL D308 OPEN/ SCREEN NAVI CLOSE TP513 STHR CPH3 CPH2 L501 CPH1 10uH DGND Q502 Q502 TP517 TOUCH PANEL...
- Page 38 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD (X37-1230-00/1250-00) VPU1 C219 TP198 VREF1 OPTICAL PICKUP 2.2V TP22 VIN6 DFLTOP TP45 A3.3V 1.15Vp-p C221 5.0V TR(-) VCC2 DFLTON TP46 0.6Vp-p TP54 FO(+) TP131 TP47 VREF2 TP123 TR(+) VIN7(FE1) 0.75Vp-p VREF2 TP48 DVD ON TP108 FO(-) C214 0.1 2.2V R165 NC 26...
- Page 39 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD 4.7K +1.5V TP21 C453 C120 AGND 0.022 TP151 TP20 VHALF C121 D3.3V 0.022 3.3V 1.8Vp-p 1.7Vref 0.01 TRCRS 3.3V AVDDC WBLIN 3.3V 3.3V 1.7V CSLFLT 3.3V 1.6V 3.3V 16.897849MHz RFDIF 3.3V 3.3V AVSSC 0.8V 0.022 PLFLT2 1.3V TP50 PLFLT1 PLFLT1 TP51...
- Page 40 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD R121 R120 D3.3V RESET DGND(NC) DGND C451 FLASH ROM DGND(NC) 1000P +1.5V DGND D3.3V CP5 33 C452 1 VSS1 3.3V 3.3V CP6 33 3.3V DD10 DD10 NC16 DQ10 DD11 DD11 3.3V NC14 CP7 33 DQ11 NC13 3.3V 3.3V DD12 DD12 3.3V...
-
Page 41: Exploded View (Dvd Mechanism)
KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD EXPLODED VIEW (DVD MECHANISM) M1.7x2 : N09-6382-05 : N09-6408-15 φ1.7x4 M2x2 : N09-6426-15 : N09-6104-05 φ2x10 Parts with the exploded numbers larger than 700 are not supplied. -
Page 42: Exploded View (Unit)
KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD EXPLODED VIEW (UNIT) SIZE AAA BATTERY PME1 (NOT SUPPLIED) M2.6x3.2 : N09-6227-15 M2.6x22 : N09-6745-05 : N09-6302-04 M2.6x5 : N35-2605-47 : N09-6303-04 : N82-2005-48 φ2x5 M2.0x4 : N09-6355-05 : N82-2007-47 φ2x7 M2.6x27 : N09-6491-05 : N86-2606-48 φ2.6x6 : N86-2605-43 φ2.6x5 FPC2 FPC1... - Page 43 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD EXPLODED VIEW (DISPLAY ASSY) : N09-6205-05 M2x2.2 : N09-6206-05 M2x3.5 : N09-6207-05 : N09-6211-05 : N09-6255-05 M1.7x2.2 : N09-6270-05 WASHER (1.6x4) : N19-2195-04 WASHER : N19-2303-04 RETAINING RING : N29-0538-04 WASHER : N19-2327-04 WASHER : N19-2328-04 Parts with the exploded numbers larger than 700 are not supplied.
-
Page 44: Parts List
KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Desti- Desti- Ref. No. Parts No. Description Ref. - Page 45 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST DISPLAY ASSY Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation 1C ✽ B07-3300-02 ESCUTCHEON K24-4866-13 PUSH KNOB 1C ✽ B07-3301-02 ESCUTCHEON K25-1925-12 PUSH KNOB 1C ✽ B07-3305-02 ESCUTCHEON M1M2X1 B11-1453-04 REFLECTION SHEET N09-6205-05 STEPPED SCREW...
- Page 46 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST VIDEO CONTROL UNIT (X15-127x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation CK73FB0J475K CHIP C 4.7UF C111 CK73HB1E103K CHIP C 0.010UF K C112-114 CK73GB1H104K CHIP C 0.10UF CK73GB0J106M CHIP C 10UF CK73FB1E104K CHIP C...
- Page 47 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST VIDEO CONTROL UNIT (X15-127x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation C195 CK73HB1E103K CHIP C 0.010UF K C417-419 CK73GB1A474K CHIP C 0.47UF M1M2X1 C196 CK73HB1A104K CHIP C 0.10UF C423 CK73GB1A474K CHIP C 0.47UF...
- Page 48 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST VIDEO CONTROL UNIT (X15-127x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation C625 CK73GB0J475K CHIP C 4.7UF CN354 E41-2960-05 PIN ASSY E1Q1Q2 C626-630 CK73HB1A104K CHIP C 0.10UF CN354 E41-2960-05 PIN ASSY M1M2X1 C631 CK73GB0J475K...
- Page 49 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST VIDEO CONTROL UNIT (X15-127x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation CP753,754 RK74HB1J220J CHIP-COM 22 J 1/16W RK73HB1J333J CHIP R J 1/16W RK73HB1J103J CHIP R J 1/16W RK73HB1J224J CHIP R 220K J 1/16W RK73EB2E272J...
- Page 50 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST VIDEO CONTROL UNIT (X15-127x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation R183,184 RK73EB2E101J CHIP R J 1/4W R281 RK73HB1J000J CHIP R J 1/16W R185 RK73HB1J101J CHIP R J 1/16W R282 RK73HB1J102J CHIP R...
- Page 51 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST VIDEO CONTROL UNIT (X15-127x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation R416,417 RK73HB1J222J CHIP R 2.2K J 1/16W Q1Q2M1 R481,482 RK73HB1J122J CHIP R 1.2K J 1/16W R416,417 RK73HB1J222J CHIP R 2.2K J 1/16W M2 R483...
- Page 52 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST VIDEO CONTROL UNIT (X15-127x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation R669,670 RK73HB1J473J CHIP R J 1/16W R857,858 RK73HB1J152J CHIP R 1.5K J 1/16W R859-861 RK73HB1J472J CHIP R 4.7K J 1/16W R673,674 RK73HB1J272J...
- Page 53 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST VIDEO CONTROL UNIT (X15-127x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation D384 AVRM16270MAAB VARISTOR E1Q1Q2 IC602 NJM2573V-ZB ANALOGUE IC D384 AVRM16270MAAB VARISTOR M1M2X1 IC651 PCM1754DB MOS-IC D388 UDZW6.2(B) ZENER DIODE E1Q1Q2 IC652 NJM4565V-ZB...
- Page 54 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST VIDEO CONTROL UNIT (X15-127x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation KRC408-P DIGITAL TRANSISTOR C93-1363-05 CHIP C 10PF Q54 ,55 HAT2218R-E DUAL FET C93-1464-05 CHIP C 0.012UF F Q56 ,57 KRC408-P DIGITAL TRANSISTOR CK73GB1H473K...
- Page 55 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST VIDEO UNIT (X35-4960-10) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation C205 CK73EB1C106K CHIP C 10UF CN503 E41-2901-15 FLAT CABLE CONNECTOR C206 CK73HB1E103K CHIP C 0.010UF K C221 CK73GB1C104K CHIP C 0.10UF F53-0297-05 FUSE (UL,CSA) 1.6A...
- Page 56 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST VIDEO UNIT (X35-4960-10) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation R206 RK73HH1J472D CHIP R 4.7K D 1/16W D101 EP05Q04 DIODE R207 RK73HH1J222D CHIP R 2.2K D 1/16W D102 EP05Q06 DIODE R208 RK73HH1J153D...
- Page 57 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST DVD UNIT (X37-1250-00) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation CC73HCH1H331J CHIP C 330PF R3 ,4 RK73HB1J103J CHIP R J 1/16W CK73HB1H222K CHIP C 2200PF R5 ,6 RK73HH1J123D CHIP R D 1/16W CC73HCH1E681J CHIP C...
- Page 58 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST The IC3, and IC11 in the DVD unit (X37-1250-00) are not replaceable components. When these ICs are defective, replace the whole DVD mechanism assembly (X92-6400-00). DVD UNIT (X37-1250-00) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No.
- Page 59 KVT-514/524DVD/534DVD /534DVDM/54DVDR/554DVD PARTS LIST CAPACITORS 2 2 0 • Capacitor value CC45 Color* 010 = 1pF 0 = 22pF 1 = Type ... ceramic, electrolytic, etc. 4 = Voltage rating 100 = 10pF 2 = Shape ... round, square, etc. 5 = Value 101 = 100pF Multiplier...
- Page 60 Weight ............2.3 kg (5.1 lbs) Audio Decoder ......... MP3/ WMA/ WAV/ AAC Video Decoder ..... MPEG1/ MPEG2 (Maximum: 2Mbps) KENWOOD follows a policy of continuous advancements in development. For this reason specifications may be FM tuner section changed without notice.
- Page 61 Usable Sensitivity (S/N : 26 dB) ..9.3 dBf (0.8 μV/ 75 Ω) Quieting Sensitivity (S/N : 46 dB) ..15.2 dBf (1.6 μV/ 75 Ω) KENWOOD follows a policy of continuous advancements Frequency Response (± 3.0 dB) .....30 Hz – 15 kHz in development.
- Page 62 Quieting Sensitivity (S/N : 46 dB) .......1.6 μV/ 75 Ω Frequency Response (± 3.0 dB) .....30 Hz – 15 kHz KENWOOD follows a policy of continuous advancements S/N Ratio (dB) ..........65 dB (MONO) in development. For this reason specifications may be changed without notice.