Copyright 2006 InnoLux Tech. Corp. Ltd All Rights Reserved This manual may not, in whole or in part, be copied, Photocopied, reproduced, translated, or converted to any electronic or machine readable form without prior written permission of InnoLux Tech. Corp. Ltd. Acer X163W Service Manual...
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W Important Safety Notice 1. Safety precautions This monitor is manufactured and tested on a ground principle that a user’s safety comes first. However, improper used or installation may cause damage to the monitor as well as to the user.
General: Acer X163W is designed with analog interface input, it featured with embedded universal AC power supply . It’s a green product and meets all ROHS standard. The power button and display control buttons are on the front of the monitor. The monitors shall automatically to display lower resolution video modes into 1366 x768 full screen display.
Page 5
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W Operating Specification 0°C to 40°C Temperature range Relative humidity 20% to 90% Altitude 0 to 3048M (10000 ft) Storage -20°C to 60°C Temperature range Relative humidity 10% to 90% Altitude 0 to 9144M (30000 ft) 2.2 Safety, EMC, Ergonomics and Compatibility Requirements...
Page 6
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W Electrostatic Discharge Requirements Item Condition Spec Contact discharge : 4KV Contact discharge : 8KV ● Electrostatic Discharge IEC61000-4-2(EN55024) Air discharge : 8KV Air discharge : 15KV ● Reliability Items Condition...
Page 7
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W blanked < 2W Orange Power Off < 1W 3.2 Backlight Power Supply : CMO M156B1-L01 Panel Items Specification Lamp 2 CCFL Input Voltage 14 (13.5~16.3)V Input current 1.1A(typ.), 1.4A(max.) 5.5V V ≧...
Page 8
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W Min. luminance nine points (backlight ≥ 75 Max. luminance nine points (backlight 4. Input / Output Signal Specifications 4.1 Video signals Items Condition Specification Analog RGB signal Input impedance = 75 Ohm 0.7Vp-p...
Page 10
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W Sync Inputs Supported [3] Separate Syncs. Supported Sync Inputs Supported [2] No Composite Sync. Supported Sync Inputs Supported [1] No Sync. on Green Supported Sync Inputs Supported [0] No Serration Required Max.
Page 11
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W VESA [6] 800 x 600 @ 85Hz (N/A) VESA [5] 1024 x 768 @ 85Hz (N/A) VESA [4] 1280 x 1024 @ 60Hz (N/A) VESA [3] 1280 x 1024 @ 85Hz (N/A)
Page 12
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W Max. Horizontal Frequency 57 kHz Max. Pixel Clock 90 MHz 5A~6Bh Monitor Serial Number 1234567890AB 6C~7Dh Monitor Name X163W Extension Flag Checksum 5. Function Specifications All the tests to verify specifications in this section shall be performed under the following standard conditions unless otherwise noted.
Page 13
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W A. When OSD un-displays, when press [ ] the e-Color menu will show B. When OSD displays, when press [ ] the e-Color menu will show, OSD will disappear A. When “main OSD” isn’t shown on screen, press [MENU] to enter “main OSD”...
Page 14
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W Deutsch Deutsch Español Español Hollands 简体中文 Русский 繁體中文 Français Français Italiano Italiano Suomalainen 日本語 Hor. Position 0 ~ 100 Ver. Position 0 ~ 100 OSD Timeout 10~ 120 Analog Input...
Page 15
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W 2. Adjust ISP programming Firstly, double click ISP_Tool_v3.7.5EXEI and open ISP program, then select “Device”, next select manufacturer model of FW IC, which should be correspondent with that of PCBA FW IC. Double click Figure One.
Page 16
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W Fourthly, select “AUTO”, and keep its default value. Click “RUN” for beginning programming. There will be prompting if programming is OK. Note: if programming fails or success rate is not high, click “Config” and adjust its speed in...
Page 17
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W After connecting, AC ON, DC ON ◆Flowing chart Open ISP program Choose manufacturer and model of FW IC LOAD FW software Click Connect and enter ISP MODE Choose Config Click AUTO and RUN for...
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W 03 Exploded Diagram 3.1. LCD Exploded drawing (All) Q’ty/ Description Unit Torque Remark 509146306200R pcs 3.75±0.25 SCREW,P,CROSS,W/WAS,M3*6,Zn-Cc FOR PCB&CHASSIS 509000000700R 3.5~4.0 BOLT,#4-40x11.8,Ni for VGA 509412610500R 6.0~7.0 SCREW,B,CROSS,T.T-4*10,BLK ,ROHS FOR Bezel AND BACKCOVER 509216608110R 11.0...
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W 04 Troubleshooting 1 No Power & LED Off No power Check IC802, Check circuit Check primary C805, T801 if short rectifier voltage Check F801, L801, D801 Check pin1 of Check R803, R807,...
Page 37
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W nstable 2. DC output voltage is u Output voltage unstable Check ZD801, D803, Check circuit Check Voltage of D805 if short ZD801 below 12V? Check ZD801 Check R809, IC801, Check Pin R of...
Page 38
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W 3. No Raster No raster? LED Blue? Backlight can’t be turned on. Is there 14Vdc Check power supply voltage on pin9 of IC501? Is there high-level Is Ok R503? voltage on pin8 of...
Page 39
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W Black Screen...
Page 40
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W Bad Screen...
Page 41
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W White Screen...
Page 47
All manuals and user guides at all-guides.com R903 0603 3K9 R902 R901 0603 3K9 0603 3K9 SW906 SW905 SW904 SW903 SW902 SW901 SW TACT SW TACT SW TACT SW TACT SW TACT SW TACT E-COLOR AUTO MENU MINUS PLUS POWER Title <Title>...
Page 48
All manuals and user guides at all-guides.com CN104 2x4P 2.0mm ADC 0 ADC 0 ADC 1 ADC 1 ADC 2 ADC 2 LED A LED A LED G LED G Title <Title> Size Document Number <Doc> Date: Wednesday, April 09,...
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W 7.0 Assembly and Disassembly The tool of Assembly and disassembly : 1) Electrostatic gloves 2) Electric screwdriver: the lengthe of screwdriv top is Φ5*H5mm...
Page 54
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W Assembly and Disassembly (continue F ix In s e rt p o w e rb o a rd in to th e d e s ig n a te d...
Page 55
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W Assembly and Disassembly (continue) Tw ist Fix 3 pcs of screw s separately on the PCBA pow eboard and m ainboard like the screw attached Picture1 (1). Handle hexagonal screw s and elec...
Page 56
All manuals and user guides at all-guides.com Acer Acer –LCD-X163W Assembly and Disassembly (continue Insert Thread lamp wire into the relevant hole lamp wire chassis like the attached Picture Assemble Assemble keypad as picture keypad Assemble cover Check if back cover and stand is fixed...