Page 1: Table Of Contents
All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by ER/EL 0968 BU TV Consumer Care, the Netherlands...
Page 2: Revision List
Here is product information available, as well as getting started, user manuals, frequently asked questions and software & drivers. Table 2-1 Described Model numbers Styling Published in: 40PFL9704H/12 Elite Premium 3122 785 18320 40PFL9704H/60 3122 785 18320 46PFL9704H/12 3122 785 18321...
Page 3 Technical Specifications and, Connections Q549.3E LA EN 3 Connections 18320_001_090728.eps 090728 Figure 2-1 Connection overview Note: The following connector colour abbreviations are used Cinch: Video CVBS - In, Audio - In (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, Gy= Rd - Audio R 0.5 V / 10 kohm...
Page 4 EN 4 Q549.3E LA Technical Specifications and, Connections - Ground Red 21 - Shield - Ground Green - Ground Blue RJ45: Ethernet (if present) - +5V +5 V 10 - Ground Sync 1 1 2 3 4 5 6 7 8 11 - n.c.
Page 5: Precautions, Notes, And Abbreviation List
Spare Parts • Check the strain relief of the Mains/AC Power cord for proper function. For the latest spare part overview, consult your Philips Spare • Check the electrical DC resistance between the Mains/AC Part web portal. Power plug and the secondary side (only for sets that have a Mains/AC Power isolated power supply): 1.
Page 6 EN 6 Q549.3E LA Precautions, Notes, and Abbreviation List 3.3.6 Alternative BOM identification Abbreviation List It should be noted that on the European Service website, 0/6/12 SCART switch control signal on A/V “Alternative BOM” is referred to as “Design variant”. board.
Page 7 6.5 MHz. L' is Band E-DDC Enhanced Display Data Channel I, L is all bands except for Band I (VESA standard for communication LG.Philips LCD (supplier) channel and display). Using E-DDC, Loudspeaker the video source can read the EDID LVDS Low Voltage Differential Signalling information form the display.
Page 8 System on Chip Sync On Green SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4- wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board STBY STand-BY SVGA 800 ×...
Page 9: Mechanical Instructions
Mechanical Instructions Q549.3E LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assy/Panel Removal 4.4 Set Re-assembly Cable Dressing 8586 1M 84...
Page 10 EN 10 Q549.3E LA Mechanical Instructions 1 M 84 1 M 83 1 M 84 1M 83 1 M 84 1M 83 8589 8588 8586 8587 T ico n 8151 8150 8316 C N2 : 4 1p C N1 : 5 1 p 1 4 p M a ste r 8159...
Page 11 Mechanical Instructions Q549.3E LA EN 11 Service Positions 4.3.3 Ambi Light Each Ambi Light unit is mounted on a subframe. Refer to For easy servicing of this set, there are a few possibilities Figure 4-5 for details. created: • The buffers from the packaging. •...
Page 12 EN 12 Q549.3E LA Mechanical Instructions 18310_216_090318.eps 18310_213_090318.eps 090319 090319 Figure 4-8 Piezo Touch Control Panel -2- Figure 4-6 IR & LED Board 1. Now gently pull the top side of the PWB out of the cabinet 1. Remove the Main Supply Panel as earlier described. without damaging the flexfoil until you can unplug the 2.
Page 13 Mechanical Instructions Q549.3E LA EN 13 5. Remove both AL subframes (with the AL unit still mounted Set Re-assembly on it) by unplugging the connector [2] and removing the screws [3]. To re-assemble the whole set, execute all processes in reverse 6.
Page 14: Service Modes, Error Codes, And Fault Finding
EN 14 Q549.3E LA Service Modes, Error Codes, and Fault Finding 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: • All service-unfriendly modes (if present) are disabled, like: 5.1 Test Points – (Sleep) timer. 5.2 Service Modes –...
Page 15 “OK” button on the RC. Display Option Code Contents of SAM (see also Table 6-4) • Hardware Info. 39mm PHILIPS – A. SW Version. Displays the software version of the MODEL: 32PF9968/10 main software (example: Q5492-1.2.3.4 = PROD.SERIAL NO: AAAAB_X.Y.W.Z). AG 1A0620 000001 (CTN Sticker) •...
Page 16 EN 16 Q549.3E LA Service Modes, Error Codes, and Fault Finding • With the “OK” key, it is possible to activate the selected • 12NC SSB. Gives an identification of the SSB as stored in action. NVM. Note that if an NVM is replaced or is initialized after corruption, this identification number has to be re-written to NVM.
Page 17 Service Modes, Error Codes, and Fault Finding Q549.3E LA EN 17 Stepwise Start-up mode with a faulty FET 7U08 is done, you can destroy all ICs supplied by the +3V3, due to overvoltage (12V on 3V3-line). It is recommended to measure first the FET 7U08 or others When the TV is in a protection state due to an error detected by FET’s on shortcircuit before activating SDM via the service stand-by software (error blinking is displayed) and SDM is...
Page 18 EN 18 Q549.3E LA Service Modes, Error Codes, and Fault Finding Stand by or Mains is applied Protection Standby Supply starts running. All standby supply voltages become available . st-by µP resets Initialise I/O pins of the st-by µP: If the protection state was left by short circuiting the - Switch reset-AVC LOW (reset state) SDM pins, detection of a protection condition during - Switch WP-NandFlash LOW (protected)
Page 19 Service Modes, Error Codes, and Fault Finding Q549.3E LA EN 19 From I_17660_125a.eps From I_17660_125a.eps Reset-system is switched HIGH by the Reset-system is switched HIGH by the Release reset MPEG4 module: AVC at the end of the bootscript AVC at the end of the bootscript BOLT-ON-IO: High Reset-system is connected to USB -reset,...
Page 20 EN 20 Q549.3E LA Service Modes, Error Codes, and Fault Finding Constraints taken into account: - Display may only be started when valid LVDS output clock can be delivered by the AVC . - Between 5 and 50 ms after power is supplied, display should receive valid lvds clock . action holder: AVC - minimum wait time to switch on the lamp after power up is 200ms.
Page 21 Service Modes, Error Codes, and Fault Finding Q549.3E LA EN 21 Constraints taken into account: - Display may only be started when valid LVDS output clock can be delivered by the AVC . - Between 5 and 50 ms after power is supplied, display should receive valid lvds clock . action holder: AVC - minimum wait time to switch on the lamp after power up is 200ms.
Page 22 EN 22 Q549.3E LA Service Modes, Error Codes, and Fault Finding action holder: AVC Constraints taken into account: - Display may only be started when valid LVDS output clock can be delivered by the AVC . action holder : St-by - Between 5 and 50 ms after power is supplied, display should receive valid lvds clock .
Page 23 Service Modes, Error Codes, and Fault Finding Q549.3E LA EN 23 action holder: AVC Active action holder: St-by autonomous action Mute all sound outputs via softmute Wait 100ms Set main amplifier mute (I/O: audio-mute) Force ext audio outputs to ground (I/O: audio reset) And wait 5ms switch off Ambilight...
Page 24 EN 24 Q549.3E LA Service Modes, Error Codes, and Fault Finding Semi Stand by action holder: MIPS action holder: St-by autonomous action If ambientlight functionality was used in semi -standby (lampadaire mode), switch off ambient light *) If this is not performed and the set is Delay transition until ramping down of ambient light is switched to standby when the switch off of finished.
Page 25 4. ComPair features TV software up possibilities. Introduction Specifications ComPair (Computer Aided Repair) is a Service tool for Philips ComPair consists of a Windows based fault finding program Consumer Electronics products. and offers the following: and an interface box between PC and the (defective) product.
Page 26 LAYER 1 errors are one digit errors. • ComPair II interface: 3122 785 91020. – LAYER 2 errors are 2 digit errors. • Software is available via the Philips Service web portal. • In protection mode. • ComPair UART interface cable for Q54x.x. –...
Page 27 Service Modes, Error Codes, and Fault Finding Q549.3E LA EN 27 out via ComPair, via blinking LED method LAYER 1-2 error, or in case picture is visible, via SAM. 5.5.2 How to Read the Error Buffer Use one of the following methods: •...
Page 28 EN 28 Q549.3E LA Service Modes, Error Codes, and Fault Finding Table 5-2 Error code overview Monitored Error/ Error Buffer/ Description Layer 1 Layer 2 Prot Blinking LED Device Defective Board MIPS BL / EB MIPS BL / EB SSB/Display SSB/display PNX doesn’t boot (HW cause) Stby µP...
Page 29 Service Modes, Error Codes, and Fault Finding Q549.3E LA EN 29 • Error 34 (Tuner). When there is no I C communication 5.6.2 How to Activate towards the tuner after start-up, LAYER 2 error = 34 will be logged and displayed via the blinking LED procedure when Use one of the following methods: SDM is switched on.
Page 30 EN 30 Q549.3E LA Service Modes, Error Codes, and Fault Finding Repair Tip • There will be still picture available but no sound. While the +3V3-STANDY and +1V2-STANDBY are permanent voltages. Class D amplifier tries to start-up again, the cone of the Supply voltages +1V2-PNX85XX and +1V2-PNX5120 are loudspeakers will move slowly in one or the other direction started immediately when +12V incoming voltage is available...
Page 31 Service Modes, Error Codes, and Fault Finding Q549.3E LA EN 31 During the start-up of the TV set, the logging will be displayed. This is also the case during rebooting of the TV set (the same logging appears time after time). Also available in the logging is the “Display Option Code”...
Page 32 1. Disconnect the TV from the Mains/AC Power. • FUS_Q5492_x.x.x.x_commercial.zip. Contains the 2. Press the “OK” button on a Philips TV remote control or a “autorun.upg” which is needed to upgrade the TV main Philips DVD RC-6 remote control (it is also possible to use software and the software download application.
Page 33 (UPG). This SW is not part of the FUS autorun.upg! and is not available in the One-Zip software file but provided separately via the commercial Philips website (software for servicers only).The way of work on how to upgrade is included in the zip file.
Page 34: Alignments
EN 34 Q549.3E LA Alignments 6. Alignments Index of this chapter: For the next alignments, supply the following test signals via a 6.1 General Alignment Conditions video generator to the RF input: 6.2 Hardware Alignments • EU/AP-PAL models: a PAL B/G TV-signal with a signal 6.3 Software Alignments strength of at least 1 mV and a frequency of 475.25 MHz 6.4 Option Settings...
Page 35 Alignments Q549.3E LA EN 35 • Select a COLOUR TEMPERATURE (e.g. COOL, When all the correct options are set, the sum of the decimal NORMAL, or WARM). values of each Option Byte (OB) will give the option number. • Set the RED, GREEN and BLUE default values according See Table 6-3 Option and display code overviewfor the...
Page 36 This implies that only a main software upgrade is 2. Download the latest main software (FUS) from the required if you use a “repaired” SSB for board swap instead of www.p4c.philips.com website. a “new” SSB. Total Overview SAM modes...
Page 37 Alignments Q549.3E LA EN 37 Main Menu Sub-menu 1 Sub-menu 2 Sub-menu 3 Description Dealer options Picture mute Off/On Select Picture mute On/Off. Picture is muted / not muted in case no input signal is detected at input connectors. Virgin mode Off/On Select Virgin mode On/Off.
Page 38 EN 38 Q549.3E LA Alignments Main Menu Sub-menu 1 Sub-menu 2 Sub-menu 3 Description Audio reproduction Acoustic system Cabinet design used for setting dynamic audio pa- rameters. Source selection EXT1/AV1 type SCART CVBS RGB LR Select input source when connected with external equipment.
Page 39 Alignments Q549.3E LA EN 39 Main Menu Sub-menu 1 Sub-menu 2 Sub-menu 3 Description Development file ver- Development 1 file version Display parameters DISPT 3.26.8.7 Display information is for development purposes. sions Acoustics parameters ACSTS 3.6.6.5 PQ - PRFPP 1.26.10.4 Ambilight parameters PRFAM 2.6.1.3 Development 2 file version 12NC one zip software...
Page 40: Circuit Descriptions
EN 40 Q549.3E LA Circuit Descriptions 7. Circuit Descriptions Index of this chapter: Main delta’s with the previous chassis are the introduction of 7.1 Introduction “White LED backlight” and the implementation of the LAN9420 7.2 Power Architecture ethernet controller (item no.7N04, diagram B07G). 7.3 Front-End 7.4 HDMI 7.1.1...
Page 41 Circuit Descriptions Q549.3E LA EN 41 7.1.3 SSB Cell Layout 1M71 1M59 1M01 1F02 1R12 serv Xilinx 1E51 DDR2 1E50 uart Head PCI/ pci/xio ² Right Left DDR2 CVBS Tuner Wifi DDR2 HDMI RJ45 Ethernet 1P00 FLASH Class-D 18310_201_090317.eps 090317 Figure 7-2 SSB layout cells (top view) 2009-Aug-07...
Page 42 EN 42 Q549.3E LA Circuit Descriptions Power Architecture Refer to figure Figure 7-3 for the power architecture of this platform. F use 12VD isp V display P la tfo rm LC D P o w e r Power-on Standby PNX5100 3V3stby +3V3 stby +1V2...
Page 43 Circuit Descriptions Q549.3E LA EN 43 Front-End P la tfo rm w ith e m b e d d e d E D ID The Front-End consist of the following key components: • Tuner HD1816AF E D ID : 2 5 3 B •...
Page 44 EN 44 Q549.3E LA Circuit Descriptions PNX8543x MEMORY CONTROLLER TS in from channel decoder MPEG SYSTEM CI/CA LVDS for TS out/in for PRIMARY PROCESSOR flat panel display VIDEO PCMCIA LVDS (single or dual OUTPUT channel) DV-ITU-656 DV INPUT AV-PIP SUB-PICTURE VIDEO CVBS, Y/C, 3D COMB...
Page 45 Circuit Descriptions Q549.3E LA EN 45 DDR2-SDRAM PNX8543x MCU-DDR VCP/PC 2D_DE VCP_ VCP_RX LOW IF GFX1 VCP_ LCD panel CVBS GFX2 WIFD FPD-LVDS1 CPIPE_ LVDS_BUF (ADC) L2QTV LVDS_TX YPbPr LCD panel PC_RX FPD-LVDS2 main HDMI MBVP_ L2QTV HDMI_ Dual HDMI HDMI_UIP MBVP_ L2VO1...
Page 46 EN 46 Q549.3E LA Circuit Descriptions DDR2-SDRAM PNX8543x TM2270 TS-IN VMSP (MPEG, AC-3, MP3 DECODER) SPDIF-IN1 SPDIF-IN SPDIF-OUT SPDIF-Out SPDIF-IN2 fast SPDIF I2S-IN-SD1 I2S-IN-SD2 I2S-IN-SD3 I2S-IN-SD4 I2S-IN-WS I2S-IN-SCK I2S-IN-OSC 4 × I 2 S SPDIF 4 × I 2 S HDMI HDMI_RX 4 ×...
Page 47 Circuit Descriptions Q549.3E LA EN 47 DDR2-SDRAM PNX8543x MCU_DDR I2C-1 IIC4_DMA I2C-2 IIC2_DMA MIPS 4KEc EJTAG I2C-3 IIC3_DMA AVDSP UART-1 UART1 PCI_XIO PCI/XIO UART-2 UART2 CI/CA USB2.0 I2C-MC SYSTEM UART-3 CONTROLLER PWMs 80C51 JTAG_MMIO EJTAG GPIOs 18440_205_090226.eps 090226 Figure 7-10 PNX8543 connectivity and compute subsystem The Connectivity Subsystem consists of: keys in the components, unauthorised exchange of these •...
Page 48 EN 48 Q549.3E LA Circuit Descriptions Common Interface CI+ Access Module (CAM) and the Integrated Digital Television (IDTV). The security mechanisms in CI+ are derived/copied from POD (with the exception of Out Of Band (OOB) used in Together with this platform, an extension to the Common US CA systems).
Page 49 Circuit Descriptions Q549.3E LA EN 49 18310_203_090317.eps 090317 Figure 7-12 Interface between Ambi Light and SSB 7.8.1 ARM controller The SPI bus is a synchronous serial data link standard that operates in full duplex mode. Refer to Figure 7-13 below for signal interfacing to and from the ARM controller.
Page 50 EN 50 Q549.3E LA Circuit Descriptions The ARM controller communicates with the LED drivers (on each AL module) via an SPI bus. For debugging purposes, the working principle is given below: • Data from the ARM controller is linked through the drivers, which are connected in cascade •...
Page 51: Ic Data Sheets
IC Data Sheets Q549.3E LA EN 51 8. IC Data Sheets This chapter shows the internal block diagrams and pin electrical diagrams (with the exception of “memory” and “logic” configurations of ICs that are drawn as “black boxes” in the ICs).
Page 52 EN 52 Q549.3E LA IC Data Sheets Diagram SSB: Demodulator B02B, DRX3926K (IC 7T50) Block Diagram RF AGC MPEG-2 DVB-T/QAM IF AGC Main IF AMP CVBS Tuner DVB-T/QAM/ATV Demodulator Stereo Decoder Integrated Tuner S Audio Presaw Sense System Controller GPIO Pin Configuration VSSAH_CVBS VDDAH_CVBS...
Page 53 IC Data Sheets Q549.3E LA EN 53 Diagram SSB: PNX8543 - Stand-by Controller B04A, PNX8543 (IC7H00) Block Diagram PNX8543x MEMORY CONTROLLER TS in from channel decoder MPEG CI/CA SYSTEM LVDS for PRIMARY TS out/in for PROCESSOR flat panel display PCMCIA VIDEO LVDS (single or dual...
Page 54 EN 54 Q549.3E LA IC Data Sheets Diagram SSB: Ethernet B05A, PNX5120 (IC7C00) Block Diagram PNX51xx MEMORY CONTROLLER TM327x 1 LVDS RX 1 GIC 1 Video UIP L3K7 TM327x 2 GIC 2 LVDS RX 2 TM327x 3 GIC 3 PCI/XIO LVDS TX 1 Video LVDS TX 2...
Page 55 IC Data Sheets Q549.3E LA EN 55 Diagram SSB: Ethernet B07G, LAN9420 (IC7N04) Block Diagram EEPROM (optional) PCI Host To Ethernet LAN9420/LAN9420i Magnetics GPIOs/LEDs PCI Bus (optional) External PCI Device 25MHz Crystal PCI Device Pin Configuration 18561_300_090717.eps 090717 Figure 8-5 Internal block diagram and pin configuration 2009-Aug-07...
Page 56 EN 56 Q549.3E LA IC Data Sheets Diagram SSB: Audio B10A, TPA3123D (IC 7D10) Block Diagram 0.22 F 22 H 470 F ROUT 0.68 F PGNDR 0.68 F PGNDL LOUT BYPASS 22 H 470 F AGND 0.22 F PVCCL AVCC PVCCR VCLAMP Shutdown...
Page 57: Block Diagrams
Block Diagrams Q549.3E LA EN 57 9. Block Diagrams Wiring Diagram 40" (Elite Premium) WIRING DIAGRAM 40" (ELITE PREMIUM) AMBILIGHT MODULE AMBILIGHT MODULE 12 LED 12 LED (1072) (1070) 8586 Board Level Repair 1M84 (AL1) 1M83 (AL1) 14. GND 1. SCL 13.
Page 58: Wiring Diagram 46" (Elite Premium)
Block Diagrams Q549.3E LA EN 58 Wiring Diagram 46" (Elite Premium) WIRING DIAGRAM 46" (ELITE PREMIUM) AMBILIGHT MODULE AMBILIGHT MODULE AMBILIGHT MODULE 8 LED (1072) 10 LED (1071) 8 LED (1070) 8586 8587 Board Level Repair 1M84 (AL1) 1M83 (AL1) 14.
Page 59: Wiring Diagram 52" (Elite Premium)
Block Diagrams Q549.3E LA EN 59 Wiring Diagram 52" (Elite Premium) WIRING DIAGRAM 52" (ELITE PREMIUM) AMBILIGHT MODULE AMBILIGHT MODULE AMBILIGHT MODULE 10 LED 10 LED 10 LED (1072) (1072) (1070) 8586 8587 Board Level Repair 1M84 (AL1) 1M83 (AL1) 14.
Page 60: Block Diagram Video
Block Diagrams Q549.3E LA EN 60 Block Diagram Video VIDEO B02A FRONT-END B07A CI: PCMCIA CONNECTOR 7P15-7P16 PNX8543: B06G FPGA WOW - IO BANKS B05B PNX5100: VIDEO-IN B05E PNX5100: LVDS 74LVC245APW 1G50 1P00 7H00 +3V3 PNX85439EH/M2 7FN0 7C00 EP3C25F324C7N PNX5120EH/M2 B04N VIDEO STREAMS B04O...
Page 61: Block Diagram Audio
Block Diagrams Q549.3E LA EN 61 Block Diagram Audio AUDIO B02A FRONT-END B07A CI: PCMCIA CONNECTOR PNX8543: B04I PNX8543: AUDIO B10A AUDIO 7P15-7P16 74LVC245APW 1P00 7H00 +3V3 PNX85439EH/M2 B04N VIDEO STREAMS B04L AUDIO MDO(0-7) BUFFER CA-MDO(0-7) CA_MD0 5HRW 7D10 AADC VDDA-AUDIO 5HRZ TPA3123D2PWP...
Page 62: Block Diagram Control & Clock Signals
Block Diagrams Q549.3E LA EN 62 Block Diagram Control & Clock Signals CONTROL + CLOCK SIGNALS B07G ETHERNET B07A CI: PCMCIA CONNECTOR PNX8543: B02A FRONT END 7N04 1N00 DP83816AVNGNOPB 7H00 7303 PNX85439EH/M2 DRX3926K-XK-A3 TUN_CA ETHERNET B04N CONTROLLER 1P00 ETHERNET TNR_TSDI FE-DATA(0-7) DEMODULATOR CONNECTOR...
Page 63: Block Diagram I2C
Block Diagrams Q549.3E LA EN 63 Block Diagram I I²C B04E PNX8543: CONTROL B07D HDMI B02B DEMODULATOR B02A FRONT-END B05F PNX5100: CONTROL B06E FPGA WOW B06G FPGA WOW - IO BANKS B06A FPGA BACKLIGHT - LVDS & I2C - MUX B08D ANALOGUE EXTERNALS D- POWER &...
Page 64: Supply Lines Overview
Block Diagrams Q549.3E LA EN 64 Supply Lines Overview SUPPLY LINES OVERVIEW SUPPLY B01B DC / DC B07A CI: PCMCIA CONNECTOR B04I PNX8543: AUDIO +3V3 B01C DC/DC B05F PNX5100: CONTROL +3V3 B09A MINI PCI CONNECTOR B01a +AUDIO-POWER +AUDIO-POWER B01b +12V +3V3 +3V3 +12VD...
Page 65: Circuit Diagrams And Pwb Layouts
DC-DC INTERFACE 08-08-06 3104 328 58351 08-06-19 08-09-18 3104 313 6325 AMBI 2K9 3104 328 58361 08-08-06 08-10-23 3104 328 58371 08-10-23 08-12-06 NAME Peter Van Hove SUPERS. CHECK ******** DATE 08-06-06 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_600_090305.eps 090305 2009-Aug-07...
Page 66: Interface Ambilight: Dual Dc-Dc
I209 B6 I210 C6 I211 C3 I212 C3 08-06-19 CLASS_NO DC-DC INTERFACE 08-08-06 08-06-19 3104 313 6325 08-09-18 AMBI 2K9 08-08-06 08-10-23 08-10-23 08-12-06 NAME Peter Van Hove SUPERS. CHECK DATE 08-06-09 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_601_090305.eps 090305 2009-Aug-07...
Page 67: Interface Ambilight: Microcontrollerblock
7303 F2 9300 E3 9301 F3 9302 F3 SETNAME 08-06-19 CLASS_NO DC-DC INTERFACE 08-08-06 08-06-19 08-09-18 3104 313 6325 AMBI 2K9 08-08-06 08-10-23 08-10-23 08-12-06 NAME Peter Van Hove SUPERS. CHECK DATE 08-06-09 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_602_090305.eps 090410 2009-Aug-07...
Page 68 Circuit Diagrams and PWB Layouts Q549.3E LA EN 68 Layout DC/DC Interface Ambilight Personal Notes: 1M85 1302 5201 2208 2209 3338 6201 2210 9104 2203 9103 2301 3306 2302 2321 3308 2218 2323 2319 3324 2206 2200 9201 3326 2312 9202 6200 5200...
Page 69: Led Low-Pow: Microcontroller Block
7101 A7 7102 E6 7110 F4 7116-1 B11 1X03 REF EMC HOLE SETNAME CLASS_NO 2008-06-10 DRIVER 6LED LITEON 2008-08-08 2008-10-27 8204 000 8857 2008-08-08 2008-10-27 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_610_090305.eps 090730 2009-Aug-07...
Page 70: Led Low-Pow: Microcontroller Block
SPI-DATA-OUT-FIL 100R DATA-RETURN-SWITCH DATA-RETURN-SWITCH 3214 +3V3 XHALF XERR GND GND_HS +3V3 SETNAME CLASS_NO 2008-06-10 DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-10-27 2008-08-08 2008-10-27 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_610_090305.eps 090730 2009-Aug-07...
Page 71 9307 A6 9308 A6 9309-1 B6 9309-2 B6 9309-4 B6 9310-1 B8 SETNAME CLASS_NO 2008-06-10 DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-10-27 2008-08-08 2008-10-27 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_612_090305.eps 090730 2009-Aug-07...
Page 72 Circuit Diagrams and PWB Layouts Q549.3E LA EN 72 Layout 6 LED Low-Pow 9313 2129 2128 3120 1M83 1M84 3128 3119 9315 3129 2101 9121 3132 3133 3138 3136 C140 3106 3127 I110 2106 3139 3222 7110 2209 2108 1101 2119 2117 3103...
Page 73 7102 E6 7110 F4 7116-1 B11 1X03 REF EMC HOLE SETNAME CLASS_NO 2008-06-10 DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 3104 313 6314.3 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_650_090508.eps 090507 2009-Aug-07...
Page 74 100R DATA-RETURN-SWITCH DATA-RETURN-SWITCH 3214 +3V3 XHALF XERR GND GND_HS +3V3 SETNAME CLASS_NO 2008-06-10 DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 3104 313 6314.3 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_651_090508.eps 090508 2009-Aug-07...
Page 75 9308 A6 9309-1 B6 9309-2 B6 9309-4 B6 9310-1 B8 SETNAME CLASS_NO 2008-06-10 DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 3104 313 6314.3 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_652_090508.eps 090508 2009-Aug-07...
Page 76 3574 3590 560R 3591 1X04 REF EMC HOLE SETNAME 2008-05-23 CLASS_NO 2LED + CONNECTOR 2008-08-08 2008-05-23 8204 000 8874 3104 313 6314.3 2008-08-08 2008-10-31 NAME Peter Van Hove SUPERS. CHECK DATE 2008-04-20 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_653_090508.eps 090508 2009-Aug-07...
Page 77 Circuit Diagrams and PWB Layouts Q549.3E LA EN 77 Layout 8 LED Low-Pow 9313 2129 2128 1M83 3120 1M84 1M85 3128 3119 3129 9315 2101 9121 3132 3133 3138 3136 3106 3127 C140 2106 3139 3222 I110 7110 2209 2108 1101 2119 2117...
Page 78 3142 F11 7101 A7 7102 E6 7110 F4 7116-1 B11 1X03 REF EMC HOLE SETNAME 2008-06-10 CLASS_NO DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_630_090306.eps 090306 2009-Aug-07...
Page 79 SPI-DATA-OUT SOUT SPI-DATA-OUT-FIL 100R DATA-RETURN-SWITCH DATA-RETURN-SWITCH 3214 +3V3 XHALF XERR GND GND_HS +3V3 SETNAME 2008-06-10 CLASS_NO DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_631_090306.eps 090306 2009-Aug-07...
Page 80 9306-4 D5 9307 A6 9308 A6 9309-1 B6 9309-2 B6 9309-4 B6 9310-1 B8 SETNAME 2008-06-10 CLASS_NO DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_632_090306.eps 090306 2009-Aug-07...
Page 81 560R 3574 3590 560R 3591 1X04 REF EMC HOLE 2008-08-14 CLASS_NO 4 LED + CONNECTOR 2008-10-24 2008-10-31 8204 000 8897 LITEON 2K9 2008-08-14 2008-10-31 NAME Peter Van Hove SUPERS. CHECK DATE 2008-07-29 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_633_090306.eps 090306 2009-Aug-07...
Page 82 Circuit Diagrams and PWB Layouts Q549.3E LA EN 82 Layout 10 LED Low-Pow 9313 2129 2128 1M83 1M84 1M85 3120 3128 3119 3129 9315 2101 9121 3132 3133 3138 3136 3106 3127 C140 I110 2106 3139 3222 7110 2209 1101 2119 2117 2108...
Page 83 3142 F11 7101 A7 7102 E6 7110 F4 7116-1 B11 1X03 REF EMC HOLE SETNAME CLASS_NO 2008-06-10 DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18560_510_090403.eps 090410 2009-Aug-07...
Page 84 EEPROM-CS-LOCAL SOUT 100R SPI-DATA-OUT-FIL DATA-RETURN-SWITCH DATA-RETURN-SWITCH 3214 +3V3 XHALF XERR GND GND_HS +3V3 SETNAME CLASS_NO 2008-06-10 DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18560_511_090403.eps 090410 2009-Aug-07...
Page 85 9306-4 D5 9307 A6 9308 A6 9309-1 B6 9309-2 B6 9309-4 B6 9310-1 B8 SETNAME CLASS_NO 2008-06-10 DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18560_512_090403.eps 090403 2009-Aug-07...
Page 86: Led Low-Pow: Led Drive
3589 560R 3574 3590 560R 3591 1X04 REF EMC HOLE SETNAME CLASS_NO 2008-10-29 6 LED + CONNECTOR 8204 000 8898 2K9 LITEON 2008-08-14 2008-10-29 NAME Peter Van Hove SUPERS. CHECK DATE 2008-07-30 ROYAL PHILIPS ELECTRONICS N.V. 2008 18560_513_090403.eps 090729 2009-Aug-07...
Page 87 Circuit Diagrams and PWB Layouts Q549.3E LA EN 87 Layout 12 LED Low-Power 9313 2129 2128 1M83 3120 1M84 1M85 3128 3119 3129 9315 2101 9121 3132 3133 3138 3136 3106 3127 C140 I110 2106 3139 3222 7110 2209 2108 1101 2119 2117...
Page 88 IU31 120R 1% IU0T IU19 GND-SIG GND-SIG GND-SIG GND-SIG GND-SIG GND-SIG 1X08 REF EMC HOLE 2008-11-21 CLASS_NO DC/DC 8204 000 8932 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-20 ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_500_090728.eps 090728 2009-Aug-07...
Page 89 5U20 5U07 A1 5U08 E7 2K9 supplies 5U10 A1 5U21 5U11 A1 5U12 A1 SETNAME 2008-11-21 CLASS_NO DC/DC 8204 000 8932 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-20 ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_501_090728.eps 090728 2009-Aug-07...
Page 90 FU0D SENSE+1V2-PNX5100 IU2Y IU33 120R 1% CU25 IU2T GND-SIG1 GND-SIG1 GND-SIG1 GND-SIG1 GND-SIG1 GND-SIG1 GND-SIG1 CLASS_NO 2008-11-21 DC/DC 8204 000 8932 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-20 ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_502_090728.eps 090728 2009-Aug-07...
Page 91 IT25 C13 IT26 D10 IT28 D7 IT30 D9 IT32 D11 IT34 F11 IT36 G11 CLASS_NO 2008-11-21 FRONT-END 8204 000 8929 TV543 R2 LDIPNX 2008-10-10 NAME Randal De Keyzer SUPERS. CHECK DATE 2008-06-03 ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_503_090728.eps 090728 2009-Aug-07...
Page 92 9T62 F6 5T55 FT63 9T63 E11 +5V-TUN +5V-TUN-CVBS 9T64 F6 9T70 C2 9T71 C2 SETNAME 2008-11-21 CLASS_NO FRONT-END 8204 000 8929 TV543 R2 LDIPNX 2008-10-10 NAME Randal De Keyzer SUPERS. CHECK DATE 2008-06-03 ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_504_090728.eps 090728 2009-Aug-07...
Page 93 FHC1 H13 FHC2 I14 FHC3 C5 FHC6 H11 1X03 EMC HOLE SETNAME CLASS_NO 2009-01-29 STANDBY CONTROLLER 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME De Pauw B SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_505_090728.eps 090728 2009-Aug-07...
Page 94 FOR DEBUG FH01 IH95 2H07 100p TSTPOINT FOR DEBUG FH08 2009-01-29 CLASS_NO DEBUG STBY CTRL 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME De Pauw B SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 10000_012_090121.eps 090121 18320_506_090728.eps 090728 2009-Aug-07...
Page 95 +3V3-PER 100R FH12 3HPU 3HPV SDA2 SDA-SET SDA-SET 100R 2009-01-29 CLASS_NO MIPS , I2C & EJTAG 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME De Pauw B SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_507_090728.eps 090728 2009-Aug-07...
Page 96 3HFP IHF5 PCI-CLK-ETHERNET 3HF2 PCI-CLK-PNX8535 3HF4 CLKOUT 3HFM PCI-CLK-MINI PCI-CLK-PNX5100 3HFN PCI-CLK-MINI SETNAME CLASS_NO 2009-01-29 CONTROL 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME De Pauw B SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_508_090728.eps 090728 2009-Aug-07...
Page 97 DDR2-DQS3_N 7HG1 F11 VSSQ VSSQ FH06 A12 FH07 A11 IHG0 C7 SETNAME 2009-01-29 CLASS_NO DDR2 INTERFACE 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME De Pauw B SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_509_090728.eps 090728 2009-Aug-07...
Page 98 TH07 DV_YIN HDMIB-RXC- TH08 HDMI_RXC_B HDMIB-RXC+ 9HK0 HOT-PLUG-A HOT_PLUG_A HOT-PLUG HOT_PLUG_B SETNAME CLASS_NO 2009-01-29 VIDEO IN 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME De Pauw B SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_510_090728.eps 090728 2009-Aug-07...
Page 99 7HM2-2 AUDIO-OUT-R IHNE BC847BS(COL) 2HM2 IHNH IHMG 3HMU -AUDIO-R IHNK 3HMM-2 3HMM-1 2HMZ CLASS_NO 2009-01-29 AUDIO 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME De Pauw B SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_511_090728.eps 090728 2009-Aug-07...
Page 100 3HRV B8 3HRW C12 3HRY D10 3HRZ D12 3HS0 E10 3HS1 D9 CLASS_NO 2009-01-29 ANALOG AV 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME De Pauw B SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_512_090728.eps 090728 2009-Aug-07...
Page 101 IHS1 D3 IHSU C6 IHSV D6 IHSW C9 IHSY D11 IHSZ D6 SETNAME 2009-01-29 CLASS_NO AUDIO 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME De Pauw B SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2006 18320_513_090728.eps 090728 2009-Aug-07...
Page 102 3HV4-4 RESET-AUDIO IHW8 E7 7HVA-1 BC847BPN(COL) IHWE C2 IHWJ C5 IHWL C2 SETNAME CLASS_NO 2009-01-29 AUDIO 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME De Pauw B SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_514_090728.eps 090728 2009-Aug-07...
Page 103 BOLT-ON-TS-ENn 3HB6 3HB7 FE-SOP TSO-SYNC FE-VALID TSO-BIT-VALID FE-CLK TSO-BIT-CLK FE-ERR TSO-BIT-ERR SETNAME CLASS_NO 2009-01-29 CONDITIONAL ACCESS 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME De Pauw B SUPERS. CHECK DATE 2008-06-05 ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_515_090728.eps 090728 2009-Aug-07...
Page 104 AP24 TX852D+ AL24 TX852E- LOUT2_E AM24 TX852E+ AL23 TX852CLK- LOUT2_CLK AM23 TX852CLK+ SETNAME 2009-01-29 CLASS_NO LVDS 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME De Pauw B SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_516_090728.eps 090728 2009-Aug-07...
Page 105 5HV5 D3 5HV6 D1 5HV7 E1 5HV8 F2 5HV9 E3 5HVA E3 SETNAME CLASS_NO 2009-01-29 POWER 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME DE Pauw B SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_517_090728.eps 090728 2009-Aug-07...
Page 106 PNX5100-DDR2-DQS1_P PNX5100-DDR2-DQS3_P PNX5100-DDR2-DQS1_N 3C13 UDQS PNX5100-DDR2-DQS3_N UDQS 100n 100n 3C30-3 1X01 REF EMC HOLE SETNAME 2008-11-21 CLASS_NO DDR2 PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_518_090728.eps 090728 2009-Aug-07...
Page 107 AF19 AE18 AF18 RX51001B- RX51001CLK+ AC18 AD18 RX51001CLK- RX51001C+ RX51001C- RX51001D+ RX51001D- RX51001E+ RX51001E- SETNAME CLASS_NO 2008-11-21 VIDEO PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_519_090728.eps 090728 2009-Aug-07...
Page 108 +1V2-PNX5100-LVDS-PLL 2C92 F9 2C94 F7 2C95 A1 2C96 A2 2C97 A2 5C60 D6 5C61 D6 CLASS_NO 2008-11-21 SUPPLY PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_520_090728.eps 090728 2009-Aug-07...
Page 109 AC10 AMBI AB10 AF11 AE11 AD11 AC11 AB11 AB12 SYNC_H 3C41 AC12 AMBI-VS SYNC_V 100R CLASS_NO 2008-11-21 AUDIO PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_521_090728.eps 090728 2009-Aug-07...
Page 110 FCA3 C7 FCA4 C8 FCA5 C7 FCA6 D8 FCA7 D7 FCA8 D8 FCA9 D7 FCAA D8 2008-11-21 CLASS_NO LVDS PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_522_090728.eps 090728 2009-Aug-07...
Page 111 3CDB WC-EEPROM-PNX5100 WC-EEPROM-PNX5100 +3V3 EEPROM 3CDC SCL-SSB 100R 3CDD only for DEBUG SDA-SSB 100R FCD9 CLASS_NO 2008-11-21 CONTROL PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_523_090728.eps 090728 2009-Aug-07...
Page 112 PCI-AD22 PCI-AD23 PCI-AD24 IC50 PCI-AD25 PCI-AD26 PCI-AD27 PCI-AD28 IC51 3CF1 PCI-AD29 +3V3 PCI-AD30 AD25 PCI-AD31 SETNAME CLASS_NO 2008-11-21 PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_524_090728.eps 090728 2009-Aug-07...
Page 113 FCG7 E13 FCG8 B4 IC01 E3 IC02 G3 IC03 G3 ICG1 C4 ICG2 C2 CLASS_NO 2008-11-21 DISPLAY INTERF PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_525_090728.eps 090728 2009-Aug-07...
Page 114 FCJ0 D3 PNX5100 : DEBUG RESERVED +3V3 +3V3 PNX5100-RST-OUT 7CJ0 PDTC114EU FCJ0 SETNAME CLASS_NO 2008-11-21 DEBUG SHEET PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 10000_012_090121.eps 090121 18320_526_090728.eps 090728 2009-Aug-07...
Page 115 5F02 C1 5F03 A2 5F04 A2 5F05 B14 5F06 B14 1X02 EMC HOLE 2008-11-21 CLASS_NO FPGA Backlight-LVDS & I2C-MUX 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-04 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_527_090728.eps 090728 2009-Aug-07...
Page 116 FFHE EJTAG-TMS FFHF USE ONLY EJTAG-TCK FFHG FFHJ FFHK FFHH FFHL 5-147279-3 +3V3 CLASS_NO 2008-11-21 U-WAND 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-04 ROYAL PHILIPS ELECTRONICS N.V. 2007 10000_012_090121.eps 090121 18320_528_090728.eps 090728 2009-Aug-07...
Page 117 IF60 F8 IF61 F8 IF62 B8 IF63 B7 IF64 B9 IF65 B7 SETNAME 2008-11-21 CLASS_NO TEMPERATURE- & FAN-CONTROL 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-04 ROYAL PHILIPS ELECTRONICS N.V. 2007 18320_529_090728.eps 090728 2009-Aug-07...
Page 118 TX852E+ 9FG7-1 9FGD-1 RX51002E+ TXF2E+ RX51002E+ 3FH5 B8 180R 5FG1 E8 CLASS_NO 2008-11-21 FPGA WOW - LVDS IN/OUT 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-04 ROYAL PHILIPS ELECTRONICS N.V. 2007 18320_530_090728.eps 090728 2009-Aug-07...
Page 119 FFHP B9 FFHR C9 FFHS C9 FFHT C11 IFH4 A7 CLASS_NO 2008-11-21 FPGA WOW - POWER & CONTROL 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-04 ROYAL PHILIPS ELECTRONICS N.V. 2007 18320_531_090728.eps 090728 2009-Aug-07...
Page 120 MM1-CAS 5FL1 C7 MM1-WE 7FL0 B2 FFL0 B8 FFL1 B7 IFL1 C7 2008-11-21 CLASS_NO FPGA WOW - DDR 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-04 ROYAL PHILIPS ELECTRONICS N.V. 2007 18320_532_090728.eps 090728 2009-Aug-07...
Page 121 VCCINT VCCIO7 +2V5-DDR1 +1V2-FPGA +2V5-DDR1 +1V2-FPGA +1V2-FPGA +2V5-DDR1 VCCIO8 +2V5-DDR1 +2V5-DDR1 SETNAME CLASS_NO 2008-11-21 FPGA WOW - IO-BANKS 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-06 ROYAL PHILIPS ELECTRONICS N.V. 2007 18320_533_090728.eps 090728 2009-Aug-07...
Page 122 MDO6 MOCLK_VS2 CA-MOCLK_VS2 3P27-1 MDO7 SETNAME 1X06 EMC HOLE 1X05 2009-01-22 CLASS_NO REF EMC HOLE UFD2K8 8204 000 8948 DIGI i/O TV543 R2 LDIPNX_ET NAME De Pauw B SUPERS. CHECK DATE 2009-01-22 ROYAL PHILIPS ELECTRONICS N.V. 2007 18320_534_090728.eps 090728 2009-Aug-07...
Page 123 IP07 D4 YKB11-3004 AUDIO-IN4-L 1P0A +12V IP07 FP01 3P07 YKB11-3004 AUDIO-IN4-R FP24 1P0B SETNAME 2009-01-22 CLASS_NO UFD2K8 8204 000 8948 DIGI I/O TV543 R2 LDIPNX_ET NAME De Pauw B SUPERS. CHECK DATE 2009-01-22 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_535_090728.eps 090728 2009-Aug-07...
Page 124 FP29 FP2A 1P10 292303-4 IP13 9P21 9P22 IP19 502382-0570 SETNAME CLASS_NO 2009-01-22 DIGI I/O UFD2K8 8204 000 8948 TV 543 R2 LDIPNX_ET NAME De Pauw B SUPERS. CHECK DATE 2009-01-22 ROYAL PHILIPS ELECTRONICS N.V. 2007 10000_012_090121.eps 090121 18320_536_090728.eps 090728 2009-Aug-07...
Page 125 FP0H D2 FP0W FP0J E1 BP1W FP0P D1 DC1R019JB1E400 FP0R I1 1X07 CLASS_NO 2009-01-22 EMC HOLE UFD2K8 8204 000 8948 DIGI IO TV543 R2 LDIPNX_ET NAME De Pauw B SUPERS. CHECK DATE 2009-01-22 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_537_090728.eps 090728 2009-Aug-07...
Page 126 9P31-2 IP23 C5 HDMIA-RX1+ 9P31-3 HDMIA-RX2- IP28 B4 9P31-4 HDMIA-RX2+ IP68 C6 FI-RE21S-HF-R1500 2009-01-22 CLASS_NO UFD2K8 8204 000 8948 DIGI I/O TV543 R2 LDIPNX_ET NAME De Pauw B SUPERS. CHECK DATE 2009-01-22 ROYAL PHILIPS ELECTRONICS N.V. 2006 18320_538_090728.eps 090728 2009-Aug-07...
Page 127 100R NAND-ALE 3P48-3 100R PCI-CBE1 NAND-WEn PCI-CBE2 3P48-4 100R NAND-REn 100R SETNAME CLASS_NO 2009-01-22 UFD 2K8 8204 000 8948 DIGI I/O TV543 R2 LDIPNX_ET NAME De Pauw B SUPERS. CHECK DATE 2009-01-22 ROYAL PHILIPS ELECTRONICS N.V. 2007 18320_539_090728.eps 090728 2009-Aug-07...
Page 128 FN09 IN0L 5N06 +3V3 +3V3-ET-DIG 220R 5N07 IN0U +3V3 +3V3-ET-ANA 220R SETNAME CLASS_NO 2009-01-22 UFD 2K8 8204 000 8948 DIGI I/O TV543 R2 LDIPNX_ET NAME De Pauw B SUPERS. CHECK DATE 2009-01-22 ROYAL PHILIPS ELECTRONICS N.V. 2007 18320_540_090728.eps 090728 2009-Aug-07...
Page 129 PCMCIA-A11 PCI-AD23 CA-IOWR PCI-AD10 PCMCIA-A10 PCI-AD9 PCMCIA-A9 PCI-AD8 PCMCIA-A8 3N33 IN32 SETNAME CLASS_NO 2009-01-22 UFD 2K8 8204 000 8948 DIGI I/O TV543 R2 LDIPNX_ET NAME De Pauw B SUPERS. CHECK DATE 2009-01-22 ROYAL PHILIPS ELECTRONICS N.V. 2007 18320_541_090728.eps 090728 2009-Aug-07...
Page 130 6E12 B6 6E14 C6 6E22 E12 6E23 D11 6E24 D6 1X04 EMC HOLE 2008-11-21 CLASS_NO ANA + SIDE I/O 8204 000 8930 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2008-01-18 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_542_090728.eps 090728 2009-Aug-07...
Page 131 CVBS-MON-OUT-CINCH 6E47 E10 6E48 F10 FE43 Y_CVBS-MON-OUT 6E51 H4 6E52 G4 SETNAME CLASS_NO 2008-11-21 ANA + SIDE I/O 8204 000 8930 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2008-01-18 ROYAL PHILIPS ELECTRONICS N.V. 2005 18320_543_090728.eps 090724 2009-Aug-07...
Page 132 FE22 C3 FE23 D3 FE24 F3 FE25 F5 FE56 A2 FE86 B7 CLASS_NO 2008-11-21 ANA + SIDE I/O 8204 000 8930 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2008-01-18 ROYAL PHILIPS ELECTRONICS N.V. 2007 18320_544_090728.eps 090724 2009-Aug-07...
Page 133 9E05 E1 3E93 FE28 100R 9E08 C3 9E09 C4 9E30 H11 SETNAME CLASS_NO 2008-11-21 ANA + SIDE I/O 8204 000 8930 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2008-01-18 ROYAL PHILIPS ELECTRONICS N.V. 2007 18320_545_090728.eps 090724 2009-Aug-07...
Page 134 FA36 3A06 MPCIACT MPCIACT +3V3-mPCI IA25 FA33 1734065-3 1734065-3 1X09 REF EMC HOLE SETNAME CLASS_NO 2008-11-21 MINI PCI 8204 000 8935 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-10-16 ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_546_090728.eps 090728 2009-Aug-07...
Page 135 IA07 D4 IA08 D3 2AC0 IA09 E5 100p IA10 C1 IA11 E5 IA12 E7 CLASS_NO 2008-11-21 MINI PCI 8204 000 8935 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2008-01-18 ROYAL PHILIPS ELECTRONICS N.V. 2008 18320_547_090728.eps 090728 2009-Aug-07...
Page 136 FD14 A5 ID05 C8 ID06 C8 RIGHT-SPEAKER ID07 C8 ID08 C8 ID09 C7 SETNAME CLASS_NO 2008-11-21 CLASS D 8204 000 8931 TV543 R2 LDIPNX 2008-10-10 NAME Randal De Keyzer SUPERS. CHECK DATE 2007-10-12 ROYAL PHILIPS ELECTRONICS N.V. 2007 18320_548_090728.eps 090728 2009-Aug-07...
Page 137 Circuit Diagrams and PWB Layouts Q549.3E LA EN 137 SSB: SRP List Explanation Personal Notes: Example 1 . 1 . Introduction Net Name Diagram +12-15V AP1 (4x) +12-15V AP4 (4x) SRP (Service Re ference Protocol) is a softw are too l that creates a list w i th all refer e n c es to signal lines. The list contains +12-15V AP5 (12x) references to the signals w i thin all schemat ics of a PWB.
Page 138 Circuit Diagrams and PWB Layouts Q549.3E LA EN 138 SSB: SRP List Part 1 Netname Schematic B08D +3V3-STANDBY B08A (1×) AV1-B B07H (1×) CA-DATAEN B04H (1×) DDC-SCL B06B (1×) EJTAG-TDO B04A (2×) LED2 B09B +3V3-STANDBY B08D (3×) AV1-B B07A (2×) CA-INPACK B07D (1×) DDC-SCL...
Page 139 Circuit Diagrams and PWB Layouts Q549.3E LA EN 139 SSB: SRP List Part 2 Netname Schematic B05G (2×) PCI-AD25 B09A (1×) PCI-IRDY B05A (2×) PNX5100-DDR2-D30 B05F (1×) SCL-AMBI-3V3 B05E (3×) TX1C- B05E (1×) TXDAT+ B07F (1×) PCI-AD25 B04F (1×) PCI-PAR B05A (2×) PNX5100-DDR2-D31 B06A (1×)
Page 140 Circuit Diagrams and PWB Layouts Q549.3E LA EN 140 Layout Small Signal Board (Top Side) 1F05 1M71 1M59 1R20 1242 1012 1R12 1X01 1X04 1F53 1FA1 1FA0 1E05 3F01 3F36 2F46 3F383F39 2F47 2EB3 3F37 9F17 9F19 9F20 3ED3 9F18 9FA1 9FA2 2FNE...
Page 141 Circuit Diagrams and PWB Layouts Q549.3E LA EN 141 Layout Small Signal Board (Bottom Side) 5E02 FF42 2E81 FF24 FF23 2EB1 IE07 3EA3 IE90 FF41 FF40 FF31 FF44 IE89 FEA8 FF43 3EB2 3EA2 FEA9 7E16 FEA5 FEB1 7E06 FEA7 FEA6 FF50 FF21 IE60...
Page 142 18310_557_090309 3104 313 6328.2 090309 1000 U.FL-R-SMT-1(10) ******** SETNAME ******** CLASS_NO 08-07-07 WIFI antenna ****** 08-10-20 **-**-** **-**-** 3104 303 5212 08-07-07 **-**-** 08-10-20 **-**-** NAME Maelegheer Ingrid SUPERS. CHECK DATE ****-**-** ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_640_090306.eps 090730 2009-Aug-07...

This manual is also suitable for:

40pfl9704h/60 46pfl9704h/12 46pfl9704h/60 52pfl9704h/12

Philips 40PFL9704H/12 Service Manual

Quick Links

Related Manuals for Philips 40PFL9704H/12

Summary of Contents for Philips 40PFL9704H/12

This manual is also suitable for:

Table of Contents