Page 2
If and when new materials and production techniques are developed that can improve the quality of its product, or material substitutions are necessary due to availability, Airstream reserves the right to make such changes.
Section 1 Section 1 INTRODUCTION INTRODUCTION The Owner’s Manual for your new Airstream Touring We have provided many important safety messages Coach is designed to respond to the most frequent in this manual. Always read and obey all safety inquiries regarding the operation, function, and care of messages.
Improper use may result in a fire and/or explosion. Make sure to follow all instructions and warnings in this manual as well as those in the specific owner’s manuals of the appliances and equipment� 2022 Interstate 24X...
Ventilation is an essential Detector� If you have not received the manual, contact requirement for touring coach use for many reasons� your dealership to obtain one, or contact Airstream Any effects of formaldehyde can be greatly reduced Customer Relations at 937-596-6111�...
Carbon Monoxide concentration Activation of your Carbon Monoxide alarm’s under 30 ppm. If in doubt, consult your medical audible horn indicates the presence of Carbon practitioner. Monoxide that can kill you. Leave the area immediately! 2022 Interstate 24X...
Failure to test units used in RVs as pipe designs which can amplify the above described may remove your protection. situations� 2� Extended use of un-vented fuel burning devices� 3� Temperature increase that can trap exhaust gases near the ground� 2022 Interstate 24X...
Failure to do so NOTE can result in injury or death. If the low voltage warning sounds, the detector will need to be reset by disconnecting the battery, before normal operation will occur. 2022 Interstate 24X...
Have a qualified technician check your LPG system annually or if you detect any signs of leaks or malfunctions. NOTE Refer to Section 5 - Interior and Section 6 - Exterior for additional LPG warnings and safety information. 2022 Interstate 24X...
WARNING Your touring coach is equipped with an Automatic Generator Start System. Exposure to carbon monoxide, moving parts, and electricity hazards are possible due to unexpected automatic starting. NOTE The generator is located under the touring coach. 2022 Interstate 24X...
Do not clean with flammable material. Keep flammable material away from open flame. We have all heard these warnings many times, but they are still among the leading causes of fires. 2022 Interstate 24X...
There is portions of your motorhome not excluded under the no warranty of any nature made by airstream beyond section “What is Not Covered”� “Defect” means the that contained in this limited warranty� No person has...
MUST the name of a business association (such as any notify your dealer OR Airstream within 10 days of LLC, corporation, or partnership). If the motorhome the date of purchase to have damage repaired at no owner or user files a tax form claiming a business cost to you�...
Airstream may direct you to an authorized Airstream dealer, or may request that you bring your motorhome to the Airstream factory in Jackson Center, Ohio for repairs� Airstream does not control the scheduling of repairs at its authorized Airstream dealers, and repairs at the Airstream factory may not be immediately available�...
Events That Discharge Airstream’s Obligations Lack of customer care and/or improper maintenance Under This Limited Warranty will result in early failure for which Airstream cannot be Misuse or neglect, accidents, unauthorized alteration, held responsible� failure to provide reasonable and necessary Exposure maintenance (see Owner’s Manual), damage caused...
Your Sprinter Van and its components are pre-checked When you require service for your touring coach from by its manufacturer before delivery to Airstream� All the Airstream Factory Service Center or a Certified service to the Sprinter Van and its components must...
Before moving on, turn off the LP gas and water pump� 9� Emergency light and first aid kits. Check your campsite, both for cleanliness and to be sure you have not left anything behind� Make sure everything is properly stowed� 2022 Interstate 24X...
LP system for some time, lighting When you stop for the night, your Airstream Touring a cooktop burner to bleed any air from the system will Coach is built to be safely parked in any spot that make it easier to start the generator�...
Damage or deterioration due to long-term occupancy may not be considered normal, and may under the terms of the warranty constitute misuse, abuse, or neglect, and may therefore reduce the warranty protection. 2022 Interstate 24X...
2� Black Water Tank (Toilet) facilities, while on the road or parked, without being connected to a sewage line� It may also be used when 3� Galley Drain parked while connected to a sewage hose� 4� Gray Water Tank 3-10 2022 Interstate 24X...
For instance, with an outside temperature of zero degrees, and the wind velocity of 10 miles per hour, the equivalent chill temperature is -20°F� 7� Remember to remove and drain the exterior shower faucet to prevent freeze damage� 3-11 2022 Interstate 24X...
Page 28
General Information NOTES NOTES 3-12 2022 Interstate 24X...
Vehicle Identification Number (VIN), and GAWR. must be checked immediately after changing a tire and again after 30 miles to 140 ft-lbs. The wheels For a complete list of capacities, see the Specifications could otherwise come loose. Chart on the previous page. 2022 Interstate 24X...
Interior General Information and Cleaning CAUTION The interior of each Airstream Touring Coach has been Abrasive polishes or cleaning solvents such as designed for comfort, convenience, durability, and automatic dishwasher or acid etch cleaners are appearance� How you use it and how you take care of too strong and should never be used.
NOTE completely. Do not use any abrasive material, abrasive Please see the toilet owner’s/user manual for warranty, cleaners, cloths and pads as there is the possibility user tips, and maintenance information� they could scratch the surface. 2022 Interstate 24X...
Faucet Cleaning and Care All that is needed to clean your faucet is a soft, damp cloth� Airstream does not recommend the use of scour pads, cleansers, or chemicals� The abrasive nature of these substances could damage the faucet’s finish. A CAUTION non-abrasive car wax will help to protect the finish.
Table System The driver and passenger heated seats are provided The Interstate 24X is equipped with two adjustable by Sprinter, sent out to be recovered by Airstream to tables and four mounting locations� One table is match the interior decor�...
12-Volt System If you are not plugged into city power, and you plan The major portion of electrical power in your Airstream on staying longer than a day or two, you will want to is 12 volt� The 12-volt current powers almost everything...
2� Exterior Lighting: 1 - 10A, 2 - 15A, 1 - 20A, Under roadside lounge seat� 3� Chassis solar controller & trickle charger: 2 - 15A The Interstate 24X has a power center installed under fuses, under driver’s seat� the roadside bench seat� Open the decorative door for 4�...
ON the possibly faulty device a fault condition may power center (120 VAC section)� Airstream has pre- exist in that device and should be service by a qualified installed the correct breakers per RVIA (NEC) listing Technician�...
Do not operate the generator in an enclosed building or in a partly enclosed area such as a garage� Nor should the generator be operated while sleeping� Be sure to follow all instructions and warnings in this manual and the generator manufacturer’s manual� 5-10 2022 Interstate 24X...
Pressing “ENTER” will enable the selected auto feature� NOTE Do not select “AUTO ON” mode before carefully reading and understanding the instructions providing in the generators operating manual provided in the owner’s packet. 5-11 2022 Interstate 24X...
The main disconnect will not disable these systems� NOTE As a safety precaution, the electric gas shut-off solenoid closes automatically when 12-volt power is disconnected, cutting gas to appliances. It will reopen when power is restored. 5-12 2022 Interstate 24X...
Converter Protecting the Charging System The Airstream converter system enables you to use The DC-DC Battery Converter monitors the house the 12-volt lights and equipment whether operating on battery system to determine if the batteries are being self-contained battery power or hooked up to 120-volt charged�...
If The GFCI circuit breaker provides protection only that does not solve the problem, consult an Airstream to the circuit to which it is connected. It does NOT Service Center�...
Connected RV Antenna Pre-Wire blends well with the designs of recreational vehicles� The Airstream Interstate 24X is pre-wired with The amplified signal maximizes signal strength to a Connected RV high gain, multi-band antenna�...
Interior Appliances WARNING All appliances are delivered to Airstream, Inc�, with in-depth owner’s manuals� Those manuals are For additional Liquid Propane Gas (LPG) safety included in the owner’s packet supplied by your dealer� and warning information, refer to Section 2 - Safety The manuals may contain Warnings, Cautions, and and Section 6 - Exterior of this manual.
Monitor Panel The Interstate 24X is equipped with an all-in-one diesel/electric hydronic heating and hot water system� Gas is supplied from the vehicles diesel fuel tank� Make sure the tank has enough fuel to run the heating system�...
(clockwise); conversely turning the thermostat knob to the left (counterclockwise) yields a warmer setting� The OFF position is reached by turning hard counterclockwise past the click� The reference point is shown with an indicator sticker beside the knob� 5-19 2022 Interstate 24X...
VictronConnect app is free to download, and is available for Apple and Android devices� The Interstate 24X is equipped with 300 watts of solar, a charge controller, and display� Ensuring the The Interstate 24X also includes 2 exterior solar ports�...
The following additional information is provided by application� Airstream to help you understand the finish and its A hand-applied polish or wax will offer outstanding care� Following these instructions will provide a long performance and protect the touring coach finish.
Caulking and sealing material is For replacement of a damaged window, contact an available from your touring coach dealer and most RV Airstream Service Center� supply stores� 2022 Interstate 24X...
Cable/ 7� Solar Port: designed as a quick plug-in for a Satellite TV inlet� A portable satellite dish can be portable solar charging kit connected and used in this cable connection� 2022 Interstate 24X...
7� Coated Rims: Steel rims coated in a Urethane spray-on protective coating� 2� Exterior 120-volt Outlet: provides an exterior GFCI protected electrical source when plugged in to shore power or when the generator is running� 2022 Interstate 24X...
Exterior Urethane Coated Rims City Water Hookup Airstream uses the same black Urethane spray-on protective coating on the wheels that it uses on the body kit� The coating is applied directly to the steel rims� The coating has the same rust and abrasion protection for the rims as it provides for the lower trim panels�...
A few features of the SmartPlug include: • Eliminates Overheating - Increased pin & clip surface area greatly improves electrical conductivity during The Interstate 24X is equipped with a front high high amperage demand� intensity light bar mounted to the roof rack, as well as side and rear camp-pod lights�...
Hydraulic Leveling System Towing Hitch The Interstate 24X can be equipped with the optional electrically/hydraulically driven leveling system� The hydraulic pump is powered by a 12 volt direct current motor, which pumps hydraulic oil through the hydraulic hoses to four leveling jacks�...
Do NOT attempt to force the lead rail in with the override, serious damage can occur to the awning. NOTE Manual override cannot be used to extend the awning. 2022 Interstate 24X...
CAUTION Check that the screen door is in the stowed position before closing the exterior door. Failure to follow this caution could result in damage to the screen door. 6-10 2022 Interstate 24X...
Sprinter Van Sprinter Van Serviced by Mercedes-Benz The Airstream Touring Coach is integrated into a Sprinter Van designed and manufactured by Mercedes- Sprinter or Its Suppliers Benz� Operation of the Sprinter, its engine, power train, and other related components are discussed Chassis in the Mercedes-Benz Sprinter Owner’s Manual and...
NOTE front tires to wear unevenly and can cause the vehicle to “pull” to the left or right. Please contact Airstream or Onan for a service location if repairs are need for the Vehicle Placard and Tire Inflation Pressure generator.
Break in the tires at moderate speeds for a distance of Tire inflation pressure should always meet at least about 65 miles� the minimum guidelines for vehicle weight. 2022 Interstate 24X...
Sprinter Manual if you has a few seconds to escape the vehicle� Many have any doubts about changing a tire. drivers panic as soon as the vehicle submerges and are found later with their seat belt intact� 2022 Interstate 24X...
The vehicle may tip over and cause serious injury or death to you or others. Jack stands must always be used while working beneath the vehicle. Failure to follow these precautions could result in property damage, personal injury, and/or death. 2022 Interstate 24X...
WARNING For safety reasons, the wheel tightening torque must be checked immediately after changing a tire and again after 30 miles to 140 ft-lbs. The wheels could otherwise come loose. 2022 Interstate 24X...
If not done, request an inspection and a determination of the steel cables in the sidewall of the tires may be possible damage. damaged and could lead to premature fatigue of the sidewall� 2022 Interstate 24X...
Once the vehicle is in motion, the air ride system will automatically self-adjust to ride height. You can not manually adjust the height while the vehicle is in motion. 2022 Interstate 24X...
Page 72
Sprinter Van NOTES NOTES 7-10 2022 Interstate 24X...
It must OCCUPANTS AND CARGO SHOULD NEVER never exceed the GVWR� EXCEED” number, Airstream weighs the vehicle as Gross Axle Weight Rating (GAWR) is the maximum finished and adds the weight of full tanks of LP and permissible axle weight�...
Just reducing your load by 10 Check the Sprinter manual for all weights and tire gallons of water lets you carry an additional 83�4 lb of information placard location. cargo� 2022 Interstate 24X...
Ask your authorized Mercedes-Benz Sprinter or Airstream dealer if you require an explanation of The rear lounge seat belt buckles are secured by information contained in the manuals. inserting the male end into the female buckle until the buckles are secured�...
Check the Mercedes-Benz Sprinter manual for all from the tow vehicle� Please consider using a trailer weights and tire information placard locations. sway control system� For further information, see your authorized Mercedes-Benz Sprinter or Airstream dealer� 2022 Interstate 24X...
AC. Engine coolant heat can be additionally not enough for standstill safety. Do not use trailer vented by opening the windows, switching the brakes as parking brakes. climate control fan speed to high and setting the temperature control to the maximum hot position. 2022 Interstate 24X...
Their directions should always indicate to the driver the direction the rear of the trailer should go� A little practice in a parking lot with the person giving directions can save a lot of frustration when backing into a campsite� 2022 Interstate 24X...
Parking Your Touring Coach To reduce the risk of personal injury or damage to Your Airstream Touring Coach should be given a the vehicle power train as a result of vehicle/trailer thorough safety check before a trip� Regular use of...
14� The freedom of movement of the brake and accelerator pedals must not be impaired in any way� 15� Check rear view mirrors adjustment, inside and outside� Adjust window coverings if necessary for maximum visibility� 16� Secure children in a federally-approved child restraint device� 8-10 2022 Interstate 24X...
To break in the Onan generator run the generator Windows, and Door Clean with mild detergent and at 50 percent load for two hours, then at 75 percent Seals coat with “Slipicone�” load for two hours� Refer to the Onan’s manual for Exterior more details� 2022 Interstate 24X...
Maintenance Suggested Maintenance and Replacement Parts (Part numbers listed are Airstream part numbers and can be ordered by calling a certified Airstream dealer.) WARNING Always replace the bulb or light fixture with the correct bulb for that light or matching fixture. Failure to heed this warning could cause fire, property damage, personal injury, or death.
Maintenance Exterior Care Replacement Rivets The following exterior care products are recommended Interior by Airstream� Read and follow label directions� Exterior Part Number 330127-05 330149 sealant should be checked and resealed once a year� Rivet Name AD45ABS ADS46ABSR Walbernize Super Seal (PN - 28433W) - Use to clean...
2/32 could otherwise come loose. in� remaining tread depth� 7� Park out of the sun whenever possible when in warm climates� In desert regions, use tire covers to prevent ultra violet light deterioration to tires� 2022 Interstate 24X...
DC-DC converter� The DC-DC maintenance� The use of lithium batteries in Airstream’s converter will limit the charge current to the house Touring Coach, also provides the benefit of delivering more energy at typically half the weight of a traditional batteries to approximately 40 amps�...
LBCO shutdown� Amp Hours Voltage Capacity Remaining 14.4V 100% 13.6V 100% 13.4V 13.3V 13.2V 13.1V 13.0V 12.9V 12.8V 12.5V 12.0V 10.0V NOTE Values are based off a testing environment with the batteries at 100% capacity. 2022 Interstate 24X...
RVIA ANSI A 119.2 and the U.S. Public Health disconnect are free of all debris and are not damaged Service. before replacing� Check the pump system for leaks any time the disconnect fittings on the hoses and/or strainer are removed� 9-10 2022 Interstate 24X...
If the rubber ring Water holding tank is completely full, sewage cannot seems loose when used, Airstream recommends using be emptied from the toilet bowl� If the Gray Water some type of weight to further secure the hose�...
“retract” position� Be sure to guide the hose back and forth onto the reel evenly� Close the compartment door� NOTE Watch all connections while dumping. Close dump valve immediately, turn off pump, and close hose drip-proof valve if a leak is noticed. 9-12 2022 Interstate 24X...
Twice a year, or after a long storage period, we with water using the black tank flush inlet, and then suggest you take your unit into your Airstream dealer drive the touring coach for a few miles� Don’t wait until for a check-up and cleaning of the gas-operated the tank is packed solid�...
4� Poor flush: The pedal must be held completely down to flush. A good flush should be obtained within 2 to 3 seconds� If problem persists, remove the water supply line and check flow rate. 9-15 2022 Interstate 24X...
Maintenance Solar Panel Wiring A manual on the use of the solar system is included with the Airstream Owner’s Packet� Please read and understand all information before operating the system� The charge controller senses the actual battery charge and regulates the charging to prevent over charging� The system requires the 12-volt feed from the battery to operate�...
Turning the corner or stopping Answer: No, your Airstream is equipped with a built in quickly while oil is low can cause this to happen�...
Page 111
5. How do I use my Black Water tank flush? Appliances Answer: First, empty your Black Water tank, and then 1. I am planning for a trip in my Airstream. How close your Black Water tank valve� Hook up your hose should I get the refrigerator cooled down?
Page 113
Fuel 7-2 Chemical Sensitivity 2-2 Furnace and Water Heater 5-18 City Water Hookup 6-6 Cleaning Exterior 6-2 Generator Interior 5-3 Automatic Generator Start (AGS) 5-11 Converter 5-13 Operation 5-10 Cooktop 5-16 Safety 2-8 Gravity Water Fill 6-6 Index-1 2021 Interstate 24X...
Page 114
Water Heater (see Furnace and Water Heater) Winterizing 9-14 Water System 9-10 Rear Screens and Shades 6-10 Sanitizing 9-10 Refrigerator 5-19 Water Pump 9-10 Weight Distribution 8-3 Windows 6-3 Winterizing and Storage 9-13 Winter Traveling 3-11 Index-2 2021 Interstate 24X REV# 03...
Page 115
Beautiful is a call to action to pick up the litter, toss it in a can, and not simply step over it and pass it by. Your purchase of a new Airstream will open doors to new experiences and places you’ve only dreamed of – but it takes all of us working together to ensure those places remain pristine, accessible, and ready for the next adventure.
Page 116
428 West Pike Street P.O. Box 629 Jackson Center, OH. 45334-0629 Phone: (937) 596-6111 Fax: (937) 596-6539 www.airstream.com...