Jenn-Air 740-0338 Manual
  1. Manuals
  2. Brands
  3. Jenn-Air Manuals
  4. Gas grills
  5. 740-0338
  6. Manual
Jenn-Air 740-0338 Manual

Jenn-Air 740-0338 Manual

Stainless steel built-in
Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
STAINLESS STEEL BUILT-IN GAS GRILL
MODEL #s: 740-0338 / 750-0338
Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe's Companies, Incorporated.
PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE
DO NOT RETURN TO PLACE OF PURCHASE
LOWE'S ITEM #s: 144541 / 157618
300
400
500
200
600
100
700
800
FOR OUTDOOR USE ONLY
B27Y07-1

Advertisement

Table of Contents
loading

Related Manuals for Jenn-Air 740-0338

Summary of Contents for Jenn-Air 740-0338

  • Page 1 STAINLESS STEEL BUILT-IN GAS GRILL MODEL #s: 740-0338 / 750-0338 LOWE’S ITEM #s: 144541 / 157618 Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Incorporated. FOR OUTDOOR USE ONLY B27Y07-1 PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE...

  • Page 2: Table Of Contents

    TABLE OF CONTENTS SECTION ONE SECTION FIVE Safety Instructions Exploded View Model 750-0338 Placement of the Grill Parts List Model 750-0338 Exploded View Model 740-0338 SECTION TWO Parts List Model 740-0338 Model Specifications Island Construction SECTION SIX Front View of Opening...

  • Page 3: Safety Instructions

    SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS WARNING WARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. WARNING – Hazards or unsafe practices which COULD result in severe personal injury or death. WARNING Spiders and insects can nest inside the burners of CAUTION...
  • Page 4 (3.5 kpa). When using a match to light the grill make sure to use the attached lighting rod. CAUTION Model 740-0338 LP Gas Grill When using the rotisserie burner, remove WARNING the warming rack. High heat from the 1. Do not store spare LP gas cylinders under or burner may cause the warming rack to near this appliance.
  • Page 5 SAFETY INSTRUCTIONS This grill is not intended to be installed in or on WARNING recreational vehicles or boats. Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this Children should not be left alone or unattended in an manual.

  • Page 6: Placement Of The Grill

    Do not use briquettes of any kind in the grill. Clean the grill with caution. To avoid steam burns, The 740-0338 and 750-0338 grills are designed for do not use a wet sponge or cloth to clean the grill optimum performance without the use of briquettes.

  • Page 7: Model Specifications

    GRILL SPECIFICATIONS Description 740-0338 and 750-0338 Cutout Width 39 in. (99.06m) Cutout Depth 23 in. (58.42m) Cutout Height 11 in. (27.94m) Natural Gas: Standard residential 1/2 in. (1.3 cm) ID gas service line. Natural gas hose/regulator assembly included with quick-connect fitting for attachment to house natural gas line.

  • Page 8: Island Construction

    Width 39 inches (99.06 cm) Depth 23 inches (58.42 cm) Height 11 inches (27.94 cm) Tank bolt dimension for Jenn-Air 4 burner +1Sear Burner +Rotisserie burner LP Tank bolt type: 1/2 inches-12UNC (1.27cm) Tank bolt length:9/20 inches (11.5 cm) nk bolt length:9/20 inches (11.5 cm)
  • Page 9 Island Construction 740-0338 1 7/16 in.(3.65cm) 7 7/8 in.(20cm) Measurements shown are for attaching 1 7/16 in.(3.65cm) the LP regulator to the island. 13/16 in.(2.06cm) 2 15/16 in.(7.46cm) 750-0338 1 9/16 in.(3.97cm) 2 15/16 in.(7.46cm) Measurements shown are for attaching the NG regulator to the island.

  • Page 10: Front View Of Opening

    FRONT VIEW FOR BUILT-IN OPENING 8 in.(20.32cm) 6 in.(15.24cm) 38 1/4 in.(97.16cm) 3 in.(7.62cm) ° ° 2 in.(5.08cm) 2 in.(5.08cm) 1 7/8 in.(4.76cm) The following are minimum dimensions necessary to install the 4 burner + 1 sear burner built-in grills: Width of grill head: 38 1/4 in.

  • Page 11: Side View Of Opening

    The following are minimum clearances necessary around the Jenn-Air built-in 4 burner +1 sear burner grills: Rear Clearance: 24 in. to combustible materials Combustion gap below control panel: 1 7/8 in.

  • Page 12: Battery Installation

    BATTERY INSTALLATION 1. Unscrew the ignition button housing by turning counterclockwise. 2. Insert the battery into the housing with the positive (+) terminal facing outward. 3. Replace the ignition button housing after the battery has been installed.

  • Page 13: Lp Gas Hook Up

    1. The tank valve should be in the “OFF” position. Total gas consumption (per hour) of 740-0338 grill If not, turn the knob clockwise until it stops. with all burners on “IGNITE / HI”: 2.

  • Page 14: Propane Tank Assembly

    INSTALLATION OF PROPANE LIQUID REGULATOR Fig. 1 Make sure the LP regulator is located under the island hole as shown in Fig. Fig. 2 3 00 20 0 60 0 1 00 Use the 4 screws and clamp provided to attach the brass connector to the island as shown in Fig.

  • Page 15: Installation Of Ng Regulator

    INSTALLATION OF NATURAL GAS REGULATOR 1. The Natural Gas regulator has been factory installed. Attach the PVC gas hose to the regulator (see drawing below). 2. Adjust the brass elbow so that it is pointing down. 3. Connect the other end of the PVC gas hose to the house gas line using the quick-connect fitting.

  • Page 16: Natural Gas Hook-Up Xxxxxxxxxxxxxxxxxxxxxxxx

    NATURAL GAS HOOK-UP XXXXXXXXXXXXXXXXXXXXXXXX Only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. The installation of this appliance must conform with the local codes or, in the absence of local codes, to the national fuel gas code, ANSI Z223.1.

  • Page 17: Leak Testing Xxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxx

    LEAK TESTING XXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXX GENERAL Although all gas connections on the grill are leak 6. If it is evident there is excessive abrasion or tested at the factory prior to shipment, a complete wear, or the hose is cut, it must be replaced gas tightness check must be performed at the prior to the outdoor cooking gas appliance installation site.

  • Page 18: Installer Final Checklist

    1/2 psi (3.5 kpa). Model 740-0338 WARNING 1. Do not store spare LP gas cylinders under or near this appliance.

  • Page 19: Operating Instructions

    OPERATING INSTRUCTIONS GENERAL USE OF THE GRILL AND ROTISSERIE Each main burner is rated at 13,000 BTU/Hr. The CAUTION main grill burners encompass the entire cooking Do not leave the grill unattended while cooking. area and are side ported to minimize blockage from falling grease and debris.
  • Page 20 LOADING THE ROTISSERIE SKEWER It is normal for the skewer to flex when larger cuts 1. Screw the bushing into the skewer rod at the of meat are being cooked. It may also be necessary opposite end from the point. to remove the cooking grids for larger cuts of meat.

  • Page 21: Lighting Instructions

    LIGHTING INSTRUCTIONS BEFORE LIGHTING… Inspect the gas supply piping prior to turning the gas “ON”. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use. WARNING Do not use the grill if gas odor is present. Contact Yellow flames indicate insufficient air.

  • Page 22: Lighting Illustrations

    LIGHTING ILLUSTRATIONS MAIN BURNER LIGHTING ROTISSERIE BURNING LIGHTING 1. Open the top cover or lid. 4. Push and turn the Rear Burner knob to the “ IGNITE/ON” setting and hold in for 5 seconds while holding, push electronic ignition button, until burner is lit.

  • Page 23: To Match Light The Grill

    MATCH LIGHTING THE GRILL If the burner will not light after several attempts using the control knobs, the burner may be lit with a match. 1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate.

  • Page 24: Care And Maintenance

    To reinstall the main burners: 3. Insert the burner over the valve assembly CAUTION (model 750-0338/740-0338 Item # 26 on Before cleaning, make sure the gas supply and pages 24 and 26). control knobs are in the “OFF” position and the Insert the back of the burner into the hole at burners have cooled.

  • Page 25: Troubleshooting

    TROUBLE SHOOTING WHEN TO LOOK FOR SPIDERS INSECT WARNING You should inspect the burners twice a year or Spiders and insects can nest in the burners of immediately after any of the following conditions this and other grills, which could disrupt gas occur: flow.

  • Page 26: Exploded View Model 750-0338

    EXPLODED VIEW MODEL 750-0338 30 0 40 0 5 00 20 0 6 00 1 00 8 00 70 0 40( A) 40( B) 40( D) 40( C)

  • Page 27: Parts List Model 750-0338

    PARTS LIST MODEL 750-0338 REF# DESCRIPTION REF# DESCRIPTION Main Lid Grease Tray Temperature Gauge Lighting Rod cover Logo Lighting Rod Main Lid Handle Heat Insulating Main Manifold Spacer Main Lid Handle Heat Insulating Main Gas Valve Cover Main Lid Handle Rotisserie Gas Valve Rotisserie lgniter Wire Main Burner Flex Gas Line...

  • Page 28: Exploded View Model 740-0338

    EXPLODED VIEW MODEL 740-0338 4 0 0 3 0 0 5 0 0 2 0 0 6 0 0 1 0 0 8 0 0 7 0 0 37( A) 37( B) 37( D) 37( C)

  • Page 29: Parts List Model 740-0338

    PARTS LIST MODEL 740-0338 REF# DESCRIPTION REF# DESCRIPTION Main Lid Grease Tray Temperature Gauge Lighting Rod Cover Logo Lighting Rod Main Lid Handle Heat Insulating Main Manifold Spacer Main Lid Handle Heat Insulating Main Gas Valve Cover Main Lid Handle...

  • Page 30: Grilling Hints

    GRILLING HINTS The preparation of meat, whether rare, medium, or To get the juiciest meat, add seasoning or salt after well done, is affected to a large degree by the the cooking is finished and turn the meat only once thickness of the cut.
  • Page 31 WEIGHT OR FLAME APPROXIMATE SPEICAL INSTRUCTIONS FOOD THICKNESS SIZE TIME AND TIPS Place in aluminum foil pan. French Fries Medium 15 to 30 minutes Grill, stirring occasionally. MEATS Grill, turning once when juices rise to the surface. Do not leave hamburgers unattended since a flare-up Hamburgers 1/2 to 3/4 inch...
  • Page 32 WEIGHT OR FLAME APPROXIMATE SPEICAL INSTRUCTIONS FOOD THICKNESS SIZE TIME AND TIPS Grill, turning occasionally. Ribs During last few minutes brush with barbecue sauce, turn Medium 30 to 40 minutes several times. Ham steaks Remove excess fat from edge. Slash remaining fat at 2-inch (precooked) 1/2 inch slices High...

  • Page 33: Grill Recipe Suggestions

    GRILL RECIPES BBQ SALMON Half-hour before cooking, turn the 1tsp. Worcestershire sauce 2 large salmon steaks burner to the grill on high. Drain 1tsp. Dry mustard 2 tbs. oil seafood-reserving marinade. On each ¼ tsp. Thyme, crushed Salt & pepper of twelve 10 in.
  • Page 34 heat tortillas on grill. Slice meat across CHICKEN TANDOORI STYLE 2 oz. lemon juice grain in thin slices. Place on hot platter. 8 large chicken thighs or drumsticks 10 lbs. pork roast Squeeze lemon juice over. Wrap meat and 1 c. plain nonfat yogurt any of the following toppings in tortillas: ½...

  • Page 35: Limited Warranty

    1-800-554-5799, FAX number 1-800-598-8829. Please direct all correspondence to: Nexgrill Industries, Inc. 280 Machlin Court, City of Industry, CA 91789, ATTN: Warranty Service Center. *Jenn-Air is a trademark of the Maytag Corporation and is used under license to Lowe’s Company Inc. Printed In China...

This manual is also suitable for:

750-0338

Table of Contents