Table of Contents
Advertisement
Quick Links
SIDE MOUNT SAND FILTERS
Sta-Rite Pool/Spa Group
293 Wright Street, Delavan, WI 53115
International: 262-728-5551, FAX: 262-728-7550
www.starite.com
Union City, TN • Delavan, WI • Mississauga, Ont. • Murrieta, CA
© 2004, Sta-Rite Industries
CLEAR-FLO
O
W
N
E
R '
INSTALLATION, OPERATION & PARTS
SR-300-2U
TM
S
M
A
N
MODELS
SR-360-2U
Printed in U.S.A.
U
A
L
SR-360-3T
This manual should be furnished to the
end user of this filter; its use will reduce
service calls and chance of
injury and will lengthen filter life.
S621 (Rev. 6/9/04)
Advertisement
Table of Contents
Related Manuals for STA-RITE CLEAR-FLO SR-300-2U
Summary of Contents for STA-RITE CLEAR-FLO SR-300-2U
- Page 1 Sta-Rite Pool/Spa Group 293 Wright Street, Delavan, WI 53115 International: 262-728-5551, FAX: 262-728-7550 www.starite.com Union City, TN • Delavan, WI • Mississauga, Ont. • Murrieta, CA S621 (Rev. 6/9/04) © 2004, Sta-Rite Industries Printed in U.S.A.
-
Page 2: Table Of Contents
Keep safety labels in good condition. READ THIS MANUAL CAREFULLY! Replace missing or damaged safety labels. The Sta-Rite Clear-Flo Fiber Wound Sand Filter is designed Incorrectly installed or tested equipment to reliably filter water for swimming pools. may fail, causing severe injury or property damage. -
Page 3: General Information
GENERAL INSTALLATION - INFORMATION GENERAL Theory of Operation Installation of filter should only be done by qualified, licensed personnel. Water from the pool flows through the pump and into the distributors located above the filter bed. The water then Filter mount must flows through the sand where particles and debris are Provide space and lighting for easy access for routine captured and removed from the water. -
Page 4: Specifications
NOTICE: Use of other sands will reduce filter perfor- mance, may damage pump, and will void warranty. Recommended Gravel Grades: Use washed, dried and sized pea gravel, 1/4 x 1/8 inch. TABLE II - STA-RITE VALVES FOR USE WITH MODEL SR-300-2U 5,5 " AND SR-360-2U FILTERS 2"... -
Page 5: Filter Setup
FILTER SETUP 4. Hold the lid by the handle. 5. Turn the dogs sideways so they clear the edge of the 1. Plumbing Connections: tank opening. NOTICE: Refer to the owner’s manual in the box with your valve for valve installation and operation instructions. 6. -
Page 6: Startup/Operation
NOTICE: The laterals may get damaged if gravel is 3. Install Gauge poured too fast or recklessly. 4. Close 3. Pour sand into filter tank. See Page 4 for correct type Pressure Relief 1. Turn Clamp Dogs and quantity of sand to use. 2. - Page 7 “FILTER” position. Handle for winter storage. Handle is fully depressed is fully extended and and locked with lock pin locked with lock pin TABLE V - STA-RITE VALVES FOR USE WITH assembly. assembly. MODEL SR-300-2U AND SR-360-2U FILTERS Port Part...
-
Page 8: Maintenance
MAINTENANCE STORAGE / WINTERIZING General: Pool chemicals may give off corrosive • Wash outside of filter with a mild detergent and water. fumes. Store chemicals away from system in a well ven- Rinse off with hose. tilated area. NOTICE: DO NOT use solvents to clean filter; sol- NOTICE: Allowing water to freeze will damage filter and vents may damage plastic components in system. -
Page 9: Troubleshooting Guide
Removing Sand and Gravel From Filter: G. Residual chlorine level too low. Consult pool profes- sional about proper chemical maintenance. A. Remove both drain plug and the drain fitting. Sand H. Inspect filter sand for solidification caused by dust, and water will drain from tank. A “wet-vac” can be calcium, skin oils, or suntan lotions. -
Page 10: Repair Parts List
CLEAR-FLO™ 30" SAND FILTER EXPLODED VIEW... - Page 11 30" SAND FILTER REPAIR PARTS LIST Part Model Description Qty. SR-300-2U Pressure Gauge U239-3 Air Vent Stem Assembly (Includes O-Ring) 24206-0103 O-Ring, Air Vent 35505-7439 Lid Clamp Knob 24300-0004 PVC Cap 24300-0023 Washer, 3/8x13/32” U43-42SS Lockwasher U43-12SS O-Ring, Lid 24300-0019 Lid Clamp Dog 24300-0005 Lid Assembly (Includes Key Nos.
-
Page 12: Warranty
CLEAR-FLO™ 36" SAND FILTER EXPLODED VIEW... - Page 13 36" SAND FILTER REPAIR PARTS LIST Part Model Model Description Qty. SR-360-2U SR-360-3T Pressure Gauge U239-3 U239-3 Air Vent Stem Assembly (Includes O-Ring) 24206-0103 24206-0103 O-Ring, Air Vent 35505-7439 35505-7439 Lid Clamp Knob 24300-0004 24300-0004 PVC Cap 24300-0023 24300-0023 Washer, 3/8x13/32” U43-42SS U43-42SS Lockwasher...
- Page 16 • Complete a warranty registration at www.staritepool.com by clicking on “Register Products” and selecting Sta-Rite Pool OR • Complete bottom portion completely and mail within 10 days of installation to Sta-Rite, Attn.: Pool Warranty Dept., 293 Wright St., Delavan , WI 53115 Warranty Registration Card ■...