Intermatic RC2000 Series Installation, Operation & Service Manual

WIRING DIAGRAMS RC2343PT
240V SINGLE SPEED PUMP
TIMER
240V BLOWER
240V FREEZE PROTECTION
OPTIONAL
NEUTRAL FREEZE
LOAD
L2
L1
LOAD
BREAKER BLOWER
L2 L2
240V TWO SPEED PUMP
TIMER
240V BLOWER
240V FREEZE PROTECTION
OPTIONAL
NEUTRAL FREEZE
HIGH
LOW
L2
L1 LOAD
BREAKER
L2 L2
120V SINGLE SPEED PUMP
TIMER
120V BLOWER
120V FREEZE PROTECTION
OPTIONAL
FREEZE
BREAKER
L1 LOAD
N
LOAD
NEUTRAL
N
120V TWO SPEED PUMP
TIMER
120V BLOWER
120V FREEZE PROTECTION
OPTIONAL
FREEZE
BREAKER
L1 LOAD
N
HIGH
LOW
NEUTRAL N
IMPORTANT NEUTRAL WIRE MUST ALWAYS BE USED
NOTES:
1. Dot (•) indicates twist on wire connector.
2. If freeze protection is not required, permanently cap (twist on wire connector) brown lead.
LIMITED WARRANTY
Warranty service is available by either (a) returning the product to the dealer from whom the unit was purchased or (b)
completing a warranty claim online at www.intermatic.com. This warranty is made by: Intermatic Incorporated, Customer
Service 1950 Innovation Way, Suite 300, Libertyville, IL 60048.
For warranty service go to: http://www.Intermatic.com or call 815-675-7000
Because of our commitment to continuing research and improvements, Intermatic Incorporated reserves the right to make changes,
without notice, in the specifications and material contained herein and shall not be responsible for any damages, direct or consequential,
caused by reliance on the material presented.
INTERMATIC INCORPORATED, LIBERTYVILLE, IL 60048
158--02178
240V SINGLE SPEED PUMP
TIMER
240V BLOWER
240V FREEZE PROTECTION
NEUTRAL
L1
PUMP BREAKER
L2
L1
BREAKER
L2
240V TWO SPEED PUMP
TIMER
240V BLOWER
240V FREEZE PROTECTION
NEUTRAL
PUMP
L1
BREAKER
L2
L1
BLOWER BREAKER
L2
120V SINGLE SPEED PUMP
TIMER
120V BLOWER
120V FREEZE PROTECTION
BREAKER
L1
BREAKER
L1
BLOWER
PUMP
NEUTRAL
120V TWO SPEED PUMP
TIMER
120V BLOWER
120V FREEZE PROTECTION
BREAKER
L1
BREAKER
L1
BLOWER
PUMP
NEUTRAL
4
RC2000 SERIES
AIR ACTUATED SPA CONTROLS
OPTIONAL
FOUR FUNCTION AIR SWITCH WITH TIMER
FREEZE
Model: RC2343PT - Plastic Outdoor Enclosure Suitable for POOL/SPA Equipment Control
LOAD
RATINGS: 20 A (R), 1 HP, 120 V, 60 Hz.; 20 A (R), 2 HP, 240 V, 60 Hz.
PUMP
L2
READ AND FOLLOW ALL INSTRUCTIONS • IMPORTANT SAFTEY INSTRUCTIONS • SAVE THESE INSTRUCTIONS
LOAD
BLOWER
L2
WARNING
• Electrical connections to this equipment must be accomplished by a qualified electrician in accordance with the
National Electrical Code and in accordance with all local codes.
OPTIONAL
FREEZE
• Disconnect power at the circuit breaker(s) or disconnect switch(es) before installing or servicing. More than one
HIGH
circuit breaker or disconnect switch may be required to de-energize the equipment before servicing.
PUMP
LOW
• For outdoor locations or wet locations (rain-tight), conduit hubs that comply with requirements of the UL514B
L2
(standard for fitting conduit and outlet boxes) are to be used.
LOAD • Do NOT exceed maximum current carrying capacity.
BLOWER
L2
• Reinstall wire terminal cover after wiring is complete.
• KEEP DOOR CLOSED AT ALL TIMES when not servicing.
• The control panel is to be a minimum of 3 M. (in Canada) or 5 ft. (in USA) from the inside wall of the pool, spa, or
pond, unless separated from the body of water by a fence, wall or other permanent barrier that will make the unit
OPTIONAL
inaccessible to persons in the water.
FREEZE
• For grounding and bonding of this Control and the installation, refer to section 680 of the National Electrical Code.
LOAD
BLOWER
N
LOAD
PUMP
N
This Air Switch is designed to control two separate
pieces of equipment with one air button. Without
electricity at the spa side, it can safely control a
pump and blower. Each press of the air button
OPTIONAL
FREEZE will cycle between the sequences shown below.
When left in sequence one, the timer will operate
LOAD
BLOWER
the pump at the times set for daily filtration. It also
N
has an input for freeze protection.
HIGH
PUMP
LOW
N
EQUIPMENT
PUMP (SINGLE-SPEED) TIMER
ON/OFF
PUMP (TWO-SPEED) TIMER
ON/OFF
LOW
BLOWER OFF
®
Risk of Fire or Electric Shock
GENERAL INFORMATION
SEQUENCE
1 2 3 4
ON ON OFF
HIGH HIGH OFF
OFF ON ON
1
INSTALLATION
OPERATION &
SERVICE MANUAL